2022 FIAT 500X jacking

5
OCCUPANT RESTRAINT SYSTEMS .................... 188 Occupant Restraint Systems ........................ 188
Important Safety Precautions....................... 188
Seat Belt Systems ......................................... 189
Supplemental Restraint Systems (SRS) ...... 195
Child Restraints ............................................ 204
SAFETY TIPS ......................................................... 214
Transporting Passengers .............................. 214Transporting Pets .......................................... 215
Safety Checks You Should Make Inside
The Vehicle ................................................... 215Periodic Safety Checks You Should Make
Outside The Vehicle ...................................... 216Exhaust Gas .................................................. 216
Carbon Monoxide Warnings ......................... 217
IN CASE OF EMERGENCY
HAZARD WARNING FLASHERS ......................... 218
JACKING AND TIRE CHANGING ........................ 218
Preparations For Jacking ............................. 218
Jack Location/Spare Tire Stowage —
If Equipped..................................................... 219
Jacking Instructions ...................................... 220
SEMI–AUTO KIT ................................................... 223
Description..................................................... 223
Inflation Procedure........................................ 224
Sealant Cartridge Replacement ................... 226 JUMP STARTING .................................................. 226
Preparations For Jump Start ........................ 227
Jump Starting Procedure .............................. 227
REFUELING IN EMERGENCY .............................. 229
IF YOUR ENGINE OVERHEATS ........................... 229
GEAR SELECTOR OVERRIDE ............................. 230
FREEING A STUCK VEHICLE .............................. 231
TOWING A DISABLED VEHICLE ........................ 232
All Wheel Drive (AWD) Models ...................... 232Tow Eye Usage — If Equipped ...................... 232
ENHANCED ACCIDENT RESPONSE SYSTEM
(EARS) .................................................................. 234
EVENT DATA RECORDER (EDR) ........................ 234
SERVICING AND MAINTENANCE
SCHEDULED MAINTENANCE.............................. 235
Maintenance Plan ......................................... 236
ENGINE COMPARTMENT .................................... 240
1.3L Turbo Engine ......................................... 240
Checking Oil Level ......................................... 241
Adding Washer Fluid ..................................... 241
Maintenance-Free Battery ........................... 241Pressure Washing ......................................... 242
VEHICLE MAINTENANCE..................................... 242
Engine Oil ...................................................... 242
Engine Oil Filter ............................................. 243Engine Air Cleaner Filter ............................... 243
Accessory Drive Belt Inspection ................... 243Air Conditioner Maintenance........................ 244
Body Lubrication ........................................... 244 Windshield Wiper Blades.............................. 245
Exhaust System ............................................ 246
Cooling System.............................................. 247
Brake System ............................................... 250
Automatic Transmission ............................... 251
FUSES ............................................................ 252
BULB REPLACEMENT .................................... 259
TIRES ..................................................................... 269
Tire Safety Information ................................. 269
Tires — General Information ......................... 276
Tire Types....................................................... 279Spare Tires — If Equipped............................. 280Wheel And Wheel Trim Care......................... 282
Snow Traction Devices ................................. 283
Tire Rotation Recommendations ................ 284
DEPARTMENT OF TRANSPORTATION
UNIFORM TIRE QUALITY GRADES .................... 285
Treadwear...................................................... 285
Traction Grades ............................................. 285Temperature Grades..................................... 285
STORING THE VEHICLE ....................................... 286
BODYWORK .......................................................... 286
Protection From Atmospheric Agents .......... 286
Body And Underbody Maintenance ............. 286
Preserving The Bodywork ............................. 286
INTERIORS ........................................................... 287
Seats And Fabric Parts ................................. 287
Plastic And Coated Parts .............................. 287
Leather Surfaces........................................... 288
Glass Surfaces ............................................. 288

22_FD_OM_EN_USC_t.book Page 5

218 (Continued)
IN CASE OF EMERGENCY
HAZARD WARNING FLASHERS
The Hazard Warning Flashers button is located on
the switch bank below the radio.
Hazard Warning Flasher Button

Push the button to turn on the Hazard Warning
Flashers. When the button is activated, all
directional turn signals will flash on and off to warn
oncoming traffic of an emergency. Push the button
a second time to turn off the Hazard Warning
Flashers.
This is an emergency warning system and it should
not be used when the vehicle is in motion. Use only
when your vehicle is disabled and is creating a
safety hazard warning for other motorists. When you must leave the vehicle to seek
assistance, the Hazard Warning Flashers will
continue to operate even though the ignition is
placed in OFF mode.
NOTE:With extended use the Hazard Warning Flashers
may wear down your battery.
JACKING AND TIRE CHANGING
PREPARATIONS FOR JACKING

1. Park on a firm, level surface. Avoid ice or
slippery areas.

2. Turn on the Hazard Warning Flashers.
3. Apply the Electric Park Brake.
WARNING!
Do not attempt to change a tire on the side of
the vehicle close to moving traffic. Pull far
enough off the road to avoid the danger of
being hit when operating the jack or changing
the wheel.
Being under a jacked-up vehicle is dangerous.
The vehicle could slip off the jack and fall on
you. You could be crushed. Never put any part
of your body under a vehicle that is on a jack.
If you need to get under a raised vehicle, take
it to a service center where it can be raised on
a lift.
Never start or run the engine while the vehicle
is on a jack.
The jack is designed to be used as a tool for
changing tires only. The jack should not be
used to lift the vehicle for service purposes.
The vehicle should be jacked on a firm level
surface only. Avoid ice or slippery areas.
WARNING!
Do not attempt to change a tire on the side of
the vehicle close to moving traffic. Pull far
enough off the road to avoid being hit when
operating the jack or changing the wheel.
WARNING!

22_FD_OM_EN_USC_t.book Page 218

IN CASE OF EMERGENCY219
4. Place the gear selector into PARK (P).
5. Turn the ignition to STOP mode.
6. Block both the front and rear wheel diagonally opposite of each jacking position. For example,
if the driver’s front wheel is being changed,
block the passenger’s rear wheel.

Wheels Chocked

NOTE:Passengers should not remain in the vehicle when
the vehicle is being raised or lifted.
JACK LOCATION/SPARE TIRE
S
TOWAGE — IF EQUIPPED
The jack and tools are located in the rear storage
compartment, under the load floor.

Jack And Tools Location

1. Open the liftgate.

2. Lift the access cover using the load floor handle.
Load Floor Handle

3. Remove the fastener securing the spare tire.

Spare Tire Fastener

7

22_FD_OM_EN_USC_t.book Page 219

220IN CASE OF EMERGENCY
(Continued)
4. Remove the jack, wheel bolt wrench, and
wheel chocks (if equipped).

Jack And Tools

5. Remove the spare tire.
JACKING INSTRUCTIONS

Jack Warning Label

1 — Wheel Bolt Wrench
2 — Jack
3 — Emergency Funnel
4 — Wheel Chock (If Equipped)
5 — Screwdriver
6 — Emergency Allen Key
WARNING!
A loose tire or jack thrown forward in a collision
or hard stop could endanger the occupants of
the vehicle. Always stow the jack parts and the
spare tire in the places provided. Have the
deflated (flat) tire repaired or replaced
immediately.
WARNING!
Carefully follow these tire changing warnings to
help prevent personal injury or damage to your
vehicle:
Always park on a firm, level surface as far from
the edge of the roadway as possible before
raising the vehicle.
Turn on the Hazard Warning Flashers.
Apply the parking brake and place an auto
-
matic transmission in PARK.
Block the wheel diagonally opposite of the
wheel to be raised.
Never start or run the engine with the vehicle
on a jack.
Do not let anyone sit in the vehicle when it is
on a jack.
Do not get under the vehicle when it is on a
jack. If you need to get under a raised vehicle,
take it to a service center where it can be
raised on a lift.
Only use the jack in the positions indicated
and for lifting this vehicle during a tire change.
If working on or near a roadway, be extremely
careful of motor traffic.
To assure that spare tires, flat or inflated, are
securely stowed, spares must be stowed with
the valve stem facing the ground.
WARNING!

22_FD_OM_EN_USC_t.book Page 220

IN CASE OF EMERGENCY221

1. Remove the spare tire, jack, and wheel bolt wrench.

2. If equipped with wheels where the center cap covers the wheel bolts, use the wheel bolt
wrench to pry the center cap off carefully
before raising the vehicle.
3. Before raising the vehicle, use the wheel bolt wrench to loosen, but not remove, the wheel
bolts on the wheel with the flat tire. Turn the
wheel bolts counterclockwise one turn while
the wheel is still on the ground.

