1992 VOLKSWAGEN TRANSPORTER warning

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

Notes

Pools of
water
under
the
vehicle

• When the ambient temperature is high
and
the air very humid, condensed water

can
drip off the evaporator and form a puddle under the vehicle. This is quite nor­

mal
and does not indicate a leak.

Operating
faults

• Should the air conditioner not work at
any
time, either:
- the ambient temperature is below about + 5 degrees C,
- the fuse has blown.

Check
fuse and if necessary renew it - see

page
122. If the trouble is not due to
a
defec­
tive fuse, switch the system off and have it
checked.

- the air conditioner has switched off due to the coolant temperature being too high -
see
page 41
also.

• If the cooling
output
drops off, switch the
A/C
off and have the system
checked.
Using air
conditioner

economically
In cooling operation the air conditioner
com­

pressor
places demands on the engine and
therefore influences the fuel consumption.

To
keep the period switched on as short as
possible,
the following points should be

noted:

• If the inside temperature is very high after the vehicle has been parked in the sun, it is recommended to open doors or win­

dows
briefly to enable the hot air to
escape.

• The air conditioner should not be
switched
on during a journey if the windows

or
sliding/tilting
roof*
are open.
• If the desired interior temperature can be attained
without
switching on the air condi­
tioner, the fresh air operation should be se­
lected.
Recirculating
air
switch

If badly contaminated air is to be prevented
from entering the vehicle, e.g. when driving
through a tunnel, the recirculating air switch in the instrument panel can be
pressed.

When
the recirculating air system is
switched
on, a small warning lamp lights up in the switch.

However,
the recirculating air system

should
only be used for a short period other­

wise
the windows will mist up.

60
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND EQUIPMENT
To
switch
heater
off
• Move rocker switch D to centre position.
The
heater in-operation lamp C then goes out, but the biower continues to run for a
short time.

Note

The
warning lamp B flashes if the heater

overheats.
If this happens, check whether
the air intake or the warm air outlet are
blocked.
Switching
blower
on
without
heat

Press
rocker switch D on the
left.
The green
in-operation lamp C comes on.

Switching
off
• Move switch D to centre position. The in-operation lamp goes out.
Stipulation is
that
the heater is not being
controlled at the same time by the timer
(see
next page).

Attention

The
heater
must
be
switched
off in enclosed spaces and
when
fil­

ling
the
tank.

Notes

• Every time the heater is switched off the blower continues to run for a while to cool
the heater down quicker. When filling tank it is not necessary to wait to end of run-on.
• When driving cross-country or through mud or deep snow the heater exhaust pipe

can
become blocked. Before switching the heater on intheseconditions, check thatthe
pipe is clear. • The
following
official
regulation

is
applicable
in
Germany:

The
heat exchanger of the heater may be
used
for 10 years. After this period the heat

exchanger
must be replaced by a Genuine heat exchanger in a Volkswagen Dealer­

ship.
To enable this period of time to be monitored the year when the heater is taken
into use is marked on the maker's plate on
the heater (under vehicle floor).

The
Volkswagen dealer enters the date of
replacement on the plate on the heater.
64
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DRIVING
TIPS

General
notes

• During the running-in period avoid trailer "owing as much as possible.
• It is advisable to have the vehicle ser-
.ced
between the Inspection intervals if it
s
used frequently for towing a trailer.
• ""he trailer and drawbar load figures on
:re
data plate of the towing bracket are for
:es:
certification only. The correct figures

forthe
vehicle, which may be lower than the
acove
figures, are given in the vehicle docu-

~e~:s
and in this manual.
• The towing bracket increases the un-
535"
weight of the towing vehicle and the

pay-load
must be reduced to correspond. In some countries (for example Germany)
the following additional legal requirements
apply:
• A special warning lamp must be
fitted
within
the driver's range of vision to show

that
the trailer
turn
signals are working.
• The maximum draw bar weight - see
page
151 - must be shown on a clearly
vis­

ible sticker at the rear of the towing vehicle.
• The installation of a towing bracket must
be
passed by a legally approved test centre

and
then proof of installation is entered in
the vehicle documents by the
traffic
author­ ity.
• The maximum speed permissible when towing a trailer is 80 km/h (50 mph).
84
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Engine
compartment

Page

Windscreen
washer
container
.. 108
Power
assisted
steering

fluid
reservoir*
100
Engine
oil filler
opening
97

Engine
oil
dipstick
97

Coolant
expansion
tank 102
Brake
fluid
reservoir
104

Battery
106 Attention
Particular care should be
taken

when working in the engine
com­
partment!

•
Switch off engine, remove ignition key.

•
Pull handbrake on firmly.

•
Move gear lever into neutral or
"P"
position.

•
Allow engine to cool off.

•
As long as the engine is at op­
erating temperature:

-
Do not put your hand into the radiator fan, it could switch on

suddenly.

-
Do not open the radiator cap be­
cause
the cooling system is

under
pressure.

•
Avoid causing short circuits in
the electrical system - particular­ ly at the
battery
-.
•
If tests have to be
carried
out

with
the engine running,
there
is
an additional danger
present

from rotating parts - e.g.
V-belts,
generator, radiator fan etc. - and
from the high voltage ignition
system.

Attention must be paid to the warnings given in this Instruc­
tion Manual and to the generally
applicable
safety regulations.
When topping up fluids one
should
ensure
that
they are not mistaken,

one
for the other, under any
circum­

stances,
otherwise serious
func­

tional defects
will
result.
So
that
leaks
are quickly de­
tected
the ground underneath
the vehicle should be checked
reg­

ularly.
If spots as caused by oil or

other
operating fluids can be seen, the vehicle should be
taken
to the
workshop for checking.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Checking
coolant
level

The
expansion tank
is in the
engine
com­
partment on the bulkhead
-
see Fig.

The
correct coolant level
is
essential
to
the satisfactory operation
of
cooling system.
For
this reason, the coolant level should
be

checked
regularly,
and
this
is
best done
when refueling.

The
level
can
only
be
checked properly
when engine
is
not running.

The
coolant level must be between the MIN
and
MAX marks
on the
expansion tank
when engine
is
cold
and can be
slightly
above
the MAX mark when
it
is warm.
When
the
coolant level
is too low on ve­

hicles
with
an automatic coolant level moni­
toring device,
it is
indicated by the coolant
temperature/coolant level warning lamp
flashing continuously (see page 47).

Coolant
losses

Coolant
loss normally indicates leaks in the

system.
In
this
case
the
cooling system
should
be checked by a Volkswagen dealer

without
delay.
It is
not sufficient merely
to

add
coolant.
In
a
sealed system
losses
can only occur
if

the boiling point
of
the coolant is exceeded
as
a
result
of
overheating, and coolant
is

forced out
of
the system.
Overheating can occur
if:

• the flow
of
cooling air is reduced, e.g.
by
a
radiator
muff,
very
dirty
radiator fins
(leaves,
dust, insects)
or
additional driving
lights
in
front
of
the cooling air intake.
• the boiling point
of
the coolant has been lowered by an incorrect mixture
-
see previ­

ous
page.
•
the
radiator
fan is not
working
- see
"Fan"
on next page
-
or, • the vehicle
is
driven up
a
long hill
in too

low a gear
with
engine speed very high and
at very high ambient temperatures
-
see
"Fan"
on
next page.
If
the
cause
of the
overheating cannot
be

found
and
eliminated, contact
a
Volks­
wagen dealer
as
soon
as
possible other­

wise
serious damage may
be
done
to the
engine.

Topping
up
coolant
Switch
engine
off
and let
it
cool down. Then

cover
expansion tank cap
with
a
cloth and

turn
cap carefully
to
the
left
and remove.

Attention
Do
not
remove
expansion
tank

cap
when
engine
is
hot
-
Danger
of scalding.

System
is
under
pressure.

If, in an
emergency only water
can be

added,
the
correct mixture concentration must be restored
with
the specified coolant
additive (see previous page)
as
soon
as
possible.

•02
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF

First
aid kit.
Warning

triangle
Vehicle
tools

The First Aid Kit and warning triangle can be
secured
under the
front
passenger's seat mot on vehicles
with
swivelling seats).

Note:

The
first
aid kit and warning triangle are not part of vehicle equipment.
Double
Cab
under rear seat
1 Pick-up behind the driver's seat

Vehicle
tools and jack are stowed as fol­
lows:

Van, Kombi,
Caravelle

at rear
left
of luggage compartment
Note

On
vehicles
with
side
trim
panels the tools
are stored behind a removable cover.
118
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Changing
wheels

Park
the vehicle as far as possible away
from the
traffic
flow, if necessary switch on emergency warning lights and place the
warning triangle in position - note legal re­
quirements.
• All vehicles occupants should leave the vehicle and move to a safe area (e.g. behind
the barrier).
• Apply handbrake firmly. If the car is on a
slope,
block one of the wheels on the oppo­
site side
with
a stone or some similar object.
• Take the tools out of the vehicle.
• Take spare wheel out of carrier at rear of vehicle - see previous page.
JB70
- 121J
•
Push
the wheel spanner as far as
poss­
ible onto the wheel bolt as shown and
turn

the spanner anti-clockwise. When doing this, grip the spanner as far as possible to­
wards the lever end.
If the bolts cannot be loosened, one can in
an emergency, carefully push the spanner
down
with
a
foot
on the end of the lever.
One
should ensure
that
one has a
firm

stance
and a good grip on the vehicle.

Loosen
wheel bolts about one turn. 8"" 1 •>!
•
Place
jack under vehicle: - Depressions in the side member at
front
and rear indicate the points at which the
jack must be
fitted
- see arrows in illus­
tration. On the sliding door side
ensure

that
the
claw
of the
jack
does not
fit
under
the sliding door.
- On the Pick-.up the jack is placed under the mounting of the trailing arm (triangu­lar mark) at the rear.
- If the
jack
is not
placed
at the
marked
points, the
vehicle
can be

damaged.

120
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Fuse
layout

<*'om
left
to
right)

No.
Component
A11
' - Dipped beam
left,
headlight range control
left
10
I- Dipped beam
right,
headlight range control
right
10
3-
Instrument
and number plate lighting 10
--
Rear
wiper, seat heating 15

5-
Windscreen wiper,
windscreen and rear window

washer/elec.
heated

washer
jets 15

5-
Blower, air conditioner 30
/- Tail and side
light
right,
engine compartment
light
10

3-
Tail and side
light
left
10
9-
Rear
window heating, mirror heating 20

10-
Fog lights, rear fog
light
15
II- High beam
left,
high beam
warning lamp 10

12-
High beam
right
10

13-
Horn, radiator fan (run-on) 10
1 Ampere No.
Component
A

14-
Reversing lights, electric outside mirrors, sliding/tilting
roof,
shift pattern auto, gearbox,

cruise
control system
(cancel contacts on the brake
and clutch pedal) 10

15-
Engine electronics 10

16-
Warning lamps,
dash
panel insert,
glove box
light
15

17-
Turn signals 10

18-
Electric fuel pump,

Lambda
probe 20

19-
Radiator fan, air conditioner 30

20-
Brake lights 10

21-
Interior
and luggage compartment lights, make-up mirror
light,

clock,
radio,
central locking 15

22-
Cigarette lighter 10
Additional
fuses
(in separate holders)
• above the relays A11

Fuse
for electric windows 20
• In the engine compartment on the bulk­
head
above the brake servo:

Glow
plugs21 50
• Under the driver's seat

Fuse
for additional water heater 10

Fuse
for heater blower .30

Fuse
for water heater
glow plug 20
Fuse
for auxiliary heater3' 25
Fuse colour code:

Red:
10 Ampere

Blue:
15 Ampere

Yellow:
20 Ampere

Green:
30 Ampere
21 This fuse should only be renewed by
a
Volks­
wagen dealer.
31 On vehicles
with
swivelling seats this fuse
can
be found in the side
trim
behind the
driver's seat.

123
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans