1993 GMC SIERRA automatic transmission

3. Check both sides of the dipstick, and read the lower level. The fluid
level must be in the
COLD area for a cold check or in the HOT area or
cross-hatched area for a hot check.
4. If the fluid level is where it should be, push the dipstick back in all the
way; then flip the handle down to lock the dipstick in place.
How To Add Fluid:
Refer to the Maintenance Schedule to determine what kind of transmission
fluid
to use. See “Recommended Fluids and Lubricants’’ in the Index.
If the fluid level
is low, add only enough of the proper fluid to bring the level
up
to the COLD area for a cold check or the HOT area for a hot check. It
doesn’t take much fluid, generally less than a pint. Don’t overfill. We
recommend you use only fluid labeled DEXRON@IIE, because fluids \
with that
label are especially made for your automatic transmission. Damag\
e caused by
fluid other than
DEXRON@IIE is not covered by your new vehicle warranty.
After adding fluid, recheck the fluid level as described under “How To
Check”.
When the correct fluid level is obtained, push the dipstick back in all the
way; then flip the handle down
to lock the dipstick in place.
6-35
ProCarManuals.com

6. AIR CLEANER FILTER REPLACEMENT* -Replace at every 30,000
miles (50 000 km) or more often under dusty conditions. Ask your dealer
for the proper replacement intervals for your driving conditions\
.
7. FRONT WHEEL BEARING REPACK (2 WHEEL DRIVE ONLY) -Clean
and repack the front wheel bearings at each brake relining, or\
at the specified interval, whichever comes first.
8.
TRANSMISSION SERVICE
Automatic Transmission
-Change the transmission fluid and filter every
15,000 miles (25 000 km) for vehicles under 8,600 GVWR or every
12,000 miles (20 000 km) for vehicles over 8,600 GVWR if the vehicle
is mainly driven under one or more of these conditions:
In heavy city traffic.
Where the outside temperature regularly reaches 90°F (32°C\
) or
higher.
In hilly or mountainous terrain.
Frequent trailer pulling.
Uses such as taxi, police, delivery or other commercial service\
.
If the vehicle is not used mainly under any of these conditions, change
the fluid and filter every 30,000 miles
(50 000 km) for vehicles under
8600 GVWR or every
24,000 miles (40 000 km) for vehicles over 8600
GVWR. See “Automatic Transmission Fluid” in the Index for more
information.
Manual Transmission -Transmission fluid does not require periodic
changing.
Regulator Valve System for any worn, plugged or collapsed hoses. Have
the system checked as described in the Service Manual.
9.
CDRV SYSTEM INSPECTION* -Check
the Crankcase Depression
10. FUEL FILTER REPLACEMENT* -Replace the fuel filter at the specified
interval
or sooner if clogged.
11. SPARK PLUGS REPLACEMENT* -Replace spark plugs with the type
listed in Section
6. See “Specification Charts” in the Index.
12.
SPARK PLUG WIRE INSPECTION* -Clean wires and inspect for burns,
cracks or other damage. Check the wire boot fit at the distributor and at
the spark plugs. Replace wires as needed.
*An Emission Control Service
7-1 9
ProCarManuals.com

Scheduled Maintenance Sewices
When the wheels are removed for rotation, inspect disc brake pads f\
or wear
and rotors for surface condition.
Also inspect drum brake linings for wear and
cracks. Inspect other brake parts, including drums, wheel cylind\
ers, parking
brake, etc., at the same time. Remove any rust
or dirt from the wheel and
mounting surfaces before mounting the wheel.
Inspect brakes more often if driving habits or conditions resull In
frequent braking.
Owner Checks and Services
Listed below are owner checks and services which should be mad\
e at the
time period specified
to help ensure proper safety, emission performance, and
dependability of your vehicle.
Be sure any necessary repairs are completed at once. Whenever \
any fluids
or lubricants are added to your vehicle, make sure they are the proper ones,
as shown
in this Section.
At Least Once a Month
Tire inflation pressure check -Check the tires for proper inflation. If they
are low, inflate them
to the level specified on the certification label or on the
tire inflation charts. See “Loading Your Vehicle’’ or “Inflation-Tire Pressure” in
the Index.
At Least Once a Year
Key lock cylinder lubrication -Lubricate key lock cylinders with engine oil.
See the “Recommended Fluid and Lubricants’’ chart in this section.
Transmission neutral or clutch start switch operation
CAUTION
~
1. Before you start, be sure you have enough room around the veh\
icle.
2. Firmly apply both the manual parking brake and the regular brake. See
“Brakes” and “Parking Brake” in the Index.
Do not use the accelerator
pedal.
3. Be ready to turn off the engine immediately if it starts.
4. On automatic transmission vehicles, try to start the engine in each gear.
The starter should work only in
P (Park) or N (Neutral).
7-22
ProCarManuals.com

On manual transmission vehicles, put the shift lever in N (Neutral), push the
clutch down halfway, and try to start the engine. The starter should work only
when the clutch is pushed down all the way to the floor.
Steering column lock operation -While parked, try to turn the key to Lock
in each gear shift position.
With an automatic transmission, the key should turn to
Lock only when the
gear shift is in
P (Park).
On vehicles with a key release lever, try to turn the key to
Lock without
pressing the lever. The key should turn to
Lock only with the key lever
depressed.
On all vehicles, the key should come out only in
Lock.
Parking brake and transmission
P (PARK) mechanism operation -
CAUTION I
4 When you are doing this check, your vehicle could begin to move.
You
or others could be injured and property could be damaged.
Make sure there is
room in front of your vehicle in case you begin
to
roll. Be ready to apply the regular brake at once should the
vehicle begin to move.
IW
Park on a fairly steep hill, with the vehicle facing downhill.\
Keeping your foot
on the regular brake, set the manual parking brake.
To check the parking brake: With the engine running and the
transmission in
N (Neutral), slowly remove foot pressure from the regular
brake pedal.
Do this until the vehicle is held by the parking brake only.
To check the “Park” mechanism’s holding ability: Apply the \
regular brake
and shift to
P (Park). Release the manual parking brake, then slowly
release the regular brake.
Lap and shoulder belts condition and operation -Inspect belt system,
including: webbing, buckles, latch plates, retractors, guide loop\
s and anchors.
Have a belt assembly replaced
if the webbing has been cut or otherwise
damaged.
Body
Lubrication Service -Lubricate all body door hinges with engine oil.
Also lubricate the tailgate, tailgate handle pivot points, and tailga\
te mounted
spare tire carrier
(if equipped). Lubricate the body hood, fuel door and rear
compartment hinges, latches and locks including interior glove
box and
console
doors, and any folding seat hardware. Lubricate the hood safety lever
pivot and prop
rod pivot. More frequent lubrication may be required when
exposed to a corrosive environment.
7-23
ProCarManuals.com

Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or
specification may be obtained from your
GM Dealer.
USAGE I FLUID/LUBRICANT
Engine Oil
I
GM Goodwrench Motor Oil or equivalent for API Service SG
or SGlCE of the recommended viscositv.
Engine Coolant Mixture
of water and a good quality ethylene glycol base
antifreeze conforming
to GM-6038-M (GM Part No. 1052103).
Hydraulic Clutch System Hydraulic Clutch Fluid (GM Part
No. 12345347 or equivalent).
Hydraulic Brake Systems Delco Supreme
11
@ brake fluid (GM Part No. 1052535 or
DOT-3).
Parking Brake Cables
GM Lubricant (GM Part
No. 1052182) or equivalent.
Manual Steering Gear GM Power Steering
Fluid (GM Part
No. 1050017) or
Power Steering System Chassis grease meeting requirements of
NLGl Grade 2,
Automatic Transmission DEXRONB
HE Automatic Transmission Fluid (GM Part
No.
Catagory LB or GC-LB (GM Part No. 1052497).
equivalent conforming
to GM spec 9985010.
1051
855l.
Manual Transmission:
a. 5-Speed with Low Gear
b. Standard Transmission Fluid (GM Part
No. 12345349).
b. 5-Speed without Low Gear a.
CastrolB Syntorq or equivalent (GM Part
No.
1 2346074).
Differential:
a. Standard (Saginaw) Front
b. SAE-80W-90 gear lubricant (GM Part No. 1052271). b. Locking a.
SAE-80W-90 gear lubricant (GM Part
No. 1052271).
and Rear Axle
Transfer Case Gas Line De-lcer (GM Part
No. 1051516).
Gas Line DexronB
IIE Automatic Transmission
Fluid (GM Part No.
12345881).
Weather Strips
Category LB or GC-LB (GM Part
No. 1052497).
Chassis grease meeting requirements
of NLGl
Grade 2,
Clutch Fork Ball Stud Category
LB or GC-LB (GM Part
No. 1052497).
Shift Lever, and Propeller Shaft. Chassis grease meeting requirements
of NLGl Grade 2,
Column Shift, Transfer Case Spray-A-Squeek
(GM Part
No. 1052277).
(Continued next
page^
TO391
7-25
ProCarManuals.com

