2023 KIA K5 Warranty and Consumer Information Guide

24CaliforniaEmission Control Warranty
Your Warranty Rights And Obligations
The California Air Resources Board and Kia America,
Inc., are pleased to explain the emission control
system warranty on your 2023 Kia vehicle. In
California, new motor vehicles must be designed, built
and equipped to meet the State’s stringent anti-smog
standards. Kia must warrant the emission control
system on your Kia vehicle for the periods of time
listed below provided there has been no abuse, neglect
or improper maintenance of your Kia vehicle.
Your emission control system may include parts such
as the carburetor or fuel-injection system, the ignition
system, catalytic converter, and engine computer. Also
included may be hoses, belts, connectors and other
emission-related assemblies. Where a warrantable
condition exists, Kia will repair your Kia vehicle at no
cost to you including diagnosis, parts and labor.
Manufacturer’s Warranty Coverage
For 3 years or 50,000 miles, whichever first occurs:
1. If your Kia vehicle fails a Smog Check inspection, all necessary repairs and adjustments will be made by Kia to ensure that your vehicle passes the inspection. This is your emission control system PERFORMANCE WARRANTY.
2. If any emission-related part on your Kia vehicle is defective, the part will be repaired or replaced by Kia. This is your short-term emission control system DEFECTS WARRANTY.
For 7 years or 70,000 miles for emission related parts, whichever first occurs (8 years or 80,000 miles for Federal Emission Control Warranty) :
If an emission-related part listed in this warranty booklet specially noted with coverage for 7 years or 70,000 miles is defective, the part will be repaired or replaced by Kia. This is your long-term emission control system DEFECTS WARRANTY.
For 2023 SULEV(Super Ultra Low Emission Vehicle), all parts covered under the PERFORMANCE WARRANTY and the DEFECT WARRANTY, which are listed in this warranty booklet on the Emission Warranty Parts List, are warranted for 15 years or 150,000 miles, whichever occurs first.
California Emission Control Warranty Statement
��� 23MY ��� (��1-37).indd 242022-02-10 �� 3:18:15

25
California
Emission Control Warranty
Owner’s Warranty Responsibilities
As the Kia vehicle owner, you are responsible for the
performance of the required maintenance listed in your
owner’s manual. Kia recommends that you retain all
receipts covering maintenance on your vehicle but Kia
cannot deny warranty solely for the lack of receipts or
for your failure to ensure the performance of all
scheduled maintenance.
You are responsible for presenting your Kia vehicle to a
Kia dealer as soon as a problem exists. The warranty
repairs should be completed in a reasonable amount of
time, not to exceed 30 days.
As the Kia vehicle owner, you should also be aware that
Kia may deny you warranty coverage if your Kia vehicle
or a part has failed due to abuse, neglect, improper
maintenance or unapproved modifications.
If you have any questions regarding your warranty rights
and responsibilities, you should contact Kia America,
Inc., Consumer Affairs Department at 1-800-333-4542
or the California Air Resource Board at 9528 Telstar
Avenue, El Monte, CA 91731 (1-800-242-4450).
Coverage
Kia America, Inc. (Kia), warrants to the owner that any
vehicle certified for sale in the State of California and
registered in the State of California is designed, built and
equipped so as to conform with the emissions standards
adopted by the California Air Resources Board. Kia
warrants that this vehicle is free from defects in material
and workmanship which would cause any part on this
vehicle which affects emissions to fail to conform with
applicable requirements or to fail to pass a required state
smog check test for 3 years or 50,000 miles, whichever
occurs first. Kia also warrants that, any part on the
warranted emissions parts list in this warranty and
installed as original equipment, is free from defects in
material and workmanship which would cause this
vehicle to fail to conform with applicable regulations for 7
years or 70,000 miles, whichever first occurs.
��� 23MY ��� (��1-37).indd 252022-02-10 �� 3:18:15

26CaliforniaEmission Control Warranty
Warranty Service
To obtain warranty service, return the vehicle to any
authorized Kia dealer. Service will be performed without
charge for diagnosis, parts and labor. In case of
emergency, see Emergency Service Instructions.
Exclusions
This warranty does not apply to failures caused by abuse,
tampering or lack of maintenance; or to any vehicle on
which the odometer mileage has been altered so that the
vehicle’s actual mileage cannot be determined.
STATEMENT OF OWNER’S RIGHTS AND
OBLIGATIONS
What Is Covered By The Warranty
If a vehicle fails a state Smog Check test during the
coverage period, Kia will repair the vehicle so that it will
pass a state Smog Check retest. The owner should take the
vehicle to any authorized dealer for Warranty repairs and
present a copy of the failed Smog Check test report to the
dealer. If the owner is not notified within 30 days that a
performance warranty claim is not valid then the
manufacture is required to repair the vehicle free of charge.
In addition, if a warranted part fails because of a defect,
Kia will repair or replace it at any authorized Kia dealer.
Any other parts damaged by the failure of a warranted
part will also be repaired or replaced. The repair and/or
replacement will be made at no charge to the owner for
parts, labor and diagnosis. For emergency situations, see
the instructions under Emergency Service.
How Long Does The Warranty Last
The warranty shall apply for 3 years or 50,000 miles,
whichever occurs first, except that those parts listed on the
warranted parts list are covered for 7 years or 70,000
miles, whichever first occurs. For 2023 SULEV(Super
Ultra Low Emission Vehicle), all parts covered under the
PERFORMANCE WARRANTY and the DEFECT
WARRANTY, which are listed in this warranty booklet
on the Emission Warranty Parts List, are warranted for 15
years or 150,000 miles, whichever occurs first. Where
parts are scheduled for replacement as required
maintenance, the warranty shall apply until the first
scheduled maintenance point listed in the Owner’s
Manual. This warranty begins on the date the vehicle is
delivered to the original purchaser or on the date the
vehicle is first placed in service, whichever occurs first.
��� 23MY ��� (��1-37).indd 262022-02-10 �� 3:18:15

27
California
Emission Control Warranty
What The Owner Must Do
It is your responsibility to perform the required
maintenance and use the vehicle in accordance with
Kia’s written instructions. Warranty coverage will not be
denied solely because there is no record of maintenance.
However, failures caused by lack of required
maintenance are not covered by the warranty. To avoid
questions as to whether the vehicle maintenance has
been performed, Kia urges that you retain all receipts
and/or maintenance records indicating that service has
been performed on the vehicle and these documents
should be transferred to any subsequent owner of the
vehicle.
Service
MAINTENANCE SERVICE CAN BE PERFORMED
BY ANY QUALIFIED SERVICE OUTLET OR BY
THE OWNER. HOWEVER, EXCEPT IN AN
EMERGENCY SITUATION (SEE EMERGENCY
SERVICE), WARRANTY SERVICE MUST BE
PERFORMED BY AN AUTHORIZED KIA DEALER.
Parts
IT IS RECOMMENDED THAT ANY REPLACEMENT
PARTS USED FOR MAINTENANCE OR FOR THE
REPAIR OF EMISSIONS CONTROL SYSTEMS BE
NEW, KIA GENUINE PARTS. However, the warranty
obligations are not dependent upon the use of any
particular brand of replacement parts. The owner may
elect to use non-Kia parts for maintenance purposes. Use
of replacement parts which are not of equivalent quality
may impair the effectiveness of emissions control systems.
What Is Not Covered By Emission Warranty
Malfunctions in any part caused by misuse, alteration,
tampering, disconnection or improper or inadequate
maintenance.
Damage to catalytic converter due to use of leaded
gasoline.
Damage resulting from fire, accident, negligence, act of
God or other events beyond the control of Kia.
Maintenance replacement parts (such as spark plugs)
beyond the first scheduled replacement point.
��� 23MY ��� (��1-37).indd 272022-02-10 �� 3:18:15

28CaliforniaEmission Control Warranty
Incidental or consequential damages such as loss of use
of the vehicle, loss of time, inconvenience, expense for
gasoline, telephone, travel or lodging.
Any vehicle on which the odometer mileage has been
altered so that actual vehicle mileage cannot readily be
determined. (When the Owner replaces the speedometer
or has it replaced by a repair facility, then the
“Speedometer Replacement Record” on the inside front
cover must be filled in by an Authorized Kia Dealer.)
Loss or damage to personal property, loss of revenue,
commercial loss or other matter not specifically
included.
Damage resulting from the use of a non-Kia part.
Emergency Service
If emergency Emission Control System Warranty service
is required and the owner is unable to readily locate an
authorized Kia dealer or if a warranted part is not
available within 30 days, then, repairs may be performed
at any available service establishment, or by the owner,
using any replacement part. Kia will reimburse the
owner for the owner’s expenses including diagnostic
charges for such emergency repair or replacement at
Kia’s suggested retail price for all warranted parts
replaced and labor charges based on Kia’s recommended
time allowance for the warranty repair and the
geographically appropriate hourly labor rate. Replaced
parts and copies of paid original receipts must be
available for presentation to Kia as a condition of
reimbursement for these emergency repairs. In addition,
the owner must provide Kia a detailed description
indicating why the situation was considered an
emergency and why an authorized Kia dealer was not
available. Additional information may be obtained by
calling 1-800-333-4Kia. A repair not being complete
within 30 days constitutes an emergency.
ATTACHED IS A LIST OF COMPONENTS
WARRANTED AGAINST DEFECTS IN MATERIAL
AND WORKMANSHIP FOR 7 YEARS OR 70,000
MILES ON VEHICLES/ENGINES AS NOTED.
��� 23MY ��� (��1-37).indd 282022-02-10 �� 3:18:15

29
Spark Plugs shall be warranted for the emissions warranty period, or the first scheduled replacement time or mileage, whichever occurs first. NOTE 1 : Specific emission parts covered up to 5 years or 60,000 miles, whichever occurs first, or up to the first required scheduled maintenance, whichever occurs first (See Owner's Manual for required scheduled maintenance.) NOTE 2 : Parts designated by "8/80" are warranted for 8 years or 80,000 miles, whichever occurs first.NOTE 3 : Parts designated by "7/70" are warranted for 7 years or 70,000 miles, whichever occurs first. NOTE 4 : The above parts for a Soul 2.0, Forte 2.0, Sportage 2.4 SULEV vehicles are warranted for 15 years or 150,000 miles, whichever occurs first.
California
Emission Control Warranty
California Emission Control Warranty
Air Induction System Air Cleaner Assembly Intake Manifold * 7/70 Forte 2.0, Stinger, Sorento, Rio Surge Tank -Air Intake * 7/70 Sedona, Telluride Turbo Charger * 7/70 Seltos 1.6, Soul 1.6, K5 1.6, Forte 1.6, Stinger, SorentoFuel Metering System Head Assy-Cylinder * 7/70 Seltos, Soul, Sportage, Sedona, K5 1.6, Telluride, Forte, Stinger, Sorento, Rio Thermostat Assembly * 7/70 Stinger 3.3 Engine Coolant Temperature Sensor (ECT) Mass Air Flow Sensor (MAF) Manifold Absolute Pressure Sensor (MAP) Vehicle Speed Sensor (VSS) Wheel Speed Sensor (WSS) Fuel Injector * 7/70 Telluride, Stinger, Sorento Fuel Delivery Line Throttle Body (ETC Actuator) * 7/70 Stinger 3.3 Throttle Position Sensor (TPS) Idle Speed Control System Oxygen Sensor Pulsation Damper Engine Control Module (ECM) * 8/80 All vehicles High Pressure Pump * 7/70 Seltos 1.6, Soul 1.6, Sportage, Sedona, Telluride, Forte 1.6, Stinger, Sorento High Pressure SensorIgnition System Generator * 7/70 Sportage, Sedona, Telluride, Forte, Stinger Spark Plugs Spark Plugs Cable Set Ignition Coil Camshaft Assy * 7/70 Sedona, Telluride, Forte 2.0, Stinger, Sorento, Rio Camshaft Position Sensor (CMPS) Crankshaft Position Sensor (CKPS) * 7/70 Stinger 3.3 Knock Sensor * 7/70 Stinger 3.3Auto Transmission System Transmission Control Unit * 7/70 Seltos 1.6, K5 1.6, Telluride, Forte 1.6, Stinger
Valve Timing System CVVT(D) Assy * 7/70 Sportage 2.0, Sedona, K5 1.6, Telluride, Forte 2.0, Stinger, Sorento, Rio Oil Control Valve Assy * 7/70 Stinger 3.3, Sorento Oil Temperature Sensor Valve * 7/70 Seltos, Soul, Sportage, Sedona, K5 1.6, Telluride, Forte, Stinger, Sorento, RioEvaporative Control System Intercooler Assy EGR Cooler * 7/70 Sorento 2.5, Rio Vapor Storage Canister Canister Close Valve (CCV) Purge Control Solenoid Valve (PCSV) Fuel Pump Fuel Pump Module * 7/70 Forte 1.6, Sorento 2.5 Fuel Tank * 7/70 K5 1.6, Forte, Stinger, Sorento Fuel Filler Cap Fuel Tank Pressure Sensor (FTP) ORVR(Vent) Valve Rollover(Cut) Valve Fuel Pump & Sender Assy * 7/70 Sportage 2.0Positive Crankcase Ventilation System PCV Valve and HoseCatalyst and Exhaust System Exhaust Manifold Exhaust Manifold Catalytic Assembly * 8/80 All vehicles Exhaust Pipe (Manifold to Catalyst) * 7/70 Seltos, Sportage, Sedona Catalytic Converter Assembly * 8/80 All vehicles Muffler Complete-Center * 7/70 K5 1.6, Telluride, Forte, Stinger 3.3, Sorento 2.5, RioMiscellaneous Items Used In Above Systems Hose, Clamps, Gasket or Seals Wires, Harnesses Connectors All Sensor(Switches, Solenoid Valves, Battery) associated with the ECM Onboard Emission Diagnostic Device Malfunction Indicator Light and Bulb * 8/80 All vehicles Data Link Connector * 8/80 All vehicles
��� 23MY ��� (��1-37).indd 292022-02-10 �� 3:18:15

30Replacement Parts and Accessories Limited Warranty
Subject to the other terms and conditions of this limited
warranty manual, Kia America, Inc. (“Kia”) warrants
that it will arrange for an Authorized Kia dealer at
locations of its choice to provide for the repair of your
vehicle if it fails to function properly during normal use.
Authorized service facilities will remedy such failures to
function properly at Kia’s expense, if you present your
vehicle to such a service facility during its normal
operating hours, provide sufficient information to permit
a proper identification and diagnosis of the failure to
function, and permit the facility adequate time to
perform the necessary repair. As this obligation is subject
to the terms, conditions and limitations of this manual,
you should refer to the manual to understand which
repairs and replacements are covered by this warranty.
When an Authorized Kia Dealer makes necessary repairs
pursuant to the warranty, it may do so using parts that are
new, repaired, remanufactured, reconditioned, or
otherwise authorized by Kia. These parts will be covered
by the terms and conditions of the Replacement Parts
and Accessories Limited Warranty. If an Authorized Kia
Dealer declines or fails to carry out a proper repair or
replacement covered by this limited warranty without
charge to you, Kia will (a) determine if the repair or
replacement requested by you is covered by
Replacement Parts and Accessories Limited Warranty
and, if so, (b) obtain cooperation from an Authorized Kia
Dealer to conduct such repair or replacement without
charge to you. However, Kia’s obligation to do (a) and
(b) requires you to contact the Kia Consumer Assistance
Center and provide all materials needed by them to carry
out those obligations to you. The Center can be
contacted at the address or phone number provided in the
Kia Owner Satisfaction and Assistance Section of this
manual, or can also be found at the Kia website at http://
www.kia.com.
This warranty covers Kia Genuine new or
remanufactured replacement parts and Kia Accessories
supplied from Kia America, Inc. and sold by an
Authorized Kia Dealer. This includes Kia Accessories
installed by an Authorized Kia Dealer or Kia America,
Inc. prior to the retail delivery of a new Kia Vehicle.
If a covered replacement part or accessory was installed
by anyone other than an Authorized Kia Dealer, the
replacement part or accessory will be repaired or
replaced without charge for the parts, but all labor
charges will be your responsibility.
Replacement Parts and Accessories Limited Warranty
��� 23MY ��� (��1-37).indd 302022-02-10 �� 3:18:16

31
Replacement Parts and
Accessories Limited Warranty
Warranty Period
• Kia Genuine replacement parts
Kia Genuine replacement parts (except battery)
installed by an Authorized Kia Dealer under
warranty are covered for the greater of (1) the
duration of the New Vehicle Limited Warranty or
(2) the first 12 months from the date of
installation of the Kia Genuine replacement parts
or 12,000 miles.
• Kia Genuine replacement battery
This warranty applies only to Kia Genuine
replacement batteries purchased from an
Authorized Kia Dealer in the United States. Kia
Genuine replacement batteries are covered by a
limited warranty for the period of 36 months
from the date of installation, regardless of
mileage.
��� 23MY ��� (��1-37).indd 312022-02-10 �� 3:18:16