1986 TOYOTA SUPRA horn

7. DISCONNECT THEFT DETERRENT HORN FROM BODY
8. REMOVE FRONT LOWER ARM BRACKET STAY
Remove the 2 bolts, nut, plate washer and arm bracket stay.
Torque:
Bolts
44 NVm (450 kgfVcm, 33 ftVlbf)
Nut
59 NVm (600 kgfVcm, 43 ftVlbf)
9. REMOVE UPPER FRONT CROSSMEMBER EXTENSION
Remove the 2 bolts, 2 nuts and crossmember extension.
Torque:
Bolts
29 NVm (300 kgfVcm, 22 ftVlbf)
Nuts
33 NVm (340 kgfVcm, 25 ftVlbf)
10. REMOVE NO.2 FRONT EXHAUST PIPE
(a) Remove the 2 bolts and nuts holding the front exhaust pipe
to the No.2 front exhaust pipe.
Torque: 58 NVm (590 kgfVcm, 43 ftVlbf)
(b) Remove the 2 bolts and pipe support bracket.
Torque: 43 NVm (440 kgfVcm, 32 ftVlbf)
(c) Disconnect the front exhaust pipe from the No.2 exhaust
pipe. Remove the gasket.
INSTALLATION HINT: Use a new gasket.
(d) Remove the 3 nuts, No.2 front exhaust pipe and gasket.
INSTALLATION HINT: Use a new gasket and 3 new nuts.
Torque: 62 NVm (630 kgfVcm, 46 ftVlbf)
11. REMOVE HEAT INSULATOR FOR NO.2 FRONT EXHAUST
PIPE
Remove the 2 bolts, 2 nuts and heat insulator.
12. DISCONNECT A/T OIL COOLER TUBES FROM ENGINE
(a) Remove the bolt and tube clamp, and disconnect the oil
cooler tubes from the bracket (front side) on the generator.
(b) Remove the bolt and tube clamp, and disconnect the oil
cooler tubes from the bracket (rear side) on the cylinder
block.
(c) Remove the bolt and tube bracket (rear side) from the
cylinder block.
± ENGINETURBOCHARGER SYSTEM (2JZ±GTE)EG±151

(d) Remove the rubber cap and nut, and disconnect the
generator wire.
(e) Disconnect these connectors:
(1) Connector from engine room main wire
(2) Igniter connector
(3) Theft deterrent horn connector
(f) Disconnect the engine wire from the 2 wire clamps.
(g) Disconnect the wire clamp and PS solenoid valve connector.
(h) Remove the bolt, and disconnect the ground strap from the
cylinder block.
(i) Remove the rubber cap and nut, and disconnect the starter
wire.
± ENGINEENGINE MECHANICALEG±79

METER, ANALOG
Current flow activates a magnetic
coil which causes a needle to
move, thereby providing a relative
display against a background
calibration. LED (LIGHT EMITTING DIODE)
Upon current flow, these diodes
emit light without producing the
heat of a comparable light. IGNITION COIL
Converts low±voltage DC current
into high±voltage ignition current
for firing the spark plugs. 1. SINGLE
FILAMENT
GROUND
The point at which wiring attaches
to the Body, thereby providing a
return path for an electrical circuit;
without a ground, current cannot
flow.Current flow causes a headlight
filament to heat up and emit light.
A headlight may have either a
single (1) filament or a double (2)
filament. BATTERY
Stores chemical energy and
converts it into electrical energy.
Provides DC current for the auto's
various electrical circuits.
CAPACITOR (Condenser)
A small holding unit for temporary
storage of electrical voltage.
CIRCUIT BREAKER
Basically a reusable fuse, a circuit
breaker will heat and open if too
much current flows through it. Some
units automatically reset when cool,
others must be manually reset.
DIODE
A semiconductor which allows
current flow in only one direction.
DIODE, ZENER
A diode which allows current flow
in one direction but blocks reverse
flow only up to a specific voltage.
Above that potential, it passes the
excess voltage. This acts as a
simple voltage regulator.
FUSE
A thin metal strip which burns
through when too much current
flows through it, thereby stopping
current flow and protecting a
circuit from damage.
FUSIBLE LINK
A heavy±gauge wire placed in
high amperage circuits which
burns through on overloads,
thereby protecting the circuit.
The numbers indicate the cross±
section surface area of the wires.HORN
An electric device which sounds a
loud audible signal.
LIGHT
Current flow through a filament
causes the filament to heat up
and emit light.
METER, DIGITAL
Current flow activates one or
many LED's, LCD's, or fluorescent
displays, which provide a relative
or digital display.
MOTOR
A power unit which converts
electrical energy into mechanical
energy, especially rotary motion. CIGARETTE LIGHTER
An electric resistance heating
element.
DISTRIBUTOR, IIA
Channels high±voltage current
from the ignition coil to the
individual spark plugs.2. DOUBLE
FILAMENT HEADLIGHTS
FUEL
(for High Current Fuse or
Fusible Link.)
(for Medium Current Fuse)
M
16
GLOSSARY OF TERMS AND SYMBOLS

24
ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[2JZ±GTE]
A 1 A/C Ambient Temp. Sensor E 4 Engine Coolant Temp. Sender (Water Temp. Sender)
A 2 A/C Condenser Fan Motor E 5 Engine Coolant Temp. SW (Water Temp. SW)
A 3 A/C Triple Pressure SW E 6 Engine Hood Courtesy SW
(A/C Dual and Single Pressure SW) E 7 Engine Oil Level Sensor
A 4 A/C Magnetic Clutch and Lock Sensor
A 5 A/T Fluid Temp. Sensor F 1 Front Airbag Sensor LH
A 6 ABS Actuator F 2 Front Airbag Sensor RH
A 7 ABS Actuator F 3 Front Fog Light and Parking Light LH
A 10 ABS Speed Sensor Front LH F 4 Front Fog Light and Parking Light RH
A 11 ABS Speed Sensor Front RH F 5 Front Side Marker Light LH
F 6 Front Side Marker Light RH
B 1 Back±Up Light SW (for M/T) F 7 Front Turn Signal Light LH
B 2 Brake Fluid Level Warning SW F 8 Front Turn Signal Light RH
F 9 Front Wiper Motor
C 1 Camshaft Position Sensor No. 1
C 2 Camshaft Position Sensor No. 2 G 1 Generator (Alternator)
C 3 Crankshaft Position Sensor G 2 Generator (Alternator)
C 4 Cruise Control Actuator
H 1 Headlight Hi LH
D 1 Data Link Connector 1 (Check Connector) H 2 Headlight Hi RH
D 2 Daytime Running Light Relay No. 3 H 3 Headlight Lo LH
D 3 Daytime Running Light Relay No. 3 H 4 Headlight Lo RH
H 5 Heated Oxygen Sensor (Main)
E 1 EGR Gas Temp. Sensor H 8 Horn LH
E 2 Electronically Controlled Transmission Solenoid H 9 Horn RH
E 3 Engine Coolant Temp. Sensor (EFI Water Temp. Sensor)

25
Position of Parts in Engine Compartment
[2JZ±GTE]
I 1 Idle Air Control Valve (ISC Valve) R 1Radiator Fan Motor
I 2 Igniter R 2Radiator Fan Relay No. 1
I 3 Igniter R 3Radiator Fan Relay No. 2
I 6 Ignition Coil No. 1
I 7 Ignition Coil No. 2 S 1 SFI Resistor (EFI Resistor)
I 8 Ignition Coil No. 3 S 2Starter
I 9 Ignition Coil No. 4 S 3Starter
I 10 Ignition Coil No. 5 S 4 Sub Throttle Actuator
I 11 Ignition Coil No. 6 S 5 Sub Throttle Position Sensor
I 12 Injector No. 1
I 13 Injector No. 2 T 1 Theft Deterrent Horn
I 14 Injector No. 3 T 2 Throttle Position Sensor
I 15 Injector No. 4 T 3 Traction Brake Actuator
I 16 Injector No. 5 T 4 Traction Pump and Motor
I 17 Injector No. 6 T 14 Turbo Pressure Sensor
K 1 Knock Sensor (on Front Side) V 2 VSV (for EGR)
K 2 Knock Sensor (on Rear Side) V 3 VSV (for EVAP)
V 4 VSV (for Exhaust Bypass Valve)
M 1 Mass Air Flow (Air Flow Meter) V 5 VSV (for Exhaust Gas Control Valve)
V 6 VSV (for Fuel Pressure Up)
N 1 Noise Filter V 7 VSV (for Intake Air Control Valve)
V 8 VSV (for Waste Gate Valve)
O 1 O/D Direct Clutch Speed Sensor V 10 Vehicle Speed Sensor (Speed Sensor) No. 1 (for
O 2 Oil Pressure SW Combination Meter)
V 11 Vehicle Speed Sensor (Speed Sensor) No. 2 (for
P 1 PPS Solenoid Electronically Controlled Transmission)
P 2 Park/Neutral Position SW (Neutral Start SW),
Back±Up Light SW and A/T Indicator Light SW W 1 Washer Motor
(for A/T)

