2023 DODGE CHALLENGER fuel cap

230SERVICING AND MAINTENANCE
CHECKING OIL LEVELTo ensure proper engine lubrication, the engine oil must
be maintained at the correct level. Check the oil level at
regular intervals, such as every fuel stop. The best time to
check the engine oil level is about ten minutes after a fully
warmed up engine is shut off.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings.
There are four possible dipstick types:
Crosshatched zone.
 Crosshatched zone marked SAFE.
 Crosshatched zone marked with MIN at the low end of
the range and MAX at the high end of the range.
 Crosshatched zone marked with dimples at the MIN
and the MAX ends of the range.
NOTE:Always maintain the oil level within the crosshatch
markings on the dipstick.
Adding 1 qt (1 L) of oil when the reading is at the low end
of the dipstick range will raise the oil level to the high end
of the range marking.
ADDING WASHER FLUID
The windshield washer fluid reservoir is located in the
front of the engine compartment. Be sure to check the
fluid level at regular intervals. Fill the reservoir with
windshield washer solvent (not radiator antifreeze) and
operate the system for a few seconds to flush out the
residual water.
When refilling the washer fluid reservoir, apply some
washer fluid to a cloth or towel and wipe the wiper blades
clean. This will help blade performance.
To prevent freeze-up of your windshield washer system in
cold weather, select a solution or mixture that meets or
exceeds the temperature range of your climate. This rating
information can be found on most washer fluid containers.
The fluid reservoir will hold nearly 1 Gallon (4 Liters) of
washer fluid when the message “Low Washer Fluid”
appears in the instrument cluster.WARNING!
Never smoke while working in the engine compart -
ment: gas and flammable vapors may be present,
with the risk of fire.
 Be very careful when working in the engine compart -
ment when the engine is hot: you may get burned. Do
not get too close to the radiator cooling fan: the elec -
tric fan may start; danger of injury. Scarves, ties and
other loose clothing might be pulled by moving parts.
CAUTION!
 Be careful not to confuse the various types of fluids
while topping up: they are not compatible with each
other! Topping up with an unsuitable fluid could
severely damage your car.
 The oil level must never exceed the MAX mark.
 Always top up using engine oil of the same specifica -
tions as what is already in the engine.
 If the engine oil is being topped up, wait for the
engine to cool down before loosening the filler cap,
particularly for vehicles with aluminum caps (if
equipped). WARNING: risk of burns!
 Overfilling or underfilling the crankcase will cause
aeration or loss of oil pressure. This could damage
your engine.
CAUTION!
Overfilling or underfilling the crankcase will cause
aeration or loss of oil pressure. This could damage your
engine.
WARNING!
Commercially available windshield washer solvents are
flammable. They could ignite and burn you. Care must
be exercised when filling or working around the washer
solution.

23_LA_OM_EN_USC_t.book Page 230

SERVICING AND MAINTENANCE237
EXHAUST SYSTEM
The best protection against carbon monoxide entry into
the vehicle body is a properly maintained engine exhaust
system.
If you notice a change in the sound of the exhaust system;
or if the exhaust fumes can be detected inside the vehicle;
or when the underside or rear of the vehicle is damaged;
have an authorized technician inspect the complete
exhaust system and adjacent body areas for broken,
damaged, deteriorated, or mispositioned parts. Open
seams or loose connections could permit exhaust fumes
to seep into the passenger compartment. In addition, have
the exhaust system inspected each time the vehicle is
raised for lubrication or oil change. Replace as required.
Under normal operating conditions, the catalytic converter
will not require maintenance. However, it is important to
keep the engine properly tuned to ensure proper catalyst
operation and prevent possible catalyst damage.
NOTE:Intentional tampering with emissions control systems can
result in civil penalties being assessed against you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop the
vehicle, turn off the engine and allow it to cool. Service,
including a tune-up to manufacturer's specifications,
should be obtained immediately.To minimize the possibility of catalytic converter damage:

Do not shut off the engine or interrupt the ignition when
the transmission is in gear and the vehicle is in motion.
 Do not try to start the engine by pushing or towing the
vehicle.
 Do not idle the engine with any spark plug wires discon -
nected or removed, such as when diagnostic testing, or
for prolonged periods during very rough idle or malfunc -
tioning operating conditions.
NOTE:The vehicle exhaust system may be equipped with an Elec -
tronic Exhaust Valve (EEV) system, if the exhaust system is
replaced with aftermarket products a Malfunction Indi -
cator Lamp (MIL) will illuminate.
COOLING SYSTEM WARNING!
 Exhaust gases can injure or kill. They contain carbon
monoxide (CO), which is colorless and odorless.
Breathing it can make you unconscious and can
eventually poison you. To avoid breathing CO,
Úpage 196.
 A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your
exhaust system. Do not park or operate your vehicle
in areas where your exhaust system can contact
anything that can burn.
CAUTION!
The catalytic converter requires the use of unleaded
fuel only. Leaded gasoline will destroy the effective -
ness of the catalyst as an emissions control device
and may seriously reduce engine performance and
cause serious damage to the engine.
 Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition. In
the event of engine malfunction, particularly
involving engine misfire or other apparent loss of
performance, have your vehicle serviced promptly.
Continued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never open a cooling system pressure cap
when the radiator or coolant bottle is hot.
 Keep hands, tools, clothing, and jewelry away from
the radiator cooling fan when the hood is raised. The
fan starts automatically and may start at any time,
whether the engine is running or not.
 When working near the radiator cooling fan, discon -
nect the fan motor lead or turn the ignition to the OFF
position. The fan is temperature controlled and can
start at any time the ignition is in the ON position.
8

23_LA_OM_EN_USC_t.book Page 237

SERVICING AND MAINTENANCE261
(Continued)
TIRES — GENERAL INFORMATION
Tire Pressure
Proper tire inflation pressure is essential to the safe and
satisfactory operation of your vehicle. Four primary areas
are affected by improper tire pressure:
Safety
 Fuel Economy
 Tread Wear
 Ride Comfort and Vehicle Stability
Safety Both underinflation and overinflation affect the stability of
the vehicle and can produce a feeling of sluggish response
or over responsiveness in the steering.
NOTE:

Unequal tire pressures from side to side may cause
erratic and unpredictable steering response.
 Unequal tire pressure from side to side may cause the
vehicle to drift left or right.
Fuel Economy
Underinflated tires will increase tire rolling resistance
resulting in higher fuel consumption.
Tread Wear
Improper cold tire inflation pressures can cause abnormal
wear patterns and reduced tread life, resulting in the need
for earlier tire replacement. Ride Comfort And Vehicle Stability
Proper tire inflation contributes to a comfortable ride.
Overinflation produces a jarring and uncomfortable ride.
Tire Inflation Pressures
The proper cold tire inflation pressure is listed on the
driver's side B-pillar or rear edge of the driver's side door.
At least once a month:

Check and adjust tire pressure with a good quality
pocket-type pressure gauge. Do not make a visual judg -
ment when determining proper inflation. Tires may look
properly inflated even when they are underinflated.
 Inspect tires for signs of tire wear or visible damage.
Inflation pressures specified on the placard are always
“cold tire inflation pressure”. Cold tire inflation pressure is
defined as the tire pressure after the vehicle has not been
driven for at least 3 hours, or driven less than 1 mile
(1.6 km) after sitting for a minimum of 3 hours. The cold
tire inflation pressure must not exceed the maximum
inflation pressure molded into the tire sidewall.
WARNING!
Overloading of your tires is dangerous. Overloading can
cause tire failure, affect vehicle handling, and increase
your stopping distance. Use tires of the recommended
load capacity for your vehicle. Never overload them.
WARNING!
 Improperly inflated tires are dangerous and can
cause collisions.
 Underinflation increases tire flexing and can result in
overheating and tire failure.
 Overinflation reduces a tire's ability to cushion shock.
Objects on the road and chuckholes can cause
damage that result in tire failure.
Overinflated or underinflated tires can affect vehicle
handling and can fail suddenly, resulting in loss of
vehicle control.
 Unequal tire pressures can cause steering problems.
You could lose control of your vehicle.
 Unequal tire pressures from one side of the vehicle
to the other can cause the vehicle to drift to the right
or left.
 Always drive with each tire inflated to the recom -
mended cold tire inflation pressure.
WARNING!
CAUTION!
After inspecting or adjusting the tire pressure, always
reinstall the valve stem cap. This will prevent moisture
and dirt from entering the valve stem, which could
damage the valve stem.
8

23_LA_OM_EN_USC_t.book Page 261

TECHNICAL SPECIFICATIONS277
FLUID CAPACITIES
USMetric
Fuel (Approximate)
All Engines 18.5 gal70 L
Engine Oil With Filter
3.6L Engine 6 qt5.6 L
5.7L Engine 7 qt6.6 L
Cooling System*
3.6L Engine 11.1 qt10.5 L
5.7L Engine 14.7 qt13.9 L
* Includes heater and coolant recovery bottle filled to MAX level.
9

23_LA_OM_EN_USC_t.book Page 277

286
Brake Assist System .................................................... 160
Brake Control System .................................................. 160
Brake Fluid .......................................................... 240
, 279
Brake System ...................................................... 240, 273
Fluid Check..................................................... 240, 279
Master Cylinder ....................................................... 240
Parking ....................................................................... 74
Warning Light ................................................... 64
, 273
Brake/Transmission Interlock........................................79
Break-In Recommendations, New Vehicle .................... 74
Brightness, Interior Lights .............................................. 43
Bulb Replacement ....................................................... 250
Bulbs, Light.......................................................... 198
, 250
CCamera, Rear ..................................................................96
Capacities, Fluid ........................................................... 277
Caps, Filler Fuel .............................................................................96
Oil (Engine) .............................................................. 228
Radiator (Coolant Pressure)................................... 239
Car Washes .................................................................. 270
Carbon Monoxide Warning .......................................... 198
Cargo Vehicle Loading..........................................................97
Cargo Net .........................................................................55
CD.................................................................................. 133
Cellular Phone .............................................................. 158
Certification Label ...........................................................98
Chains, Tire................................................................... 267
Chart, Tire Sizing .......................................................... 255
Check Engine Light (Malfunction Indicator Light) .........70
Checking Your Vehicle For Safety ............................... 196
Checks, Safety.............................................................. 196 Child Restraint .............................................................. 185
Child Restraints
Booster Seats .......................................................... 187
Child Seat Installation ............................................. 194How To Stow An unused ALR Seat Belt .................192Infant And Child Restraints ..................................... 186
Lower Anchors And Tethers For Children............... 188
Older Children And Child Restraints....................... 187
Seating Positions ..................................................... 188
Clean Air Gasoline ........................................................ 275
Cleaning Wheels .....................................................................266
Climate Control ............................................................... 45
Cold Weather Operation ................................................. 74
Compact Spare Tire ...................................................... 265
Contract, Service .......................................................... 282
Controls ......................................................................... 125
Cooling Pressure Cap (Radiator Cap) ..........................239
Cooling System ............................................................. 237 Adding Coolant (Antifreeze) ....................................238
Coolant Level ................................................. 238
, 239
Cooling Capacity ...................................................... 277
Disposal Of Used Coolant ....................................... 239 Drain, Flush, And Refill............................................238
Inspection ................................................................ 239
Points To Remember............................................... 239
Pressure Cap ...........................................................239
Radiator Cap ............................................................239Selection Of Coolant (Antifreeze) ........ 238
, 277, 278
Corrosion Protection ..................................................... 270
Cruise Control ................................................................. 84
Cruise Control (Speed Control) ...................................... 84 Cruise Light ..................................................................... 69 Cupholders
Illuminated................................................................. 50
Customer Assistance ................................................... 280
Customer Programmable Features ............................. 107
Cybersecurity ................................................................ 106
DDaytime Running Lights ................................................. 40 Dealer Service .............................................................. 231
Defroster, Windshield .................................................. 197
De-Icer, Remote Start .................................................... 19
Delay (Intermittent) Wipers............................................ 44
Deleting A Phone .......................................................... 139
Deluxe Vehicle Security System .................................... 20
Diagnostic System, Onboard ......................................... 69Dimmer Control .............................................................. 43Dipsticks Oil (Engine) .............................................................. 230
Disabled Vehicle Towing .............................................. 221
Disc Drive ...................................................................... 133
Disconnecting ............................................................... 139
Disposal Antifreeze (Engine Coolant) .................................... 239
Disturb........................................................................... 141
Door Ajar ......................................................................... 64
Door Ajar Light ................................................................ 64
Door Locks Automatic .................................................................. 24
Remote Keyless Entry ............................................... 12
Doors ............................................................................... 21
Drag & Drop .................................................................. 123
Drive Modes.................................................................. 154
Driver Memory Presets ................................................ 131
Driver Memory Settings ................................................. 27

23_LA_OM_EN_USC_t.book Page 286

287
Driver’s Seat Back Tilt ....................................................28
DrivingThrough Flowing, Rising, Or Shallow Standing Water .................................................. 105
EElectric Brake Control System..................................... 160Anti-Lock Brake System ......................................... 159
Electronic Roll Mitigation .............................. 160
, 163
Electrical Power Outlets..................................................50 Electronic Power Distribution Center (Fuses) ............ 242
Electronic Stability Control (ESC) ................................ 161
Electronic Throttle Control Warning Light...................... 65Emergency Trunk Release.............................................. 55
Emergency, In Case Of Freeing Vehicle When Stuck .................................. 220
Jacking..................................................................... 202
Jump Starting ................................................. 216
, 217
Towing ..................................................................... 221
Emission Control System Maintenance.........................70
Engine .................................................................. 228
, 229
Air Cleaner ............................................................... 233 Break-In Recommendations ..................................... 74
Checking Oil Level .................................................. 230Compartment ................................................. 228
, 229
Compartment Identification ................................... 228 Coolant (Antifreeze) ................................................ 238
Cooling..................................................................... 237
Exhaust Gas Caution .............................................. 198
Fails To Start .............................................................. 74
Flooded, Starting ....................................................... 74
Fuel Requirements ................................................. 274 Jump Starting ................................................. 216
, 217
Oil ...........................................................231, 277, 278 Oil Filler Cap ............................................................. 228
Oil Filter ....................................................................233Oil Selection ................................................... 231
, 277
Oil Synthetic ............................................................. 232
Starting....................................................................... 71
Engine Oil Life Reset

b
............................................... 59
Enhanced Accident Response Feature ............. 184, 222
Ethanol .......................................................................... 275
Exhaust Gas Cautions ..................................................198
Exhaust System .................................................. 198
, 237
Exterior Lighting .............................................................. 39
Exterior Lights ........................................................39
, 198
FFiller Location Fuel ......................................................... 96
Filters Air Cleaner ............................................................... 233
Air Conditioning ................................................49
, 234
Engine Oil ................................................................. 233
Engine Oil Disposal..................................................233
Flashers ......................................................................... 199 Hazard Warning ....................................................... 199
Turn Signals ...............................................42
, 69, 198
Flash-To-Pass .................................................................. 41
Flooded Engine Starting ................................................. 74
Fluid Capacities ............................................................277
Fluid Leaks ....................................................................198
Fluid Level Checks Brake ........................................................................ 240
Cooling System ........................................................ 238
Engine Oil ................................................................. 230
Transfer Case .......................................................... 241 Fluid, Brake................................................................... 279
Fog Lights........................................................................ 42
Fold-Flat Seats ......................................................... 28
, 30
Forward Collision Warning ........................................... 167
Freeing A Stuck Vehicle ............................................... 220
Fuel................................................................................ 274 Additives .................................................................. 275
Clean Air .................................................................. 275
Ethanol..................................................................... 275Filler Cap (Gas Cap) .................................................. 96
Gasoline ................................................................... 274
Materials Added ...................................................... 275
Methanol ................................................................. 275
Octane Rating.................................................274
, 278
Requirements .......................................................... 274
Specifications .......................................................... 278
Tank Capacity .......................................................... 277
Fueling ............................................................................ 96 Fuses ............................................................................. 242
GGarage Door Opener (HomeLink) .................................. 36Gas Cap (Fuel Filler Cap) ............................................... 96
Gasoline, Clean Air ....................................................... 275
Gasoline, Reformulated ............................................... 275
Gear Ranges ................................................................... 79
Glass Cleaning .............................................................. 272
Gross Axle Weight Rating ........................................ 98
, 99
Gross Vehicle Weight Rating .................................. 98, 99
GVWR .............................................................................. 98
11

23_LA_OM_EN_USC_t.book Page 287

289
Interior ........................................................................42
License .................................................................... 253
Lights On Reminder ...................................................41
Malfunction Indicator (Check Engine) ...................... 67
Map.............................................................................42
Park ..................................................................... 41
, 68
Passing ....................................................................... 41
Reading ...................................................................... 42
Seat Belt Reminder ...................................................64
Security Alarm ............................................................66
Service ..................................................................... 250
Traction Control ...................................................... 162
Turn Signals .............................................. 42
, 69, 198
Vanity Mirror............................................................... 35
Warning Instrument Cluster Descriptions .........65
, 69
Load Shed Battery Saver On ..........................................62
Load Shed Electrical Load Reduction............................ 62
Load Shed Intelligent Battery Sensor ............................ 62
Loading Vehicle ........................................................ 97
, 98
Capacities...................................................................98
Tires ......................................................................... 258
Locks Auto Unlock ................................................................24
Automatic Door ..........................................................24
Power Door .................................................................22
Low Tire Pressure System ........................................... 168
Lubrication, Body ......................................................... 235
Lug Nuts/Bolts ............................................................. 273
MMaintenance ...................................................................53
Maintenance Free Battery ........................................... 231
Maintenance Schedule....................................... 223
, 224
Malfunction Indicator Light (Check Engine) ..................67 Manual
Park Release............................................................218Service .....................................................................283
Manual Transmission .................................. 76
, 240, 241
Fluid Level Check .......................................... 240, 241
Map/Reading Lights ....................................................... 42
Media Mode .................................................................. 133
Memory Seat ................................................................... 27 Memory Settings............................................................. 27
Methanol ....................................................................... 275
Mirrors ............................................................................. 35 Electric Powered ........................................................ 36
Heated........................................................................ 36
Outside ....................................................................... 35
Rearview ...........................................................35
, 199
Vanity.......................................................................... 35
Modifications/Alterations Vehicle.......................................................................... 8
Monitor, Tire Pressure System..................................... 168
Mopar Parts .................................................................. 282
Multi-Function Control Lever .......................................... 40
NNew Vehicle Break-In Period .......................................... 74
OOccupant Restraints ..................................................... 172
Octane Rating, Gasoline (Fuel) .......................... 274, 278
Oil Change Indicator ....................................................... 59 Reset .......................................................................... 59
Oil Filter, Change .......................................................... 233
Oil Filter, Selection........................................................ 233
Oil Pressure Light............................................................ 65 Oil, Engine ........................................................... 231
, 278 Capacity ................................................................... 277
Checking .................................................................. 230
Dipstick .................................................................... 230
Disposal ................................................................... 233
Filter ......................................................................... 233
Filter Disposal.......................................................... 233
Identification Logo .................................................. 232
Materials Added To ................................................. 233
Pressure Warning Light ............................................ 65
Recommendation...........................................231
, 277
Synthetic .................................................................. 232
Viscosity ................................................................... 277
Onboard Diagnostic System .......................................... 69
Operating Precautions ................................................... 69
Operator Manual Owner's Manual ...................................................... 283
Outside Rearview Mirrors .............................................. 35
PPaddle Shift Mode .......................................................... 82
Paddle Shifters ............................................................... 82 Paint Care ..................................................................... 270
Pair (link) Uconnect Phone To A mobile Phone

b
... 137
Panic Alarm ..................................................................... 13 Parking Brake ................................................................. 74
ParkSense System, Rear ............................................... 92
Passenger Seat Easy Entry .................................................................. 33
Passing Light .................................................................. 41
Performance ................................................................... 60
Performance Shift Indicator .......................................... 59
Personalized Main Menu Bar ...................................... 123
Pets ............................................................................... 196
Phone Mode ................................................................. 135
11

