2022 FORD F-150 check engine light

PREPARING YOUR VEHICLE
FOR STORAGE
If you plan on storing your vehicle for 30
days or more, the following maintenance
recommendations ensures your vehicle
stays in good operating condition.
Under various conditions, long-term
storage may lead to degraded engine
performance or failure unless you use
specific precautions to preserve your
vehicle.
General
•
Store all vehicles in a dry, ventilated
place.
• If vehicles are stored outside, they
require regular maintenance to protect
against rust and weather damage.
• Make sure all linkages, cables, levers
and pins under your vehicle are covered
with grease to prevent rust.
• Move vehicles at least 25 ft (7.5 m)
every 15 days to lubricate working parts
and prevent corrosion.
• Fill the fuel tank with high-quality fuel
until the first automatic shutoff of the
fuel pump nozzle.
Engine
• Change the engine oil and filter prior to
storage because used engine oil
contains contaminants which may
cause engine damage.
• Start the engine every 15 days for a
minimum of 15 minutes. Run at fast
idle with the climate controls set to
defrost until the engine reaches normal
operating temperature.
• With your foot on the brake, shift
through all the gears while the engine
is running. Body
•
Wash your vehicle thoroughly to
remove dirt, grease, oil, tar or mud from
exterior surfaces, rear-wheel housings
and the underside of front fenders.
• Periodically wash your vehicle if it is
stored in exposed locations.
• Touch-up exposed or primed metal to
prevent rust.
• Cover chrome and stainless steel parts
with a thick coat of auto wax to prevent
discoloration. Re-wax as necessary
when you wash your vehicle.
• Lubricate all hood, door and luggage
compartment hinges and latches with
a light grade oil.
• Cover interior trim to prevent fading.
• Keep all rubber parts free from oil and
solvents.
Hybrid Battery Systems
We recommend the following actions for
your vehicle:
• When storing your vehicle for greater
than 30 days the state of charge
should be approximately 50%.
Additionally we recommend
disconnecting the 12V battery which
will reduce system loads on the HV
battery.
12 Volt Battery
• Check and recharge as necessary. Keep
connections clean.
Note: It is necessary to reset memory
features if you disconnect the battery
cables.
Brakes
Make sure the brakes and parking brake
release fully.
517
2022 F-150 (TFD) Canada/United States of America, enUSA, Edition date: 202109, First-Printing Storing Your Vehicle

It is important to rely upon your dealership
to properly diagnose and repair your
vehicle.
We strongly recommend only using our
genuine or our authorized re-manufactured
replacement parts engineered for your
vehicle.
Additives and Chemicals
We do not recommend using chemicals or
additives not approved by us as part of
your vehicle
’s normal maintenance. Please
consult your warranty information.
Oils, Fluids and Flushing
In many cases, fluid discoloration is a
normal operating characteristic and, by
itself, does not necessarily indicate a
concern or that the fluid needs to be
changed. Have discolored fluids that also
show signs of overheating or foreign
material contamination checked
immediately. Make sure to change the vehicle
’s oils and
fluids at the specified intervals or in
conjunction with a repair. Flushing is a
viable way to change fluid for many vehicle
sub-systems during scheduled
maintenance. It is critical that systems are
flushed only with new fluid that is the same
as that required to fill and operate the
system or using our approved flushing
chemical.
Owner Checks and Services
Make sure you perform the following basic
maintenance checks and inspections. Check Every Month
The engine oil level.
Function of all interior and the exterior lights.
The tires including the spare for wear and proper pressure. The windshield washer fluid level. Check Every Six Months
The battery connections. Clean if necessary.
The body and door drain holes for obstructions. Clean if necessary. The cooling system fluid level and the coolant system strength. The door weatherstrips for wear. Lubricate if necessary.
The hinges, latches and outside locks for proper operation. Lubricate if necessary. The parking brake for proper operation.
643
2022 F-150 (TFD) Canada/United States of America, enUSA, Edition date: 202109, First-Printing Scheduled Maintenance

