1993 PONTIAC GRAND-PRIX recommended oil

INST ECON: Press to display your
fuel economy at the time you press the
button. The display will be updated
every five seconds until you turn it off.
Press again to turn off the display.
SYSTEMS CHECK: Press to display
the systems monitor
(STE Model only).
If your model does not have the systems
monitor, it will display the sewice
reminder sequence.
If it has the systems
monitor, press again to display the
service reminder sequence.
Systems Monitor: This checks to be
sure the following systems in your
vehicle are in proper working order:
Front lights
Rear lights
Side lights
Doors
Hood
Washer fluid
Trunk
Fuel tank
Anti-lock brakes (if equipped)
The systems monitor briefly displays
messages as it checks these systems. If
it finds a problem, the systems monitor
will display a continuous
or flashing
message about the problem. If all
systems are satisfactory, the service
reminder sequence will begin.
If you pull a trailer, the extra trailer
lamp bulbs will not allow the systems
monitor to properly detect a burned-out
bulb. When the trailer lights are
disconnected, the systems monitor will
again monitor the bulbs.
Service Reminder Sequence: This
shows the distance remaining to the
next recommended:
Oil change (OIL)
Oil filter change (OIL FILT)
Air filter change (AIR FILT)
Tire rotation (ROT TIRE)
Tune up (TUNE UP)
Press SYSTEMS CHECK each time
you want to see the next item in the
sequence.
When you have any of these services
performed, be sure to reset the service
reminder.
ProCarManuals.com

Your Driving and the Road
Drkjng a Long Distance
Although most long trips today are
made on freeways, there are still many
made
on regular highways.
Long-distance driving on freeways and
reguIar highways is the same in some
ways. The trip has to be planned and
the vehicle prepared, you drive at
higher-than-city speeds, and there are
longer turns behind the wheel. You’ll
enjoy your trip more if you and your
vehicle are in good shape. Here are
some tips for a successful long trip.
Before Leaving on a Long Trip
Make sure you’re ready. Try to be well
rested. If you must start when you’re
not fresh-such as after a day’s work-
don’t plan to make too many miles that
first part of the journey. Wear
comfortable clothing and shoes you can
easily drive in.
Is your vehicle ready for a long trip? If
you keep it serviced and maintained, it’s
ready to go. If it needs service, have it
done before starting out. Of course,
you’ll find experienced and able service
experts in Pontiac dealerships all across
North America. They’ll be ready and
willing to help
if you need it. Here
are some things you can check
before a trip:
Windshield Washer Fluid Is the
reservoir full? Are all windows clean
inside and outside?
shape?
Have you checked all levels?
lenses clean? safe, trouble-free trip.
Is the tread
good enough for long-distance
driving? Are the tires all inflated to
the recommended pressure?
weather outlook along your route?
Should
you delay your trip a short
time to avoid a major storm system?
Maps: Do you have up-to-date maps?
Wiper Blades: Are they in good
Fuel, Engine Oil, Other Fluids:
Lights: Are they all working? Are the
Tires: They are vitally important to a
Weather Forecasts: What’s the
ProCarManuals.com

IMPORTANT
KEEP ENGINE OIL
AT THE PROPER
LEVEL AND CHANGE
AS
RECOMMENDED
This part covers the maintenance
required for your Pontiac. Your
vehicle needs these services to retain its safety, dependability and emission
control performance.
Have you purchased the GM
Protection Plan?
The Plan supplements your new
vehicle warranties. See your Pontiac dealer for details.
Part 7 '.
Maintenance Schedule
Section
Introduction
A Word About Maintenance .......................................................... 288
Your Vehicle and the Environment
................................................ 288
How This Part is Organized
........................................................... 289
A. Scheduled Maintenance Services
Using Your Maintenance Schedules .............................................. 290
Selecting the Right Schedule
.......................................................... 290
Schedule
I ........................................................................\
............... 292
Schedule
I1 ....... .............................................................. .. ........... .... 294
Explanation
of Scheduled Maintenance Services ... ... . . . . . . . . . . . . . . . . . . . 296
B. Owner Checks & Services
At Each Fuel Fill ........................................................................\
..... 299
At Least Once a Month
.................................................................. 299
At Least Twice a Year
..................................................................... 299
At Least Once a Year
...................................................................... 300
C. Periodic Maintenance Inspections ....................................................... 302
D. Recommended Fluids & Lubricants .................................................... 303
E. Maintenance Record ........................................................................\
...... 306
ProCarManuals.com

