2022 KIA RIO Battery

Maintenance
62
7
✽ ✽
NOTICE - Window tinting pre-
caution
Window tint(especially metallic
film) might cause communication
disorder or poor radio reception,
and malfunction of the automatic
lighting system due to excessive
change of illumination inside the
vehicle. The solution used might also
flow into electric, electronic devices
causing disorder and failure.
CAUTION
Visually inspect the battery cap
to ensure it is securely closed.If the battery cap is not securelyclosed, moisture may enter thesystem and damage the electri-cal components.
CAUTION - Remodeling
Prohibited
Do not try remodeling the vehi-cle in any way. It is illegal, andmay affect the vehicle's perform-ance, durability, and safety. Themanufacturer's warranty doesnot cover any problems causedby remodeling. Remodeling thevehicle can cause malfunction ofthe vehicle, wiring damage, bat-tery discharge, connector dam-age, or fire.
CAUTION
Do not disassemble nor assem-ble the multi fuse when it issecured with nuts and bolts.Incorrect or partial assemblytorque may cause a fire. Havethe vehicle checked by anauthorized Kia dealer.
CAUTION - Random
wiring prohibited when
retrofitting equipment
Use of random wiring in the vehicle might cause danger dueto failure and damage of thevehicle’s performance.
Using random wires especiallywhen retrofitting AVN or theftalarm system, remote enginecontrol, car phone or radiomight damage the vehicle orcause fire.
SC PE USA 7.qxp 9/9/2021 6:28 PM Page 62

Maintenance
70
7
Fuse NameFuse ratingCircuit Protected
B/UP LAMP10ABack-Up Lamp Switch
B+140AInstrument Panel Junction Block (Fuse - DRL2, FOGLAMP FRONT, STOP LAMP, MODULE6, Power
Connector (AUDIO, ROOM LAMP))
B+250AInstrument Panel Junction Block (Fuse - IMMO, SMART KEY, BRAKE SWITCH, SAFETY P/WINDOW,
S/HEATER, SUNROOF, Power Window Relay)
IG240AIgnition Switch, IG2 Relay, Start Relay
COOLING FAN40ACooling Fan1/2 Relay
ECU130AFuse - ECU3, ECU4, Main Relay
HEAD LAMP20AHead Lamp Relay
H/LAMP HI20AWith CANADA DRL : SLM(Seat Belt & Lighting Module) or BCM(Body Control Module)
Without CANADA DRL : Head Lamp HI Relay
FUEL PUMP20AFuel Pump Relay
HORN15AHorn Relay/ Burglar Alarm Horn Relay
A/C10AAir Conditioner Relay
AMS10ABattery Sensor
B+340AInstrument Panel Junction Block (Fuse - T/SIGNAL LAMP, DOOR LOCK, Tail Lamp Relay)
IG140AStart Relay, [With Smart Key] IG1 Relay, ACC Relay,
[With Out Smart Key] Ignition Switch
POWER OUTLET40AInstrument Panel Junction Block (Power Outlet Relay)
SC PE USA 7.qxp 9/9/2021 6:28 PM Page 70

Maintenance
72
7
LIGHT BULBS
Bulb replacement precaution
Please keep extra bulbs on hand
with appropriate wattage ratings in
case of emergencies.
Refer to “Bulb Wattage” in chapter 8.
When changing lamps, first turn off
the engine at a safe place, firmly
apply the parking brake and detach
the battery’s negative (-) terminal.
Use only bulbs of the specified
wattage. Lamp part malfunction due to net-work failure
The headlamp, taillight, and fog light
may light up when the head lamp
switch is turned ON, and not light up
when the taillight or for light switch is
turned ON. This may be cause by
network failure or vehicle electrical
control system malfunction. If there is
a problem, we recommend the sys-
tem be serviced by an authorized Kia
dealer.
 Lamp part malfunction due to elec- trical control system stabilization
A normally functioning lamp may
flicker momentarily. This momentary
occurrence is due to stabilization
function of the vehicle's electrical
control system. If the lamp soon
returns to normal, the vehicle does
not require service.
However, if the lamp goes out after
the momentary flickering, or the flick-
ering continues, we recommend the
system be serviced by an authorized
Kia dealer.
WARNING- Working on the lights
Prior to working on the lights,
firmly apply the parking brake,
ensure that the ignition switch
is turned to the LOCK position
and turn off the lights to avoid
sudden movement of the vehi-
cle and burning your fingers or
receiving an electric shock.
CAUTION -Light replace-
ment
Be sure to replace the burned- out bulb with one of the samewattage rating. Otherwise, itmay cause damage to the fuseor electric wiring system.
CAUTION -Headlamp
Lens
To prevent damage, do notclean the headlamp lens withchemical solvents or strongdetergents.
SC PE USA 7.qxp 9/9/2021 6:28 PM Page 72

783
Maintenance
5. Remove the bulb from the headlamp assembly.
6. Install a new static bending light bulb and snap the static bending
light bulb retaining wire into posi-
tion by aligning the wire with the
groove on the bulb.
7. Connect the static bending light bulb socket-connector.
8. Install the headlamp bulb cover by turning it clockwise.Front fog lamp (Bulb type)
bulb replacement
1. Disconnect the negative (-) batteryterminal.
2. Disconnect the side after loosen- ing the front bumper sides screws
and clips.
3. Disconnect the front fog lamp con- nector.
4. Remove the socket from the assembly by turning the socket
counterclockwise until the tabs on
the socket align with the slots on
the assembly. 5. Remove the bulb from the socket
by pressing it in and rotating it
counter-clockwise until the tabs on
the bulb align with the slots in the
socket. Pull the bulb out of the
socket.
6. Insert a new bulb by inserting it into the socket and rotating it until
it locks into place.
7. Install the socket in the assembly by aligning the tabs on the socket
with the slots in the assembly.
Push the socket into the assembly
and turn the socket clockwise.
8. Connect the front fog lamp con- nector.
9. Install the front bumper side assembly to the body of the vehi-
cle.
OYB070152L
SC PE USA 7.qxp 9/9/2021 6:29 PM Page 83

Specifications, Consumer information, Reporting safety defects
12
8
Kia utilizes a network of over 30,000 roadside assistance
providers. Should you accidentally run out of fuel, require
a battery jump, or need help changing a tire, a Kia
Roadside Assistance Representative will dispatch some-
one to deliver a small quantity of gas, change a flat tire
with your inflated spare, or arrange a battery jump to
allow you to proceed to your destination. We have access
to a network of over 10,000 locksmiths to help you should
you become locked out of your Kia.
In the event that mechanical difficulty renders your vehi-
cle undriveable due to a warranty-related concern, Kia’s
Roadside Assistance Representative will arrange to
transport your vehicle to the nearest Kia dealer or to an
alternative service location.
Your vehicle must be accessible to our dispatch transport
vehicle, as determined by our driver, to receive this service.
✽ ✽
NOTICE
Roadside Assistance benefits are not available for any
Kia vehicle that has ever been or should be issued a “sal-
vage” title or similar “branded” title under any state’s
law or has been declared a “total loss” or equivalent by
a financial institution or insurance company.
Trip interruption
Trip interruption expense benefits are provided in the
event that a warranty-related disablement occurs more
than 150 miles from your home, and the repairs require
more than 24 hours to complete. Reasonable reimburse-
ment is included for meals, lodging, or rental car expens-
es. Trip interruption coverage is limited to $100 per day
subject to a three day maximum limit per incident. You
must contact the Kia Roadside Assistance Center to
obtain pre-authorization of expenses. Once the Kia
Roadside Assistance Center gives authorization for trip
interruption benefits, they will assist you in making the
necessary arrangements. Insurance deductibles,
expenses, and claims paid by your insurance company or
other providers are not eligible for reimbursement.
Fleet vehicles are excluded from reimbursement under
Kia’s Trip Interruption Policy.
SC PE USA 8.qxp 8/23/2021 5:30 PM Page 12

Index
2I
Air bag - advanced supplemental restraint system ........3-34Adding equipment to or modifying your air bag-equipped vehicle ......................................................3-62
Air bag warning label ................................................3-62
Air bag warning light ..................................................3-38
Curtain air bag ............................................................3-54
Driver's and passenger's front air bag ........................3-49
How does the air bag system operate ........................3-35
Inflation and non-inflation conditions of the air bag..3-56
Occupant detection system ........................................3-41
Side air bag ................................................................3-52
SRS Care ....................................................................3-61\
SRS components and functions ..................................3-38
Air cleaner ....................................................................7-31\
Filter replacement ......................................................7-31
Air conditioning system ..................................................8-6
Appearance care ..........................................................7-102 Exterior care ..............................................................7-102
Interior care ..............................................................7-108
Automatic climate control system ..............................4-122 Activate upon washer fluid use ..............................4-134
Air Conditioning refrigerant label ............................4-133
Automatic heating and air conditioning ..................4-123
Checking the amount of air conditioner refrigerant and compressor lubricant ..............................................4-132
Climate control air filter ..........................................4-131 Manual heating and air conditioning ........................4-124
System operation ......................................................4-129
Battery........................................................................\
....7-39 For best battery service ..............................................7-39
Recharging the battery ................................................7-40
Reset items ..................................................................7-41
Before driving ..................................................................5-5 Before entering vehicle ................................................5-5
Before starting ............................................................5-5
Necessary inspections ................................................5-5
Blind-Spot Collision Warning (BCW) ..........................5-65 Blind-Spot Collision Warning malfunction andlimitations ................................................................5-70
Blind-Spot Collision Warning operation ....................5-69
Blind-Spot Collision Warning settings ......................5-67
Detecting sensor ..........................................................5-66
Brake fluid ....................................................................7-27\
Checking the brake fluid level ....................................7-27
Brake system..................................................................5-25 Anti-lock Brake System (ABS) ..................................5-30
Electronic Stability Control (ESC) ............................5-31
Good braking practices ..............................................5-38
Hill-start Assist Control (HAC) ..................................5-35
Parking brake ..............................................................5-27
Power brakes ............................................................5-25
A
B
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 2

