1991 MITSUBISHI MONTERO power steering

USB port boot fuel pressure oil filter fuse chart ECU

Page 720 of 1333

$MITSUBISHI MONTERO 1991 Service Manual Fluid Capacities \ \ \ \ \ \$

Fluid Capacities

\
\
\
\
\
\
\

Application Quantity

Engine Oil

1987 ......................................... 5.2 Qts. (5.0L)

1988 ......................................... 5.0 Qts. (4.8L)

1989-92 ...................................... 5.5 Qts. (5.3L)

1993-95 ...................................... 5.2 Qts. (4.9L)

\
\
\
\
\
\
\
\f

105,000 MILE (168,000 KM) SERVICE
105,000 MILE (168,000 KM) SERVICE\
\
\
\
\
\
\

Service Or Inspect

\
\
\
\
\
\
\

Verify Last Major Service Was Performed

\b\
\
\
\
\
\
\

Fluid Levels

\b\
\
\
\
\
\
\

Braking System

\b\
\
\
\
\
\
\

Drive Shaft Boots

\
\
\
\
\
\
\

Replace

\
\
\
\
\
\
\

Engine Oil

\b\
\
\
\
\
\
\

Oil Filter

\
\
\
\
\
\
\

Lubrication Specifications

\
\
\
\
\
\
\

Application Specification

Brake & Clutch Fluid ............................ DOT 3 Or DOT 4

Engine Coolant .............. Ethylene-Glycol Antifreeze Coolant

Engine Oil (
1)

Minimum Temperature

Greater Than 32
F (0
C) ...... SAE 20W-40 Or 20W-50 API SG/CD

Greater Than -10
F (-23
C) ..... SAE 10W-30, 10W-40 API SG/CD

Maximum Temperature

Less Than 60
F (16
C) .......... SAE 5W-30 Or 5W-40 API SG/CD

Front Axle & Conventional Rear Axle

Minimum Temperature

Greater Than -10
F (-23
C) ........... SAE 90, 85W-90, 80W-90

API GL-5

Maximum Temperature

Less Than -30
F (-34
C) .................... SAE 75W API GL-5

Power Steering Fluid ............................. Dexron-II ATF

Rear Axle (With Limited

Slip Differential) ............ Hypoid Gear Oil (8149630EX) Or

Equivalent

Transmission

Automatic ...................................... Dexron-II ATF

Manual Transaxle &

Transfer Case (4WD) ................. SAE 75W-85W, 75W-90 API

GL-4 Or GL-5

(
1) - Since temperature ranges for different oil grades overlap,

brief fluctuations in outside temperatures are no cause for

concern.

Page 724 of 1333

MITSUBISHI MONTERO 1991 Service Manual Engine Coolant .............. Ethylene-Glycol Antifreeze Coolant

Engine Oil (
1)

Minimum Temperature

Engine Coolant .............. Ethylene-Glycol Antifreeze Coolant

Engine Oil (
1)

Minimum Temperature

Greater Than 32
F (0
C) ...... SAE 20W-40 Or 20W-50 API SG/CD

Greater Than -10
F (-23
C) ..... SAE 10W-30, 10W-40 API SG/CD

Maximum Temperature

Less Than 60
F (16
C) .......... SAE 5W-30 Or 5W-40 API SG/CD

Front Axle & Conventional Rear Axle

Minimum Temperature

Greater Than -10
F (-23
C) ........... SAE 90, 85W-90, 80W-90

API GL-5

Maximum Temperature

Less Than -30
F (-34
C) .................... SAE 75W API GL-5

Power Steering Fluid ............................. Dexron-II ATF

Rear Axle (With Limited

Slip Differential) ............ Hypoid Gear Oil (8149630EX) Or

Equivalent

Transmission

Automatic ...................................... Dexron-II ATF

Manual Transaxle &

Transfer Case (4WD) ................. SAE 75W-85W, 75W-90 API

GL-4 Or GL-5

(
1) - Since temperature ranges for different oil grades overlap,

brief fluctuations in outside temperatures are no cause for

concern.

\
\
\
\
\
\
\

Fluid Capacities

\
\
\
\
\
\
\

Application Quantity

Automatic Transmission

1987-93 ...................................... 7.6 Qts. (7.2L)

1994 (3.0L SOHC) ............................. 7.6 Qts. (7.2L) \

1994 (3.0L DOHC & 3.5L) ...................... 9.0 Qts. (8.5L) \

1995 ......................................... 7.9 Qts. (7.5L)

Cooling System

1987-88 ...................................... 8.5 Qts. (8.0L)

1989-95

2.6L ........................................ 9.7 Qts. (9.2L)

3.0L ....................................... 10.0 Qts. (9.5L)

1994-95

3.5L ....................................... 10.0 Qts. (9.5L)

Differential

1987-88 ...................................... 1.9 Qts. (1.8L)

1989-94

2.6L ........................................ 1.9 Qts. (1.8L)

3.0L ........................................ 2.7 Qts. (2.6L)

1994

3.5L ........................................ 2.7 Qts. (2.6L)

1995

3.0L ........................................ 2.7 Qts. (2.6L)

3.5L ........................................ 3.3 Qts. (3.2L)

Engine Oil

1987 ......................................... 5.2 Qts. (5.0L)

1988 ......................................... 5.0 Qts. (4.8L)

1989-92 ...................................... 5.5 Qts. (5.3L)

1993-95 ...................................... 5.2 Qts. (4.9L)

Manual Transmission

1987-91 ...................................... 2.3 Qts. (2.2L)

1992 ......................................... 2.4 Qts. (2.3L)

1993-95 ...................................... 2.6 Qts. (2.5L)

Transfer Case

Page 725 of 1333

$MITSUBISHI MONTERO 1991 Service Manual 1987-91 ...................................... 2.3 Qts. (2.2L) 1992-95 ...................................... 2.4 Qts. (2.3L) \ \$

1987-91 ...................................... 2.3 Qts. (2.2L)

1992-95 ...................................... 2.4 Qts. (2.3L)

\
\
\
\
\
\
\

Service Labor Times

\
\
\
\
\
\
\

Application Hours

30,000 (60,000) 50,000

Application Mile Service Mile Service

2.6L 4-Cylinder

Automatic Transmission .... 7.9 (8.9) ................. 2.6

Manual Transmission ....... 6.9 (7.9) ................. 2.6

3.0L V6

Automatic Transmission .... 6.1 (10.6) ................ 2.6

Manual Transmission ....... 5.1 (9.6) ................. 2.6

\
\
\
\
\
\
\
\f
LUBRICATION SPECIFICATIONS TABLE\
\
\
\
\
\
\

Application Fluid Specifications
Brake & Clutch Fluid ........................... DOT 3 Or DOT 4
Engine Coolant ............. Ethylene-Glycol Antifreeze Coolant
Engine Oil (
1)
Minimum Temperature
Greater Than 32
F (0
C) ..... SAE 20W-40 Or 20W-50 API SG/CD
Greater Than -10
F (-23
C) .. SAE 10W-30 Or 10W-40 API SG/CD
Maximum Temperature
Less Than 60
F (16
C) ......... SAE 5W-30 Or 5W-40 API SG/CD
Front Axle & Conventional Rear Axle
Minimum Temperature
Greater Than -10
F (-23
C) ..... SAE 85W-90, 80W-90 API GL-5
Maximum Temperature
Less Than -30
F (-34
C) ................... SAE 75W API GL-5
Power Steering Fluid ........................... Dexron-IIE ATF
Rear Axle (With Limited
Slip Differential) ........... Hypoid Gear Oil (8149630EX) Or
Equivalent
Transmission
Automatic .................................... Dexron-IIE ATF
Manual Transaxle &
Transfer Case (4WD) ........... SAE 75W-85W, 75W-90 API GL-5
( 1) - Since temperature ranges for different oil grades overlap,
brief fluctuations in outside temperatures are no cause for
concern.
\
\
\
\
\
\
\

FLUID CAPACITIES
FLUID CAPACITIES TABLE\
\
\
\
\
\
\

Application Quantity
A/C System R-12 Refrigerant
1983-87 .......................................... 24-26 Ozs.
1988-91 ............................................. 32 Ozs.
1992-93 ............................................. 28 Ozs.
A/C System R-134a Refrigerant ( 1)
1994-95 .......................................... 21-23 Ozs.
Automatic Transmission

Page 726 of 1333

MITSUBISHI MONTERO 1991 Service Manual 1984-86 ................................. (2) 7.2 Qts. (6.8L)
1987-93 ..................................... 7.6 Qts. (7.2L)
1994 (3.0L SOHC) ............................ 7.6 Qts. (7.2L)

1984-86 ................................. (2) 7.2 Qts. (6.8L)
1987-93 ..................................... 7.6 Qts. (7.2L)
1994 (3.0L SOHC) ............................ 7.6 Qts. (7.2L)
1994 (3.0L DOHC & 3.5L) ..................... 9.0 Qts. (8.5L)
1995 ........................................ 7.9 Qts. (7.5L)
Cooling System
1983-88 ..................................... 8.5 Qts. (8.0L)
1989-95
2.6L ....................................... 9.7 Qts. (9.2L)
3.0L ...................................... 10.0 Qts. (9.5L)
1994
95
3.5L ...................................... 10.0 Qts. (9.5L)
Differential
1983-88 ..................................... 1.9 Qts. (1.8L)
1989-93
2.6L ....................................... 1.9 Qts. (1.8L)
3.0L ....................................... 2.7 Qts. (2.6L)
1994
3.0L & 3.5L ................................ 2.7 Qts. (2.6L)
1995
3.0L ....................................... 2.7 Qts. (2.6L)
3.5L ....................................... 3.3 Qts. (3.2L)
Engine Oil
1983-86 ..................................... 6.0 Qts. (5.8L)
1987 ........................................ 5.2 Qts. (5.0L)
1988 ........................................ 5.0 Qts. (4.8L)
1989-91 ..................................... 5.5 Qts. (5.3L)
1992-95 ..................................... 5.2 Qts. (4.9L)
Power Steering ................................ 1.1 Qts. (1.0L)
Fuel Tank
1983-88 .................................... 15.9 Gals. (60L)
1989-90
2.6L 2-Door ............................... 15.9 Gals. (60L)
3.0L 2-Door ............................... 19.9 Gals. (75L)
2.6L & 3.0L 4-Door .......................... 24 Gals. (92L)
1991-95 ...................................... 24 Gals. (92L)
Manual Transmission
1983-91 ..................................... 2.3 Qts. (2.2L)
1992 ........................................ 2.4 Qts. (2.3L)
1993-95 ..................................... 2.6 Qts. (2.5L)
Transfer Case
1983-91 ..................................... 2.3 Qts. (2.2L)
1992-95 ..................................... 2.4 Qts. (2.3L)
( 1) - Use of R12 in a R134a system will result in SEVERE DAMAGE.
( 2) - 1983 model equipped with manual transmission only.
\
\
\
\
\
\
\

Page 736 of 1333

$MITSUBISHI MONTERO 1991 Service Manual Power Steering (Dexron-II) Colt, Colt Vista, Colt 200, Mirage & Summit ...... 1.9 Qts. (.9L)\ Eclipse & Galant .................................. 1.9 Qts. (.9L)\ Montero ................$

Power Steering (Dexron-II)
Colt, Colt Vista, Colt 200, Mirage & Summit ...... 1.9 Qts. (.9L)\
Eclipse & Galant .................................. 1.9 Qts. (.9L)\
Montero .......................................... 2.2 Pts. (1.0L)\
Pickup & Ram-50 ................................... 1.9 Qts. (.9L)\
Stealth & 3000GT
2-Wheel Steering ................................ 1.9 Pts. (.9L)\
4-Wheel Steering ............................... 2.5 Pts. (1.2L)\
Transfer Case (SAE 75W-85/API GL-4)
Colt Vista ........................................ 1.5 Pts. (.7L)\
Eclipse & Galant .................................. 1.3 Pts. (.6L)\
Montero, Pickup & Ram-50 ......................... 4.7 Pts. (2.2L)\
Stealth ............................................. .3 Pt. (.2L)\
3000GT .............................................. .6 Pt. (.3L)\
(1) - Add 1.0 Pt. (.5L) with oil cooler.
\
\
\
\
\
\
\

QUICK-SERVICE
SERVICE INTERVALS & SPECIFICATIONS
REPLACEMENT INTERVALS\
\
\
\

Component Miles
Colt, Colt 200, Mirage & Summit
Air Filter ....................... 30,000
Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Fuel & Vapor Hoses ............... 50,000
Oil ................................ 7500
Oil Filter ....................... 15,000
Spark Plugs ...................... 30,000
Timing Belt ...................... 60,000
Colt Vista
Air Filter ....................... 30,000
Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
EGR Valve ( 1) .................... 50,000
Fuel & Vapor Hoses ............... 50,000
Oil ................................ 7500
Oil Filter ....................... 15,000
O2 Sensor ( 1) .................... 80,000
Rear Axle Fluid .................. 30,000
Spark Plugs ...................... 30,000
Spark Plug Wires ( 1) ............. 60,000
Timing Belt ...................... 60,000
Vapor Canister ( 1) .............. 100,000
Mirage
Air Filter ....................... 30,000
Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Fuel & Vapor Hoses ............... 50,000
Oil ................................ 7500
Filter ........................... 15,000
Spark Plugs ...................... 30,000
Timing Belt ...................... 60,000
Eclipse

Page 738 of 1333

MITSUBISHI MONTERO 1991 Service Manual Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Front & Rear Axle Fluid .......... 30,000
Fuel & Vapor H

Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Front & Rear Axle Fluid .......... 30,000
Fuel & Vapor Hoses ............... 50,000
Oil
Non-Turbo ........................ 7500
Turbo ............................ 5000
Oil Filter
Non-Turbo ...................... 15,000
Turbo .......................... 10,000
Spark Plugs ...................... 60,000
Timing Belt ...................... 60,000
3000GT
Air Filter ....................... 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Fuel & Vapor Hoses ............... 50,000
Front & Rear Axle Fluid .......... 30,000
Oil
Non-Turbo ........................ 7500
Turbo ............................ 5000
Oil Filter
Non-Turbo ...................... 15,000
Turbo .......................... 10,000
Spark Plugs ...................... 60,000
Timing Belt ...................... 60,000
(1) - Federal 4WD models only.
( 2) - Federal models only.
\
\
\
\

BELT ADJUSTMENT\
\
\
\
\
\
\

Deflection
Application ( 1) In. (mm)
Colt, Colt 200, Mirage & Summit
1.5L ...................................... .28-.35 (7.1-8.9)
1.6L ..................................... .35-.45 (8.9-11.4)
Colt Vista
2.0L ..................................... .28-.40 (7.1-10.2)
Eclipse
1.8L ..................................... .32-.43 (8.1-11.1)
2.0L ..................................... .35-.45 (8.9-11.4)
Galant
Alternator Belt .......................... .35-.45 (8.9-11.4)
A/C Belt .......................................... .32 (8.1)
Power Steering Belt ....................... .24-.35 (6.1-8.9)
Montero
3.0L ...................................... .20-.24 (5.1-6.1)
Pickup & Ram-50
2.4L ...................................... .27-.39 (6.8-9.9)
3.0L ...................................... .32-.39 (8.1-9.9)
Stealth & 3000GT
SOHC
Alternator & Power Steering Belt ........ .24-.35 (6.1-8.9)
A/C Belt ................................ .28-.37 (7.1-9.5)
DOHC
Alternator Belt (With or Without A/C) ... .16-.22 (4.1-5.6)
Power Steering Belt .................... .35-.43 (8.9-11.1)
( 1) - With 22 lbs. (10 kg) pressure applied midway on belt run.

Page 777 of 1333

$MITSUBISHI MONTERO 1991 Service Manual \003 * S U SPEN SIO N U NIF O RM IN SPEC TIO N G UID ELIN ES * 1 991 M it s u bis h i M onte ro GENERAL INFORMATION Steering, Suspension, Wheel Alignment, Wheels and Tires$

\003
* S U SPEN SIO N U NIF O RM IN SPEC TIO N G UID ELIN ES *

1 991 M it s u bis h i M onte ro
GENERAL INFORMATION
Steering, Suspension, Wheel Alignment, Wheels and Tires
Motorist Assurance Program
Standards For Automotive Repair
All Makes and Models
INTRODUCTION TO MOTORIST ASSURANCE PROGRAM (MAP)
CONTENTS
Motorist Assurance Program (MAP)
OVERVIEW
OVERVIEW OF SERVICE REQUIREMENTS & SUGGESTIONS
Steering and Suspension
AIR RIDE SUSPENSION
AIR RIDE SUSPENSION - AIR SHOCKS AND AIR STRUTS
AIR RIDE SUSPENSION - AIR SPRING VALVES
AIR RIDE SUSPENSION - AIR SPRINGS
AIR RIDE SUSPENSION - COMPRESSORS
AIR RIDE SUSPENSION - HEIGHT SENSORS
AIR RIDE SUSPENSION - MODULES
AIR RIDE SUSPENSION - RELAYS (COMPRESSOR)
AIR RIDE SUSPENSION - SWITCHES (ON/OFF)
AIR RIDE SUSPENSION - TORSION SPRINGS (COUNTER BALANCING)
AIR RIDE SUSPENSION - TUBING
AIR RIDE SUSPENSION - WARNING LAMPS
AIR RIDE SUSPENSION - WIRING HARNESSES
BALL JOINTS
BUSHINGS
CENTER LINKS
CONTROL ARM SHAFTS
CONTROL ARMS
DRAG LINKS
ELECTRONIC RIDE CONTROL SHOCKS AND STRUTS
IDLER ARMS
KING PINS
PITMAN ARMS
POWER STEERING HOSES
POWER STEERING (HYDRAULIC) PUMPS
RADIUS ARMS
RELAY RODS
SHOCK ABSORBERS, STRUT CARTRIDGES AND STRUT ASSEMBLIES
SPINDLES
SPRINGS - COIL, LEAF AND TORSION BAR
STEEL POWER STEERING LINES
STEERING ARMS
STEERING DAMPERS
STEERING GEARS (EXCEPT RACK AND PINION)
STEERING GEARS - RACK AND PINION
STEERING KNUCKLES
STRIKE OUT BUMPERS
STRUT RODS
STRUT UPPER BEARING PLATE ASSEMBLIES
SWAY BAR LINKS
SWAY BARS

Page 798 of 1333

$MITSUBISHI MONTERO 1991 Service Manual POWER STEERING HOSES POWER STEERING HOSE INSPECTION��\ ��\ ��\ ��\ ��\ ��\ ��\$

POWER STEERING HOSES
POWER STEERING HOSE INSPECTION\
\
\
\
\
\
\

Condition Code Procedure
Blistered ............... B ........... Require replacement.
Blocked ................. A . Require repair or replacement.
Fitting threads damaged . A . Require repair or replacement.
Fitting threads stripped
(threads missing) ...... A ........... Require replacement.
Inner fabric
(webbing) cut .......... A ........... Require replacement.
Leaking ................. A . Require repair or replacement.
Missing ................. C ........... Require replacement.
Outer covering is cracked
to the extent that
the inner fabric of
hose is visible ........ B ........... Require replacement.
Restricted .............. A . Require repair or replacement.
\
\
\
\
\
\
\

POWER STEERING (HYDRAULIC) PUMPS
If diagnosis has determined that complete disassembly is
necessary to determine the extent of the system failure, the
suggestion may be made to rebuild or replace the power steering pump.
Repair or replacement of the following components may be required if
performed as part of a power steering pump overhaul or rebuild service
to meet a minimum rebuild standard.
POWER STEERING (HYDRAULIC) PUMP INSPECTION
\
\
\
\
\
\
\

Condition Code Procedure
Attaching hardware bent . B ... Require repair or replacement
of bent part.
Attaching hardware
broken ................. A ... Require replacement of broken
part.
Attaching hardware
loose .................. A ... Require repair or replacement
of loose part.
Attaching hardware
missing ................ C .. Require replacement of missing
part.
Attaching hardware
threads damaged ........ A ... Require repair or replacement
of part with damaged threads.
Attaching hardware
threads stripped
(threads missing) ...... A ..... Require replacement of part
with stripped threads.
Belt alignment
incorrect .............. B .......... ( 1) Further inspection
required.
Belt cracked ............ 1 ............ Suggest replacement.
Belt frayed ............. 1 ............ Suggest replacement.
Belt missing ............ C ............ Require replacement.
Belt noisy .............. 2 .......... ( 2) Further inspection
required.
Belt plies separated .... A ............ Require replacement.

Load next 8 pages

Page: < prev 1-10 9-16 17-24 25-32 33-40 41-48 49-56 56 next >

wheel torque cabin filter 4WD remove seats rims oil temperature