1990 VOLKSWAGEN TRANSPORTER checking oil

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE
ENGINE OIL
Engine oil consumption t 3 normal for your engine to consume oil.

T-Q
rate of oil consumption depends on
re quality and viscosity of
oil,
the speed at
Mich
the engine is operated, the climate,

read
conditions as well as the amount of : ution and oxidation of the lubricant.

Because
of these variables, no standard
•e:e
of oil consumption can be esta-
:
shed,
but drivers should expect an in­
creased
oil consumption at high speeds
s.nd when the engine is new.
• The
engine
in your
vehicle
depends
on oil to
lubricate
and cool all of its
mov­

ing
parts.
Therefore
the
engine
oil
should be checked
regularly
and
kept
at
the
required
level.
•
Make
it a
habit
to
have
the
engine
oil

level
checked
with
every
fuel
filling.

• Lack of
sufficient
engine
oil may
lead

to
severe
engine
damage.

• The oil pressure
warning
light
is not
an oil
level
indicator.

Always
heed
WARNINGS
on
page
97.
The
engine oil dipstick and the oil filler

neck
are located behind the license plate

lid.

Checking the
engine
oil
level

The
best time to check the engine oil level
is
when the oil is warm.
• Turn off the engine.
• To get a true reading, the vehicle should

be
on level ground. After turning off the en­

gine,
wait a few minutes for the oil to return
to the crankcase.
• Flip license plate down.
• Pull out dipstick and wipe it clean
with
a

rag.

• Reinsert dipstick; push it in all the way. • Pull dipstick out again. The oil level is
correct if it is between the "max" and "min" marks on the dipstick.
• If oil level is below "min" mark, or not
showing on dipstick, add oil immediately.
• Make sure
that
the dipstick is com­
pletely in.
Adding
engine
oil • Unscrew cap from oil filler neck.
• Pull extension tube out of filler neck as
far as it will go.
• Only add the amount of oil needed. The
difference between the "min" and "max" marks on the dipstick is about
1
U.S. quart
or
1
liter. Always select a quality oil
with
the
correct specification. See "Lubricants" on
page
85.
Do not exceed the MAX
marking.

Otherwise,
the excess oil may be drawn in
through the crankcase breather into the exhaust system. The oil would then burn in
the catalytic converter and cause dam­
age.

•
Push
in the extension tube, replace fil­
ler cap and hand tighten securely.

WARNING

The oil
filler
cap
must
be secure to avoid oil spill causing
fire
hazard.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE
AUTOMATIC TRANSMISSION FLUID / MANUAL TRANSMISSION OIL
Automatic Transmission Fluid
The torque converter and the transmis­
sion are lubricated with Automatic Trans­ mission Fluid (ATF).
The final drive requires hypoid oil SAE 90,
which does not have to be changed.
Checking the ATF level
The ATF has to be checked at frequent intervals, for instance, when the engine
oil is being checked or at least at the intervals specified in your Maintenance
booklet.
Always heed WARNINGS on page 97. A correct ATF level is very important for
transmission operation.
To obtain an accurate reading, the
vehicle must be on level ground, and the
fluid must have reached operating
tem­

perature. Normally, after a cold-start the
fluid will reach operating temperature when the vehicle has been driven for ab­
out 6 miles or 10 km. If the ATF is too cool
or too hot, the fluid level reading will be inaccurate.
WARNING Before checking the ATF, the selector
lever must be securely locked in the Park position and the parking brake ap­
plied firmly.
Checking the ATF level is potentially hazardous because the hot engine has
to be running during the check. Do not
attempt to check the ATF before read­ ing all WARNINGS on page 97.
The ATF filler neck is in the engine com- partement on the left hand side. The dip­
stick is attached to the
plug.
Pull it out
and wipe clean first before inserting it to
take a reading. The Automatic transmission may be da­
maged by even a tiny speck of dirt.
Only use lint free rags to wipe the dip­
stick.
To get a true reading, the ATF must be at operating temperature.
You have enough ATF if the fluid level is between the two marks on the dipstick. I:
should never be above or below these marks. If level is too high or too low do not
just add or drain ATF. Have your dealer check and correct the cause as soon as possible.
For correct ATF specifications, see "Lub­
ricants" on page 85.
Changing the ATF
The ATF has to be changed at the inter­ vals specified in your Maintenance boo­klet.
Do not tow the vehicle or run the engine
without ATF in the transmission.
Manual Transmisson Oil Both transmission and final drive are
combined in one housing. The lubrican: used is hypoid oil which does not have tc
be checked or changed. If you shoulc
suspect a leak, contact your VW dealer.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
VEHICLE CARE
BRAKE FLUID 3 ATT
108 Brake fluid reservoir
The brake fluid reservoir is located under the instrument cluster in the dashboard
panel.

To gain access to the reservoir, grasp the two recesses provided on back of the frame cover and pull up.
When replacing the cover, insert the front edge first, then press the cover down
firmly. Make sure it is correctly seated.
Checking fluid level
The correct fluid level is important for the proper functioning of the brake system.
The fluid level in the brake fluid reservoir should always be between the MAX and MIN markings. Your brake fluid level is automatically monitored by the brake
warning light (see page 43).
The fluid level may drop slightly after some time due to the automatic adjustment of
the brake pads. This is no cause for alarm.
If the brake fluid level falls considerably
below the mark
"MIN",
the brake warning
light will come on. Do not continue to oper­
ate the vehicle. The complete brake sys­
tem should be thoroughly checked by your
Volkswagen dealer and the cause cor­
rected.

WARNING • Brake fluid is poisonous. Brake fluid
is also harmful to the paint of your
vehicle.
When adding or replacing brake fluid, make certain to avoid spilling. Brake
fluid will damage fabric, paint, plastics and metal. Cover the areas sorround-ing the reservoir before removing the
filler cap.
• If brake fluid must be added to the
reservoir, use only new and unused
DOT 4 brake fluid that meets SAE
specification J 1703 and conforms to Federal Motor Vehicle Safety Standard

116.
• Do not use any other brake fluid, or
brake fluid that has absorbed moisture
from the open air, or brake fluid that is
dirty. It may cause premature wear or unreliable braking action.
• Do not add or mix DOT 5 silicone
type brake fluid with the brake fluid in your vehicle as severe component cor­rosion may result. Such corrosion
could lead to brake system failure.
Changing brake fluid Brake fluid absorbs moisture from the at­
mosphere. If the watercontent in the brake
fluid is too high, corrosion in the brake sys­
tem may result after a period of time. The boiling point of the brake fluid will also de­
crease considerably. If the brakes are under constant and extreme use, a vapc
lock may result impairing the effectiveness
of the brakes and the vehicle safety. -e s
Dn seat arc
WARNING
The brake fluid must be replaced every 2 years. Your Volkswagen dealer will perform this service for you.
Always heed WARNINGS on page 97.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
ALPHABETICAL
INDEX

page

Accessories
122

Air
cleaner 103

Air
Conditioner 54 All-wheel-drive 75
Alternator warning
light
44

Ashtrays
64
Assist
handles and coat hooks ... 67
Automatic safety belts 14
Automatic Transmission 35
Automatic Transmission Fluid .... 102 Auxiliary Heater 57, 60
Battery 109
Battery charging 110

Brake
fluid reservoir 108

Brake
warning
light
43
Brakes
29

Break-in
period 69

Bulb
chart 130

Bulb
replacing 130
Buzzer
7,35

Capacities
147

Catalytic
converter 144

Central
locking system 8
Cigarette lighter 63
Child
safety 15

Chime
7,35

Cleaning
products 89

Climate
controls 51
Clock
41 page

Coolant
temperature gauge .... 41

Cooling
system 104

Consumer
information 152
Corrosion
protection 94

Cruise
control 49

Curtains
27

Cup
holder 66

Dashboard
4

Data
146
Defogging/defrosting 52 Differential lock 33

Dimensions
148
Do-it-yourself service 123

Doors
9

Economically
driving 72

Electric
windows 12

Emergency
equipment 70
Emergency
flasher 46

Emergency
starting 136

Emergency
towing 138

Emission
Control System 144
Engine
code letter 151

Engine
compartment lid 97

Engine
cooling 41,104
Engine
exhaust 144

Engine
number 151

Engine
oil changing 100
pace

Engine
oil checking 9?

Engine
oil grades 9E

Expansion
tank 105

Fan
41, 10c

Folding
table 65

Foreign
country driving 120 Front seats 20

Fuel
economy 72

Fuel
gauge 42
Fuel
injection 142

Fuel
supply 86

Fuel
tank 85

Fuses
12E

Gas
Station
Information
156

Gasoline
additives 86
Gearshift lever 32

Glove
compartment 64
Headlight dimmer and flasher .... 48 Headlights 13C
Headlight adjustment 134
Headlight switch 46

Head
restraints 19 HeatingA/entilation 51
High beam 45,48
Horn 4
Identification label and number ... 151
Ignition/steering lock 38
Indicator lights 43


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans