1993 Oldsmobile Cutlass Supreme service

The services shown in this schedule up to 48,000 miles (80 000 km) are to be
performed after 48,000 miles
at the same intervals.
MILES (000)
3 16 19 I12 I15 I18 121 124 127 130 133 136 139 142 145 148
293

,. .
Maintenance Schedule
Section A: Scheduled Maintenance Services (cant.)
* An Emission Control Service.
TO BE SERWCED WHEN TO PERFO'RM ITEM
Nom See J&plm.#ion of Scheduled Maintenance Miles (kiomtm) or Mmth
Sewices hllowing !khedules I and II. (whichaver occurs first).
At 7,500 Mks (E 500 kin) and then every l5,oOa
Miles (25 Oao km) or as necessary. I
Camshaft Timing Belt Insptim ~t 6U,OOO Miles (lo0 OOO h) and rherrewy
(3.4L Engine, VIN Code X)* ls,~ Miles (25 OOO km).
I 8 I Transaxle Service
10 I SDarkPlnpl Wm Inspection*a I Every 30,000 Miles (50 OOO km). I
I 14 I Fuel Ti&, Cap and Lines Jnsption*a I Every 30,000 Miles (SO OOO lan). I

The services shown in this schedule up to 45,000 miles (75 000 km) are to be
performed after
45,000 miles at the same intervals.
MILES (000)
KILOMETERS (000)
7.5 45 37.5 30 22.5
15
I 0 I 0 I 0 I 0 I 0 I 0 I
I 0 I I 0 I I 0 I I
295

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cant.)
Explanation of Scheduled Maintenance Services
Below are explanations of the services listed in Schedule I
and Schedule 11.
The proper fluids and lubricants to use are listed in Section
D. Make sure whoever services your vehicle uses these. All
parts should be replaced and all necessary repairs done
before you or anyone else drives the vehicle.
ITEM
NO. SERVICE
1 Engine Oil and Filter Change”-Always use SG
296
2
Energy Conserving I1 oils for proper viscosity. The
“SG” designation may be shown alone or in
combination with others, such as “SG/CC,”
“SG/CD” or “SF, SG, CC,” etc.
To determine the
preferred viscosity for your vehicle’s engine (e.g.,
SAE 5W-30 or SAE 1OW-30) see the Index under
Engine Oil.
Chassis Lubrication-Lubricate the transaxle shift
linkage, parking brake cable guides, underbody
contact points and linkage. Lubricate the front and
rear suspension and steering linkage.
ITEM
NO. SERVICE
3 Throttle Body Mounting Bolt Torque (3.1L
Code T or M engines only)*-Check the torque of
the mounting bolts and/or nuts.
4 Tire and Wheel Rotation and Inspection-For
proper wear and maximum tire life, rotate your
tires following the instructions in this manual. See
the
Index under Tires, Inspection G Rotation.
Check the tires for uneven wear or damage. If you
see irregular or premature wear, check the wheel
alignment. Check for damaged wheels also.
NOTE: To determine your engine’s displacement and code, see the Index under Engine Identification
* An Emission Control Service.
0 The U.S. Environmental Protection Agency has determined that the failure to perform this maintenance item will not nullify the emission warranty QY
limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all re\
commended maintenance services be
performed
at the indicated intervals and the maintenance be recorded in Section E: Maintenance Record.

ITEM
NO. SERVICE
5
6
7
Engine Accessory Drive Belt (s) Inspection
(California
3.1L Code T engine”)-Inspect the
belt for cracks, fraying, wear and proper tension.
Replace as needed.
Camshaft Timing Belt Inspection
(3.4L Code X
engine only)*-Inspect for cracks, wear or oiliness.
Check tensioner for proper operation. See the
service manual. (To purchase a service manual,
see the
Index under Publications.) Replace parts
as needed.
Cooling System Service*-Drain, flush, and refill
the system with new or approved recycled coolant
conforming to
GM Specification 1825M. Keep
coolant at the proper mixture as specified. See the
Index under Coolant. This provides proper freeze
protection, corrosion inhibitor level, and engine
operating temperature.
Inspect hoses and replace if they are cracked,
swollen or deteriorated. Tighten screw-type hose
clamps. Clean the outside of the radiator and air
conditioning condenser. Wash the pressure cap
and neck.
To help ensure proper operation, we recommend a
pressure test of both the cooling system and the
pressure cap.
ITEM
NO. SERVICE
8 Transaxle Service-Change both the fluid and
filter every 15,000 miles (25 000 ltm) if the vehicle
is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside
temperature regularly reaches
90°F (32°C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing. (With some
models, you shouldn’t ever tow a trailer. See the
Index under Towing a Trailer.)
Uses such as found in taxi, police car, or delivery
service.
If you do not use your vehicle under any
of these
conditions, change both the fluid and filter every
100,000 miles (160 000 lun) .
Spark Plug Replacement*-Replace spark plugs
with the proper type. See the
Index under
Replacement Parts.
burns, cracks or other damage. Check the boot fit
at the coils and at the spark plugs. Replace wires
as needed.
10 Spark Plug Wire Inspection**-Inspect for
9
297

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cant.)
ITEM
NO.
11
12
SERVICE
Positive Crankcase Ventilation Inspection*-Inspect system for proper function.
Replace
any worn, plugged or collapsed hoses or
seals. Replace valve only if necessary.
Exhaust Gas Recirculation (EGR) System
Inspection
(3.4L Code X engine only) *A-
Conduct the EGR system service as described in
the service manual.
To purchase a service manual,
see the
Index under Service Publications.
ITEM
NO.
13
14
SERVICE
Air Cleaner Filter Replacement*-Replace every
30,000 miles (50 000 km) or more often under
dusty conditions. Ask
your dealer for the proper
replacement intervals for your driving conditions,
Fuel Tank, Cap and Lines Inspection94nspect
.
fuel tank, cap and lines (including fuel rails and
injection assembly) for damage or leaks. Inspect
fuel cap gasket for
an even filler neck imprint or
any damage. Replace parts as needed. Periodic
replacement
of the fuel filter is not required.
Note: To determine your engine's displacement and code, see the Index under Engine Identification.
* An Emission Control Service.
Q The US. Environmental Protection Agency has determined that the failure to perform this maintenance item will not nullib the emission warranty or
limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended maintenance services be
performed at the indicated intervals and the maintenance be recorded
in Section E: Maintenance Record.

Section B: Owner Checks & Services
Listed below are owner checks and services which should be Be sure any necessary repairs are completed at once.
made at the intervals specified to help ensure the safety, Whenever any fluids or lubricants are added to your vehicle,
dependability and emission control performance of your make sure they are the proper ones, as
shown in Section D.
vehicle.
At Each Fuel Fill (/t is important for you or a service station attendant to perform these underhood check\
s at each fuel fill.)
CHECK
OR SERVICE I WHAT TO DO
Engine Oil Level Check the engine oil level and add the proper oil if necessary. See the Index under Engine Oil for
further details.
Engine Coolant Level
See the
Index under Windshield Washer Fluid for further details.
Fluid Level Check the
windshield washer fluid level in the windshield washer
tank and add fluid if necessary. Windshield Washer
Check the engine coolant
level in the coolant recovery tank and add the proper coolant mix if
~~ ~ ~~
necessary. See the Index under Coolant for further details.
At Least Once a Month
CHECK
I OR SERVICE I WHAT TO DO
Tire Inflation
Check tire inflation. Make sure they are inflated to the pressures specified on the Tire-Loading
~~ ~
Information label located on the rear edge of the driver’s door. See the Index under Tires for
further details.
r
L
299

Maintenance Schedule
Section 8: Owner Checks & Services (cant.)
300
At Least Once a Year
CHECK
OR SERVICE WHAT TO DO
~ ~_~__
Key Lock Cylinders Lubricate the key lock cylinders with the lubricant specified in Section D.
Body Lubrication Lubricate all body door hinges. Also lubricate all hinges and latches, including those for the
hood, rear compartment, glove box door, console door and any folding seat hardware. Section
D
tells you what to use.
CAUTION
n
I When you are doing this chock, the vehicle could move suddenly. If it does, you or others
1. Before you start, be sure you have enough room around the vehicle.
2. Firmly apply both the parking brake (see the Index under Parking Brake if necessary) and the
regular brake.
NOTE:
Do not use the accelerator pedal, and be ready to turn off the engine immediately if it
starts.
3. Try to start the engine in each gear. The starter should work only in P (Park) or N (Neutral).
If the starter works in any other position, your vehicle needs service.