1992 VOLKSWAGEN TRANSPORTER Owners Manual

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

Warning
lamps

~ne layout of the warning lamps depends on
:ne model and the engine fitted. The sym-
: ols shown here are also on the actual warn-ng lamps.
|- Coolant temperature/ coolant level 47
1- Engine oil pressure 47
I- High beams 48
-- Turn signals 48

5-
Brake system 48
V Alternator 49
" Glow plugs 49 Coolant
temperature/

Coolant level1'

This
lamp flashes for a few seconds as a
functional check when ignition is switched
on.

If the lamp does not go out afterwards or

flashes
when driving, either the coolant
temperature is too high orthe coolant level1'
too low:
Stop,
switch
engine
off and check

level.
Add coolant if necessary.
11 Only on vehicles
with
automatic coolant level monitor(see page 102).
Attention

• Be
careful
when
opening the

coolant
expansion
tank!
When
the
engine
is hot the cooling
sys­

tem is
under
pressure -
Danger
of scalding!
Therefore
let
engine
cool
down
before
unscrewing

the cap.
• Do not
touch
the fan. The fan can
switch
on suddenly -
even

when
ignition
is
switched
off.

For
further details see pages 102 and 103.
If the coolant level is in order the trouble
may be due to failure of the radiator fan.

Check
radiator fan fuse and renew if
necessary-seepage
122.
If the warning lamp does not go out al­
though coolant level and fan fuse are in order, do not
drive
on - call in expert as­

sistance.

If the trouble is only caused by the fan and

assuming
coolant level is in order and tem­ perature warning lamp is out - one can drive
on to the nearest Volkswagen dealer. In
order to make good use of the air stream for

cooling,
do not let engine idle or drive very
slowly.
2 - Engine oil pressure -7
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND EQUIPMENT

The
warning lamp flashes when ignition is
switched
on. the lamp must go out when

engine
has started.
If the warning lamp does not go out or

flashes
when driving - a buzzer also sounds
at engine speeds above 2000 rpm - stop,
switch
engine
off, check oil level and if
necessary,
add oil - see page 97.
If the lamp comes on although the oil level

is
in order, do not
drive
on. Do not even
run the engine at idling speed-call in expert

assistance.

Note

The oil pressure
warning
lamp
is not an oil
level
indicator.
The oil
level
should
therefore
be checked at reg­

ular
intervals,
preferably
every
time

the
fuel
tank
is filled.
3 -
High
beams 10 4 - Turn signals

The
warning lampflashes when
turn
signals

are
switched on. If a
turn
signal fails, the
warning lamp flashes twice as fast. (Not
when towing a trailer).

Further
details are given on pages 49

and
52. 5 -
Brake
system «^

The
warning lamp comes on when
• the handbrake is on
• the brake fluid level is too low
The
ignition must be switched on.

Attention
If the
lamp
does not go out
when

handbrake
is released or comes
on
when
driving, the
fluid
level
in
the reservoir is too low. If an in­ crease in
pedal
free
travel
is no­

ticed
at the same
time,
one of the
brake
circuits may
have
failed.
You can
drive
on
carefully
to the

nearest
Volkswagen
dealer
but

allow
for
higher
pedal
pressures and longer
braking
distances on
the way.

The
warning lamp comes on when high
beams
are on or when the headlight flasher

is
used.

48
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

6-Alternator
Q

~ne warning lamp comes on when the
igni-

I
on
is
switched on and must go out when

She
engine
is
started.
i the warning lamp comes on when driving,

stop,
switch
engine
off
and
check
the
alternator V-belt.
f the V-belt
is
broken or loose do not
drive

on with
a
vehicle which
has a 4 cylinder
engine
because the coolant pump
is
then
no
longer being driven. The V-belt must
be

tensioned
or
renewed.
ehicles with
a 5
cylinder engine
can
nor­
mally
be
driven to the nearest Volkswagen
dealer when
the
V-belt
is
broken
or
loose oecause
the
coolant pump
is
driven separ­
ately but then the battery will discharge
con­

tinuously
and all
non-essential electrical consumers should
be
switched
off.

f the warning lamp comes on although
the

belt
is
not broken, one can normally drive on

to
the nearest Volkswagen dealer (all engine

types)
but the
battery will then discharge
continuously
- see
previous paragraph.
7-Glow
plugs
W

(Diesel engines only)

When
the engine
is cold
the warning lamp comes on when key
is
turned to Drive
posi­

tion
(ignition on).

If
the warning lamp does not come
on,
there
is
a
defect in the glow plug system
-
call
in

expert assistance.

When
the
lamp goes out,
start
the engine
immediately
-
see page
38.

When
the
engine
is warm the
glow plug
lamp
does
not
come on -the engine can
be

started straight
away.
(®)
-
Anti-locking
Brake

System
(ABS)*

The operational readiness
of the
essential electrical components
of the ABS are

checked,
both before moving off and when

driving,
by an electronic monitoring system.
The warning lamp lights up when
the
igni­

tion
is
switched on and
it
must go out again, at the latest, after the engine
has
started.

If
the warning lamp does not go out
or if it

comes on when driving the system
is
not
in

order.
The
vehicle can then only
be
braked
with
the
normal system
-
that
is
without
ABS-.The vehicle must be taken to a Volks­
wagen Dealership
as
soon
as
possible.
Further details on ABS
is
given on page
30.

<]1i>
-
Trailer
turn
signals

The warning lamp
*
flashes when turn
sig­
nals are switched on when towing
a
trailer.

If a
turn signal fails on the trailer or vehicle,
the warning lamp does not flash.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT

JB70-
1251

Switches

Notes
• On vehicles
with
righthand drive the ar­ rangement of the switches differs. The

symbols
on the switches are however the

same
as on vehicles
with
lefthand drive.
• The use of the lighting described here is subject to local regulations.
1 -
Lighting
switch
-n

First
detent -side lights11

Second
detent -headlight high/low beams
The
headlights only work when the ignition

is
on. When the engine is being started and
after ignition has been switched off, the headlights are switched off automatically.

When
the side lights are on, a warning lamp lights up in the switch.

When
the lights are on, the level of the in­ strument lighting can be regulated by turn­ing the knurled disc on the
right
of the

switch.

Dipping and flashing the headlights - see

page
52. 2 -
Headlight
range
control
* %\_)
With the electrical range control the
head­
light settings can be matched exactly to the
load
condition of vehicle. This prevents on­
coming traffic from being
dazzled
more than

is
unavoidable. At the same time the correct headlight beam setting provides the best

possible
visibility for the driver.

The
headlights can only be regulated
with

the dipped headlights switched on.
To
lower the beams,
turn
knurled disc from
the
basic
position (-) downwards.
Note

The
basic
headlight setting (only possible
with
headlight adjusting appliance) must al­

ways
be done
with
the headlight headlight range control knurled disc in the
basic
posi­

tion (-) - see page 128
also.

On
vehicles for some export countries when
the side lights are switched on
with
the igni­
tion switched on, the dipped headlights also

come
on
with
reduced intensity.
50
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

3
-
Emergency lights .
nen the emergency lights are on, a warn-
'z lamp in the switch flashes as well.
Ine system also works when the ignition is
;
.-.itched off.

4
-
Knurled wheel for seat
^Jf
heating*

~~e cushion and backrest of the
front
seats
:
=
n
be heated electrically when the ignition
s
on.

_~e
heating is switched on and regulated .vth the knurled wheel.

•
switch heating off,
turn
knurled wheel to

:_e
left
to the detent position.
5
-
Heated rear window
QpJ

The
heating works only when ignition is on.

When
heater is on a lamp in the switch lights up.

As soon
as
window
is
clear,

switch element
off. The
reduced
current consumption helps
to re­

duce
the
fuel
consumption
- see
also
page
80.

On
vehicles
with
electrically adjustable ex­
terior mirrors the mirrors are heated as long

as
the rear window heating is switched on.
6
-
Fog lights •/
|Q

Rear fog light

First
detent - fog lights

Second
-
front
and rear fog
detent lights, or rear fog
light
only

At the second position a warning lamp in the switch comes on.

The fog lights
work
with
the side lights (ignition on), low or high beams.

The rear fog light
works only
with
the fog lights or
with
the low or high beams.

Due
to the amount of
dazzle
it
causes
the

rear
fog
light
should only be switched on
when the visibility is very poor (in Germany
for example, below 50 metres).

Note
The
electrical system of the factory
fitted

tow bar* is wired-up so
that
when towing

a
trailer
fitted
with
rear fog lights, the rear
fog
light
on the towing vehicle are automati­
cally
switched off.
51
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND EQUIPMENT
Turn signal and dip
lever

The
turn
signals only work when the ignition
is
switched on.

Right
turn
signals - lever up
Left
turn
signals - lever down

When
turn
signals are working, the warning lamp flashes as well - see page 48
also.

The
turn
signals cancel automatically after
completing a turn. To
signal
a
lane
change

Move
lever up or down to pressure point

and
hold in this position - the warning lamp must also be flashing.
To dip
headlights
Pull
lever past pressure point towards steer­
ing wheel. When high beams are on, the
high beam warning light will light up.
Headlight
flasher
Pull
lever towards steering wheel to pres­

sure
point - the high beam warning lamp lights up.

Parking
lights

The
parking lights only work when ignition
is
switched off.

Right
parking lights - lever up
Left parking lights - lever down. Note

The
use of the signals and lighting described
here
is subject to local regulations.

52
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND
EQUIPMENT

Cruise
control
system* : "elieve the
foot
on the accelerator pedal

~ -
s system can hold any speed aboveabout output

is'mits.

Attention

The
cruise
control
system
should not be used in
dense
traffic
and

poor
road
conditions
(slippery

surfaces,
aquaplaning,
gravel).

iVhen
system
is
switched
on do not

•nove
into
neutral
without
depres­

sing the
clutch
pedal,
otherwise
the

engine
will
race
and can,
under
cer­

tain
circumstances,
become
dam­
aged.
B
A
|B
33
- 696[
The
system
is
operated
with
the sliding switch A and the press
button
B on the
turn

signal lever.
The system is
switched
on by moving switch A to I.
When the speed to be maintained has been reached the press
button
B (FIX) must be

pressed
briefly. The
foot
can then be taken
off the accelerator pedal.
The programmed speed can also be in­

creased
without
pressing the accelerator
pedal.
The
button
B need only be pressed

until
the desired speed has been reached.
The speed can also be increased in the nor­ mal way
with
the accelerator pedal. When
the pedal is then released the previously programmed speed is resumed. The system is
temporarily
switched

off when brake or clutch pedals sre _se; : •
when speed is considerably bee.', z'z- grammed speed i.e. when driving _c =
steep gradient in too high a gear.
To resume speed previously programmed
when brake or clutch pedals are releasee or at end of gradient, push switch A to the
left
(AUFN).

Attention

The
programmed
speed
must
only
be
resumed
when
it is not
too
high
for the
existing
traffic
conditions.

The system is
completely
switched
off by moving the switch A to the
right
(0) or -
when vehicle is stationary - by switching
the ignition off.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT
Windscreen
wiper
and
washer
system

Wipers
and washers only work when igni­
tion is switched on.
The
heated
windscreen
washer
jets*
are switched on when the ignition is switched on and the amount of heat is regu­lated automatically according to the ambi­
ent temperature

When
it is freezing, check
that
the wiper
blades
are not frozen to the glass before
switching the wipers on for the
first
time.
Windscreen
• Flick
wipe
Lift lever to pressure point before detent 1.
•
Wiper
slow
Lever
at position 1. •
Wiper
fast

Lever
at position 2.
•
Intermittent
wipe
Lever
at position 3

The
wipers work about every 6
seconds.

With an
infinitely
variable
intermit­

tent
wipe*
the wipe delay can be pro­grammed between about 1.5 and 22
sec­

onds:

- Switch on
intermittent
wipe
- Switch off
intermittent
wipe and then switch on again after the desired delay.

The
selected delay can be changed as often

as
required. After switching off the ignition
the selected pause reverts back to a six
sec­

ond interval.
•
Automatic
wash/wipe
facility
Pull
lever towards steering wheel - wipers

and
washer work.

Release
lever -

The
washer stops and the wipers carry on
for about 4
seconds.

Headlight washer system*

When
the headlights are on, the lenses are
washed
every time the windscreen is

washed.

At regular intervals such as when filling the
tank, caked-on
dirt
and insects should be

removed.
Rear
window

Press
lever away from steering wheel and

release
- the wiper works about every 6

seconds
(intermittent
wipe).
Pressing
and
releasing
lever again switches the wiper off.

Automatic
wash/wipe
Press
lever away from steering wheel, and
hold in this position -

The
wiper and washer work as long as the
lever
is held in this position.

Release
lever -

The
washer stops and the wiper carries on
for about 4
seconds.

Notes
Topping-up washer fluid
- see page 108.

Changing
windscreen wiper blades
- see page 109
54
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans