1992 VOLKSWAGEN CARAVELLE low beam

Downloaded from www.Manualslib.com manuals search engine
DASHBOARD
AND
CONTROLS
Warning lamps

Symbol Page Symbol
Page
Coolant temperature/
Coolant level
47

A Emergency light system
51
Engine oil pressure f^i
47

m Rear
window
heating
51

ID
Headlight
high
beams

48

to Fog lights
rear fog light 51

Turn
signals
49

Notes
((D)
Brake
system l^i

48
•
If one of the lamps marked
with
comes on when driving
stop and switch engine off. Details can be found on the pages
given

B Some of the lamps shown here are
only
on certain models or are optional extras.

£3

Alternator
49 •
If one of the lamps marked
with
comes on when driving
stop and switch engine off. Details can be found on the pages
given

B Some of the lamps shown here are
only
on certain models or are optional extras.
m Glow plugs - Diesel

49
(©)
Anti-locking brake system (ABS)

49


Trailer turn signals

49
6
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

Warning
lamps

~ne layout of the warning lamps depends on
:ne model and the engine fitted. The sym-
: ols shown here are also on the actual warn-ng lamps.
|- Coolant temperature/ coolant level 47
1- Engine oil pressure 47
I- High beams 48
-- Turn signals 48

5-
Brake system 48
V Alternator 49
" Glow plugs 49 Coolant
temperature/

Coolant level1'

This
lamp flashes for a few seconds as a
functional check when ignition is switched
on.

If the lamp does not go out afterwards or

flashes
when driving, either the coolant
temperature is too high orthe coolant level1'
too low:
Stop,
switch
engine
off and check

level.
Add coolant if necessary.
11 Only on vehicles
with
automatic coolant level monitor(see page 102).
Attention

• Be
careful
when
opening the

coolant
expansion
tank!
When
the
engine
is hot the cooling
sys­

tem is
under
pressure -
Danger
of scalding!
Therefore
let
engine
cool
down
before
unscrewing

the cap.
• Do not
touch
the fan. The fan can
switch
on suddenly -
even

when
ignition
is
switched
off.

For
further details see pages 102 and 103.
If the coolant level is in order the trouble
may be due to failure of the radiator fan.

Check
radiator fan fuse and renew if
necessary-seepage
122.
If the warning lamp does not go out al­
though coolant level and fan fuse are in order, do not
drive
on - call in expert as­

sistance.

If the trouble is only caused by the fan and

assuming
coolant level is in order and tem­ perature warning lamp is out - one can drive
on to the nearest Volkswagen dealer. In
order to make good use of the air stream for

cooling,
do not let engine idle or drive very
slowly.
2 - Engine oil pressure -7
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND EQUIPMENT

The
warning lamp flashes when ignition is
switched
on. the lamp must go out when

engine
has started.
If the warning lamp does not go out or

flashes
when driving - a buzzer also sounds
at engine speeds above 2000 rpm - stop,
switch
engine
off, check oil level and if
necessary,
add oil - see page 97.
If the lamp comes on although the oil level

is
in order, do not
drive
on. Do not even
run the engine at idling speed-call in expert

assistance.

Note

The oil pressure
warning
lamp
is not an oil
level
indicator.
The oil
level
should
therefore
be checked at reg­

ular
intervals,
preferably
every
time

the
fuel
tank
is filled.
3 -
High
beams 10 4 - Turn signals

The
warning lampflashes when
turn
signals

are
switched on. If a
turn
signal fails, the
warning lamp flashes twice as fast. (Not
when towing a trailer).

Further
details are given on pages 49

and
52. 5 -
Brake
system «^

The
warning lamp comes on when
• the handbrake is on
• the brake fluid level is too low
The
ignition must be switched on.

Attention
If the
lamp
does not go out
when

handbrake
is released or comes
on
when
driving, the
fluid
level
in
the reservoir is too low. If an in­ crease in
pedal
free
travel
is no­

ticed
at the same
time,
one of the
brake
circuits may
have
failed.
You can
drive
on
carefully
to the

nearest
Volkswagen
dealer
but

allow
for
higher
pedal
pressures and longer
braking
distances on
the way.

The
warning lamp comes on when high
beams
are on or when the headlight flasher

is
used.

48
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT

JB70-
1251

Switches

Notes
• On vehicles
with
righthand drive the ar­ rangement of the switches differs. The

symbols
on the switches are however the

same
as on vehicles
with
lefthand drive.
• The use of the lighting described here is subject to local regulations.
1 -
Lighting
switch
-n

First
detent -side lights11

Second
detent -headlight high/low beams
The
headlights only work when the ignition

is
on. When the engine is being started and
after ignition has been switched off, the headlights are switched off automatically.

When
the side lights are on, a warning lamp lights up in the switch.

When
the lights are on, the level of the in­ strument lighting can be regulated by turn­ing the knurled disc on the
right
of the

switch.

Dipping and flashing the headlights - see

page
52. 2 -
Headlight
range
control
* %\_)
With the electrical range control the
head­
light settings can be matched exactly to the
load
condition of vehicle. This prevents on­
coming traffic from being
dazzled
more than

is
unavoidable. At the same time the correct headlight beam setting provides the best

possible
visibility for the driver.

The
headlights can only be regulated
with

the dipped headlights switched on.
To
lower the beams,
turn
knurled disc from
the
basic
position (-) downwards.
Note

The
basic
headlight setting (only possible
with
headlight adjusting appliance) must al­

ways
be done
with
the headlight headlight range control knurled disc in the
basic
posi­

tion (-) - see page 128
also.

On
vehicles for some export countries when
the side lights are switched on
with
the igni­
tion switched on, the dipped headlights also

come
on
with
reduced intensity.
50
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

3
-
Emergency lights .
nen the emergency lights are on, a warn-
'z lamp in the switch flashes as well.
Ine system also works when the ignition is
;
.-.itched off.

4
-
Knurled wheel for seat
^Jf
heating*

~~e cushion and backrest of the
front
seats
:
=
n
be heated electrically when the ignition
s
on.

_~e
heating is switched on and regulated .vth the knurled wheel.

•
switch heating off,
turn
knurled wheel to

:_e
left
to the detent position.
5
-
Heated rear window
QpJ

The
heating works only when ignition is on.

When
heater is on a lamp in the switch lights up.

As soon
as
window
is
clear,

switch element
off. The
reduced
current consumption helps
to re­

duce
the
fuel
consumption
- see
also
page
80.

On
vehicles
with
electrically adjustable ex­
terior mirrors the mirrors are heated as long

as
the rear window heating is switched on.
6
-
Fog lights •/
|Q

Rear fog light

First
detent - fog lights

Second
-
front
and rear fog
detent lights, or rear fog
light
only

At the second position a warning lamp in the switch comes on.

The fog lights
work
with
the side lights (ignition on), low or high beams.

The rear fog light
works only
with
the fog lights or
with
the low or high beams.

Due
to the amount of
dazzle
it
causes
the

rear
fog
light
should only be switched on
when the visibility is very poor (in Germany
for example, below 50 metres).

Note
The
electrical system of the factory
fitted

tow bar* is wired-up so
that
when towing

a
trailer
fitted
with
rear fog lights, the rear
fog
light
on the towing vehicle are automati­
cally
switched off.
51
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DRIVING
TIPS

• Where possible make
full
use of the maximum permissible drawbar weight on

call
of the towing bracket - see page 151 -
cut do not exceed it.
• While observing the permissible trailer
and
drawbar weight, distribute the load in
the trailer so
that
heavy objects are as near
as
possible to the axle. The objects must
a
so be secured so
that
they cannot slip
aoout.
• Check the
tyre
pressures on the towing
/ehicle
and the trailer.
• The headlight settings, should be
:hecked
with
trailer attached before mov- ng off and adjusted as necessary.

On
vehicles
with
headlight beam control it

is
only necessary to
turn
the knurled disc in
:ash
in the appropriate direction.
Driving
instructions

To
obtain the best possible handling of ve­
hicle
and trailer, the following should be

noted:

• Try to avoid driving
with
an unladen ve­
hicle
and a loaded trailer. If this cannot be

avoided,
only drive slowly to allow for the unfavourable weight distribution.
• As driving stability of vehicle and trailer
decreases
when the speed increases do not
drive at the maximum permissible top
speed
in unfavourable road, weather or
wind conditions - particularly when going downhill. In any
case
the speed must be reduced im­
mediately the trailer shows the slightest

sign
of snaking. On no account try to stop
the snaking by accelerating.
• For safety reasons one should not drive faster than 80 km/h (50 mph). This also
applies
in countries where higher speeds
are permitted. • Always brake in good time. If the trailer

has
an overrun brake, apply the brakes gen­
tly at
first
then firmly. This will avoid the
jerk­
ing caused by the trailer wheels locking.

Change
down before going down a steep hill so
that
the engine can act as a brake.
• When a long climb in a low gear
with
ex­ tremely high engine revs must be nego­
tiated at exceptionally high ambient tem­peratures the coolant temperature gauge must be observed. When the gauge needle

moves
to the
>~zza'
e~z of :ne
scale,
the road speed must be reduced immediately. If nevertheless ~g amp flashes,
stop immediately and si ow the engine to

cool
off at idling speed for several minutes.
• The cooling effect of the radiator fan
can­
not be increased by changing down, be­

cause
the speec of t~e
~a~
s ~o! dependent
on the engine
speed.
One should therefore not change down even when towing a
trailer as long as :-e e-g -e zar cope with­ out the vehicle speed dropping too much.
83
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Fuse
layout

<*'om
left
to
right)

No.
Component
A11
' - Dipped beam
left,
headlight range control
left
10
I- Dipped beam
right,
headlight range control
right
10
3-
Instrument
and number plate lighting 10
--
Rear
wiper, seat heating 15

5-
Windscreen wiper,
windscreen and rear window

washer/elec.
heated

washer
jets 15

5-
Blower, air conditioner 30
/- Tail and side
light
right,
engine compartment
light
10

3-
Tail and side
light
left
10
9-
Rear
window heating, mirror heating 20

10-
Fog lights, rear fog
light
15
II- High beam
left,
high beam
warning lamp 10

12-
High beam
right
10

13-
Horn, radiator fan (run-on) 10
1 Ampere No.
Component
A

14-
Reversing lights, electric outside mirrors, sliding/tilting
roof,
shift pattern auto, gearbox,

cruise
control system
(cancel contacts on the brake
and clutch pedal) 10

15-
Engine electronics 10

16-
Warning lamps,
dash
panel insert,
glove box
light
15

17-
Turn signals 10

18-
Electric fuel pump,

Lambda
probe 20

19-
Radiator fan, air conditioner 30

20-
Brake lights 10

21-
Interior
and luggage compartment lights, make-up mirror
light,

clock,
radio,
central locking 15

22-
Cigarette lighter 10
Additional
fuses
(in separate holders)
• above the relays A11

Fuse
for electric windows 20
• In the engine compartment on the bulk­
head
above the brake servo:

Glow
plugs21 50
• Under the driver's seat

Fuse
for additional water heater 10

Fuse
for heater blower .30

Fuse
for water heater
glow plug 20
Fuse
for auxiliary heater3' 25
Fuse colour code:

Red:
10 Ampere

Blue:
15 Ampere

Yellow:
20 Ampere

Green:
30 Ampere
21 This fuse should only be renewed by
a
Volks­
wagen dealer.
31 On vehicles
with
swivelling seats this fuse
can
be found in the side
trim
behind the
driver's seat.

123
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Changing bulbs

Before
starting to replace a bulb, switch off
the light concerned.

Do
not touch the glass part of the new bulb

with
bare fingers because the finger marks
left
on the glass evaporate when the bulb

becomes
hot, the vapour settles on the re­
flector and dims it.

Always
use the same type of bulb. The
des­

ignation is marked on the base of the bulb
or on the
glass.

It is advisable to always a carry a box of

spare
bulbs in the vehicle. These can be ob­
tained from Volkswagen dealers. It should contain at least the following bulbs which
are essential for traffic safety:
12 V 60/55 W Headlight (H4)

12V21W
Turn signal

12V21/5W
Brake
and tail light
12 V4W
Side
light

12V5W

Glass
base
Number
plate light
Headlights

The
headlight bulbs can be reached through
the opened bonnet.
• Pull off the connector.
• Pull cap off.
•
Squeeze
the spring clip of the bulb holder together and pull down.
• Take the bulb out and insert the new bulb
so
that
the locating lug on the bulb plate en­

gages
the recess in the reflector. The centre
of the three terminals on the bulb base is
then at the top.
• Fold the spring clip over bulb
base.
Squeeze
the clip together and engage it in
the retaining lugs.
•
Press
the cap back on.
• Attach the connector.
• Have the headlight beam alignment
checked.
Side
light
bulb

The
side light bulbs are located in the head­ light reflectors.
• Turn the bulb holder fully to the
left
and take it out of the reflector.
•
Press
the defective bulb into the holder,
turn
it to
left
and take it out.
• Insert the new bulb.
• Insert the bulb holder in the reflector and
turn
the holder fully to the
right.

124
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans