1992 VOLKSWAGEN TRANSPORTER battery

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT

Auxiliary
heater*
To
switch heater on
•
Press
rocker switch D on rent.
• Select desired heat
with
knee -
The
green heater in-operatior. =~~" _
comes
on.
Regulating
heat

The
heat is infinitely adjustable
with
:~e knob A.
After heater has been switched on it takes

a
little
time before heat can be
felt.

When
the set temperature is reached, the green in-operation lamp becomes darker.

The
temperature is then held fairly constant by the heater thermostatically.
w-^
=
jxiliary heater works independently of
me .ehicle heating. It is supplied
with
fuel
I: rr the vehicle tank.
He suxiliary heater can be used continu­

es
. when on the move or stationary.
|r~? current is supplied from a 2nd battery.

r~T
air flows from the outlets behind the p*.er's seat.
k- the summer the heater blower can be

(sed
to circulate the air in the vehicle with-
it.: heat.
5v. itching on and off and regulating the aux-
tey heater are done from the control panel
r the dash panel.
-
a
timer* is
fitted
(see page 65) the control

panel
is located on the roof cross member I the passenger compartment.
A
BCD

[J70~-T971

Control
elements

A
- Regulating heat output
B
- Overheating indicator (red)

C
- Heater in-operation lamp (green)
D
-
Rocker
switch for switching heater on
and
off and operating blower without heat.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPVE\

Additional
water
heater*
E
additional water heater heats the
cool-

— ;he heater circuit and supplies the nor- • ^eating heat exchanger and the addi-

:~a
heat exchanger* for heating up the
rsaenger
compartment
with
heated
cool-
' ""e engine coolant circuit is not heated.
I current is supplied from a 2nd battery.

:ching
on and off and pre-selecting the
. :ch on/off times is effected via the timer,
- :h can be found in the instrument panel.

~a
air distribution and the air flow is ef-

:::ed
via the normal heating and ventila- : li aontrol elements (operating see page

a
additional water heater can be used

•en
stationary (short term operation) or -g the journey (continuous operation). If

.a;
when the vehicle is stationary the

•Her
runs for maximum 30 minutes,
;eoy
preserving the battery. Apart from
• 5 t switches off automatically, when a .: ant temperature of 92 degrees C is

Bcned.

"
an
the coolant temperature has dropped
-: .v 84 degrees C the heater switches on
The
additional water heater is supplied
with

fuel from the vehicle tank. It consumes up
to
1
litre
of fuel per hour. The heater output

is
approx. 7.0 kW.

Notes

• If the coolant temperature in the heater circuit reaches 55 degrees C, the fresh air
blower is automatically switched to stage 2.
• The additional water heater will only switch on when the temperature selector
lever
(see page 55, lever C) is pushed fully
to the
right.

• With the heater switched on the tem­ perature selector lever must not be pushed
to the
left.

• Regulating the heat output is not
poss­
ible
with
the temperature selector lever.
• When driving across country through mud or deep snow the heater exhaust pipe

can
become blocked. Therefore under

these
conditions check
that
the pipe is clear before switching on the heater.
Attention

The
heater
must
be s . ::'-
a
: : in confined spaces and when fil­

ling
the
tank.

•
Each
time the heater is sw :ce:
circu
at .-' pump and the comes::-blower continues to run for a v. K.e :: :::
down the heater
unit
quicker. Wher,-:. rg
the tank it is not necessary to vva :
end
of the run-on.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
Sun visors
Ashtrays CONTROLS AND EQUIPMENT

Cigarette
lighter

•= sun visors can be pulled out of the
x~:re mountings and swung towards the

*
i
z
'S.

"*"
e
make-up mirror can also have a sliding
'." :he mirror
with
light* (illustration), mov-•: :ne sliding cover switches mirror lighting
:" and off. The lighting is also automatically
= '. iched off and on when the sun visor is
'= sed or lowered. Ashtray in dash
panel

To
empty - Open ashtray, press spring down and pull ashtray out.

To
replace -
Push
ashtray into the
guides.

Ashtray in passenger
compart­
ment

Removing:

Open
ashtray, press down and take out.
Replacing:

Insert ashtray in from above and then push
fully in.
The
cigarette
lighter
is switched on by
pushing in the element. When the heating
element glows, the lighter springs back
automatically - pull it out immediately and
use
it.

The
cigarette
lighter
socket can be
used
for other electrical
accessories
with
a

capacity
of up to 120 watts. When the en­
gine is not running this will however dis­
charge
the battery. Further information see
chapter
Accessories
on page 117 .

Attention
Be
careful
when
using the ciga­

rette
lighter!

Careless or
uncontrolled
use of
the
cigarette
lighter
can cause burns.
The
cigarette
lighter
and the socket also
work
when
the igni­

tion
is
switched
off and the key removed.
For
this
reason
children
should

never
be
left
in the
vehicle
on

their
own.

73
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DRIVING
TIPS

Trailer
towing

~~e
vehicle is intended mainly for the trans-
cctation of persons and luggage but it can, th the appropriate technical equipment,

=
so be used to tow a trailer.
Ibiler towing not only places more stress : - the vehicle, it also calls for more concen-
ration from the driver.
::r this reason the operating and driving in­ductions on the next pages must be strict- . adhered to.
Technical
requirements
" :he vehicle is supplied
with
a factory-
• ::ed towing bracket, all
that
is technically -
d
legally necessary for trailer towing will =ve been taken into account.
: should be noted
that
a 13 pin socket is
::ed
instead of the 7 pin one used previous- . This new socket makes it possible to con-
ect additional electrical components on trailer for which there were no connec-

ns
in the previous socket, such as a
cara-

n refrigerator, reversing lights etc.
the following table the wiring of the ter-
nals
in the 7 pin socket is compared
with

at of the 13 pin socket.
I a 7

13
Trailer electrical

Pin Pin
components

L
1 Turn signal
left

54g
2
Rear
fog light
31
311

Earth
for the circuits 1-8

R
4
Turn signal
right

58
R
5
Tail
light, outline -, marker
- and number plate lights

right

54 6
Brake
lights

58L
7
Tail
light, outline -, marker
- and number plate lights

left

- 82>

Reversing
light
-
92!

Power
supply (cont. +)
-
102!

Charging
wire + for battery
in trailer
- 11
free
- 12
free
-
1311

Earth
for circuits 9-12
1) Both earth wires must not be connected to­ gether on the trailer side.
21 Not connected at the factory. If the trailer to be towed has a 7 pin plug,
either a 13 pin plug can be
fitted
as shown
in the table or an adapter cable can ce zz-
tained from a Volkswagen dealer.
If the vehicle is to be
fitted
with
a towing
bracket subsequently, the following must

be
noted:
• The towing bracket is a safety part. Only
a
bracket which has been designed and
type-approved for this vehicle may be
used.
It is advisable to use towing brackets from
the Volkswagen range of accessories as

these
are identical to the ones
fitted
by the
factory. The
fitting
instructions supplied

with
these brackets have also been ap­ proved by the factory.
• The trailer socket must be connected properly to the electrical system of the ve­
hicle.
This applies to terminal 54 g in the 7
pin socket or for terminals 2 and 8 -13 in the
13
pin socket.
81
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Engine
compartment

Page

Windscreen
washer
container
.. 108
Power
assisted
steering

fluid
reservoir*
100
Engine
oil filler
opening
97

Engine
oil
dipstick
97

Coolant
expansion
tank 102
Brake
fluid
reservoir
104

Battery
106 Attention
Particular care should be
taken

when working in the engine
com­
partment!

•
Switch off engine, remove ignition key.

•
Pull handbrake on firmly.

•
Move gear lever into neutral or
"P"
position.

•
Allow engine to cool off.

•
As long as the engine is at op­
erating temperature:

-
Do not put your hand into the radiator fan, it could switch on

suddenly.

-
Do not open the radiator cap be­
cause
the cooling system is

under
pressure.

•
Avoid causing short circuits in
the electrical system - particular­ ly at the
battery
-.
•
If tests have to be
carried
out

with
the engine running,
there
is
an additional danger
present

from rotating parts - e.g.
V-belts,
generator, radiator fan etc. - and
from the high voltage ignition
system.

Attention must be paid to the warnings given in this Instruc­
tion Manual and to the generally
applicable
safety regulations.
When topping up fluids one
should
ensure
that
they are not mistaken,

one
for the other, under any
circum­

stances,
otherwise serious
func­

tional defects
will
result.
So
that
leaks
are quickly de­
tected
the ground underneath
the vehicle should be checked
reg­

ularly.
If spots as caused by oil or

other
operating fluids can be seen, the vehicle should be
taken
to the
workshop for checking.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Battery

The
battery is in the engine compartment on
the left looking forward. It can be
reached

when
the lid of the battery box is
removed.
2nd
battery*

The
2nd battery is located under the left
seat.

To
reach
it the
seat
must be
pushed
fully for­

ward
past the stop. The stop must be
freed.

To
do this - see page 21. Attention

•
Battery
acid is corrosive and must not get
into
the eyes or onto
skin and clothing.

Any
acid splashes must be
washed off thoroughly
with

water.
If necessary see a doctor.

•
Never short the
battery
ter­
minals (e.g.
with
tools) as this

causes
the
battery
to
heat
up
very quickly and it may burst.

•
To prevent any possibility of
short circuiting, detach
battery

earth
cable before doing any

work
on the electrical system.
When changing a bulb, it is suffi­cient to switch off the lamp
con­

cerned.

•
When disconnecting the
bat­

tery
from the vehicle electrical system
first
disconnect the nega­

tive
cable and
then
the positive cable.
The
battery
must not be discon­ nected
with
the engine running,
as this
will
damage the electrical
system (electronic components).
•
When reconnecting the
bat­

tery
connect the positive cable
first
and
then
the negative cable.
The connecting cables must on no account be interchanged - can

cause
wiring
to burn out.

Starting
by
connecting
an additional battery

is
described
in the Do-it-yourself
section.

Checking
acid level In normal operating conditions the battery

requires
hardly any maintenance. At high

ambient
temperatures however it is
advis­
able
to
check
the
acid
level at regular inter­

vals.
It should always be between the MIN
and
MAX marks on the battery. If the
acid
level
drops below the MIN mark, the af­

fected
cells
must be topped-up to the MAX
mark
with distiled water.
It is recommended that the
acid
level is

checked
and corrected by a
Volkswager

dealer.

106
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Winter
driving
A/inter weather
is
particularly hard
on the

cattery. Furthermore at low temperatures
it

has
only a part
of
the capacity
it
has
at
nor­ mal temperatures.
We
recommend there-
-'ore
that
the battery should be checked pre­
ferably
by a
Volkswagen dealer before
the

onset
of
cold weather
and
charged
if
"ecessary.
At
the same time,
if
necessary,
the terminals will
be
cleaned
and
special
grease
applied. This will
not
only result
in
quicker, more reliable starting but will help
:o prolong the life
of
the battery.

If the
vehicle
is not
driven
for
sev­

eral
weeks
when
temperatures
are

very
low, the
battery
should
be

taken
out
and
stored
in a
frost-free
room, so
that
it
cannot
freeze
up and
become damaged.

Attention
Store
the
battery
out of
reach
of

children.

To
take battery out,
first
disconnect the two
cables
(see previous page) and then remove
-etainer.
Charging
battery

When
charging
with
a low current (e.g.
with

a
small charger) the battery cables need not normally be taken off. The instructions from
the charger manufacturer must however be
noted.

Before
Quick charging,
that
is
charging

with
a
high current, both battery cables must be disconnected
-
see previous page.

The
following information must be noted:
• When charging
the
battery
do not re­
move
caps.

•
A
discharged battery can freeze
at - 10
degrees
C. It is
essential
to
thaw
out a

frozen battery before
it is
given
a
quick
charge
otherwise
it
may explode!
• The mains cable
of the
charger should not be connected until after the clips
of
the

charger
have been properly secured
to the

battery terminals:

Red
=
plus
(or
positive)

Black
=
minus
(or
negative)
• Reconnect cables correctly after charg­ ing battery.
Attention

The
gas
given
off
during
the

charging process
is
highly
in­

flammable
so
keep
sources
of
ignition
(naked
flames,
burning

cigarettes
etc.)
well
away
from

the
battery.

Renewing
a battery If the
battery has
to be
renewed,
the
new
battery must have the same capacity, volt­

age
(12 Volts), current capacity and shape.

Volkswagen
dealers have
a
range
of
suit­

able
batteries.
Because
of the
problem
of
dis­

posing
of
the
old
battery
the re­

newal
of
a
battery
should
preferably

be
done
by a
Volkswagen
dealer.

Batteries
contain,
amongst
other
things,
sulphuric
acid
and
lead
and

must
on no
account
be put
with
nor­

mal
household
waste.

107
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Winter
driving
T

Ac

The an«

safe
high

ensi

supf

with
poin

sub:

tech latei
• /
fori

any

thro

SWc
pete

A
In
m
s<
V
G
u
P
SI
a

s|
r<
In winter the following points should be
noted:
• Winter weather is particularly hard on the
battery
and it should therefore be
checked,
preferably by a Volkswagen
dealer, before the onset of cold weather. If the vehicle is not driven for several weeks
when the temperatures are very low, the
battery
should be taken out - for
further
in­
formation see page 107.
• On a vehicle
with
a Diesel engine, winter
Diesel
must be used at temperatures below
0 degrees C - see page 87.
• The water should be drained out of the
Diesel
fuel
filter
before the onset of
winter.

This
operation is also included in the Lubri­ cation
Service.

• The anti-freeze in the cooling system should be checked before the cold
season
starts - see page 101.
• The engine oil viscosity must be correct for the ambient temperature - see page 99.
• Particularly in
winter,
frequent washing and waxing of the vehicle is the best way to protect it against harmful environmental in­

fluences.
• In winter the windscreen washer
sys­

tem should always be filled
with
a window
cleaning solution containing an anti-freeze
additive.
• To remove snow and ice
from
the win­ dows and mirrors, a plastic scraper should be used - see page 90.
• The road holding and handling can be im­ proved in winter road conditions by the use
of winter or All-weather tyres - see pages 114and146.
• When driving in mountainous districts in winter it is advisable to take snow chains

with
you. On some such roads, snow chains
are obligatory - see also page 114.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans