2022 KIA RIO Maintenance

815
Specifications, Consumer information, Reporting safety defects
Reporting Safety Defects.
If you believe that your vehicle has a defect which could
cause a crash or could cause injury or death, you should
immediately inform the National Highway Traffic Safety
Administration (NHTSA) in addition to notifying Kia
America, Inc..
If NHTSA receives similar complaints, it may open an
investigation, and if it finds that a safety defect exists in a
group of vehicles, it may order a recall and remedy cam-
paign. However, NHTSA cannot become involved in indi-
vidual problems between you, your dealer, or Kia
America, Inc..
To contact NHTSA, you may call the Vehicle Safety
Hotline toll-free at 1-888-327-4236 (TTY: 1-800-424-
9153); go to http://www.safercar.gov; download the
SaferCar mobile application; or write to: Administrator,
NHTSA, 1200 New Jersey Ave. SE., Washington, DC
20590. You can also obtain other information about
motor vehicle safety from http://www.safercar.gov.The following publications are available on
www.KiaTechinfo.com
Service manual:
This manual covers maintenance and recommended pro-
cedures for repair to engine and chassis components. It
is written for the Journeyman mechanic, but is simple
enough for most mechanically inclined owners to under-
stand.
Electrical troubleshooting manual:
This manual complements the Service Manual by provid-
ing indepth troubleshooting information for each electrical
circuit in your vehicle.
Owner's manual:
This manual describes the overall features and operating
procedures for the vehicle.
REPORTING SAFETY DEFECTS
(U.S. ONLY)
ONLINE FACTORY AUTHORIZED MANUALS
(U.S. ONLY)
SC PE USA 8.qxp 8/23/2021 5:30 PM Page 15

Index
4I
Emission control system ..............................................7-111Crankcase emission control system ..........................7-111
Evaporative emission control (including ORVR: Onboard Refueling Vapor Recovery) system ........7-111
Exhaust emission control system ..............................7-112
Engine .................................................................\
...........8-2
Engine compartment ................................................2-7, 7-4
Engine coolant ..............................................................7-24 Changing the coolant ..................................................7-26
Checking the coolant level..........................................7-24\
Engine number ..............................................................8-10
Engine oil ......................................................................7-\
21 Changing the engine oil and filter ..............................7-22
Checking the engine oil level ....................................7-21
ENGINE START/STOP button ....................................5-10 ENGINE START/STOP button position ....................5-10
Illuminated ENGINE START/STOP button ..............5-10
Starting the engine ......................................................5-13
Explanation of scheduled maintenance items ..............7-15
Exterior overview ............................................................2-2
Forward Collision-Avoidance Assist (FCA)..................5-41 Brake operation ..........................................................5-46
Detecting sensor ..........................................................5-41
Forward Collision-Avoidance Assist malfunction ......5-48
Forward Collision-Avoidance Assist settings ............5-42 Forward Collision-Avoidance Assist warning message
and function control ..................................................5-44
Limitations of Forward Collision-Avoidance Assist ..5-50
Warning message and warning light ..........................5-47
Fuel filler door ..............................................................4-42 Closing the fuel filler door..........................................4-\
43
Opening the fuel filler door ........................................4-42
Fuel requirements ............................................................1-3 Do not use methanol ....................................................1-4
Gasoline containing alcohol and methanol ..................1-3
Fuses ........................................................................\
......7-57 Engine compartment fuse replacement ......................7-61
Fuse/relay panel description ......................................7-63
Inner panel fuse replacement ......................................7-59
Memory fuse ..............................................................7-60
Hood ........................................................................\
......4-39 Closing the hood ........................................................4-40
Hood open warning ....................................................4-40
Opening the hood ......................................................4-39
How to use this manual ..................................................1-2
F
H
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 4

I7
Index
Light bulb position (Front) ........................................7-74
Light bulb position (Rear) (4 Door) ..........................7-76
Light bulb position (Rear) (5 Door) ..........................7-75
Light bulb position (Side) ..........................................7-77
Map lamp bulb replacement ......................................7-98
Position lamp + DRL (LED type) bulb replacement..7-84
Position lamp bulb replacement (Headlamp Type A)..7-81
Rear turn signal lamp bulb replacement (for 4 door) ..7-93
Rear turn signal lamp bulb replacement (for 5 door) ..7-86
Room lamp bulb replacement ..................................7-100
Side marker (front) (Bulb type) bulb replacement (Headlamp Type A) ..................................................7-82
Side marker (front) (LED type) bulb replacement (Headlamp Type B, C) ..............................................7-84
Side marker (rear) (Bulb type) bulb replacement (Rear combination lamp Type A) (for 5 door) ........7-90
Side marker (rear) (LED type) bulb replacement (Rear combination lamp Type B) (for 4 door) ........7-97
Side marker (rear) (LED type) bulb replacement (Rear combination lamp Type B) (for 5 door) ........7-91
Side repeater lamp (bulb type) bulb replacement ......7-85
Side repeater lamp (LED type) bulb replacement ......7-85
Static bending light replacement (Headlamp Type B, C) ............................................7-82
Stop and tail lamp (LED type) bulb replacement (for 4 door)................................................................7-96
Stop and tail lamp (LED type) bulb replacement (for 5 door)................................................................7-91 Stop and tail lamp / Side marker (Bulb type)
replacement (for 4 door) ..........................................7-94
Stop and tail lamp bulb replacement (for 5 door) ......7-88
Tail lamp (Bulb type) bulb replacement (for 4 door) ..7-95
Tail lamp (inside) bulb replacement (for 5 door) ......7-89
Trunk lamp bulb replacement (for 4 door) ................7-98
Vanity mirror lamp bulb replacement ........................7-99
Lighting........................................................................\
..4-92 Battery saver function ................................................4-92
Front fog light ............................................................4-98
Headlight escort function ............................................4-92
Headlight welcome function ......................................4-92
High Beam Assist (HBA) ..........................................4-96
High beam operation ..................................................4-95
Lighting control ..........................................................4-93
Turn signals and lane change signals ........................4-97
Maintenance services ......................................................7-5 Owner maintenance precautions ..................................7-6
Owner’s responsibility ..................................................7-5
Manual climate control system ....................................4-110 Activate upon Washer Fluid Use ............................4-121
Air Conditioning refrigerant label ............................4-120
Checking the amount of air conditioner refrigerant and compressor lubricant ........................................4-119
Climate control air filter ..........................................4-118
M
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 7

