1994 CHEVROLET CAMARO maintenance schedule

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (cont.)
Explanation of Scheduled
Maintenance Services
Following are explanations of the services
listed in Schedule
I and Schedule 11.
The proper fluids and lubricants to use are
listed
in Section D. Make sure whoever
services your vehicle uses these. All parts
should be replaced and all necessary
repairs done before you or anyone else
drives the vehicle.
NOTE: To determine your engine’s
displacement and code, see
“Engine Identification”
in the
Index.
ITEM
NO. SERVICE
1 Engine Oil and Filter Change” -
Always use SH or SG Energy
Conserving I1 oils of proper
viscosity. The
“SH” or “SG”
designation may be shown alone
or
in combination with others,
such as “SH/CD,”
“SH, SG,
CD,” “SG/CD,” etc. To deter-
mine the preferred viscosity for
your vehicle’s engine (e.g., SAE
ITEM
NO.
2
3
4
SERVICE
5W-30 or SAE 1OW-30)’ see
“Engine Oil”
in the Index.
Chassis Lubrication
- Lubricate
the suspension and steering
linkage. Lubricate the
transmission shift linkage.
Tire and Wheel Rotation and
InsDection
- For proper wear
and maximum tire life, rotate
your tires following the
instructions
in this manual. See
“Tires, Inspection and Rotation”
in the Index. Check the tires for
uneven wear or damage. If you
see irregular or premature wear,
check the wheel alignment.
Check for damaged wheels also.
Engine Accessory Drive Belt(s)
Inspection
- Inspect the belt(s)
for cracks, fraying, wear and
proper tension. Replace as needed. (Belts can have many
small cracks
in individual ribs
without affecting performance.)
ITEM
NO. SERVICE
5 Cooling System Service* -
Drain, flush and refill the system
with new or approved recycled
coolant conforming to
GM
Specification 1825M. Keep
coolant at the proper mixture as
specified. See “Coolant”
in the
Index. This provides proper
freeze and boil protection,
corrosion inhibitor level and
maintains proper engine
operating temperature.
Inspect hoses and replace
if they
are cracked, swollen or deterior-
ated. Tighten screw-type hose
clamps. Clean the outside
of the
radiator and air conditioning
condenser. Wash the pressure
cap and neck.
To help ensure proper operation,
we recommend a pressure test of
both the cooling system and the
pressure cap.
* An Emission Control Service.
. . .244

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section B: Owner Checks and Services
Listed below are owner checks and services which should be performed at the intervals specified to help ensure the safety,
dependability and emission control performance of your vehicle. Be sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your vehicle, make sure they are the proper ones, as shown in Section
D.
At Each Fuel Fill (It is important for you or a service station attendant to perform these underhood checks at each fuel fill.)
CHECK
OR SERVICE WHAT TO DO
Engine
Oil Level
Check the engine coolant level and add the proper coolant mix if necessary. See “Coolant” in
Engine Coolant Level Check the engine
oil level and add the proper oil if necessary. See “Engine Oil” in the Index for
Check the windshield washer fluid level
in the windshield washer tank and add the proper fluid if
Windshield Washer
Fluid Level necessary. See “Windshield
Washer Fluid”
in the Index for further details.
further details.
the Index for further details.
At Least Once
a Month
CHECK
OR SERVICE WHAT TO DO
Tire Inflation
Check tire inflation.
Make sure they are inflated to the pressures specified on the Tire-Loading
Information label located on the rear edge of the driver’s door. See “Tires” in the Index for
further details.
Cassette Deck Clean cassette deck. Cleaning should
be done every
15 hours of tape play. See “Audio Systems”
in the Index for further details.
At Least Twice a Year
CHECK
I OR SERVICE
I
Hydraulic Clutch
System Inspection
WHAT TO DO I
Check the fluid level in the clutch reservoir. See “Hydraulic Clutch Fluid” in the Index. A fluid
loss
in this system could indicate a problem. Have the system inspected and repaired at once.
. . .246

