2023 CITROEN C3 clutch

32
Driving
Avoid attaching heavy objects to the key or the remote control. It would weigh
down on its shaft in the ignition switch and
could cause a malfunction.
Ignition on position
It allows the use of the vehicle's electric
equipment or portable devices to be charged.
Starting the engine
With the parking brake applied:
► Place the gear lever in neutral then fully
depress the clutch pedal.
►

Insert the key into the ignition switch; the
system recognises the code.
►


Unlock
the steering column by simultaneously
turning the steering wheel and the key.
In certain cases, you may have to apply
significant force to move the steering
wheel (wheels on full lock, for example).
►

Operate the starter motor by turning the key
to position

3 without pressing the accelerator
pedal, until the engine starts. Once the engine
starts, release the key.
After a cold start, preheating the catalytic converter can cause noticeable engine
vibrations for anything up to 2 minutes while
stationary with the engine running
(accelerated idle speed).
If the engine does not start straight away,
switch off the ignition. Wait a few
seconds before operating the starter motor
again. If the engine does not start after a few
attempts, do not keep trying - risk of
damaging the starter motor, the battery and
the engine.
Contact a CITROËN dealer.
In mild conditions, do not leave the
engine at idle to warm up but move off
straight away and drive at moderate speed.
5-speed manual gearbox
Engaging reverse gear

► Fully depress the clutch pedal.
► Push the gear lever fully to the right, then
backwards.
Only engage reverse gear when the
vehicle is stationary with the engine at
idle.
As a safety precaution and to facilitate starting the engine:
–

Always select neutral.
–


Depress the clutch pedal.
6-speed manual gearbox
Engaging 5th or 6th gear
► Move the gear selector fully to the right to
engage 5th or 6th gear.
Failure to follow this instruction could
cause permanent damage to the gearbox
(inadvertent engagement of 3
rd or 4th gear).
Engaging reverse gear

► Raise the ring under the knob and move the
gear selector to the left, then forwards.

33
Driving
6Only engage reverse gear when the
vehicle is stationary with the engine at
idle.
As a safety precaution and to facilitate starting the engine:
–

Always select neutral.
–


Press the clutch pedal.
Gear efficiency indicator
This system helps reduce fuel consumption by
recommending the most appropriate gear.
Operation
The system advises to change gear.The information appears in the instrument panel in the form of an ascending or
descending arrow.
The number displayed is the current gear.
Gear shift recommendations should not be
considered compulsory. In fact, the road layout,
the traffic density and safety remain the deciding
factors when choosing the best gear. The driver
therefore remains responsible for deciding
whether or not to follow the indications issued by
the system.
This function cannot be deactivated.
The system adapts its gear shift recommendation according to the driving
conditions (slope, load, etc.) and the driver’s
requirements (power, acceleration, braking,
etc.).
The system never suggests:
–

engaging first gear;
–


engaging reverse.
Overspeed alert
An audible overspeed alert is triggered when the
vehicle exceeds predefined speed thresholds.
When the vehicle speed is greater than 80 km/h,
the alert is emitted every 2 minutes.
When the vehicle speed is greater than 120
km/h, the alert is emitted every 2 seconds.
This system cannot be modified nor deactivated.
Parking sensors

Using sensors located in the bumper, this
system signals the proximity of obstacles
(e.g.
pedestrian, vehicle, tree, barrier) present in
their field of detection.
Rear parking sensors
The system is switched on by engaging reverse
gear.
The system is switched off when disengaging
reverse gear.
Audible assistance

The system signals the presence of obstacles
within the sensors’ detection zone.
The proximity information is given by an
intermittent audible signal, the frequency of
which increases as the vehicle approaches the
obstacle.
When the distance between the vehicle
and the obstacle becomes less than about
60
centimetres, the audible signal becomes
continuous.
Operating limits
If the boot is heavily loaded, the vehicle may tilt,
affecting distance measurements.