Index
8I
Heating and air conditioning ....................................4-111
System operation ......................................................4-116
Mirrors ........................................................................\
..4-48 Inside rearview mirror ................................................4-48
Outside rearview mirror ..............................................4-49
Online factory authorized manuals (U.S. only) ............8-15
Owner maintenance ........................................................7-7 Owner maintenance schedule ......................................7-7
Parking brake ................................................................7-30 Checking the parking brake ........................................7-30
Rear Cross-Traffic Collision Warning (RCCW) ..........5-94 Detecting sensor ..........................................................5-94
Rear Cross-Traffic Collision Warning malfunction and limitations ................................................................5-97
Rear Cross-Traffic Collision Warning operation ........5-96
Rear Cross-Traffic Collision Warning settings ..........5-95
Rear View Monitor (RVM)............................................4-90 Rear View Monitor malfunction and limitations ........4-90 Recommended lubricants and capacities ........................8-7
Recommended SAE viscosity number ........................8-8
Refrigerant label ............................................................8-10
Reporting Safety Defects (U.S. only)............................8-15
Road warning ..................................................................6-2 Hazard warning flasher ................................................6-2
Scheduled maintenance service ......................................7-9 Scheduled maintenance service precaution ..................7-9
Seat ........................................................................\
..........3-4 Driver’s seat ..................................................................3-4
Front passenger’s seat ..................................................3-4
Front seat adjustment ....................................................3-7
Headrest (for front seat) ................................................3-8
Rear seat ........................................................................\
3-4
Rear seat adjustment ..................................................3-11
Seatback pocket ..........................................................3-10
Seat belts ........................................................................\
3-15 Care of seat belts ........................................................3-25
Pre-tensioner seat belt ................................................3-21
Seat belt precautions ..................................................3-23
Seat belt restraint system ............................................3-15
Smart key ......................................................................4-\
11 Smart key functions ....................................................4-11
Smart key immobilizer system ..................................4-14
Smart key precautions ................................................4-13
S
R
P
O
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 8

I9
Index
Smart Trunk Release (4 door) ......................................4-26
Special driving conditions ..........................................5-105Driving at night ......................................................5-106
Driving in flooded areas ..........................................5-108
Driving in the rain ....................................................5-107
Driving off-road ........................................................5-108
Hazardous driving conditions ..................................5-105
Highway driving ......................................................5-108
Rocking the vehicle ..................................................5-105
Smooth cornering ......................................................5-106
Sport mode integrated control system ..........................5-40 SPORT mode ..............................................................5-40
Steering wheel...........................................................\
.....4-45 Electric Power Steering (EPS) ....................................4-45
Horn ........................................................................\
....4-47
Tilt steering ................................................................4-46
Storage compartment ..................................................4-140 Center console storage ..............................................4-140
Glove box ..................................................................4-140
Luggage net holder ..................................................4-141
Sunglass holder ........................................................4-141
Theft-alarm system ........................................................4-15 Armed stage ................................................................4-15
Disarmed stage ............................................................4-17
Theft-alarm stage ........................................................4-16 Tire Pressure Monitoring System (TPMS - Type A) ......6-8
Changing a tire with TPMS ........................................6-11
Low tire pressure telltale ..............................................6-9
TPMS (Tire Pressure Monitoring System) malfunction indicator ....................................................................6-10\
Tire Pressure Monitoring System (TPMS - Type B) ....6-13 Changing a tire with TPMS ........................................6-17
Check tire pressure.....................................................\
.6-13
Low tire pressure position telltale ..............................6-15
Low tire pressure telltale ............................................6-15
Tire specification and pressure label ............................8-10
Tires and wheels ..............................................................8-5
Tires and wheels ............................................................7-42 All season tires ..........................................................7-54
Checking tire inflation pressure ..................................7-43
Low aspect ratio tire ..................................................7-56
Radial-ply tires ............................................................7-55
Recommended cold tire inflation pressures................7-42
Snow tires ..................................................................7-54
Summer tires ..............................................................7-54
Tire care ....................................................................7-42\
Tire chains ..................................................................7-55
Tire maintenance ........................................................7-47
Tire pressure................................................................7-43
Tire replacement ........................................................7-46
Tire rotation ..............................................................7-44
Tire sidewall labeling..................................................7-47
Tire traction ................................................................7-47
T
SC PE USA Index.qxp 8/23/2021 5:25 PM Page 9