1994 CHEVROLET CAMARO maintenance schedule

Downloaded from www.Manualslib.com manuals search engine 0
0
5.7L LTl (Code P)
When the engine compartment is hot,
the level should be at the
“H” or
“HOT” mark.
When the engine compartment is cool,
the level should be at
the “C” or
“FULL COLD” mark.
w1
Re
del
“R
in
n
hat to Add:
fer to the Maintenance Schedule to
:ermine what kind of fluid to use. See
ecommended Fluids and Lubricants”
the Index.
NOTICE:
When adding power steering fluid or
making a complete fluid change,
always use the proper fluid. Failure
to use the proper fluid can cause
leaks and damage hoses and seals.
I
/intishield Washer Fluid
3 Add:
pen the cap labeled “WASHER FLUID
NLY.” Add washer fluid until the bottle
full.
201 . . .

Downloaded from www.Manualslib.com manuals search engine Service and Appearance Care
NOTICE:
0
0
0
0
When using concentrated washer
fluid, follow the manufacturer’s
instructions for adding water.
Don’t mix water with
ready-to-use washer fluid. Water
can cause the solution
to freeze
and damage your washer fluid
tank and other parts of the washer
system. Also, water doesn’t clean
as well as washer fluid.
Fill your washer fluid tank only
314 full when it’s very cold. This
allows for expansion, which could
damage the tank
if it is completely
full.
Don’t use radiator antifreeze in
your windshield washer.
It can
damage your washer system and
paint.
r
#
-
I
E
fi
T
fl
g
g
n
li
b
1€
Yi
si
Y
u
3rake Masfer Cylinder
‘our brake master cylinder is here. It is
dled with DOT-3 brake fluid.
‘here are only two reasons why the brake
luid level
in your master cylinder might
o down. The first is that the brake fluid
oes down to an acceptable level during
ormal brake lining wear. When new
nings
are put in, the fluid level goes
ack
up. The other reason is that fluid is
:aking
out of the brake system. If it is,
ou should have your brake system fixed,
mce a leak means that sooner or later
our brakes won’t work well, or won’t
lork at all.
So, it isn’t a good idea to “top off’ your
brake fluid. Adding brake fluid won’t
correct a leak. If you add fluid when your
linings are worn, then you’ll have too
much fluid when you get new brake
linings.
You should add (or remove)
brake fluid, as necessary, only when work
is done on the brake hydraulic system.
Refer to the Maintenance Schedule to
determine when to check your brake
fluid. See “Periodic Maintenance
Inspections” in the Index.
. . .1u1

Downloaded from www.Manualslib.com manuals search engine Service and Appearance Care
When to Check: Check your tires once a
month or more. Don’t forget your
compact spare tire. It should be at
60 psi
(420 kPa).
How to Check: Use a good quality
pocket-type gage to check tire pressure.
Simply looking at the tires will not tell
you the pressure, especially if you have
radial tires
- which may look properly
inflated even
if they’re underinflated.
If your tires have valve caps, be sure to
put them back on. They help prevent
leaks by keeping out dirt and moisture. Tire Inspection and Rotation
To make your tires last longer, have them
inspected and rotated at the mileages
recommended
in the Maintenance
Schedule. See “Scheduled Maintenance
Services” in the Index.
[f you don’t have P245/50ZR16 size tires
use the rotation pattern shown above for
your size tires.
4-
f you have P245/50ZR16 size tires, they
nust roll in
a certain direction for the best
werall performance. The direction is
hown by an arrow on both sidewalls.
3ecause these tires are directional, they
hould be rotated as shown
in the
:xample above. These tires should only
,e moved from front to rear and rear to
ront on the same side of the vehicle.
ifter the tires have been rotated, adjust
he front and rear inflation pressure as
.hown on
the Tire-Loading Information
abel. Make certain that all wheel nuts are
u-operly tightened. See “Wheel Nut
rorque” in the Index.
. . .216