Maintenance Schedule
.
Section A: Scheduled Maintenance Services ~ont.3
Schedule I
Follow Schedule I if your vehicle is
MAINLY driven under one or more of
the following conditions:
When most trips are less than 4 miles
When most trips are less than 10 miles
(6 km).
(16 lun) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as in stop-and-go traffic.
When towing a trailer.*+
When operating in dusty areas.
Schedule I should also be followed if
the vehicle is used for delivery service,
police, taxi
or other commercial
applications.
An Emission Control Service.
~2 The US. Environmental Protection Agency has
determined that the failure to perform this
maintenance item will not nullify the emission
warranty
or limit recall liability prior to the
completion of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in Section
E: Maintenance Record.
292
TO BE SERVICED
See Euplnrzatior~ of Scheduled Maintennitce
Sercices following Schedules I and II.
ITEM
NO.
2 I Chassis Lubrication
3 Throttle Body Mounting Bolt Torque
(3.E Engine, VIN Code T)*
41
Tire and Wheel Rotation and Inspection
Camshaft Timing Belt Inspection (3.4L Engine,
VIN Code X)*
81
Transaxle Service
10 I Spark Plug Wire Inspection*+
Exhaust Gas Recirculation
(EGR) System
Inspection
(3.4L Code X engine only)**
14 Fuel Tank, Cap & Lines Inspection**
T
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occurs first).
Every other oil change.
At
6,000 Miles (10 000 km) and then every
15,000 Miles (25 000 !an) or as necessary.
At
60,000 Miles (100 000 km) and then every
l5,000 Miles (25 000 km).
See Explmution of Scheduled Muinterzance Services
following Schedules I and II.
Every 30,000 Miles (50 000 km).
Every 30:000 Miles (50 000 km).
Every 30,000 Miles (50 000 km).
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services t~ont.3
Explanation of Scheduled Maintenance Services
Below are explanations of the services listed in Schedule I
and Schedule 11.
ITEM
NO. SERVICE
1 Engine Oil and Filter Change’:-Always use SG
Energy Conserving I1 oils for proper viscosity. The
“SG” designation may be shown alone or in
combination with others, such as “SG/CC,”
“SG/CD” or
“SF, SG, CC,” etc. To determine the
preferred viscosity for your vehicle’s engine (e.g.,
SAE
5W-30 or SAE 1OW-30) see the Index under
Engine OiZ. If your vehicle is equipped with an
Engine Oil-Change Indicator (EOCI)
, the
indicator will show you when to change oil. See
the
Index under Driver Information Center.
2 Chassis Lubrication-Lubricate the transaxle shift
linkage, parking brake cable guides, underbody
contact points and linkage. Lubricate the front and
rear suspension and steering linkage. The
proper fluids and lubricants to use are listed in Section
D. Make sure whoever services your vehicle uses these. All
parts should be replaced and all necessary repairs done
before you or anyone else drives the vehicle.
ITEM
NO. SERVICE
3 Throttle Body Mounting Bolt Torque (3.1L
Code T engine only)‘x- Check the torque of the
mounting bolts and/or nuts.
Tire and Wheel Rotation and Inspection -For
long wear and maximum tire life, rotate your tires
following the instructions in this manual. See the
Index under Tires, Inspection G. Rotation. Check
the tires for uneven wear or damage.
If you see
irregular or premature wear, check the wheel alignment. Check for damaged wheels also.
4
a The U.S. Environmental Protection Agency has determined that the failure to perform this maintenance item will not nullify the emission warranty or
limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended maintenance services be
performed at the indicated intervals and the maintenance be recorded
in Section E: Maintenance Record.
296
ProCarManuals.com

Section D: Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer.
I USAGE
Engine Oil
Engine Coolant Hydraulic Brake
I system
Hydraulic Clutch
I system
I Parking Brake Guides
II
I I Automatic Transaxle
FWID/WBRICANT
GM Goodwrench Motor Oil or equivalent for API service SG Energy Conserving II oils of the
proper viscosity. The “SG” designation may be shown alone \
or
in combination with others, such
as “SGICC,” “SG/CD,” or “SF, SG, CC,” etc. To determine the preferred viscosity for your
vehicle’s engine,
see the Index under Engine Oil.
A 5060 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM
Part No. 1052753 or equivalent) conforming to GM Specification 1825M or approved
recycled coolant
conforming to GM Specification 1825111.
Delco Supreme
ll@ Brake Fluid (GM Part No. 1052535) or equivalent DOT-3 brake fluid.
Hydraulic Clutch Fluid (GM
Part No. 12345347) or equivalent.
~
Chassis lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB
(GM Part No. 1052497 or equivalent).
GM Hydraulic Power Steering Fluid (GM
Part No. 1052884) or equivalent.
Synchromesh Transmission Fluid (GM
Part No. 12345349) or equivalent.
DEXRON@-IIE Automatic Transmission Fluid (GM
Part No. 12345881).
I
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids & Lubricants t~ont.3
USAGE
Key Lock Cylinders
Manual Transaxle Shifr
Linkage
Automatic Transaxle Shift Linkage
Clutch Linkage Pivot
Points
Floor Shift Linkage
Chassis Lubrication
Windshield Washer
Solvent
1 '1 304
FLUID/LUBRICANT
Lubricate with Multi-Purpose Lubricant (GM Part No. l2345l20), synthetic SAE 5W-30 engine
oil or silicone lubricant (GM
Part No. 1052276 or 1052277).
Chassis lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB (GM Part
No. 1052497 or equivalent).
Engine oil.
Engine oil.
Engine oil.
Chassis lubricant meeting requirements
of NLGI Grade 2, Category LB or GC-LB
(GM
Part No. 1052497 or equivalent).
GM Optikleen@ Washer Solvent (GM
Part No. 1051515) or equivalent.
~~~
ProCarManuals.com

USAGE
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl Anchor
Hood and door hinges,
fuel door hinge trunk
access panel hinges
Weatherstrips
I
FUJID/LUBRICANT
a. Engine oil.
b. Chassis lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB
Engine oil or Lubriplate Lubricant (GM Part
No. 1050109).
(GM
Part
No. 1052497 or equivalent).
Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).
See the
Index under Replacement Parts for recommended replacement filters, valves and spark plugs.
ProCarManuals.com