39
Practical information
7Consumables
DesignationGrade/Specs Quantity
Engine options EB2 - NA5W40 B712296 Synthetic 2.55 Lts
EB2 G2 Turbo 5W30 B712297 Synthetic 3.1 Lts
Transmission options Transmission fluid - MA75W - 80 B13/0067 API GL-4 2.1 ± 0.2 Lts
Transmission fluid - MB6 75W - 80 B13/0067 API GL-4 1.8 ± 0.2 Lts
HVAC Compressor Oil PS R1120 ml
AC Refrigerant for EB2 - NA R134A425 grams
AC Refrigerant for EB2 G2 Turbo R134A550 grams
Cooling Coolant (Premixed) for EB2 NA
(Antifreeze Coolant 40% + DM
/ DI
Water 60%) GOLDEN CRUISER LONG LIFE
ANTIFREEZE-COOLANT, GC LLC 2200 NP 4.65 ± 0.1 Lts
Coolant (Premixed) for EB2 G2 Turbo
(Antifreeze Coolant 40% + DM
/ DI
Water 60%) GOLDEN CRUISER LONG LIFE
ANTIFREEZE-COOLANT, GC LLC 2200 NP 5.7 ± 0.1 Lts
Brake/Clutch Brake fluidDOT3/DOT4 450 ± 50 ml
Clutch fluid Clutch fluid line connected with brake reservoir
Axle Axle oil NA
Checks
Unless otherwise indicated, check these
components in accordance with the
manufacturer's service schedule.
Otherwise, have them checked by a CITROËN
dealer.
Only use products recommended by
CITROËN.
In order to optimise the operation of
components as important as those in the
braking system, CITROËN selects and offers
very specific products.12 V battery
Check regularly during service that the
terminals and coin plug caps are clean
and tightened.

78
STANDARD WARRANTY
CITROËN New Vehicle Warranty
PCA Automobiles India Private Limited (hereinafter called “PAIPL”),
warrants that each new CITROËN vehicle sold shall be free from any
defects in material and workmanship, under normal use and maintenance,
subject to the following terms and conditions.
New Vehicle Warranty Period
This warranty (“New Vehicle Warranty“) shall exist for a period of
24 months or 40,000 kilometres, from the date of delivery whichever
is earlier (“New Vehicle Warranty Period”). This warranty is transferable
to subsequent owner for the remaining New Vehicle Warranty Period.
This warranty is applicable only in India and not transferable to any ot\
her
country.
What is covered?
Except as provided in “What is not covered?” hereof, our Authorised
Dealers shall either repair or replace, any CITROËN genuine part that is
acknowledged by PAIPL to be defective in material or workmanship within
the New Vehicle Warranty Period stipulated above, at no cost to the owner
of the CITROËN vehicle for parts or labour. Such defective parts which
have been replaced will become the property of PAIPL.
What is not covered?
This warranty shall not apply to:
• Normal maintenance services, including without limitation, cleaning and
polishing, minor adjustments, engine tuning, oil/ fluid changes, filters
replenishment, fastener retightening, wheel balancing, wheel alignment
and tyre rotation etc.
•

Replacement of parts as a result of normal wear and tear such as spark
plugs, belts, brake pads and linings, clutch disc/facing, filters, wiper
blades, bulbs, fuses, etc. •


Any vehicle on which the odometer reading has been altered so that
mileage cannot be accurately determined.
What is not covered?
Damage or failure resulting from:
• Negligence of proper maintenance as required in the chapter
.
• Misuse, abuse, accident, theft, flooding or fire.
•

Use of improper or insufficient fuel, fluids or lubricants.
•


Use of parts other than CITROËN Genuine Parts.
•


Any device and/or accessories not supplied by P
AIPL.
•

Modifications, alterations, tampering or improper repair
.
•

Parts used in applications of which they were not designed or not
approved by P

AIPL.
•

Slight irregularities not recognised as affecting quality or function of the
vehicle or parts, such as slight noise or vibrations, or items considere\
d
characteristic of the vehicle.
•


Airborne, fallout, industrial fallout, acid rain, hail and wind storms, \
or
other

Acts of God.
•

Paint scratches, dents or similar paint or body damage.
•


Action of road elements (sand, gravel, dust or road debris) which resu\
lts
in stone chipping of paint or glass.
•


Incidental or consequential damages, including without limitation, loss \
of
time, inconvenience, loss of use of vehicle or commercial loss.
•


This warranty is the entire warranty given by P
AIPL for CITROËN
vehicles and no dealer or its or his agent or employee is authorised
to extend or enlarge this warranty and no dealer or its or his agent or \
employee is authorised to make any oral warranty on PAIPL behalf.
•

P
AIPL reserves the right to make any change in design or make any
improvement on the vehicle at any time without any obligation to make
the same change on vehicles previously sold.
•

P
AIPL reserves the right for the final decision in all warranty matters.
Maintenance and Warranty

92
MAINTENANCE
Necessity of maintenance
Your CITROËN vehicle has been manufactured using the latest technology
and under the strictest quality control standards. It is also designed t\
o
minimize maintenance requirements with longer service intervals to save \
you both time and money.
However, scheduled maintenance is necessary to ensure your CITROËN
vehicle operates properly and efficiently for the reasons listed below:
Lubricants:
Your CITROËN vehicle uses various kinds of oils and fluids, including
engine oil, transmission fluid, differential fluid, battery fluid, and engine
coolant. These oils and fluids play very important roles, such as lubricating
and cooling the vehicle and preventing rust. Periodically they need to b\
e
properly refilled or replaced.
Rubber parts:
Hoses, belts and boots use rubber parts, which are bound to crack when
worn out. They need to be replaced with new ones if they should wear out.
Normal deterioration
Vehicles are equipped with many parts for which it is impossible to avoid\

normal wear and tear. These parts include: tires, brake pads, clutch
disc, etc. They are indispensable for basic vehicle functions and must be
replaced regularly.
Maintenance services at CITROËN Authorised Dealers
A CITROËN Authorised Dealer has factory-trained technicians and genuine
CITROËN parts to service your vehicle properly. For expert advice and
quality service, visit a CITROËN Authorised Dealer.
Inadequate, incomplete or insufficient servicing may result in operational
problems with your vehicle that could lead to vehicle damage, an acciden\
t,
or personal injury.
We appreciate your understanding of the importance of these instructions,\

and we look forward to servicing your vehicle at CITROËN Authorised
Dealers.Failure to perform scheduled maintenance may result in
reduced vehicle performance or possible breakdowns,
as well as exclusion from warranty coverage
WARNING!
Maintenance and Warranty

94
MAINTENANCE SCHEDULE
The following maintenance services must be performed to ensure good emis\
sion control and performance. Keep receipts for all vehicle emission ser\
vices
to protect your warranty. Where both mileage and time are shown, the frequency of service is determined by whichever occurs first.
A: Adjust
C: Clean

I: Inspect

R: Replace
Service 1 2 3 4 5 6 7 8 9 10 11
C3 Naturally Aspirated Months
2 12 24 36 48 60 72 84 96 108 120
Km (K) 2 10 20 30 40 50 60 70 80 90 100
1.2L (1199cc) (3 Cyl)
60KW @ 5750 rpm
115Nm @ 3750 rpm Air cleaner filter element
C R C R C R C R C R
Engine oil I R R R R R R R R R R
Oil Filter R R R R R R R R R R
Drain Plug Gasket R R R R R R R R R R
Change Spark plugs RR
Check accessory belt (waterpump & Strech belt) I I I I I I I R I I
Change coolant I I I I I R I I I I R
Pollen Filter R R R R R R R R R R
Fuel Filter (intank) R
Brake Fluid/Clutch Fluid I I R I R I R I R I R
Check timing belt visual condition, replace if found
damage R
Rear Twist Beam Bush – Check wear and tear or noise,
replace if found. I I I I I I I I I I
Maintenance and Warranty

95
A: Adjust C: Clean I: Inspect R: Replace
Service 1 2 3 4 5 6 7 8 9 10 11
C3 Turbo Months
2 12 24 36 48 60 72 84 96 108 120
Km (K) 2 10 20 30 40 50 60 70 80 90 100
1.2L (1199 cc) (3 Cyl)
81KW @ 5500 rpm
190Nm @ 1750 rpm Air cleaner filter element
C R C R C R C R C R
Change engine oil R R R R R R R R R R
Oil Filter R R R R R R R R R R
Drain Plug Gasket R R R R R R R R R R
Change Spark plugs RR
Check accessory belt condition visually, replace if
found damage I I I I I I I R I I
Change coolant I I I I R I I I I R
Pollen Filter R R R R R R R R R R
Fuel Filter (intank) R
Brake/Clutch Fluid I R I R I R I R I R
Check timing belt visual condition, replace if found
damage R
Rear Twist Beam Bush – Check wear and tear or
noise, replace if found. I I I I I I I I I I
Maintenance and Warranty