1960 CHEVROLET CORVAIR spare tire

LUGGAGE COMPARTMENT
The front luggage compartment has a capacity of
more than 10 cu. ft. with the spare tire in place.
• To open the luggage compartment, insert the ignition
key and, holding the lid down to relieve the tension on
the
lock, turn fully clockwise and allow the counter­
bdlanced lid to open.
• To close, slam the lid firmly.
A second luggage space is located behind the rear
seat, for parcels or luggage which would otherwise take
up seat or floor space.
13
GAS CAP
The gas cap is concealed beneath the spring loaded
door on the left front fender.
ENGINE COMPARTMENT
• To open: Push up the release while lifting the lid. Lift
the
lid .all the way up, then release.
• To close: Lift up on lid, unlock the support arm catch
lock, then lower the lid carefully. Slam firmly to assure
that the lid lock mechanism is engaged.
For proper engine cooling keep the engine compart­
ment lid vents free of ice, snow or leaves.

TIRE CARE
Your new Chevrolet Corvair is designed to operate
most efficiently with the inflation pressure shown in the
following table. Nothing will be gained by exceeding
pressure shown, whereas, excessive pressures can ad­
versely affect riding comfort and quietness. Under infla­
tion affects vehicle handling and tire life. Over-steer
problems may also be encountered with incorrect pres­
sures. Maintain the recommended inflation pressures at
all times.
All four wheels of your Corvair have been static-balanced for best performance and tire life. Wheels should be rebal­anced after tire service or replacement.
FRONT AND REAR PRESSURE DIFFERENCE IS IMPORTANT
TO VEHICLE HANDLING.
18
Inspection and Repair
Inspect every 1000 miles for puncturing objects in
the tires. If any are found, do not attempt removal until
you are in a position to change the tire or have it
repaired. Also, check regularly that the wheel rim has
sustained
no damage which could affect the air seal.
Jacking the Car
The scissors type jack, its adapter and ratchet han­
dle are stowed under the spare tire. One end of the
ad~pter is a wrench which fits over the wheel nuts and
the hex connection on the jack. The other end fits into
the non-adjustable ratchet wrench. One side of the wrench
faces the car for raising the car or tightening the wheel
nuts. Turn the wrench over so that the opposite side faces
ADAPTER
JACK
WRENCH SPARE TIRE AND JACK STOWAGE

the car for lowering the car or removing the wheel nuts.
When jacking the car, set the hand brake, block diagonal
wheel, and, if changing wheels, remove the hub cap and
loosen wheel nuts. Place the jack under the side of the
car located as shown.
Spare Tire
The tire is mounted in the luggage compartment.
Switching Tires
Switching tires every 5000 miles as shown will pro­
mote more even tire wear and longer tire life. After
switch ing tires readjust tire pressure to correspond to
table on page 18.
CAUTION: Never attempt to raise the Corvair by
placing any kind of jack under the bumper.
FRONT
JACKING CAR SWITCHING TIRES 19
CHASSIS LUBRICATION
------
.-
Your Corvair deserves the best care you can give it.
Regular maintenance will guarantee you more, depend­
able, trouble free miles of enjoyable driving. The
following pages are devoted to maintenance and lubri­
cation items which should be performed at regular inter­
vals
. Each item is numbered to correspond to the items
shown on the Lubrication Diagram on page 26. The
Lubrication and Maintenance Guide on pages 24 and
25 provides an easy way of checking on necessary
maintenance at any given mileage or seasonal interval.

SPECIFICATIONS
SERIAL AND UNIT NUMBERS
Serial Number . Stamped on plate attached to left center body pillar. Body Number .. Stamped on a plate attached to the left rear wheel well, within the engine compartment.
Engine Number. Stamped on the engine block behind and to
left of the fuel pump.
DIMENSIONS
Overall length ............................. 180.0 in.
Height
(loaded) .......... ................. 51.3 in.
Width
............... . . . . . . . . . . . . . . . . . . .. 66.4 in.
Wheelbase ...........•................... 108.0 in.
Turning
diameter ................. ............ 39 ft.
CAPACITIES
Gasoline Tank .........................•.... 11 gal.
Crankcase Refill ............................... 4 qt.
Add for Filter .......... , ... : ............... 1 pt.
Transmission
3-Speed .................................. 2 pt.
Powerglide
(Refill) ...... 4% to 8 pts . (depending on drain period) Differential .................. ............ 3 pt.
Air Cleaner ..................... . Polyurethane Element
Cooling System ...
.................. Air Cooled Engine
28
TIRE INFORMATION
Type .................................... Tubeless
Size .............................. 6.50 x 13-4 ply
Inflation COLD HOT
Front ............................ 15 18
Rear ......................•..... 26 30
Spare Tire-Inflate to 26 Ibs. Deflate to 15 Ibs. when using as front wheel.
ENGINE SPECIFICATIONS
Horsepower .•..............................
Compression Ratio ........................... 8.0:1
Displacement ....... ....................• 140 cu. in.
Bore
................... ' ............ ' ....... 3.375
Stroke ...................................... 2.60
Firing Order .............. .............. 1-4-5-2-3-6
Spark Plugs .............•. AC-4.4FF (Gap: .033-.038")
Idle Speed
3-Speed .................. 450-500 RPM (in Neutral)
Powerglide
................ .. 475-500 RPM (In Drive)
Ignition Timing .......................... 40 B.T.D.C.
Axle Ratio
(Std.) ......... ................... 3.55:1
(Opl.) ............................ 3.89:1

Page
Light Control Knob ........................ 8
locks ................................... 11
lubrication Diagram .. ....... . .......... .. . 26
lubrication & Maintenance Guide ............ 24-25
luggage Compartment . . . . . . . . . . . . . . . . . . . . .. 13
Maintenance and Lubrication ....... ......... 16
Octane Requirements . . . . . . . . . . . . . . . . . . . . . .. 16
Oil Filter ................................ 20
Owner Protection Policy ............ '. . . . . . . .. 30
Parking Brake
Operation ............................ 9
Service .
............................. 23
Polishing Your Corvair ...................... 14
Pushing to Start
Three-Speed ................. ......... 4
Powerglide . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Radio
............. ..................... 10
Rear Axle .................. ............. 22
Rear Seat-Folding ....................... .
Rocking
Car-Powerglide . .................. .
Seats
12
6
Front Seat Adjustment . . . . . . . . . . . . . . . . . .. 12
Rea r Seat-Folding ..................... 1 2
Service Accessories
....................... .
Serv ice Brakes ........................... .
27
9
31
Page
Serial and Unit Numbers . . , ............... " 28
Spare Tire ..... . . . . . . . . . . . . . . . . . . . . . . . . .. 19
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . .. 28
Speedometer ... .. ........ .......... ...... 6
Starting the Engine . .. . . . . . . . . . . . . . . . . . . . .. 3
Steering Linkage ............. ;............ 20
Steering Gear . . . . . . . . . . . . . . . . . . . . . . . . . . .. 20
Switching Tires ........................... 19
Temp-Press-Indicator ........ ............... 6-7
Tire Care ............................... 18
Tire Information . . . . . . . . . . . . . . . . . . . . . . . . . .. 28
Towing-Powerglide ....................... 6
Transmission
Three-Speed
Operation ................... ...... 4
Service ........................... 22
Powerglide
Operation .... . . . . . . . . . . . . . . . . . . . .. 5-6
Service .............. ............. 22
Turn Signal .............................. 8
Universal Joints ........................... 21
Warm-up. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Washing your Corvair . . . . . . . . . . . . . . . . . . . . .. 14
White Sidewall Tires .... . . . . . . . . . . . . . . . . . .. 15
Windshield Wipers and Washers . . . . . . . . . . . . .. 9