1981 CHEVROLET MONTE CARLO automatic transmission

Downloaded from www.Manualslib.com manuals search engine COOL
WARM
Add just enough DEXRO~ II fluid to fill the transmission to the proper level. It
takes only 0.5 liter (one pint) to raise the level from "Add" to "Full" with a hot
transmission.
Automatic Transmission Drain Intervals
Change the transmission fluid and change the filter (or clean the screen) as
outlined
in Section A of the Maintenance Schedule folder.
ENGINE COOLING SYSTEM
Your vehicle has a coolant recovery system. Coolant in the system expands
with heat and overflows into the recovery tank. When the system cools down,
coolant is drawn back into the radiator.
The cooling system was
filled at the factory wrth a quality coolant that meets
GM
Spec~ication 1S99-M . The cooling ·system is designed to use coolant (a
mixture of water and ethylene glycol antifreeze) rather than plain water. The
coolant solution should be used year round.
It has many advantages, such as:
~ provides freezing protection down to -3rC (-34"F) "''''''<~. !'"","."" ' • provides boiling protection up to 12S"C (262"F),
• protects against rust and corrosio~in th~ cooling system,
• maintains the proper engine temperature for efficient operation and
emission control, and
• allows proper operation of the coolant temperature light or gage :
See Section A of the Maintenance Schedule folder to find out when the coolant
must
be ·replaced.
Cooling System Care
Check the c60ling system at regular intervals, such as during fuel stops . You usually do not need to remove the radiator cap to check the coolant level. Lift
the engine hood and look at the "see through" coolant recovery tank. When
the engine is
cold, the coolant level should be at the "Full Cold" mark on the
tank . When the engine has fully warmed . up, the level should be above the
"Full Cold" mark on the tank . If the coolantl6vel is low, remove the cap on the
coolant recovery tank. Add to the recovery tank enough of a 50/50 mixture of
water and a good quality ethylene glycol antifreeze to bring the
level up to the
proper mark. Put the cap back on the recovery tank.
Certain conditions, such
as air trapped in the system, may affect the coolant
level in the radiator. You should check"the coolant level in the radiator at the
time you change the engine
oil and when the engine Is cold. Follow.taps I, S,
9, and 10 under "Coolant Repfacement" for the correct way to remove the
radiator cap and add coolant.
5-6

Downloaded from www.Manualslib.com manuals search engine AJt Cleaner. Ail CoricIitionor FOlK Season .. Mainten ance .. AM" Pressu-e. Tires. AM" Vents. Alterna tOf tGEN) l.ghl AUniIlUffi Cafe .. AM or AM-FM Radios Antenna Antifreeze . Appearaoc e Care . Ash1rays & Lignler s. Assistance. Owl"lef Automat ic Door Locks. Automatic Transmission CorwElfter ClUlch Maintenanr;e
"""'-OpefaJ .... '1 TiPS.: AKIe. Re ar Standard . lifnited-SHp . Babies. AesCraint 01 .. BaIt Joints .. fun..., E mergency S ta ring F reedom. Gas Caution ..• GEN 191I... .•.• Test Indicator ...
. ........ 5-9
2-24
5-11
5-12
2-23 ....... 2·17 ... 2:27. 2-28 2·29 (Seo "Coolant") ,.,
2·22 6·' ,.,
2·10 5-5 .. 2 -9 2 ·'
5 ·'
5·' 1·10. ,-" . 5·1 0
3 ·' 5-10 3·' 2-17 5·10 Betore Dr iving Your Vehide... \. Bells: Sea!....,.. . (See I'Se at Belts") Blower, Healer & Air Cond.. 2-24. 2-25
Body Da mage . 4-4
.. """ ~,. Pedal Travel Trailer Towing .... Warning Ught .
2·14 2-\4 H2 2-17
Breakers . <;ircui t. • ..... 2-21. 7·3 Bteak ..... Period. New Vehicle ..• 2·2 Srioj'!( Headlights 2·7. 2·21 Brighl Metal Cleaning 4-4
Bulbs & Fuses.. 7·3. 7-4 Bumpers & HiIC:·~s. '·13 ~ 'Jack Operation ...... 3-4 B.w:ers._ . (See "'SOunds'" CoirpJler Con"mand Cont rOl System:~ 2·\8, 5·3 Cop Coolant A ecovery Tant.: .. ................. , .. 5-6 F uel.. 5-2 f>o¥Iier Steefing.. _____ -._ ....... ...... 0<. _____ -5-9 Radiator ... 5·8 Capacity, Cargo Weight. 5-11 Capacities. FlUid:. 7- Car Break-In Period . New.. 2-2 . car -Chemicals ... carbon Monoxide cautJorI .... ___ 4·' 2·' Care & Cleaning. Appearance . . .. 4·' Cargo Capacity . 5-11 Cargo on Root . Carrying,. '·2 Catalytic Converter . . ..................... ....... 5-2 ~ Command Control System .. -2·18. , ·3 Chains. Tire .. 5·15
7-6
Changing Wheets & Tires .. _ Cl-£O< ENGtl'E light .. Chectlbt, DrillSf . Child Seals & Restr ainls Chrome Protection .. ag.yette lighter ... CirCUIt Beakers QtiZOtlS Band Raoio . C!earIing .. Clock.I .. Cloth Trim Care .. ClutCh . Converter
Cold W&ather Starting ....
3 ·4 . 3·5 2 ·18. 5-3 ,., I -tO. 1·11 ... 2·22 2·21 , 7·3 2·29 . ..... 4·' 2-22 '·2 2·10 2·8 ~ip""lt Plocedu.-e . . ... 6 ·1
Condi lioner, Air (See "All" Cooditioner"~ Cons umer Relation s ... Converter ClUtch Con...eJo: Mirror Cooling System Afltilreeze (CooIanI) .. Overheating R ecovery Tank Service,. Thermoslal . COfl"lefing Lights . CorTosion Pmlection. Countries. Oper-ating in Fo.-eign .. Courtesy lights CruISe Control Cus!omer Service . 5·6
3·3
3 ·4 ,
5·6 '·7 '·8 2·7 . . 4-5 2· ' 2·30
2·12
6·' Damage, Sheet Metal . 4·4 Detogger,Re..-WiNJoW.. 2-25 DelrOSlor. Windshield . 2·24. 2·25 Delay Wipers 2·20 Descending a· Grade 2-9 Ditlererlliai (Rear Axle) limited·Slip __ 5·9 ,Malt)l~O 5 ·9
Trailllfing. 1·1 2
Dimensions 7· , Oimn'\e( Switch, Head~L 2·14 O ipshCks A.utomalic Tfansmission .. . 5-4 Engine Oil 5·3 Power Steering. 5-9 Directional Signals.. 2-7 Disc Brakes 2·15 Door loc::ks . __ ................ 1-2 Orivet' Checklist 1-1 Driving Down S teep Grades .... 2-9 in OU'sty Areas . 5 .... on Slippery Surlaces .................... 2·9 Economy ripS. Fuel .............................. 2-4 E lectric· Po_oo QpIion$ .. (See "Power"') Electrical System Banerv .. S-1 0 Bulbs .. . ....... ...... .... ........... 7,4 Circuit Breakers ....... , ........................ , 7-3 Fuses:. 7·3 GEN (Genefalor) lighI ..................... 2· 17 Jump S tarting 3- Spark Plugs 7-2 Voltmeter . 2·19 Emetgency. In Case oj Bralle WCIIllWlg li!1Il .. Eroglne Hot light .. • .. 2·17 . 2·17

Downloaded from www.Manualslib.com manuals search engine -. lap/ShOulder ..• light/Buzzer Reminder .. Pregn!lll1 Women ..
1-10 ,., ,.,
,.,
Rear Seal.. SeIr·~stiOg BrakE!S .. SENSOR Indicator:
......... 1-8. 1-9
Sensor, Oxygen .. serviCe & Maintenance Service Station Information .. CoVer)
_ 2-14 5·3 '·3 5·' (Irisioo' Back
ShOOt Metal Damage". Shoulder Belts .. Sidemarker ,lights.
4·5 (See "Seat Betts")
Signals. Turn .. Slippefy Surfaces, Driving On .. Snow Chains
Snow Tires _. Sounds (Buzzers. Tones,elc.) Disc Brake Wear Indicator.
Headlights On .. Key Reminder. Seal Bell Spare Tire
"""-Jacking Stowage Spark Plugs Sound Systems (Radios): Speakers .. Spatilicatlons
Speed,CrUise Control .. S~. New Car Break-In. Speedometer & Odometer Spot Cleaning Stainless Steel Protection. stains. RemOval' 01".,.; Starter Salety Switch Starting Emergency (Jump. Starting). Engine Fails to Start Gasoline Engine. Pushing to Start. Steering Column Controls Column lock. Power .. Wheel, Till Stereo. Radios & Tape Systems 2·29 Stowage 0( Tire & Jacl< Stowing Things In (Or (0) Gat StucfI. Car, Freeing. Sunrool ................... . Suspension Ball Joints Tachometer Tape Systems, Stereo T ernpei'ature Gage T~ature light Thefmostat
2-26,
7-4 2·' 2·' 5-15
5-15
2-15
2-21
. 2-7 ,.,
3-8 3·5 3·' 7-2
2-26 2-27
,., 2-12 2-2 2-15 4·2 4·4 4-3 2·'
3-, 2·' 2"8 5·2
2·6 2·6 2-11
2-11
2-28,
3·' '·2 3·' 2·30
5-10 2-18 2-27
2-19
2-17 5·' Tilt-Away Steering Whee! 2-11 TipS. Operating (See "Operating TIPS" TlreS) Air Pressure. 5-11
7·9
ChainS ..
-. Cleoning. 5-15 3-4,3-5,
U .; _ ... 4 .... 3·6 """-' -.. H..,·_ .. . ............. _ ..... _ ...... 5-12
Inflation Pressure. Load Capacity .. Load Range .. Overseas Use. Placatd .. PreSsur&,·Ait.,
Replacement WhOOIs .. Stowage .. Trailer Towing. Top Care, Vinyt .. Towing OisablOO Vehicle .. To start .. Trailaring .. Transmission
........ 3-4,3-5, 3-6 5-12 5-11 5-11 . ............. ; ... 2-4 . .......... _ ... 5-11 5-12 5-17 3~5. 3-6,3-7 1-12 ...
,., .._ .... : .. 3-9 1-12
Automatic .. (See ,'Automatic TransmiSSion") Transmitter, Mobile Radio .. Trip Odometer .• ... T,,... Driving With Trunk Open ......... 2-2 Key. 1-1 Release, power .................... 2·22 Turbochafgef Oil Change_. 3-33 Turbocharger Power ...... ....... , ........... 2-32 Tum Signals.. . .... 2-7 Unleaded Gasoline (See "Fuel") Upholstery Care _. . 4-I
Vehicle Identification Number 7-5 Vehicle Loading.. 5·11
Ventilation System.. 2-22 Vents, Outside Ail".. 2-22 VIN 7-5 Vinyl
Fabric Care Root Care .. Vollmeter ..
... 4-2 4-4 2-19
Warning Flasher, Hazard Warning. Lights .. '-3-1 (See "lights-:) (See WarrantY folder) Warranty Washers,· Windshield
Washing Car. Waxing & Polishing . Wear Indicators, Disc Brake
Weight, Load Carr'iiog. Wheel Changing Wheel Nut Torque
Whgels, Replacement
Wheal, Till Steering.
Windows Manual.
Pow~ Rear, Defogger .. Windshield
2-19
. .............. 4-4 ...... 4-4 ........ 2-15 5-11 3-5 . . 3-6 3-7, 7-2 5-17 2-11
Defrosting & Defogging ..... , ............. 2-25
Washer Use in Cold Weather .. 2·20 2-19 2-19 Washer Fluid .. Wipers & Washers
Wrecker Towing
Zone Offices .. ................. 3-9 6-2, 6-3