Page 33 of 471
CAUTION!
Do not close the door before reattaching the
door check to the body. Damage may occur to
the door check.
Do not overtighten Torx fasteners, damage to
the vehicle’s parts will occur.
Hinge pins can break if overtightened during
door install (Max Torque: 6.0 ft· lb/8.1 N·myf .
1 — Seat Connector Straight Into Harness
2 — Wiring Harness Lever Starts To Lower
Page 38 of 471
& $ 8 7 , 2 1
Do not close the door before reattaching the
door check to the body. Damage may occur to
the door check.
Do not overtighten Torx fasteners, damage to
the vehicle’s parts will occur.
Hinge pins can break if overtightened during
door install (Max Torque: 6.0 ft· lb/8.1 N·myf .
2
22_JL_OM_EN_USC_t.book Page 37
Page 94 of 471
CAUTION!
Do not overtighten Torx screws. Damage to the
retainers will occur.Torque
Specification
For Torx Screw Maximum Minimum
119.5 in-lb 150.5 in-lb 106.2 in-lb 13.5 N·m 17.0 N·m 12.0 N·m
CAUTION!
Failure to follow the next steps could result in
damage to the Soft Top or vehicle.
2
22_JL_OM_EN_USC_t.book Page 93
Page 110 of 471
WARNING!
Do not drive your vehicle on public roads with the
door frame(syf U H P R Y H G D V \ R X Z L O O O R V H W K H S U R W H c-
tion that they can provide. This procedure is
furnished for use during off-road operation only.
Do not drive your vehicle on public roads with
the doors removed as you will lose the protec -
tion that they can provide. This procedure is
furnished for use during off-road operation
only.
Target Torque
Specification
For Torx
Fasteners Maximum
Minimum
79.6 in-lb
(9 N·myf 87.6 in-lb
(9.9 N·myf71.7 in-lb
(8.1 N·myf
CAUTION!
Do not overtighten the screws. You can strip the
screws if they are overtightened.
2
22_JL_OM_EN_USC_t.book Page 109
Page 296 of 471
: $ 5 1 , 1 *
In the ESC “Full Off” mode, the engine torque
reduction and stability features are disabled.
Therefore, enhanced vehicle stability offered
by the ESC system is unavailable. In an emer-
gency evasive maneuver, the ESC system will
not engage to assist in maintaining stability.
ESC “Full Off” mode is intended for
off-highway or off-road use only.
The Electronic Stability Control (ESCyf F D Q Q R W
prevent the natural laws of physics from
acting on the vehicle, nor can it increase the
traction afforded by prevailing road condi -
tions. ESC cannot prevent all accidents,
including those resulting from excessive
speed in turns, driving on very slippery
surfaces, or hydroplaning. ESC also cannot
prevent collisions.
6
22_JL_OM_EN_USC_t.book Page 295
