1976 CHEVROLET MONTE CARLO automatic transmission

Downloaded from www.Manualslib.com manuals search engine Pari Number SiZe
1050520 16 oz.
1050729 8 oz.
1050803 1 lb.
1051055
16 oz.
1051186 22% oz.
1051398 8
oz.
1051515 32 oz.
1051516 32 oz.
1051772 20 oz.
1051855 32 oz.
1051858 16 oz.
Description
Lubriplate (White Grease)
Vinyl Top Cleaner
Multi-Purpose
Powdered
Cleaner
Preservatone
Gem Glo
Spot
Lifter
Optikleen
Washer Solvent and
Gas Line
De-Icer
Presoftened Cleaner/Wax
Dexron II
G.M. Super E.O:S.
(Engine Oil Supplement)
4-8 Hood,
Trunk and Door Hinges and Latches
Cleans optional vinyl tops
Qleans vinyl and cloth on door trim,
seats and carpet;
also ti res and mats
Preserves finish on
vinyl fabric
Quick
clean-up and wax; for slightly dirty finishes
Spot and stainiemoval on cloth and fabric
Windshield Washer solvent and anti-freeze
Same as 1050001
One-step cleaner and wax
Automatic Transmission fluid
Consult your Dealer for usage

Downloaded from www.Manualslib.com manuals search engine TRANSMISSION ITEMS
Automatic Transmission­
Fluid Level
Recommendations
Use automatic transmission
fluids identified with the mark
DEXRON®-II available from your
Chevrolet dealer
or local service
station.
Check the fluid level
at each en­
gine oil change period.
Automatic transmissions are
fre­
quently overfill¢ level
is checked when the fluid is
cold and the dipsick indicates fluid
should be added. However, the low
reading may
be normal since the
fluid level will rise as the fluid tem­
perature increases. A level change
of over
% inch will occur as fluid
temperature rises from
60° F. to
180° F. (16° C. to 82° C.)
Overfilling can cause foaming
and loss of fluid through the vent.
(650 -8S"F.) (18" _29°C.) COOL HOT
WARM
NOTE, DO NOT OVERFill. It takes only one pint to raise level from ADD to FULL with a hot transmission.
Slippage and transmission failure
can result.
Fluid level too low can cause
slipping, particularly when the
transmission is cold or the car is
on a hill.
Check the transmission fluid
level with the
engine running, the
shift lever
in Park, and the car
level.
Remove the dipstick and touch
the transmission
end of the dipstick
5-5
L.
NOTE: lithe vehicle has recently
been operated for an extended
period at high speed or in city
traffic
in hot weather or the vehi­
cle is being used to pull a trailer,
an accurate fluid level cannot be
determined until the fluid has
cooled down-usually apout 30
minutes after the vehicle has been
parked.)
cautiously to find out if the fluid is
cool, warm or hot.
Wipe it clean and re-insert until
cap seats. Remove dipstick and
note reading.
• If the fluid feels cool, about room
temperature
(65° F. to 85° F.)
or (18° C. to 29° C.), the level
should
be 1;8 to % inch below
the
"ADD" mark The dipstick
has two dimples below the
"ADD" mark to show this range.
"'j' S' ~ c· "

Downloaded from www.Manualslib.com manuals search engine • If it feels warm, the level should
. be close to the "AilD" mark
(either slightly above or below) .
• If it feels hot (cannot be held
comfortably) the level . should be
between the "ADD" and
"FULL" marks.
NOTE: DO NOT OVERFILL. It
takes only one pint to raise level
from ADD to
FULL with a hot
transmission.
Automatic Transmlssion­
Drain
Intervals
The transmission operating tem-perature
resulting from the type of
driving
conditions under which
your vehicle
is used is the main
consideration in establi shing the
proper frequency of transmission
fluid changes.
If you do not use your vehicle
under severe conditions, change the
fluid and filter every
60,000 miles.
Refer to section
6, "Specifications",
for required fluid quantities.
If the vehicle is usually driven
under one or more of the follow­
ing conditions
-considered severe
transmission service
-change. the
transmission fluid and filter every
15,000 miles.
5-6
• In heavy city traffic .
• Where the outside temperature
regularly reaches 90
0P (32°C)
for extended periods.
• In very hilly or mountainous
areas.
• Frequent trailer pulling .
• Commercial uses, such as taxi,
police
car or delivery service.
Transmission Shift Linkage
Every 7,500 miles or 6 months
lubric ate shift linkage with water
resistant
EP chassis Illbricant which
mee
ts GM specification 6031 M.

Downloaded from www.Manualslib.com manuals search engine Front suspension
Every 6 months or 7,500 miles
Lubricat~ fittings with water re­
sistant EP Chassis Lubricant which
meets
GM Specification6031M.
NOTE: , Ball joints should not be
lubricated unless their temperature
is
+10° F (- 12 °C), or higher.
During cold weather, they should
be allowed to
warm up as necessary
before being
l\lbricated.
Steering Linkage
Every six months or 7,500 miles,
lubri cate fittings with water
resist­
ant EP Chassis Lubricant which
meets GM Specification
6031M.
Power Steering System
Check the fluid level in the pump
reservoir at each oil change period.
Add GM
Power Steering Fluid
(or Automatic Transmission Fluid
DEXRON"-II) as necessary to
bririg level into proper range on
filler cap indicator depending upon
fluid temperature.
If at operating temperature (ap­
proximately 150°F, 66°C-hot to
the touch), fluid should be between
"HOT" and "COLD" marks. If at
room temperature (approximately
70°F, 22°C), fluid should be be­
tween "ADD " and "COLD " marks.
Fluid does not require periodic
changing.
5-10
"HOT" MARK
''COL~'' MARK
\::::j. __ "ADD"

Downloaded from www.Manualslib.com manuals search engine INDEX
Absorbers, Superlift Shock. . . . . . . . . .. 2-27
Accessory Drive Belts. . . . . . . . . . . . . .. 5-4 Accessory P()sition, Steering Column Lock. . . . . . . . . . . . . . . . . . .. 2-2
Acrylic Lacquer. . . . . . . . . . . . . . . . . . .. 4-5 Adjusters, Automatic Brake. . . . . . . . .. 2-9 Air Adjustable Superlift Shock Absorbers. . . . . . . . . . . . . . . .. 2-27 Air Circulation .......... " ..••..... 2-17 Air Cleaner . . . . . . . . . . .. . . . . • • . . . . .. 5-4 Air Conditioning
Automatic Operation. .. . . . . . . . . . .. 2-22
4 Seasons Operation. . . . . . . . . . . . .. 2-20 Maintenance. . . . . . . . . . . . . . . . . . . .. 5-12 Air Inlets , Ventilating System ........ 2-17 Antenna •.......... -•....•• , . • . . . . .. 2-25 Anti-freeze (See Cooling System).... .. ~l Anti-Spin Differential. . . . . . . . . . . . . .. 2-27 Anti-Theft Key Buzzer System ........ 2-2 Anti-Theft Steering Column Lock. . . .. 2-2
Appearance Care. . . . . . . . . . . . . . . . . .. 4-1 Ash Trays. . . . . . .. .. . . .. . . . . . . . . ... 2-10 Automatic Brake Adjusters. . . . . . . . .. 2-9 Automatic Transmissions Fluid Check.. .. . . . . . . . . . . . . . . . . .. 5-5 Fluid Recommendations ... , . . . . . .. 5~5 Maintenance. . . . . . . . . . . . . . . . . . . .. 5-5 Operation ...... ,., ....... "., .... 2.4
Starter Safety Switch .. , ..•• ' .• ' . '. 2·3 Axle Rear Fluid Level ............... , . . . . .. 5-9 Maintenance .............•...... , 5·9 Backup Lights.... . . . . .. . . ... . . . . . .. 6-3 Ban Joints . . . . . . . . . . . . . . .. .. . .. . . .. 5·10
Bassinet Placement.. • . . . . . . • . . . . .. .. 1-9 Battery Emergency Starting, . , •...... , . . .. 3-2 Auid Level ........ , , .In side Back -Cover Gas Caution. .. .. . . .. . . . . . . .. . . .. 3-3 Specifications ....... , ............. 6-1 Bearings, Front Wheel. ......... , .... 5·11 Before Driving Your Chevr olet. ...... 1-1 Belted Tires .. , "., ............ , .... 5·14 Belts Engine Drive .... , . . . . . . . . . •.. . . . .. 5-4 Lap ............................. 1-4 Shoulder, ......... , ............ '. 1-4 Blower, Ventilating ................. 2-19 Body Identif ication Number .......... 6-1 Brakes D,riying Through Deep Water, . , , .. 2-8 Linings .. , ...................... , 2-8 Maintenance ..... ' . ... , . . . . . . . . . . 5-11 Master Cylind er Level ......••..... 5-11 Parking Brake.. . . . . . . . . . . .. . . . . .. 2-8 Pedal Travel ........... , . . . . . . . .. 2-8 Power, ...................• , ..... 2-8 Self-Adjusting ... , .......• " ...... 2-8 Trailer .................... ,..... I-to Warning Light. .... -.............. 2-1 2 Break-In Period Cars Pulling Trailers. . .. ...... .... 1-10 New Car ......... ,., ... ,........ ii Bright Metal Cleaning ....... '. ' . . . . .. 4-5 "Brights" Headlamp Indicator , ...... , 2-13
Buckles, Seat Belt., ........... ,. .. .. 1-4
Bulbs and Fuses .............. , . , . .. 6-3 Bumper Jack
Operation ........ , ...•••••..•.... 3-4 Stowage ............ , .••. , . . . . . .. 3-5 Seat Belt Buzzer Key Remin der ................ , . .. 2-3
6-8
Cap,
Engine Oil ...... , . . . . • . . . . . . • . . .. 5-2 Gasoline ............. , . . . . . . • . . .. 5-2
Ca~~~fti~~·:::::::::::::::::: :::::: ~: Carbon Monoxide Caution •.. , ..•.... 2-1 Carpet Care... . . . . .. . . . . . .. . . . . .. .. 4-2 Carrier, Infant Safety................ 1-8 Carrier, Roof Luggage ........ , . . . .. 2~27 Catalytic Converter ........... , .. 5-22, 5-23 Changin g Wheels and TlCes. . . . . . . . .. 3-4 Cha rging System Indicator Light...... 2-12
Chassis Maintenance. . . . . . . . . . . . . . .. 5-9 Child Restraint
Cars Not Equipped With
Special Child Restraints. , .. , ..• 1-8
Child Safety Seat. .. . .. . . . . . .. . . .. 1-8 Infant Safety carrier. .. . . . . . . . . . .. 1-8 Chrome Protection ....... , .......... 4-5 Cigarette Lighter. . . . . . . . . . . . . . . . .. . 2-15 Circuit Breakers, Headlamps. . . . . . . .. 6-2 Cleaning
Carpet Care.. . . . . . . . . . . . . . . . • . . .. 4~2 Exterior Finish and Trim. . . . . • . . .. 4-5 Fabric and Interio r Trim .......... 4-1 Solvents Recommended ........ , . .. 4-1 Spot Removal. ...... : . . .. . . .. . . .. 4-3 Vinyl Top ........ , . , . . . . . . •• . . .. 4-5 Clock ............................. 2-15 Coa t Hooks.......... ........••.... 1-2 Cold Weather Starting.. . . . . . . • • • . . .. 2-3
Comp artment
Glove., .... , .. , ....... , ...•..... 1-1 Luggage ....................... :. 2·33 Complaint Procedure. . . . . . . . . . •• . . .. 6-4 Conditioner, Air.. .. . . . . .. . . • .. . .... 2-20 Controlled Differential .......••• , . .. 2-27

Downloaded from www.Manualslib.com manuals search engine Owner Assistance, ........••..... , ... 64 Paint Care •...............• . -. . , .... 4-1 Parkin g Brake. : .. , ........•..... ...... :. 2-8 Lights ... , .............. ; . . . . . .•• 6-3 Precautions .............. , . . . . . . . . 2-2 Polishing And Waxing ....... -........ 4-5 Positive __ Traction Differ ential: . . . . . . .. 2-27 Pow~r Brakes.. . .......... . . ....... . 2-8 Door Locks.... .... .•.. . . ........ 2-27 Seats.... .. . ..... .... ........ .... 1-3 Steering ............. '. ' . . . . . . . . .. 2-6 Windows ........... _,I I' . • • • • • • • • •• 1-3 Pressure, Tire Inflation·;~;.:' •... ,' ..•.... 5-14 PulseWiperSystem.,.:~~ ... , ........ 2-16 ,:,J.)i!J,lShing To Start .... ,,:,, " . . . . . . . . . . . .. 3-2 '-';:R~.ator """~~~ I 5 7 ;~!t,~;-_ °l_:~i'~~e" 'I~s~,tio~::::: :.::-:: 5..7 --;'~'.?}~ · verhea ting ...... '-~' •......... :... 3-3 '-'. Pressure Cap ..... ;~, .............. 5-9 Radio
~f!n~::::: ::::'::::::: :::::::: ~:~~ Stereo .... : .............. ,; . . . . .. 2-26 Tape System. . . . . . . . . . . . . . . . . . . .. 2-26 Raising Car,With Jack. , ' .......•.... 3·1 Rear Axle Lubricant. ........... '. .... .. 5-9 Window Defogger. . . . . • . . . . • . . . .. 2-20 Reclining Seat .......... ,. .. ...... .. 2-28 Registration, V ;hicle EngineNumber .•.•... ' .......... . 6-1 Vehicle Identification Number... ... 6-1 Release; -Hood .....•..... Inside Back Cover Replacem ent, Tires and Wheels. , . . . .. 5-19
Restarting ........................ , 2~_3
Res traints ,
~~t:::::::::::::::,:::::::::::: Lap Belts .......... " l ............ . Methods Of Restraining Children .. .
Shoulder Belts .. ' .... ~ ........•... '.
Rest s, Head (See Head Restraints) Retractors , Lap Belt. . _ . ............. .
Roof Care, Vinyl. ... , ... , ......... .
Roof Lugga ge. Carrier; ,:: ......•......
R otation, Tire; ....... ; ......•...... Safety
Belts (Seat Belts) ...... _ •.....•.... Carrier. Infant. ..... _. ' ......•. , . , , , Seat, Child .......... : ..... • •..... Schedule
1-8 1-7 1-4 1-8 1-4
1-4 4'5 2-27 5-16
1
-4 · 1 -8
1- 8
Break·!n ..... , .. , . ... , . ... , . . 'ii Sea t Adjustment, Manual. ....... , , .. ~. }·2 Adjustment, Power.'., .. ". , ., .. " ,; ·.-3 Back Latch, Folding. Front, ..... , .. 1-3 Belt Buzz~r/Light Remind er .... , ',1. ' 1-6 Child Safety ........ , .......... d . .1-8 Head Restraints .•. ~' •...... '. , , . . .. ,1-7 Seat Belts . Child Restraint..... .. ... ....... .. 1-8
Inspection and Care.~', ....... ,., ',' 1-7 Lap ........... ,....... .... .... •• • • 1-4
R et ractors ......... ,.< .... , .. ', ",: 1 -5 Shoulder ........ , . , .............. ' 1· 5
Self-Adjusting Brakes .... '.' ...... . , ; 2-9 S ervice and Maintenance .. , , . . . . . . .. 5-1 Sh ift Linkage Maintenance. , ' ... ' ...... " 5·6 Operation (S ee Transmi ssion) Shock Absorbers, Superlift. . . . . . . . . .. 2-27 Shoulder Belts Adjustment. ...... , .. , 1-5
Side Marker Lights. . . .. . . . . . . . . . . .. 6-3
6-11
Signals, Tum ....................... 2-5 Solvents , Rec ommen ded Cleaning -.,. " 4-1 Spare Tire .. , , , ....... , ....... , , , .. 3-4 Jacking Instru ctio ns .. ,. , . . ' ..• ,.... 3·4
Spark Knock ( S ee Fuel
R eco mmendati ons)
Specifications .-General. . . . . . . . . . . . .. ·6-1 Speed Control (Cruise Control) .. ; . . .. 2-6 Speedometer ................. ;-~ .... 2-10 Spot Cleaning •..... .........•....... 4-3 S tain less Stee I'.Pro tection ... ', . . • ..... 4·5
Stains, Removal of. .' ... ......•. '; _ ..•. 4 ·3 Starter Safety Switch ................ 2-3 . Starting . Automatic Transmission Cars. . . . 2·3
Erner.gency .. " .... , ..... ' ,' . , ... .",. 3·1 Manual Transmis sion Ca~... .. . ... 2-3 Station Wago n .. -'" .' ... '.'o'~;-;, .. , ' .. 2·28 Concealed Luggage Space ........ ·2-33 Operatibg Seats and Tailgate . •... 2-29 Steering . Column Cont,rols ,., ... ' .. ', •...... , 2-3 Column Lock~ ........... ; . . . . ... 2-3 Gear-Lubrican t ..... ;-........ ; .. --.. 5·10 Maintenance ........ _ . . , ..... ~_ •. ; . 5·10 Power. , . , .... , , , , . , •.... , . . . . . .. 2·6 Wheel, Tilt. ......... : ... : . . . . . . .. 2-6 Stereo Radio .................. : ........ 2-26
Tape S yste m ..................... -2-26 Straps, Safety (See Seat Belts) Storage Of Items .......... " .... ,... 1·3 Superlift Shock Absorbers ..• , ...... , 2-27 Suspension Maintenance .......• , ... , S~10 Tape System, Stereo •........ i.. -' ••• ,. 2·26 Temperature ' Control, Cooling ..........••. _ . . .. 2-20
Control, Heating .•.••......•...... 2-19·

Downloaded from www.Manualslib.com manuals search engine Thermostat. . . . . . . . . . . . . . • • . . . . . . .. 5~9 Tilt Steering Wheel.. . . . . . . • • . . . . . . .. 2·6 Tire Belted ........................... 5·14 Care ............................ 5·14 Changing. . . . . . . . . . . . . .. . . . . . . . .. 34 Damage and Repair ............... 5·18 Full Rated Load...... ............ 5·16 High Speed Operation............. 5·16 Hydroplaning. . . .. .. . . .. . .. . .. ... 5·18 Inflation Pressure. . . . . • • . . • . . . . . .• 5:..14 Inspection ... ".,., ... ' .••.... "., 5~16 Load Limit. . .................... 5·16 Radial Tires....... .. ....... ...... 5·14 Rotation ... ,.,.,.,." ., " .. , .... -: ·5~16 Traction .. "., ... , .. , ... " . . ,'.;'~. 5-18 Tread Wear Indicators...... ....... 5-19 US1ge andOptions ..... ' .......... 5·15 Towing Caution ....•.•........•... , ...... 3~1 Disabled Vehicle.......... ........ 3·1 To Start. . .. . . . . . . .. . . .. . . .. .. . .. 3·1 Toxic .
Cleaning Solvents ..... , , . . .. .. . . •. 4~2 Exhaust Fumes ...... , ......•• , , .. 2~ 1
Traction, Wet.Roads."' .... ,.,.,,., 5~18 Traffic Hazard flasher. . . . .. .. .. . ... 3·1 Trailer Hauling .. , . , . , ........... , . . 1·10
Break ·In Period. . .. .. .. .......... I·JO Cautions ...•................•.. ,. 1·11 Equipment. .. . . . . . . . . . .. . . . . • .. .. 1·10 Sj?ecial
Maintenance .. ,
. , ........ , 1·11 TIre Inflation ..... , .. , . ........... 5·14 Trailer Tongue Load, .......... , .. 1~11 Transmission Automatic. . . . . . . . . . . . . . . . . . . . . . . 2-4
Braking Effect On Hills.......... .. 2·4 Checking Fluid Level. ..... . . . . . . . .. 5·5 Fluid And Strainer ............ , .,. 5·5 Fluid Change Interval ..• " ....• , . .. 5·5 Maintenance. , •...... , . , '. '. . . . . . .. 5-5 Shift Controls .......... " . . .. . . .. 2-4 Turbo Hydra~matic .........• . , . .. 2·4 Tray. Ash .......................... 2-JO Tread Wear Indicators .... .',.,., ... , 5-19 Trim Care, Interior ............. , ... , 4-1 Trunk Driving With Trunk Open. .. ...... 2·1 Turoo..Hydra~matic Maintenance. . . . . . . . . . . . . . . . . . . .. 5·5 Operation .................... , . .. 2-4 Turn. Signals and Lane Change Feature ............... , . . . . . . . . .. 2~5 Underbody Maintenance .... , . . . . . . .. 5~ 13 Upholstery And Carpet Care. . . . . . . .. 4·1 Vehicle Identification Number ....... , 6-1 Vehicle Loading, ...... , ...... , .. , , . . .. 5~ 15 Ventilating Blower., ...... :., .. " .. .. 2-19
Ventilating System .................. 2-17
Vinyl
Fabric Care Interior. . . . . . . . • • . . . .. 4·1
6-12 r
Roof Care .................... '" 4·6 Volatile Cleaning Solvents, .. ,., ..... 4-2 Caution ... , . , . , , . , .. , ......•.. ,. 4-2
Volume Control, Radio ... , ..... , .... 2~25 Warning Flasher. Hazard ............ 3-1 Warning Lights ..................... 2·11 Brake ........................... 2·12
Engine Temperature ......... , .... , 2-12 Generator •............... , . , .. .. 2~ 12 Oil Pressure. . . . . . . . . . . . . . . . . . . ... 2~ 12 Warranty (See Warranty Folder) Washers Windshield..... .. ... . . .. ... .. .... 2·15 Washing Your Car .................. 4-5
Waxing And Polishin g .. , , . . . • • • . . . .. 4·5 Wheel Bearings , Front.... . . . . . . . . . .. 5~11 Wheel Changing.. ... . . . . . . . . . . . . . .. 34 Wheel, Tilt Steering ........... ...... &2·6 Wmdows ;,; Power ....................••..... 1·3 Rear, Defogger. .......... ,' ...... 2-20 Windshield
Defrosting and Defoggin g ............ 2·20
Pulse Wiper System ...... ,. . .... .. 2~16 Washer Use In Cold Weather .. ,.,. 2-15 Washer Solution ....... , .......... 2-15 Wipers And Wasbers .............. 2~15 Wrecker, Towing .•.........•....... 3~1 Zone Offices. . . . . . . . . . . . . . . . • • . . . .. &.6