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section B: Owner Checks and Services (Cont.)
At Least Once a Year (CONT.)
CHECK
OR SERVICE
Steering Column Lock
Parking Brake and
Automatic Transmission “P” (Park) Mechanism
Check
Underbody Flushing
WHAT TO DO
While parked, and with the parking brake set, try to turn the key to “LOCK” in each shift lever
position.
0 With an automatic transmission, the key should turn to “LOCK” only when the shift lever is
0 With a manual transmission, the key should turn to “LOCK” only when the shift lever is in
On vehicles
with a key release button, try to turn the key to “LOCK” without pressing the
button. The key should turn to “LOCK” only with the key button depressed. On all vehicles,
the
key should come out only in “LOCK.”
in “P” (Park).
“R” (Reverse).
Park on a fairly steep hill, with the vehicle facing downhill. Keeping your foot on the regular
brake, set the parking brake.
0 To check the parking brake: With the engine running and transmission in “N” (Neutral),
slowly remove foot pressure from the regular brake pedal.
Do this until the vehicle is held by
the parking brake only.
brakes.
0 To check the “P” (Park) mechanism’s holding ability: Shift to “P” (Park). Then release all
At least every spring, use plain water to flush any corrosive materials from the underbody. Take
care to clean thoroughly any areas where mud and other debris can collect.
. . .248

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section C: Periodic Maintenance Inspections (Cont.)
INSPECTION
OR SERVICE
Rear Axle Service
Brake System
Inspection
-
WHAT SHOULD BE DONE
Check the transmission fluid level; add if needed. See “Manual Transmission” in the Index.
A fluid loss may indicate a problem. Check the system and repair if needed.
Check the gear lubricant level in the rear axle and add if needed. See “Rear Axle” in the Index.
A fluid loss may indicate a problem. Check the axle and repair it
if needed. If your vehicle
is used to pull a trailer, have the rear axle gear lubricant changed every
7,500 miles
(12 500 km).
Inspect the complete system. Inspect brake lines and hoses for proper hookup, binding, leaks,
cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also
inspect drum brake linings for wear and cracks. Inspect other brake parts, including drums,
wheel cylinders, calipers, parking brake, etc. The parking brake is self-adjusting and
no manual
adjustment is required. You may need to have your brakes inspected more often if your driving
habits or conditions result in frequent braking.
NOTE: A low brake fluid level can indicate worn disc brake pads which may need to be serv-
iced. Also, if the brake system warning light stays on or comes on, something may be wrong
with the brake system. See “Brake System Warning Light” in the Index.
If your anti-lock brake
system warning light stays on, comes on or flashes, something may be wrong with the anti-lock
brake system. See “Anti-Lock Brake System Warning Light” in the Index.
. . .250

Downloaded from www.Manualslib.com manuals search engine USAGE FLUID/LUBRICANT
Floor
Shift Linkage
Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
Chassis Lubrication Engine oil.
NLGI Grade 2, Category LB or GC-LB.
Rear Axle
(Standard Differential)
I
Axle Lubricant (GM Part No. 1052271) or SAE SOW-90 GL-5 Gear Lubricant.
I
Rear Axle (Limited- I Axle Lubricant (GM Part No. 12345977) or SAE 80W-90 GL-5 Gear Lubricant, and Limited-
Slip Differential) Slip Differential.Lubricant
Additive (GM Part
No. 1052358 or equivalent) where required. See
“Rear Axle”
in the Index. I
Maintenance Schedule
Section D: Recommended Fluids & Lubricants (Cont.)
Windshield Washer GM Optikleen’ Washer Solvent
(GM Part No. 1051515 or equivalent).
Solvent
I
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl
Anchor
1
~~
a.
Engine oil.
b. Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
Hood and Door
Hinges, Rear Folding
Seat, Fuel Door Hinge,
Rear Compartment
Lid Hinges NLGI
Grade
2, Category LB or GC-LB.
Engine oil
or Lubriplate Lubricant (GM Part No. 1050109).
~
Weatherstrips I Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).
See “Replacement Parts”
in the Index for recomme’nded replacement filters, valves and spark plugs.
. . .252

Downloaded from www.Manualslib.com manuals search engine Section E: Maintenance Record
After the scheduled services are performed, record the date, odometer reading and who performed the service in the columns
indicated. When completing the Maintenance Performed column, insert the numbers from the Schedule
I or Schedule I1
maintenance charts which correspond to the maintenance performed. Also, you should retain all maintenance receipts, Your
owner information portfolio is a convenient place to store them.
DATE I ODOMETER I
READING SERVICED BY I MAINTENANCE PERFORMED
253. . .

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section E: Maintenance Record (Cont.)
ODOMETER DATE READING SERVICED BY MAINTENANCE PERFORMED
. . ,254

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section E: Maintenance Record (Cont.) ~~ ~ ~ ~
ODOMETER DATE READING SERVICED BY MAINTENANCE PERFORMED
. . .256