23_LA_OM_EN_USC_t.book Page 289

291
Seats ................................................................................ 28Adjustment .................................................................28
Easy Entry ...................................................................31
Head Restraints .........................................................34
Heated ........................................................................31
Height Adjustment ..................................................... 30
Power ..........................................................................30
Rear Folding ........................................................ 28
, 30
Seatback Release ...................................................... 30
Tilting ............................................................ 28
, 30, 33
Vented ........................................................................32
Ventilated ...................................................................32
Security Alarm ................................................... 19
, 20, 66
Arm The System .........................................................19
Sentry Key (Immobilizer).................................................15
Sentry Key Replacement ................................................15
Service Assistance ....................................................... 280
Service Contract ........................................................... 282
Service Manuals........................................................... 283
Settings, Audio ............................................................. 131
Shift Indicator Light.........................................................77 Shifting.............................................................................78 Automatic Transmission..................................... 78
, 79
Shoulder Belts .............................................................. 174
Side View Mirror Adjustment ..........................................35
Signals, Turn................................................... 42
, 69, 198
Sirius Satellite Radio ................................................... 126 Favorites.................................................................. 129
Replay ...................................................................... 128
SiriusXM Satellite Radio Browse in SXM ........................................................ 129Favorites.................................................................. 129
Replay ...................................................................... 128 Snow Chains (Tire Chains) ...........................................267
Snow Tires .....................................................................264
Spare Tires ........................................202
, 264, 265, 266
Specifications Fuel (Gasoline)......................................................... 278
Oil .............................................................................278
Speed Control (Cruise Control) ...................................... 84 Sport Mode ..................................................................... 83
Starting ............................................................................ 71 Automatic Transmission ........................................... 71
Button......................................................................... 15
Cold Weather ............................................................. 74
Engine Fails To Start ................................................. 74
Remote....................................................................... 17
Starting And Operating ................................................... 71
Starting Procedures ........................................................ 71
Steering Column Lock .............................................................. 24
Power ......................................................................... 83
Tilt Column ................................................................. 24
Wheel, Heated ........................................................... 25
Wheel, Tilt .................................................................. 24
Steering Wheel Audio Controls ....................................124
Steering Wheel Mounted Sound System .................... 124
Storage ...................................................................49
, 269
Storage, Vehicle .....................................................48, 269
Store Radio Presets ...................................................... 131
Storing Your Vehicle ..................................................... 269
Stuck, Freeing ............................................................... 220
Sun Roof ................................................................... 52
, 53
Supplemental Restraint System – Air Bag ..................180
Symbol Glossary ............................................................... 9
Synthetic Engine Oil ...................................................... 232
System, Remote Starting ............................................... 17
TTelescoping Steering Column ........................................ 24
Temperature Control, Automatic (ATC) ......................... 48
Tilt Steering Column ....................................................... 24 Time Delay Headlight ................................................................... 41
Tire And Loading Information Placard ........................ 258
Tire Markings ................................................................ 254
Tire Safety Information ................................................ 253
Tire Service Kit .......................................... 211
, 212, 213
Tire Service Kit — If Equipped
b
.............................. 206
Tires .......................................... 198, 261, 264, 265, 268
Aging (Life Of Tires) ................................................. 263 Air Pressure ............................................................. 261
Chains ...................................................................... 267Changing.........................................................202
, 203
Compact Spare........................................................ 265 General Information............................. 261
, 264, 265
High Speed .............................................................. 262 Inflation Pressure .................................................... 261
Jacking ............................................................ 202
, 203
Life Of Tires ............................................................. 263
Load Capacity .......................................................... 258
Pressure Monitoring System (TPMS) .............. 67
, 168
Quality Grading........................................................ 268 Radial ....................................................................... 262
Replacement ........................................................... 263
Rotation ................................................................... 268
Safety .............................................................. 253
, 261
Sizes......................................................................... 255
Snow Tires ............................................................... 264 Spare Tires .................................. 202
, 264, 265, 26611

23_LA_OM_EN_USC_t.book Page 291