Driver Training/EVOC
Replace engine oil and filter as indicated by the information
display and perform services listed in the extreme usage
scheduled maintenance chart.
As required
Inspect brake pads, rotors, calipers, hoses, and service as
required.
Inspect engine oil level.
Inspect vehicle every day
prior to starting training
Set tire pressure. Refer to driver door placard for cold tire
pressure information.
Inspect tire quality for wear.
Set wheel lug nut torque. The cold wheel lug nut torque
is 150 lb.ft (204 Nm). If wheels are torqued while they are
hot (after 15 minutes of EVOC driving), torque may be
checked to hot wheel lug nut torque of
70 lb.ft (95 Nm).
Proper functioning of safety devices (seat belts, no air bag
lights, etc.)
Front differential/axle fluid. Check front hub / bearing bolt
torque to 130 lb.ft (175 Nm).
25 hours of training use
Rear differential/axle fluid.
100 hours of training use
Change transmission and transfer case fluids.
Annually
Note: Follow base owner guide direction
for 1,000-mile vehicle break-in prior to using
vehicle for training purposes.
Note: Incorporate vehicle cool-down after
hard driving.
Note: Perform Training / EVOC service
according to the extreme usage scheduled
maintenance chart.
Note: Use police responder part numbers
for replacement parts. Engine Idle Hour Meter
Your vehicle may have an idle meter to
indicate how much time the vehicle has
been sitting in park (P) or neutral (N). The
meter is incorporated with the vehicle
odometer. Depressing the odometer-reset
button once displays the trip odometer
(miles [kilometers] following by a "T" for
trip odometer); depressing the
odometer-reset button a second time
displays the idle meter (hours following by
an "H" for hours). The idle meter only
accumulates time while the vehicle is in
park (P) or neutral (N). Displayed time is
cumulative for the vehicle and cannot be
reset to zero. Police vehicles often
650
2022 F-150 (TFD) Canada/United States of America, enUSA, Edition date: 202109, First-Printing Scheduled Maintenance

Services even if Intelematics or a Supplier
has been advised of the possibility of such
damages. You also acknowledge that the
neither Intelematics nor any Supplier
guarantees nor make any warranties that
relate to the availability, accuracy or
completeness of SUNA Products and/or
Services, and to the extent which it is
lawful to do so, both Intelematics and each
Supplier excludes any warranties which
might otherwise be implied by any State
or Federal legislation in relation to SUNA
Products and/or Services.
7. Please Note
Great care has been taken in preparing this
manual. Constant product development
may mean that some information is not
entirely up-to-date. The information in this
document is subject to change without
notice.
EMISSION LAW
WARNING: Do not remove or alter
the original equipment floor covering or
insulation between it and the metal floor
of the vehicle. The floor covering and
insulation protect occupants of the
vehicle from the engine and exhaust
system heat and noise. On vehicles with
no original equipment floor covering
insulation, do not carry passengers in a
manner that permits prolonged skin
contact with the metal floor. Failure to
follow these instructions may result in
fire or personal injury.
U.S. federal laws and certain state laws
prohibit removing or rendering inoperative
emission control system components.
Similar federal or provincial laws may
apply in Canada. We do not approve of any
vehicle modification without first
determining applicable laws. Tampering with emissions
control systems including
related sensors or the Diesel
Exhaust Fluid system can result in reduced
engine power and the illumination of the
service engine soon light.
Tampering With a Noise Control
System
Federal laws prohibit the following acts:
• Removal or rendering inoperative by
any person other than for purposes of
maintenance.
• Repair or replacement of any device or
element of the design incorporated into
a new vehicle for the purpose of noise
control prior to its sale or delivery to
the ultimate purchaser or while it is in
use.
• The use of the vehicle after any person
removes or renders inoperative any
device or element of the design.
The U.S. Environmental Protection Agency
may presume to constitute tampering as
follows:
• Removal of hood blanket, fender apron
absorbers, fender apron barriers,
underbody noise shields or acoustically
absorptive material.
• Tampering or rendering inoperative the
engine speed governor, to allow engine
speed to exceed manufacturer
specifications.
If the engine does not start, runs rough,
experiences a decrease in engine
performance, experiences excess fuel
consumption or produces excessive
exhaust smoke, check for the following:
• A plugged or disconnected air inlet
system hose.
• A plugged engine air filter element.
• Water in the fuel filter and water
separator.
714
2022 F-150 (TFD) Canada/United States of America, enUSA, Edition date: 202109, First-Printing Customer Information

Enabling Apps on an Android
Device...........................................................626
Enabling Apps on an iOS Device...........626
Enabling or Disabling Personal Profiles.........................................................628
Enabling Remote Start...............................178
End User License Agreement.................689
Engine Air Filter............................................493
Changing the Engine Air Filter...................... 493
Engine Block Heater
...................................234
Engine Block Heater Precautions................234
How Does the Engine Block Heater
Work................................................................... 235
Using the Engine Block Heater..................... 235
Engine Coolant Temperature Gauge .............................................................
169
Engine Oil Capacity and Specification - 2.7L EcoBoost™.......................................569
Engine Oil Capacity and Specification - 3.3L.................................................................570
Engine Oil Capacity and Specification - 3.5L, Hybrid Electric Vehicle
(HEV).............................................................574
Engine Oil Capacity and Specification - 3.5L Ecoboost™
........................................572
Engine Oil Capacity and Specification - 5.0L................................................................576
Engine Oil.......................................................488 Adding Engine Oil.............................................. 488
Checking the Engine Oil Level...................... 488
Engine Oil Capacity and Specification.................................................. 489
Engine Oil Dipstick Overview........................ 488
Resetting the Engine Oil Change Reminder......................................................... 488
Engine Oil Pressure Gauge.......................169
Engine Specifications - 2.7L EcoBoost™.................................................558
Engine Specifications - 3.3L....................559
Engine Specifications - 3.5L, Hybrid Electric Vehicle (HEV).............................561
Engine Specifications - 3.5L Ecoboost™................................................560
Engine Specifications - 5.0L...................562
Entering a Parallel Parking Space.........325
Entering a Perpendicular Parking Space............................................................326 Evasive Steering Assist...............................381
Evasive Steering Assist Limitations.............381
Switching Evasive Steering Assist On and
Off....................................................................... 382
What Is Evasive Steering Assist.................... 381
Event Data........................................................28
Exiting a Parking Space.............................326
Export Unique Options
...............................715
Extending the Exterior Mirrors.................163
Extending the Remote Start Duration.........................................................179
Exterior Bulbs
...............................................499
Changing a Front Fog Lamp Bulb...............505
Changing a Front Side Marker Lamp
Bulb................................................................... 504
Changing a Front Turn Signal Lamp Bulb................................................................... 503
Changing a Headlamp Bulb........................... 501
Changing a High Mounted Stoplamp Bulb.................................................................... 507
Changing a License Plate Lamp Bulb........507
Changing a Rear Lamp Bulb......................... 505
Changing a Rear Turn Signal Lamp Bulb................................................................... 506
Changing a Reversing Lamp Bulb...............507
Changing a Stoplamp Bulb........................... 506
Exterior Bulb Specification Chart................499
Removing a Rear Lamp Assembly...............501
Exterior Lamps...............................................147 Exterior Lamp Audible Warning.................... 149
Exterior Lamp Indicators................................. 149
How Do Cornering Lamps Work.................... 147
Switching the Cargo Lamps On.................... 148
Switching the Daytime Running Lamps On and Off............................................................... 147
Switching the Front Fog Lamps On and Off....................................................................... 148
Switching the Spot Lamps On and Off....................................................................... 149
Switching the Turn Signal Lamps On and Off........................................................................\
147
Exterior Lighting Control
............................145
Exterior Lighting Control - Police Responder....................................................145
Exterior Lighting
............................................145
Adaptive Front Lighting.................................... 155
Autolamps............................................................ 146
Automatic High Beam Control...................... 150
726
2022 F-150 (TFD) Canada/United States of America, enUSA, Edition date: 202109, First-Printing Index