27
Position of Parts in Engine Compartment
[2JZ±GE]
H 1 Headlight Hi LH O 2 Oil Pressure SW
H 2 Headlight Hi RH O 3 Oxygen Sensor (Except California on Front Side)
H 3 Headlight Lo LH O 4 Oxygen Sensor (Except California on Rear Side)
H 4 Headlight Lo RH
H 8 Horn LH P 1 PPS Solenoid
H 9 Horn RH P 2 Park/Neutral Position SW (Neutral Start SW),
Back±Up Light SW and A/T Indicator Light SW
I 1 Idle Air Control Valve (ISC Valve) (for A/T)
I 4 Igniter P 3 Power Steering Pressure SW
I 5 Ignition Coil
I 12 Injector No. 1 S 2 Starter
I 13 Injector No. 2 S 3 Starter
I 14 Injector No. 3
I 15 Injector No. 4 T 1 Theft Deterrent Horn
I 16 Injector No. 5 T 2 Throttle Position Sensor
I 17 Injector No. 6
V 1 VSV (for ACIS)
K 1 Knock Sensor (on Front Side) V 2 VSV (for EGR)
K 2 Knock Sensor (on Rear Side) V 3 VSV (for EVAP)
V 6 VSV (for Fuel Pressure Up)
M 2 Main Heated Oxygen Sensor V 10 Vehicle Speed Sensor (Speed Sensor) No. 1
(for California on Front Side) (for Combination Meter)
M 3 Main Heated Oxygen Sensor V 11 Vehicle Speed Sensor (Speed Sensor) No. 2
(for California on Rear Side) (for Electronically Controlled Transmission)
V 12 Volume Air Flow (Air Flow Meter)
N 1 Noise Filter
W 1 Washer Motor

44
POWER SOURCE (Current Flow Chart)
The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link,
Circuit Breaker, Fuse, etc.) and other parts.
The next page and following pages show the parts to which each electrical source outputs current.
50A MAIN Battery
* These are the page numbers of the first page on which
the related system is shown.
The part indicated is located somewhere in the system,
not necessarily on the page indicated here.
20A RAD No. 1(2JZ±GTE)
30A EFI No. 2Generator
(Alternator) 7.5A DOME
7.5A ALT±S
15A HAZ±HORN
15A FOG
30A EFI No. 1
120A ALT
Starter
30A ABS No. 2
7.5A TRAC
(2JZ±GTE)
30A AM230A FAN
50A HTR
60A ABS No. 1
60A POWER
50A AM1 (For USA)
60A AM1 (For Canada)
Headlight Relay
Dimmer Relay (Daytime
Running Light Relay No. 2)
Ignition SW
(AM2)Taillight Relay
(Point Side)
30A DOOR
15A STOP
10A ECU±B
30A DEFOG
Ignition SW
(AM1)
15A HEAD (LH) (For USA)
15A HEAD (LH±LWR)
(For Canada)
15A HEAD (RH) (For USA)
15A HEAD (RH±LWR)
(For Canada)
7.5A DRL
15A HEAD (LH±UPR)
(For Canada)
15A HEAD (RH±UPR)
(For Canada)
7.5A IGN
(2JZ±GTE)
(2JZ±GE)
(Canada)
(Canada) (Canada)
[LOCATION](1): J/B No. 1 (See page 20)(2): R/B No. 2 (See page 19)(3): R/B No. 4 (See page 23) 20
22 23

46
POWER SOURCE (Current Flow Chart)*1: (FOR CANADA)
*2: (FOR USA)
A/C Condenser Fan Motor
228
A2 *Page Nos. of
Related Systems
Parts
Code or
Location
CB or Fuse
Location
* These are the page numbers of the first page on which the related system is shown.
The part indicated is located somewhere in the system, not necessarily on the page indicated here.


7.5A HTR
7.5A IGN
7.5A RAD No. 2
7.5A ST
7.5A TURN
10A ECU±B
10A ECU±IG
10A GAUGE
10A MIR±HTR
10A PANEL
10A TAIL
15A CIG
15A SEAT±HTR
15A STOP
20A WIPER
30A DEFOG
30A DOOR
7.5A ALT±S
7.5A DOME
7.5A DRL
7.5A TRAC
15A FOG
15A HAZ±HORN
15A HEAD (LH) *2
15A HEAD (LH±LWR) *1
15A HEAD (LH±UPR) *1
15A HEAD (RH) *2
15A HEAD (RH±LWR) *1
15A HEAD (RH±UPR) *1
20A RAD No. 1
30A ABS No. 2
30A EFI No. 1
30A EFI No. 2
30A FAN
50A HTR
50A MAIN
60A ABS No. 1
60A POWERA3 A4 A6 A8 A9 A12 A14 A18 A19 A20 A22 A23 A24 A29 A30 A33 B1 B2 B4 B6 B7 228 228159
164159 159 228208
228159 159 164 164159
164228 122 210 210 116164
220228 206 206
A/C Single Pressure SW
[A/C Triple Pressure SW]
A/C Magnetic Clutch and
Lock Sensor
ABS Actuator
ABS Relay
A/C Amplifier
ABS ECU
ABS and Traction ECU
ABS Lateral Acceleration
Sensor
Air Inlet Control Servo Motor
Ashtray Illumination
Auto Antenna Control Relay
Auto Antenna Motor
Back±Up Light SW (for M/T)
Brake Fluid Level Warning SW
Blower Motor Control Relay
Buckle SW LH
Buckle SW RH
[LOCATION](1): J/B No. 1 (See page 20)(2): R/B No. 2 (See page 19)(3): R/B No. 4 (See page 23)
20 22
23