Index
6I
Key positions ..................................................................5-7Ignition switch position ................................................5-7
Starting the engine ........................................................5-9
Keys ........................................................................\
........4-4 Battery replacement ......................................................4-8
Immobilizer system ......................................................4-9
Key operations ..............................................................4-4
Record your key number ..............................................4-4
Remote keyless entry system operations ......................4-5
Transmitter precautions ................................................4-7
Lane Following Assist (LFA) ........................................5-89 Detecting sensor ..........................................................5-89
Lane Following Assist malfunction and limitations ..5-93
Lane Following Assist operation ................................5-90
Lane Following Assist settings ..................................5-89
Lane Keeping Assist (LKA) ..........................................5-58 Detecting sensor ..........................................................5-58
Lane Keeping Assist malfunction and limitations ......5-63
Lane Keeping Assist operation ..................................5-60
Lane Keeping Assist settings ......................................5-59
LCD display (For Type B cluster) ................................4-64 Driving Assist mode ..................................................4-65
LCD Display Mode ....................................................4-6\
4 User Settings Mode (For type B cluster) ....................4-66
Warning messages (For type B cluster) ......................4-74
Liftgate (For 5 door) ......................................................4-30 Closing the liftgate ......................................................4-30
Emergency liftgate safety release ..............................4-31
Opening the liftgate ....................................................4-30
Light bulbs ....................................................................7-72\
Back-up lamp bulb replacement (for 4 door) ............7-94
Back-up lamp bulb replacement (for 5 door) ............7-87
Bulb replacement precaution ....................................7-72
Front fog lamp (Bulb type) bulb replacement ..........7-83
Front turn signal lamp bulb replacement (Headlamp Type A) ..................................................7-80
Front turn signal lamp bulb replacement (Headlamp Type B, C) ..............................................7-80
Glove box lamp bulb replacement ..........................7-100
Headlamp (Low/High beam) (Bulb type) bulb replacement (Headlamp Type A) ..............................7-77
Headlamp (Low/High beam) (Bulb type) bulb replacement (Headlamp Type B) ..............................7-78
Headlamp (Low/High beam) (LED type) bulb replacement (Headlamp Type C) ..............................7-84
High mounted stop lamp bulb replacement (for 4 door)................................................................7-97
High mounted stop lamp bulb replacement (for 5 door)................................................................7-92
License plate lamp bulb replacement ........................7-92
Liftgate room lamp bulb replacement (for 5 door) ..7-101
L
K
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 6

I7
Index
Light bulb position (Front) ........................................7-74
Light bulb position (Rear) (4 Door) ..........................7-76
Light bulb position (Rear) (5 Door) ..........................7-75
Light bulb position (Side) ..........................................7-77
Map lamp bulb replacement ......................................7-98
Position lamp + DRL (LED type) bulb replacement..7-84
Position lamp bulb replacement (Headlamp Type A)..7-81
Rear turn signal lamp bulb replacement (for 4 door) ..7-93
Rear turn signal lamp bulb replacement (for 5 door) ..7-86
Room lamp bulb replacement ..................................7-100
Side marker (front) (Bulb type) bulb replacement (Headlamp Type A) ..................................................7-82
Side marker (front) (LED type) bulb replacement (Headlamp Type B, C) ..............................................7-84
Side marker (rear) (Bulb type) bulb replacement (Rear combination lamp Type A) (for 5 door) ........7-90
Side marker (rear) (LED type) bulb replacement (Rear combination lamp Type B) (for 4 door) ........7-97
Side marker (rear) (LED type) bulb replacement (Rear combination lamp Type B) (for 5 door) ........7-91
Side repeater lamp (bulb type) bulb replacement ......7-85
Side repeater lamp (LED type) bulb replacement ......7-85
Static bending light replacement (Headlamp Type B, C) ............................................7-82
Stop and tail lamp (LED type) bulb replacement (for 4 door)................................................................7-96
Stop and tail lamp (LED type) bulb replacement (for 5 door)................................................................7-91 Stop and tail lamp / Side marker (Bulb type)
replacement (for 4 door) ..........................................7-94
Stop and tail lamp bulb replacement (for 5 door) ......7-88
Tail lamp (Bulb type) bulb replacement (for 4 door) ..7-95
Tail lamp (inside) bulb replacement (for 5 door) ......7-89
Trunk lamp bulb replacement (for 4 door) ................7-98
Vanity mirror lamp bulb replacement ........................7-99
Lighting........................................................................\
..4-92 Battery saver function ................................................4-92
Front fog light ............................................................4-98
Headlight escort function ............................................4-92
Headlight welcome function ......................................4-92
High Beam Assist (HBA) ..........................................4-96
High beam operation ..................................................4-95
Lighting control ..........................................................4-93
Turn signals and lane change signals ........................4-97
Maintenance services ......................................................7-5 Owner maintenance precautions ..................................7-6
Owner’s responsibility ..................................................7-5
Manual climate control system ....................................4-110 Activate upon Washer Fluid Use ............................4-121
Air Conditioning refrigerant label ............................4-120
Checking the amount of air conditioner refrigerant and compressor lubricant ........................................4-119
Climate control air filter ..........................................4-118
M
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 7