1992 VOLKSWAGEN TRANSPORTER turn signal bulb

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Changing bulbs

Before
starting to replace a bulb, switch off
the light concerned.

Do
not touch the glass part of the new bulb

with
bare fingers because the finger marks
left
on the glass evaporate when the bulb

becomes
hot, the vapour settles on the re­
flector and dims it.

Always
use the same type of bulb. The
des­

ignation is marked on the base of the bulb
or on the
glass.

It is advisable to always a carry a box of

spare
bulbs in the vehicle. These can be ob­
tained from Volkswagen dealers. It should contain at least the following bulbs which
are essential for traffic safety:
12 V 60/55 W Headlight (H4)

12V21W
Turn signal

12V21/5W
Brake
and tail light
12 V4W
Side
light

12V5W

Glass
base
Number
plate light
Headlights

The
headlight bulbs can be reached through
the opened bonnet.
• Pull off the connector.
• Pull cap off.
•
Squeeze
the spring clip of the bulb holder together and pull down.
• Take the bulb out and insert the new bulb
so
that
the locating lug on the bulb plate en­

gages
the recess in the reflector. The centre
of the three terminals on the bulb base is
then at the top.
• Fold the spring clip over bulb
base.
Squeeze
the clip together and engage it in
the retaining lugs.
•
Press
the cap back on.
• Attach the connector.
• Have the headlight beam alignment
checked.
Side
light
bulb

The
side light bulbs are located in the head­ light reflectors.
• Turn the bulb holder fully to the
left
and take it out of the reflector.
•
Press
the defective bulb into the holder,
turn
it to
left
and take it out.
• Insert the new bulb.
• Insert the bulb holder in the reflector and
turn
the holder fully to the
right.

124
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF

Front
turn
signals

To
change a bulb the
turn
signal housing must be taken out to the
front.

•
Insert
the
flat
blade of a screwdriver be­ tween headlight and
turn
signal
with
bonnet
open.
This presses the securing tabs which hold the
turn
signal housing to the
side.

• Swing screwdriver to
front
as shown in illustration so
that
the
turn
signal housing is

pressed
out forward. • Turn bulb holder out to the
left.

• Turn bulb out and renew.
•
Insert
bulb holder. •
Insert
turn
signal housing in the grooves provided (top and
bottom)
and press it in
until
the securing tabs engage.

Fog
lights*

The foglight bulbs can betaken out from un­
derneath the bumper.
• Turn cap on rear of fog
light
to the
left
to remove it.
• Unhook spring clip of bulb holder and swing it away.
• Take bulb out.
•
Insert
new bulb so
that
the locating lug on bulb plate engages
recess
in the reflec­
tor.
• Swing spring clip over bulb plate,
squeeze
it together and engage it in the re­
taining lugs.
• Fit cap again.
• Have beam alignment
checked.
Rear
lights

Renewal
of the bulbs for the rear lights is
done from the luggage compartment
through the rear panel trim.
•
Reach
into
the hole in the rear panel
trim
with
one hand and squeeze the two retain­ing tabs of bulb carrier together.
• Take bulb carrier out (illustration). •
Press
defective bulb
into
holder slightly,
turn
it to the
left
and take it out.
•
Insert
new bulb and
turn
fully to the
right

• Install bulb carrier.

125
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
ALPHABETICAL
INDEX

A
Acceleration
figures 142

Accessories
117 Activated charcoal
filter
138
Additional heater 62
Additional water heater 67
Adjusting brake pressure regulator . . 155
Adjusting headlights 128 Adjusting washer
jets
108

Air
cleaner 100

Air
conditioner 57

Air
distribution 55

Alloy
wheels 91

Analog
clock 46

Anti-dazzle
inside mirror 13
Anti-freeze 101 Anti-locking brake system (ABS) .... 30
Arduous operating conditions 115
Armrests 21

Ashtrays
73
ATF
99
Automatic gearbox 32
Automatic wash plants 88
Auxiliary heater 63
Axle
loads 148

B

Battery 106
Belt height adjustment 16
Blower
55
Bonnet 94
Brake
fluid
104
Brake
servo 30

Brake
system 104

Brake
warning lamp 48
Brakes
29, 139
c

Capacities
153

Capacity
141

Care
of body 88
Care
of car 88

Catalyst
137

Cavity
preservation 92
Central
locking system 8

Cetane
Number 87
Changing
bulbs 124

Changing
front
turn
signal bulb 125

Changing
wheels 120

Chassis
number 154
Checks
when
filling
the
tank
160

Child
safety 18

Child
seats 18
Child-proof catch 9 Cigarette lighter 73

Cleaning
and anti-corrosion
treatment
of engine compartment 91

Clock
46

Cold
starting aid 38

Combined
weight 151

Compression
ratio
141
Consumption figures 143

Coolant
additive 101
Coolant
level 47, 102
Coolant
temperature - Gauge 41

Cooling
system 101

Cruise
control system 53
D
Dash
panel 4

Dashboard
and controls 4
Defrosting windows 56, 58

Diesel
fuel 87
Dimensions
152
Dip lever 52
Dipstick - Automatic gearbox 99
- Engine 97
Direction indicators 48
Do-it-yourself 118

Door
locks 9

Doors
9 Drawbar weight 83
Driver's seat 20
Driving abroad 115
Driving on holiday 115
Driving safely 78 Driving tips 76

E

Electric
socket 73

Electric
window
lifters
12

Emergency
lights 51
Emergency
starting 130

Emission
control system 137
56
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans