1993 BUICK REGAL steering

What to Add:
Refer to the Maintenance Schedule to determine what
kind of fluid to use. See “Recommended
Fluids and
Lubricants” in the Index.
Windshield Washer Fluid
To Add:
I -1
I NOTICE: I
When adding power steering fluid or making a
complete fluid change, always use the proper
fluid. Failure to use the proper fluid can cause
leaks and damage hoses and seals.
1
A
4 LA ..
11
Open the cap labeled “WASHER FLUID ONLY.” Add
washer fluid until
the bottle is full.
ProCarManuals.com

Explanation of Scheduled Maintenance
Services
Below are explanations of the services listed in Schedule
I and Schedule 11.
The proper fluids and lubricants to use are listed in
Section D. Make sure whoever services your vehicle uses
these. All parts should be replaced and all necessary
repairs done before
you or anyone else drives the vehicle.
NOTE: To determine your engine’s displacement and
code, see “Engine Identification” in the Index.
1. Engine Oil and Filter Change* -- Always use SG
Energy Conserving I1 oils of proper viscosity. The
“SG” designation may be shown alone or in
combination with others, such as “SG/CC”, ,“SG/CD”
or
“SF, SG, CC,” etc. To determine the preferred
viscosity for your vehicle’s engine (e.g., SAE 5W-30
or SAE 10W-30), see “Engine Oil”
in the Index.
2. Chassis Lubrication -- Lubricate the transaxle shift
linkage, parking brake cable guides, underbody
contact points and linkage. If your vehicle is
equipped with grease fittings, lubricate
the
suspension and steering linkage. 3.
Throttle Body Mounting
Bolt Torque* -- Check
the torque
of the mounting bolts and/or nuts.
4. Tire and Wheel Rotation and Inspection -- For
proper wear and maximum tire life, rotate your tires
following the instructions
in this manual. See “Tires,
Inspection
& Rotation” in the Index. Check the tires
for uneven wear or damage. If you see irregular or
premature wear, check the wheel alignment. Check
for damaged wheels also.
5. Engine Accessory Drive Belt(s) Inspection --
Inspect the belt(s) for cracks, fraying, wear and
proper tension. Replace as needed.
6. Cooling System Service* -- Drain, flush and refill
the system
with new or approved recycled coolant
conforming to GM Specification 1825M. Keep
coolant at the proper mixture as specified. See
“Coolant”
in the Index. This provides proper freeze
protection, corrosion inhibitor level and engine
operating temperature.
Inspect hoses and replace
if they are cracked,
swollen or deteriorated. Tighten screw-type hose
clamps. Clean the outside
of the radiator and air
* An Emission Control Service.
The
U.S. Environmental Protection Agency has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior tothe completion of vehicle useful life. General Motors, however, urges that all recommended maintenance \
services he performed at the indicatcd intervals and the maintenance be recorded in ”Section E:Maintenance Record”.
274
ProCarManuals.com

CHECK OR
Steering
Column Lock
WHAT TO DO
While parked, and with the parking
brake set, try to
turn the key to
“LOCK”
in each shift lever position.
The key should turn to “LOCK”
only when the shift lever is in “P’
(Park).
“LOCK.”
0 The key should come out only in
-t
CHECK OR
SERVICE
Parking Brake
and Automatic
Transaxle
“P’
(Park)
Mechanism
Check
WHAT TO DO
.r
CAUTION: When you are doing
s check, your vehicle could
begin to move. You or others
-Ad be injured and property
Jld be damaged. Make sure
rllzre
is room in front of your
U4icle
in case it begins to roll.
__ ready to apply the rnnular
brake at once shoul the
vehicle begin
to mc 5.
Park on a fairly steep hill, with the
vehicle facing downhill. Keeping
your foot on the regular brake, set
the
parking brake.
To check the parking brake: With
the engine running and transaxle
in“N” (Neutral), slowly remove
foot pressure from
the regular
brake pedal.
Do this until the
vehicle is held by the parking brake
only.
To check the “P,’ (Park)
mechanism’s holding ability: Shift
to
“P” (Park). Then release all
brakes.
278
ProCarManuals.com

CHECK OR
I SERVICE WHAT TO DO
Underbody
Flushing At
least every spring, use plain water
to flush any corrosive materials from
the underbody. Take care to clean
thoroughly any areas where mud and
other debris can collect.
Section C: Periodic Maintenance
Inspections
Listed below are inspections and services which s ,hou !Id
be performed at least twice a year (for instance, each
spring and fall).
You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
INSPECTION
OR SERVICE
Steering,
Suspension and
Front-Wheel- Drive Axle
Boot and Seal
Inspection
Exhaust System
Inspection
Throttle Linkage
Inspection
WHAT SHOULD BE DONE
Inspect the front and rear suspension
and steering system for damaged, loose or missing parts, signs of wear,
or lack of lubrication. Inspect
the
power steering lines and hoses for
proper hookup, binding, leaks,
cracks, chafing, etc. Clean and then
inspect the drive axle boot seals for
damage, tears or leakage. Replace
seals
if necessary.
Inspect the complete exhaust
system. Inspect the body near
the
exhaust system. Look for broken,
damaged, missing or out-of-position
parts as well as open seams, holes,
loose connections, or other conditions which could cause
a heat
build-up
in the floor pan or could let
exhaust fumes into the vehicle. See
“Engine Exhaust”
in the Index.
Inspect the throttle linkage for
interference or binding, and for
damaged or missing parts. Replace
parts
as needed.
279
ProCarManuals.com

~~ - -
USAGE
FLUID/LUBRICANT
Hydraulic
Brake
(GM Part No. 1052535) or
System Delco Supreme 1 l@ Brake Fluid
equivalent DOT-3 brake fluid.
Parking Brake
Category LB or GC-LB (GM Part
requirements
of NLGI Grade
2,
Guides Chassis lubricant meeting
No.
1052497
or equivalent).
Power Steering
Transmission Fluid (GM Part No.
Transaxle DEXRON@
IIE Automatic
Automatic (GM Part
No. 1052884) or
System GM
Hydraulic Power Steering Fluid
equivalent.
1234588 1)
Key Lock Lubricate with Multi-Purpose
Cylinders Lubricant (GM
Part No. 12345120),
synthetic SAE 5W-30 engine
oil or
silicone lubricant (GM Part No.
1052276 or 1052277).
Automatic
Transaxle Shift Engine oil.
Linkage
USAGE
Chassis
Lubrication
Windshield
Washer Solvent
Hood Latch
Assembly
a. Pivots and
b. Release Pawl
Spring
Anchor
i
Hood and Door
Hinges
Fuel
filler Door
Hinge and
Striker Plunger
Weatherstrips
FLUIDlLUBRICANT
Chassis lubricant meeting
requirements
of NLGI Grade 2,
Category LB or GC-LB (GM Part
No. 1052497 or equivalent).
GM Optikleen@ Washer Solvent (GM
Part No.
105 15 15) or equivalent.
a. Engine oil.
b. Chassis lubricant meeting
requirements
of NLGI Grade 2,
Category LB or GC-LB (GM Part
No. 1052497 or equivalent).
Engine
oil or Lubriplate Lubricant
(GM Part No. 1050109).
Chassis lubricant meeting
requirements
of NLGI Grade 2,
Category LB
or GC-LB (GM Part
No. 1052497 or equivalent).
Dielectric Silicone Grease (GM Part
No. 12345579 or equivalent).
See “Specifications Chart” in the Index for recommended
replacement filters, valves and spark plugs.
301
ProCarManuals.com

Acc (Ignition Key Position) ........................ 66
Adding Brake Fluid
................................... 233
Electrical Equipment
.......................... 256
Engine Coolant
....................... i ....... 228
Engine Oil
.................................... 220
Power Steering Fluid
.......................... 231
Transaxle Fluid
............................... 226
Windshield Washer Fluid
....................... 232
Additives. Engine Oil
............................. 223
Adjustment. Brake
............... : ............... 143
Adult Safety Belt Usage
............................ 26
Aircleaner
...................................... 225
Airconditioner
................................. 110
Air Outlets
..................................... 1 10
Alcohol, Driving Under the Influence of
.............. 135
Alcohol in Gasoline
.............................. 215
Aluminum Wheels, Cleaning
....................... 252
AM Radio Reception
............................. 113
AM Stereo Radio Reception
........................ 1 14
Antenna Care
..................................... 124
Antifreeze
...................................... 228 Antilock Brake System
.......................... 140
Anti-Theft Tips
.................................. 64
Appearance Care
................................ 248
Appearance Care and Materials
....................... 255
Armrest. Storage
................................... 98
Ashtrays
........................................ 96
Astroroof
....................................... 80
Audio Systems
.................................. 113
Automatic Door Locks
............................. 61
Automatic Lap-Shoulder Belt
........................ 27
Automatic Overdrive
.............................. 72
Automatic Transaxle
.............................. 71
Automatic Transaxle Fluid
......................... 226
Automatic Transaxle Torque Lock
.. ; i : .............. 165
Antilock
Braking' System Warning Light
.............. 103
Automatic Safety Belt. Use With Child Restraint
........ 42
Baby. Holding a
.................................. 41
Battery
........................................ 235
Battery Cables. Starting With
....................... 180
Blizzard. If You're Caught in a
..................... 168
293
ProCarManuals.com

......................
?.'rrrrir.rr.*..s ..r.. *rrrlr)ry)r* 14p A ..
..... * ......... L . li e 0 $ 1 .... . i., . 5 ; ....... ?. . * .
Camper. Towing a .............................. 170
Capacities and Specifications ................... 263. 264
Car Jack Instructions ............................. 201
Carbon Monoxide in Exhaust ....................... 78
Care. Appearance ................................ 248
Care. Finish .................................... 252
Carrier. Luggage ................................. 99
Cassette Tape Player Care ......................... 123
Cautions. Safety .................................. 10
Cellular Telephone. Adding a ...................... 114
Chains. Tire .................................... 247
Changing a Flat Tire ............................... 201
Checking Cap. Radiator Pressure
............................ 231
CB Radio. Adding a .............................. 114
Change the Oil. When to .......................... 221
Check Gages Light ............................... 106
Brake Fluid .................................. 233
Engine Coolant ............................... 228
Engine Oil Level .............................. 220
Power Steering Fluid .......................... 231
Safety Belt Systems ............................ 55
Transaxle Fluid ............................... 226
Under the Hood ............................... 218
Windshield Washer Fluid ....................... 232
Chemical Paint Spotting ........................... 254
.
ProCarManuals.com

Defrost ........................................ 112
Dimensions
.................................... 261
Disc Brake Wear Indicators
........................ 142
Disposal of Used Oil
............................. 224
DoorLocks
...................................... 59
Down Hills and Mountains. Driving
................. 16 1
Downhill Parking ................................ 163
Driving
Downshifting
.................................... 73
AtNight .................................... 149
Defensively
.................................. 134
Drunk
...................................... 135
In a Foreign Country
........................... 2 16
InCities
..................................... 156
In
Fog. Mist or Haze ........................... 154
InRain ..................................... 152
InWinter
.................................... 166
OnCurves ................................... 144
On Freeways
................................. 157
On Hill and Mountain Roads
.................... 16 1
On a Long Trip ............................... 159
On Snow or Ice
............................... 167
Through Deep Standing Water
.................... 70
Drunken Driving
................................ 135 Electric
Outside Rearview Mirror Control
............ 94.
Electrical Equipment. Adding .................. 114. 256
Emergencies. Braking
............................ 143
Etnergencies
on the Road .......................... 177
Emergencies. Steering
in .......................... 145
Emergency Starting. Discharged Battery
.............. 180
Emergency Wrecker Towing
....................... 185
Energy Conserving Oil ............................ 221
Engine
Block Heater
.............................. 70. 224
Coolant
..................................... 228
Coolant Temperature Warning Gage
.............. 103
Oil ......................................... 220
Oil Additives
................................. 223
Oil Pressure Warning Gage
...................... 104
Oil. When to Change .......................... 221
Starting
...................................... 67
Wa-ning Light About Need for Service ............ 107
Ethanol
in Gasoline .............................. 215
Exhaust
......................................... 78
Expectant Mothers. Use of Safety Belts by ............. 33
Expressway Driving .............................. 157
Extender. Safety Belt .............................. 55
Exterior Appearance
............................. 251
Overheating
.................................. 192
296
ProCarManuals.com