2023 JEEP GLADIATOR tailgate

338IN CASE OF EMERGENCY
SPARE TIRE LOCATION AND REMOVAL
Remove the spare tire before attempting to jack up
the truck. The spare tire is secured under the rear
of the vehicle with a winch and cable mechanism.

Spare Tire Location
For spare tire removal, see the following steps:

1. Locate the winch access hole at the rear of
the vehicle.

Access Hole Location

2. Attach the lug wrench to the extension tubes with the curved angle facing away from the
vehicle. Insert the extension tube through the
access hole between the lower tailgate and
the top of the fascia/bumper and into the
winch mechanism tube.
Winch Mechanism Tube
Inserting The Extensions Into The Winch Mechanism Access Hole

WARNING!
After using the jack and tools, always reinstall
them in the original carrier and location. While
driving you may experience abrupt stopping,
rapid acceleration or sharp turns. A loose jack,
tools, bracket or other objects in the vehicle may
move around with force, resulting in serious
injury.

23_JT_OM_EN_USC_t.book Page 338

342IN CASE OF EMERGENCY
TO STOW THE FLAT OR SPARE
See the following steps for stowing the flat or spare
tire:

1. Turn the wheel so that the valve stem is
facing upward and toward the rear of the
vehicle for convenience in checking the spare
tire inflation. Slide the wheel retainer through
the center of the wheel.

2. Lift the spare tire with one hand to give clearance to tilt the retainer at the end of the
cable and position it properly across the wheel
opening.

Reinstalling The Retainer
3. Attach the lug wrench to the extension tubes
with the curved angle facing away from the
vehicle. Insert the extension tubes through the
access hole between the lower tailgate and
the top of the fascia/bumper and into the
winch mechanism tube.

Winch Mechanism Access Hole
4. Rotate the lug wrench handle clockwise until
the wheel is drawn into place against the
underside of the vehicle. Continue to rotate
until you feel the winch mechanism slip, or
click three or four times. It cannot be
overtightened. Push against the tire several
times to ensure it is firmly in place.

Reinstalling The Flat Or Spare Tire

CAUTION!
The winch mechanism is designed for use with
the jack wrench extension tool only. Use of air
wrench or power tool may damage the winch.WARNING!
A loose tire or jack thrown forward in a collision
or hard stop could endanger the occupants of
the vehicle. Always stow the jack parts and the
spare tire in the places provided. Have the
deflated (flat) tire repaired or replaced
immediately.

23_JT_OM_EN_USC_t.book Page 342

374SERVICING AND MAINTENANCE
5. Remove the cabin air filter from the HVAC air inlet housing. Pull the filter elements out
pinching them to the right for clearance.

Cabin Air Filter

6. Install the cabin air filter with the air filter position indicators pointing in the same
direction as removal.
7. Close cabin air filter access door and secure retaining tabs. 8. Rotate the glove compartment door back into
position, ensuring you have properly engaged
the travel dampener.

Travel Dampener

For the proper maintenance intervals see
Ú page 354 for gas engines or Ú page 358 for
diesel engines.
BODY LUBRICATION
Locks and all body pivot points, including such
items as seat tracks, door hinge pivot points and
rollers, liftgate, tailgate, decklid, sliding doors, and
hood hinges should be lubricated periodically with
a lithium-based grease, such as Mopar® Spray
White Lube, to ensure quiet, easy operation and to
protect against rust and wear. Prior to the application of any lubricant, the parts concerned
should be wiped clean to remove dust and grit.
After lubricating, excess oil and grease should be
removed. Particular attention should also be given
to hood latching components to ensure proper
function. When performing other underhood
services, the hood latch, release mechanism and
safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated
twice a year, preferably in the Autumn and Spring.
Apply a small amount of a high quality lubricant,
such as Mopar® Lock Cylinder Lubricant, directly
into the lock cylinder.
WINDSHIELD WIPER BLADES
Clean the rubber edges of the wiper blades and the
windshield periodically with a sponge or soft cloth
and a mild nonabrasive cleaner. This will remove
accumulations of salt or road film.
Operation of the wipers on dry glass for long
periods may cause deterioration of the wiper
blades. Always use washer fluid when using the
wipers to remove salt or dirt from a dry windshield.
Avoid using the wiper blades to remove frost or ice
from the windshield. Keep the blade rubber out of
contact with petroleum products such as engine
oil, gasoline, etc.
CAUTION!
The cabin air filter is identified with an arrow to
indicate airflow direction through the filter.
Failure to properly install the filter will result in
the need to replace it more often.
1 — Travel Dampener Housing
2 — Travel Dampener Rod

23_JT_OM_EN_USC_t.book Page 374

SERVICING AND MAINTENANCE395
LED Front Fog Lamp
If your vehicle is equipped with LED fog lamps they
are replaced as an assembly.
NOTE:We recommend seeing an authorized dealer for
service.
REAR TAIL, STOP, TURN SIGNAL, AND BACKUP
LAMP — IF EQUIPPED
See the following steps to replace:

1. Remove the two screws that pass through the bed sheet metal.

Tail Lamp Screws
2. Pull the outboard side of the lamp rearward,
far enough to unsnap the two receptacles on
the outboard side of the lamp housing, from
the two plastic snap post retainers in the outer
box side panel.
3. Once removed, locate and rotate the appropriate socket a quarter turn counter -
clockwise, then remove it from the housing.
4. Pull the bulb straight from the socket to replace.
5. To install a new bulb, reverse the procedure above.
CENTER HIGH MOUNTED STOP LAMP (CHMSL)
The stop lamp is mounted on the tailgate. If service
is needed, obtain the LED assembly from an
authorized dealer.
LICENSE PLATE LAMPS — IF EQUIPPED
NOTE:
To install a new bulb, reverse the procedure above.
When installing the new bulb, care should be taken
to not allow bare skin to come in contact with the
bulb.
See an authorized dealer to replace LED lamps.
TIRES
TIRE SAFETY INFORMATION
Tire safety information will cover aspects of the
following information: Tire Markings, Tire
Identification Numbers, Tire Terminology and
Definitions, Tire Pressures, and Tire Loading.
NOTE:If your vehicle is equipped with bead-lock wheels,
please refer to your vehicles bead-lock specific
part number for additional information and instruc -
tions on mopar.com or by contacting an authorized
dealer.
CAUTION!
Do not touch the new bulb with your fingers.
Oil contamination will severely shorten bulb
life. If the bulb comes in contact with any oily
surface, clean the bulb with rubbing alcohol.
Always use the correct bulb size and type for
replacement. An incorrect bulb size or type
may overheat and cause damage to the lamp,
the socket or the lamp wiring.8

23_JT_OM_EN_USC_t.book Page 395

441
Security Alarm
................................................. 23Arm The System.......................................... 23Disarm The System..................................... 23Selec - Speed Control.......................... 141, 285Selection Of Coolant (Antifreeze)...................424Send & Go........................................... 267, 273Sentry Key (Immobilizer).................................. 17Sentry Key Replacement................................. 17Service Assistance......................................... 428Service Contract............................................ 430Service Manuals............................................ 431Settings, Audio.............................................. 240Shifting.......................................................... 155Automatic Transmission.................. 155, 157Manual Transmission................................ 153Transfer Case, Shifting Into Transfer Case Neutral (N)......................... 139, 206Transfer Case, Shifting Out OfTransfer Case Neutral (N)........... 139, 207Shoulder Belts............................................... 300Side Step Removal........................................ 207Signals, Turn............................... 330, 394, 395Sirius Satellite Radio..................................... 235Favorites................................................... 238Replay....................................................... 237SiriusXM Satellite RadioBrowse in SXM.......................................... 238Favorites................................................... 238Replay....................................................... 237Smart Watch.................................................. 271
Snow Chains (Tire Chains)............................ 408Snow Tires.................................................... 406Soft Top.................................................... 82, 88Soft Top Windows............................................ 88SOS Call............................................... 261, 272Spare Tires................................. 338, 406, 407SpecificationsFuel (Gasoline)......................................... 424Oil............................................................. 424Speed ControlCancel...................................................... 175Resume.................................................... 175Speed Control (Cruise Control)..................... 173Starting................................................ 144, 147Automatic Transmission.................. 144, 148Button......................................................... 18Cold Weather............................................ 146Engine Block Heater................................. 148Engine Fails To Start................................. 147Manual Transmission............................... 144Remote........................................................ 20Starting And Operating.................................. 144Starting Procedures............................. 144, 147Starting Procedures (Diesel Engines).. 139, 147Steering........................................................... 42Power.............................................. 133, 168Tilt Column.................................................. 42Wheel, Heated............................................. 42Wheel, Tilt.................................................... 42
Steering WheelVoice Recognition........................................50Steering Wheel Audio Controls...................... 233Steering Wheel Mounted Sound System....... 233Stolen Vehicle Assistance.................... 268, 273Stop/Start......................... 137, 140, 169, 171Storage..................................................... 68, 88Behind Rear Seat........................................70Storage, Vehicle..................................... 67, 411Store Radio Presets...................................... 240Storing Your Vehicle...................................... 411Stuck, Freeing............................................... 349Sunrider® For Hard Top................................ 101Sway Bar DisconnectElectronic......................................... 139, 166Sway Control, Trailer..................................... 286Synthetic Engine Oil...................................... 366System, Remote Starting.................................20
T
Tailgate......................................................... 110Telescoping Steering Column...........................42Temperature Control, Automatic (ATC).............67Three-Position Tailgate.................................. 110Tilt Steering Column.........................................42Tire And Loading Information Placard........... 400Tire Markings................................................ 396Tire Safety Information.................................. 395Tire Types...................................................... 405
11

23_JT_OM_EN_USC_t.book Page 441