Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE
'necking fluid level
Pe :orrect fluid level is essential to the sat-
:~=
:tory operation of the brake system. The
fc. Z level must always be between the
AX"
and "MIN" marks.
~- a "evel of fluid tends to sink slightly when
"a vehicle is used due to the automatic ad- ::ment of brake linings. This is quite nor-
-rwever, if the level sinks noticeably in a
srorttime or drops below the "MIN" mark
re system may be leaking. A low fluid level " the reservoir is indicated by the brake
w.arning lamp lighting up (see page 48 also), .nen this happens take car to a Volks
wagen dealer immediately and have the
cake system checked. Renewing brake fluid
Brake fluid absorbs moisture. In the course
of time it takes in water from the ambient
air. Too high a content of water in the brake
fluid can in time cause corrosion damage in
the system. Furthermore the boiling point of
the brake fluid is reduced considerably. For
this reason the brake fluid must be renewed every two years.
Attention
When the brake fluid becomes
too old vapour bubbles can form in the brake system when the
brakes are used hard. The
effi
ciency of the brakes and thus the
vehicle safety is then seriously
affected.
Only use our genuine brake fluio (see: - ra
tion to US standard FMVSS 116 DO~-
.
~-e
fluid must be new.
Attention Brake fluid is poisonous!
It must therefore only be stored in the closed original container
out of reach of children.
Remember also that brake fluid will
attack the paintwork. Because of the disposal
prob
lems,
the special tools necessary
and the specialist knowledge re
quired,
the brake fluid changing
should preferably be done by a
Volk
swagen
dealer.
It is advisable to have the fluid change car
ried out during an Inspection Service.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans
Downloaded from www.Manualslib.com manuals search engine
You
can enter the most
important
data
for
your
vehicle here.
If
you have any questions, any Volkswagen Dealer
will
be
pleased
to
help.
Vehicle
identification
number1'
Model
Engine
oil
specifications2'
• To Volkswagen Standard 501
01
• To Volkswagen Standard 500
00
• To Volkswagen Standard 505
00
Engine
output11
kW
Engine
code
letters1'
Engine
oil
specifications2'
• To Volkswagen Standard 501
01
• To Volkswagen Standard 500
00
• To Volkswagen Standard 505
00
Mixture
preparation2'
•
Injection
•
Diesel
• With catalyst
Fuel2'
• Regular unleaded31 91 RON • Diesel 1) This data can be found
in the
Service
Schedule.
21 Mark
with
cross
31 Leaded also for engines
without
catalytic con
verter.
4) Factory
fitted
tyres.
Engine
oil
specifications2'
• To Volkswagen Standard 501
01
• To Volkswagen Standard 500
00
• To Volkswagen Standard 505
00
Mixture
preparation2'
•
Injection
•
Diesel
• With catalyst
Fuel2'
• Regular unleaded31 91 RON • Diesel 1) This data can be found
in the
Service
Schedule.
21 Mark
with
cross
31 Leaded also for engines
without
catalytic con
verter.
4) Factory
fitted
tyres.
Mixture
preparation2'
•
Injection
•
Diesel
• With catalyst
Fuel2'
• Regular unleaded31 91 RON • Diesel 1) This data can be found
in the
Service
Schedule.
21 Mark
with
cross
31 Leaded also for engines
without
catalytic con
verter.
4) Factory
fitted
tyres.
Mixture
preparation2'
•
Injection
•
Diesel
• With catalyst
Fuel2'
• Regular unleaded31 91 RON • Diesel 1) This data can be found
in the
Service
Schedule.
21 Mark
with
cross
31 Leaded also for engines
without
catalytic con
verter.
4) Factory
fitted
tyres.
Mixture
preparation2'
•
Injection
•
Diesel
• With catalyst
Fuel2'
• Regular unleaded31 91 RON • Diesel 1) This data can be found
in the
Service
Schedule.
21 Mark
with
cross
31 Leaded also for engines
without
catalytic con
verter.
4) Factory
fitted
tyres.
Tyre
pressures4'
(in bar)
front
rear
Mixture
preparation2'
•
Injection
•
Diesel
• With catalyst
Fuel2'
• Regular unleaded31 91 RON • Diesel 1) This data can be found
in the
Service
Schedule.
21 Mark
with
cross
31 Leaded also for engines
without
catalytic con
verter.
4) Factory
fitted
tyres. With half load
Mixture
preparation2'
•
Injection
•
Diesel
• With catalyst
Fuel2'
• Regular unleaded31 91 RON • Diesel 1) This data can be found
in the
Service
Schedule.
21 Mark
with
cross
31 Leaded also for engines
without
catalytic con
verter.
4) Factory
fitted
tyres. With
full
load
VOLKSWAGEN
AG is working continuously on the development
of
all models.
Please
appreciate
that
we must reserve the
right
to change our models
in
shape, equpment and technology
at
any time.No legal commitment is therefore implied by the details, illustrations and descriptions
in
this manual.
Reprinting, reproducing
or
translation,
in
whole
or
in
part,
is
not permitted
without
written
permission
from
VOLKSWAGEN
AG.
All
rights are reserved expressly by
VOLKSWAGEN
AG. Subject
to
modification
without
notice.
Produced
in
Germany
.© 1992
VOLKSWAGEN
AG
TO
This paper was manufactured
from
pulp bleached
without
using chlorine
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans
