1993 CHEVROLET S10 steering
[x] Cancel search: steeringPage 329 of 356
Downloaded from www.Manualslib.com manuals search engine Periodic Maintenance Inspections
Listed below are inspections and services which should be performed at least
twice a year (for instance, each spring and fall). You should let your GM
dealer’s service department or other qualified service center
do these jobs.
Make sure any necessary repairs are completed at once.
Steering and Suspension lnspectiont -Inspect front and rear suspension
and steering system for damaged, loose or missing parts, signs \
of wear or
lack of lubrication. Inspect power steering lines and hoses for\
proper hook-up,
binding, leaks, cracks, chafing, etc. (On vehicles equipped with manual
steering gear, check for seal leakage.) Lubricate the steering linkage.
Accelerator Control System -Lubricate all pivot points with engine oil,
except the
TBI throttle shaft. Do not lubricate the cam pulley. Remove all
external deposits from pulley. Do not oil any accelerator or cruise control
cables. Replace any cables that have high effort or excessive wear.
Exhaust System Inspection -Inspect the complete system. Inspect the body
near the exhaust system. Look for broken, damaged, missing or
out-of-position parts, as well as open seams, holes, loose connections or
other conditions which could cause a heat buildup in the floor pan or could
let exhaust fumes seep into the passenger compartments. See “\
Engine Exhaust” in the Index..
Drive Axle Service -Check rear/front axle fluid level and add as needed.
Check constant velocity joints and axle seals for leaking.
Transfer Case (four-wheel drive) lnspectiont -Every
12 months or at oil
change intervals, check front axle and transfer case and add l\
ubricant when
necessary. Oil the control lever pivot point and all exposed control linkage. \
Check vent
hose at transfer case for kinks and proper installation. More
frequent lubrication may be required on off-road use.
tA fluid loss in these systems may indicate a problem. Have them inspected
and repaired at once.
7-1 3
Page 330 of 356
Downloaded from www.Manualslib.com manuals search engine i
I
Scheduled Maintenance Services
Recommended FIuids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or \
specification may be obtained from your
GM Dealer.
USAGE FLUlD/LUBRICANT
Engine Oil GM Goodwrench Motor Oil or equivalent for API Service SG
or SGICC, SG/CD, SF, SG or CC
of the recommended
viscosity. (See Section 6.)
Engine Coolant Mixture
of water and a good quality ethylene glycol base
antifreeze conforming
to GM-6038-M (GM Part No. 1052103).
Hydraulic Clutch System Hydraulic Clutch Fluid (GM Part No. 12345347 or equivalent).
Hydraulic Brake Systems Delco Supreme 11 brake fluid (GM Part No. 1052535 or
Parking Brake Cables Chassis lubricant meeting requirements
of NLGl Grade 2,
Power Steering System GM Power Steering Fluid (GM Part No. 10\
50017) or
Manual Steering Gear GM Lubricant (GM Part
No. 1052182) or equivalent.
Automatic Transmission DEXRONBIIE Automatic Transmission Fluid (GM Part No.
Manual Transmission:
DOT-3).
Catagoty LB or GC-LB (GM Part No. 1052497).
equivalent conforming
to GM spec 9985010.
1051
RKK).
a. 5-Speed (RPO ML3 and a. DEXRONBIIE Automatic Transmission Fluid (GM Part
b. 5-Speed (RPO MY2) b. Synchromesh Transmission Fluid (GM P\
art No. 12345349).
MW1) No. 1051855).
Differential:
a. Standard - Front and
a. SAE-80W-90 GL-5 gear lubricant (GM Part No.
b. Locking
b. SAE-80W-90 gear lubricant (GM Part No. 1052271).
Transfer Case DEXRONBIIE
Automatic Transmission Fluid (GM Part No.
Column Shift, Transfer Case Chassis lubricant meeting requirement\
s of NLGI Grade 2,
Shift Lever, Propeller Shaft Slip Catagory LB or GC-LB (GM Part No.\
1052497).
Splines and Universal Joints.
Clutch Linkage. Pushrod
to Chassis lubricant meeting requirements of NLGl Grade 2,
clutch fork joint. Catagory LB or GC-LB (GM Part No. 1052497).
Rear Axle 1052271).
1051 855).
(Continued next page) TO289
7-1 4
1
Page 350 of 356
Downloaded from www.Manualslib.com manuals search engine I
If You’re Stuck In Sand. Mud
Ice. or Snow
............................. 5-30
Ignition Switch ................................ 2-9
Inflation-Tire Pressure ................. 6-44
Instrument Panel ............... 2-58, 2-62
Digital Cluster ................ 2-61, 2-62
Standard Cluster ............ 2-59, 2-60
J
Jack Storage ...................... 5-17, 5-27
Jump Starting ................................. 5-3
K
Key Release Lever ....................... 2-1 1
Keys ................................................. 2-3
L
Lights ........ ................................... 2-46
Brake System Warning ............ 4-1 6
Bulb Replacement .................... 6-31
Charging System Light ............ 2-70
Check Gages Light ................... 2-71
Dome Lights ............................. 2-50
Fog Lamps ................................. 2-47
Indicator ........................ ..2-65, 2-70
Headlights (See “Headlights”)
Malfunction Indicator
.... 2-68, 6-37
Operation ................................... 2-37
Service Engine Soon ............... 6-37
Rear ............................................ 6-33
Loading Information .4-23, 6-38, 6-41
Loading Your Vehicle ........ 4-23, 6-38
Lubrication .................................... 6-35
Front Parkingnurn Signal ........ 6-32
Replacement Chart ................... 6-63
Accelerator Control System .... 6-35
Body ........................................... .- 36
Front Axle ........................ ..... 6-22
Front Suspension and
Steering Linkage
................... 6-34
Front Wheel Bearings
(Two-Wheel Drive)
................ 6-34
Tailgate Handle ......................... 6-36
Hydraulic Clutch Grease
Fitting
..................................... 6-34
Hood Latches and Hinge ........ 6-36
Lock Cylinders .......................... 6-36
Propeller Shaft Slip
SplineslUniversal Joints
....... 6-36
Rear Axle .................................. 6-21
Recommended Lubricants ...... 7-14
Transfer Case ............................ 6-21
M
Other Items ............................... 6-34
Periodic Inspections ................ 7-13
Record ....................................... 7-16
Scheduled Maintenance ............ 7-3
Underbody ................................. 6-55
Master Cylinder (See “Brakes”)
Mirrors
........................................... 2-50
Convex Outside ........................ 2-51
inside ......................................... 2-51
Outside ...................................... 2-51
Vanity ......................................... 2-52
Model Reference ............................... iii
Maintenance
0
Odometer ............................ 2-62, 2-63
Off-Road Driving (See “Driving”)
Off-Road Recovery
...................... 4-1 9
Oil .................................................... 6-9
Additives .................................... 6-13
Disposal of Used ...................... 6-14
Pressure Gage .......................... 2-69
To Check .................................. 6-10
What Kind to Use .................... 6-11
When to Add ............................ 6-10
When to Change ...................... 6-13
Owner Checks and Services ...... 7-11
P
On Hills ........................... 4-48, 4-61
Torque Lock (Automatic
Parking
Over Things That Burn
........... 2-25
Transmission) .............. 2-22, 4-50
Page 351 of 356
Downloaded from www.Manualslib.com manuals search engine Your Vehicle (Manual
Transmission)
........................ 2-24
Parking Brake
............................... 2-21
Passing Other Vehicles
.... 4.20. 4-60
Pavement Markings
........................ 4-7
Payload Capacity
.......................... 6-39
Periodic Maintenance
Inspections
................................ 7-1 3
Power
Door Locks
.................................. 2-7
Steering
...................................... 4-1 7
Steering Fluid
............................ 6-27
Winches
.................................... 4-62
Product Service Publications
........ 8-6
R
Radiator Pressure Cap ................ 6-26
Radio (See “Audio Systems”)
Recommended Fluids
And Lubricants
.......................... 7-1 4
Recovery Hooks
........................... 5-31
Replacement Parts
....................... 6-61
Reporting Safety Defects
.............. 8-5
Road Signs
..................................... 4-2
Roadside Assistance
...................... 8-5
Rocking Your Vehicle
................... 5-30
S
Safety Belts
Cleaning
..................................... 6-53
Checking Restraint System
..... 1-35
Child Restraints
........................ 1-26
Small Children and Babies
...... 1-24
Extender
.................................... 1-35
Lap
............................................. 1-22
Lap Shoulder
............................. 1-1 5
Larger Children ......................... 1-32
Proper Wear
.............................. 1-1 4
Questions and Answers
........... 1-1 2
Reminder Light
......................... 1-1 3
Replacing After a Crash
.......... 1-35
Use During Pregnancy
............. 1-20
Why They Work
.......................... 1-9 Safety Chains
............................... 4-59
Scheduled Maintenance
Seats Safety Warnings and Symbols
.... 0-2
Services
....................................... 7-3
Controls
....................................... 1-2
Jump
............................................ 1-6
Latches
........................................ 1-4
Manual Front
.............................. 1-2
Manual Lumbar Adjustment
..... 1-4
Reclining
...................................... 1-3
Do-It-Yourself
.............................. 6-3
Parts Identification Label
........ 6-59
Publications ......................... 8-6, 8-8
Replacement Parts and Filter Recommendations
...... 6-66
Service Engine Soon Light
........ 2-68
Service Station Checks
............... 7-17
Shift Indicator Light
.................... 2-72
Shift Light
..................................... 2-20
Shifting Into Park
........................ 2-23
Sliding Rear Window
.................. 2-32
Easy Entry Seat
......................... 1-5
Service
Spare Tire
..................................... 5-20
Removal
..................................... 5-20
Storage
...................................... 5-27
Speedometer
................................ 2-62
Starting Your Engine
................... 2-11
Steering
......................................... 4-17
Tips
............................................ 4-18
Storage Compartments
............... 2-55
Sun Visors
.................................... 2-52
Swing-Out Windows
.................... 2-32
T
Tachometer ................................... 2-65
Tailgate
.......................................... 2-33
Theft
................................................ 2-8
Thermostat
.................................... 6-26
Tilt Wheel
..................................... 2-34
Specification Charts .................... 6-61
In Emergencies
........................ 4-18
9-5