Scheduled Maintenance Services
Recommended Fluids & Lubricants
Hood Latch Assembly a. Pivots and spring anchor
b. Release Pawl
Front Wheel Bearings
Propeller Shaft Spline/Universal Joint
Automatic Transmission Shift Linkage, Floor
Shift Linkage, Hood and Door Hinges, Body
Door Hinge Pins, Tailgate Hinge and Linkage,
Folding Seat, Fuel
Door Hinge
Key Lock Cylinders
Zhassis Lubrication
Windshield Washer Solvent and Anti-Freeze
Neatherstrip
Mer Tailgate Handle Pivot Points a. Engine
oil (GM Part
No. 1050109).
b. Chassis grease meeting requirements
of
GM-6031-M (GM Part No. 1052497).
Chassis grease meeting requirements
of NLGl
Grade 2, Category LB or GC-LB (GM Part
No.
1052497).
Chassis grease meeting requirements
of
GM-6031-M (GM Part No. 1052497)
Engine oil
Use regular engine oil or
a synthetic light
weight engine oil
(SAE 5W-30).
Chassis grease meeting requirements
of
GM-6031 (GM Part No. 10524971.
GM Optikleen washer solvent (GM Part
No.
1051515) or equivalent.
Silicone grease (GM Part
No. 12345579) or
equivalent.
Multi-purpose lubricant meeting requirements
of
GM Part No. 12345120.
TO392
7-26
ProCarManuals.com

1 Add-on Equipment ................... 6-94
I- Electronic Heatinghir Conditioning
(See "Heating")
Adding Coolant
... 5.12, 5.14. 6-44
... Engine I
Air Cleaner ................................ 6-31
Block Heater
.......... 2.19. 3.5. 6-26
Cold Weather Starting (Diesel)
.................... 2-1 7
Coolant
....... 5.12. 5-1 4. 6.42. 6-96
Coolant Temperature Gage
...... 2-88
Diesel
................................ 6.6. 6-1 9
Crankcase
.................................. 6-96
Fan Noise
.................................. 5-1 7
Noise Control System
.............. 6-1 9
.-Identification,
............................ 6-95
Oil .(See "Oil")
Overheating
................................. 5-9
Running While Parked
............. 2-35
Equipment, Add-on
...................... 6-69
Exhaust System
................ 2.34, 6-65
Exhaust
........................... 2.34,
6-65
Starting
............................ 2.12, 2-1 5
F
Fan Noise ...................................... 5-1 7
Filter
. Replacement Chart ............ 6-99
Finish Care
............................................ 6-88
Damage
..................................... 6-90
Automatic Transmission
........... 6-33
Brake
.......................................... 6-49
Coolant
............................ 5-1 2. 6-42
Front Axle
.................................. 6- 40
Hydraulic Clutch
....................... 6-37
Leak Check
................................ 6-52
Manual Transmission
................ 6-36
Power Steering
............ 1 ............ 6-46
Radiator
....................................... 5-1 4
Fluid
9-3
Rear Axle .................................. 6-41
Recommended Fluids
.............. 7-25
. Transfer Case ............................ 6-39
Windshield Washer.
................. 6-48
Fog Lamps
.................................... 2-54 .
Four-wheel Drive ............... 2.36, 6-39
Transfer Case
................ .2-37, 6-39
Front Axle
................................. 6-40
Fuel (Diesel Engines)
..................... 6.6
Cold Weather Operation
............ 6-7
Filter Replacement
........ 6-1 1, 6.13,
6-99
Fuel Requirements
..................... 6-6
Gage
........................ ; ................. 2-87
Running Out Of
........................ 6-10
Tank Capacity
........................... 6-97
Water in Fuel
.............................. 627
Fuel (Gasoline Engines)
................. 6-4
Filling Your Ta'nk
....................... 6-16
Foreign
. Countries ..................... 6-15
Gage
.......................................... 2-87
Gasolines for Cleaner Air
......... 6-5 A-
Fuses and Circuit
Breakers
............................ 6-64, 6-1 01 * .
Fuse Block ................................ 6-65 . . f
Headlights .................... 6.64, 6-100
Power Windows and Other
Trailer Wiring Harness
.. 6.64, 6-1 00
. Windshield Wipers ...... 6-64, 6-100
G
Gages ............................................ 2.87
Coolant Temperature Gage
..... 2-88
Fuel Gage
.................................. 2-87
Odometer
................................... 2-76
Oil Pressure Gage
..................... 2-89
Speedometer.
............................ 2-76
Tachometer
..................... 2.76, 2-78
Trip Odameter 2-77
Voltmeter
................................... 2-90
-
-.
I
Power Options ......... 6.64, 6-100 :
. ...........................
...
ProCarManuals.com

Towing
A Trailer ...................................... 4-55
Maintenance
.............................. 4-61
Recommendations
................... 6-72
Turn Signals
.............................. 4-59
Traffic Lights
................................... 4-8
Trailer Brakes
.............................. 4-58
Trailering Package
........................ 6-69
Transfer Case
..................... 2.37. 6-39
Transmission
Automatic
.................................. 2-2 1
Five-Speed Manual ........ 2.24. 2-25
Fluid
................................ 6.33. 6-36
Fluid. To Add
................. 6.35. 6-37
Four-wheel
Manual Shift Speeds
............... 2-28
Shift Light
.................................. 2-27
Torque Lock (Automatic Transmission)
............. 2.30. 4-51
Trip Odometer
............................... 2-77
Turn SignaVMuItifunction Lever
.. 2.42
Indicator
...................... 2.43. 2-86
Following Distance
................... 4.59
Wiring Harness
.............. 2.91, 6-64
(See “Four-Wheel Drive”)
Turn SignaVLane Change
V
Damage Warnings ...................... 0-3
Vehicle Identification Number
............... 6-93
Loading
...................................... 4-26
Symbols
...................................... 0-4
Ventilation System
......................... 3-2
Air Vents
...................................... 3-3
Voltmeter
....................................... 2-90
Tips
............................................... 3.2
W
Warning
and Indicator Lights .... 2-78
Devices. Other
............................ 5-3
Wheels Alignment and Tire
Balance
.................................... 6-82
Aluminum
.................................. 6-89
Hub Caps and
Wheel Nut Caps
..................... 5-24
Nut Torque ..................... 6.51. 6-95
Replacement
............................. 6-83
Used Replacement
................... 6-83
Windows
........................................ 2-39
Sliding Rear
.............................. 2-40
Swing-Out
.................................. 2-40
Windshield Washer
...................... 2-46
Washer Fluid
............................ 6-48
Winter Driving
.............................. 4-52
Wipers, Windshield
........ 2-45, 6-64, 6-100
Blade Chatter
............................ 6-88
Blade Inserts
............................ 6-52
Cleaning Blades
........................ 6-88
9-7
ProCarManuals.com