Downloaded from www.Manualslib.com manuals search engine IMPORTANT: I
KEEP THE ENGINE OIL
AT THE PROPER
LEVEL AND CHANGE AS
RECOMMENDED
I
This part covers the
maintenance required for your
Chevrolet
. Your vehicle needs
these services
to retain its
safety. dependability and
emission control performance
.
Part l
Maintenance Schedule
Section
Introduction: A Word about Maintenance ........................ 238
A .
B .
C .
D .
E .
Your Vehicle and the Environment ......................... 238
How This Part Is Organized
............................... 238
Scheduled Maintenance Services ............................ 240
Using Your Maintenance Schedules ......................... 239
Selecting the Right Schedule
.............................. 239
Schedule1
............................................. 240
Schedule11
............................................ 242
Explanation
of Scheduled Maintenance Services .............. 244
Owner Checks and Services ................................ 246
AtEachFuelFill
....................................... 246
At Least Once a Month .................................. 246
AtLeastTwiceaYear
................................... 246
AtLeastOnceaYear
.................................... 247
Periodic Maintenance Inspections ........................... 249
Recommended Fluids and Lubricants ........................ 251
Maintenance Record ...................................... 253
lqq I
Have you purchased the GM Protection Plan? The Plan
supplements
your. new car warranties .
See your GM dealer for details .
237 ...

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Introduction: A Word about Maintenance
We at General Motors want to help you
keep your vehicle in good working
Condition,
But we don’t how exactly
how you’ll drive it.
You may drive very
short distances only a few times a week.
Or you may drive long distances all the
time in very hot, dusty
weather. You may
use your vehicle in making deliveries. Or
you may drive it to work, to do errands,
or in many other ways.
Because of all the different ways people
use their GM vehicles, maintenance needs
vary. You may even need more frequent
checks
and replacements than you will
find in the schedules in this part. So
please read this part and note how you
drive.
If you have any questions on how
to keep your vehicle in
good condition,
see your Ghevrolet dealer, the place
many GM owners choose to have their
maintenance
work done. Your dealer can
be relied upon to use proper parts and
practices.
Your Vehicle and the
Environment
Proper vehicle maintenance not only
keeps your vehicle in good working
condition,
but it also helps the
environment. All recommended
maintenance procedures are important.
hproper vehicle maintenance or
the
removal of important components can
significantly affect the quality of the air
we breathe. Improper fluid levels or even
the wrong tire inflation can increase the
level of emissions from your vehicle. To
help protect our environment, and to help
keep your vehicle
in good condition,
please maintain your vehicle properly.
How This Part is Organized
The remainder of this part is divided into
five sections:
“Section
A: Scheduled Maintenance
Services” shows
what to have done, and
how often. Some of these services can
be
complex, so unless you are technically
qualified and have the necessary
equipment,
you should let your dealer’s service department
or another qualified
service center
do these jobs.
If you are skilled enough to do some work
on
your vehicle, you will probably want
to get the service information GM
publishes, You will find a list of
publications and how to get them later in
this manual. See “Service Publications”
in the
Index.
“Section B: Owner Checks and Services”
tells you what should be checked
whenever
you stop for fuel. It also
explains what you can easily
do to help
keep
your vehicle in good condition.
. . .238

Downloaded from www.Manualslib.com manuals search engine “Section C: Periodic Maintenance
: Inspections” explains important
inspections that your Chevrolet dealer’s
service department or another qualified
service center should perform.
“Section
D: Recommended Fluids and
Lubricants” lists some products GM
recommends to help keep your vehicle
properly maintained. These products, or their equivalents, should be used whether
you do the work yourself or have it done.
“Section
E: Maintenance Record”
provides a place for you to record the
maintenance performed on your vehicle.
Whenever any maintenance is performed,
be sure to write it down in this section.
This will help you determine when your
next maintenance should be done. In
addition, it is a good idea
to keep your
maintenance receipts. They may be
needed to qualify your vehicle for
warranty repairs.
Using Your Maintenance
Schedules
This section tells you the maintenance
services you should have done and
when you should schedule them. Your
Chevrolet dealer knows your vehicle best
and wants you to be happy with it. If you
go to your dealer for your service needs,
you’ll know that GM-trained and
supported service people will perform
the work using genuine GM parts.
These schedules are for vehicles that:
carry passengers and cargo within
recommended limits.
You will find
these limits on your vehicle’s
Tire-Loading Information label. See
“Loading Your Vehicle” in the Index.
are driven on reasonable road pprfaces
within legal driving limits.
use
the recommended unleaded fuel.
See “Fuel” in the Index.
Selecting the Right Schedule
First you’ll need to decide which of the
two schedules is right for your vehicle.
Here’s how to decide which schedule to
follow:
Schedule
I
Is any one of these true for your vehicle?
Most trips are less than 4 miles (6 km).
Most trips are less than 10 miles (16
km) when outside temperatures are
below freezing.
The engine is at low speed most of the
time (as in door-to-door delivery, or in
stop-and-go traffic).
You operate your vehicle in dusty
You tow a trailer.
If any one (or more) of these is true for
your driving, follow Schedule
I.
Schedule 11
Follow Schedule I1 on& if none of the
above conditions is true.
areas.
239.. .

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services
Schedule 1
MAINLY driven under one or more of
the following conditions:
When most trips are less than 4 miles
(6 km).
When most trips are less than 10 miles
(16 km) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as
in stop-and-go traffic.
When towing a trailer.
0 When operating in dusty areas.
Schedule
I should also be followed if the
vehicle is used for deliverv service, police,
taxi or other commercial applications.
* An Emission Control Service.
=t The U.S. En\sironmental Protection Agency
or the California Air Resources Board has
determined that the failure to pellform this
maintemnce item will not
nullifi. the emission
warranty
or limit recall liability prior to the
cvmpletion
cf vehicle usejul life. General
Motors, however, urges rhat all rec.*ornmended
maintenance services
he performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
ITEM NO.
-
1
2
3
4
5
6
7
8 -
9
10
11
WHAT TO SERVICE
See “E,rplanation of Scheduled
Maintenunce Servicae.s”
jullowing
Schedules I and 11.
Engine Oil & Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt(s) Inspection*
Cooling System Service”
Transmission Service Spark Plug Replacement
(3.4L L32 (Code
S) Engine)*
Spark Plug Replacement
(5.7L LTI (Code P) Engine)*
Spark Plug Wire Inspection*+
Air Cleaner Filter Replacement*
Fuel Tank, Cap & Lines Inspection*?
Rear Axle Fluid Change
(For Vehicles
Towing Trailers
or for Vehicles with
Limited-Slip Differentials)
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occursfirst).
Every 3.000 miles (5 000 km) or 3 months.
Every other oil chenge.
At 6,000 miles (10 000 km) and every
15,000 miles (25 000 km) or as necessary.
Every 30,000 miles (50
000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 30,000 miles (50 000 km).
Every 100,000 miles ( 166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and II.
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
. . .240

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (cont.)
Schedule 11
Follow Schedule I1 ONLY if none of
Jhe driving: conditions specified in
Schedule I appl~
* An Emission Contsol Ses\:icc.
il- The US. Envisonmental Psotection Agency
os the Calijosrtia Ais Resousces Bousd has
detesmined that
the failuse to pesfosm this
maintenance item will not nullib the emissiott
warsanty
or limit secall liability psios to the
completion of whicle useful life. Genesal
Motoss, howews, urges that all sccommended
maintenance semices
be pesformed at the
indicated inten*als and
rhe maintenance he
secorded in “Section E: Maintenance Record.”
ITEM NO.
1
-
2
3
-
4
5
6
-
-
-
7
-
8
9
-
10
11
WHAT TO SERVICE
“E.vplanutiol? c?fSd~eduleci
Mairztetzuncx~ Ses\.ic*es‘’ fhllolz*itlg
Schedules I Ulld !I.
Engine Oil Change”
Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt(s) Inspection”
Cooling System Service”
Transmission Service Spark Plug Replacement
(3.4L L32 (Code S) Engine)”
Spark Plug Replacement
(5.7L LTI (Code P) Engine)*
Spark
Plug Wire Inspection”?
Air Cleaner Filter Replacement”
Fuel Tank, Cap & Lines Inspection’k+
Rear Axle Fluid Change (For Vehicles
with Limited-Slip Differentials) Every
7,500 miles (1 2 500
km) or 12 months.
At first and then every other oil chqnge.
Every 7,500 miles
( 12 SO0 km) or 12 months.
At 7.500 miles (1 2 SO0 km) and then every
15.000 miles
(25 000 km) or as necessary.
Every 30.000 miles
(50 000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services“ following Schedules
I and 11.
Every 30,000 miles (SO 000 km).
Every IOO.OOO miles ( 166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 30.000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” lollowing Schedules
I and 11.
. . .242