Loosen The Wheel Bolt

NOTE:Placement for the front and rear jacking locations
are critical. See below images for proper jacking
locations.
Front And Rear Jacking Locations

4. Place the jack underneath the lift area that is closest to the flat tire. Turn the jack screw
clockwise to firmly engage the jack saddle with
the lift area of the sill flange, centering the jack
saddle inside the cutout in the sill cladding.
Front Lifting Point
Front Jacking Location
CAUTION!
Do not attempt to raise the vehicle by jacking on
locations other than those indicated in the
Jacking Instructions for this vehicle.
7

22_FD_OM_EN_USC_t.book Page 221

222IN CASE OF EMERGENCY

Rear Lifting Point
Rear Jacking Location

5. Raise the vehicle just enough to remove the flat tire. 6. Remove the wheel bolts and tire.
7. Mount the spare tire.

Mounting Spare Tire

NOTE:For vehicles so equipped, do not attempt to install
a center cap or wheel cover on the compact spare
Úpage 280.
8. Install the wheel bolts with the threaded end of the wheel bolt toward the wheel. Lightly tighten
the wheel bolts.
9. Lower the vehicle to the ground by turning the wheel bolt wrench counterclockwise.
10. Finish tightening the wheel bolts. Push down on the wrench while at the end of the handle
for increased leverage. Tighten the wheel bolts
in a star pattern until each wheel bolt has been
tightened twice Ú page 289.
11. Securely stow the jack, tools, chocks and flat tire.
12. After 25 miles (40 km) check the wheel bolt to ensure that all wheel bolts are properly seated
against the wheel. If in doubt about the correct
tightness, have them checked with a torque
wrench by an authorized dealer or at a service
station.WARNING!
Raising the vehicle higher than necessary can
make the vehicle less stable. It could slip off the
jack and hurt someone near it. Raise the vehicle
only enough to remove the tire.
CAUTION!
Be sure to mount the spare tire with the valve
stem facing outward. The vehicle could be
damaged if the spare tire is mounted incorrectly.
WARNING!
To avoid the risk of forcing the vehicle off the
jack, do not fully tighten the wheel bolts until the
vehicle has been lowered. Failure to follow this
warning may result in serious injury.

22_FD_OM_EN_USC_t.book Page 222

301
Disposal Antifreeze (Engine Coolant)
....................... 249Disturb........................................................... 159Door Ajar.......................................................... 71Door Ajar Light................................................. 71Door LocksAutomatic.................................................... 24Remote Keyless Entry................................. 22Drag & Drop................................................... 140Driver Memory Presets.................................. 147Driver’s Seat Back Tilt..................................... 26DrivingThrough Flowing, Rising, Or Shallow Standing Water
..................................... 120
E
Electric Brake Control System....................... 175Anti-Lock Brake System............................. 174Traction Control System............................ 178Electric Park Brake.......................................... 82Electric Parking Brake..................................... 82Electrical Outlet, Auxiliary (Power Outlet)......... 52Electrical Power Outlets................................... 52Electronic Stability Control (ESC)...................176Electronic Throttle Control Warning Light........ 71Emergency Refueling..................................... 229Emergency, In Case OfHazard Warning Flasher............................ 218Jacking...................................................... 218Jump Starting............................................ 226
Overheating.............................................. 229Towing...................................................... 232Emission Control System Maintenance........... 78Engine........................................................... 240Air Cleaner................................................ 243Break-In Recommendations........................ 82Checking Oil Level.................................... 241Compartment........................................... 240Coolant (Antifreeze).................................. 293Cooling..................................................... 247Exhaust Gas Caution....................... 216, 217Fails To Start............................................... 81Flooded, Starting......................................... 81Jump Starting........................................... 226Oil........................................... 242, 292, 293Oil Filler Cap............................................. 240Oil Filter.................................................... 243Oil Selection.................................... 242, 292Overheating.............................................. 229Starting........................................................ 80Enhanced Accident Response
Feature................................................ 201, 234Ethanol......................................................... 291Exhaust Gas Cautions.......................... 216, 217Exhaust System................................... 216, 246Exterior Lighting............................................... 36Exterior Lights.........................................36, 216
F
FiltersAir Cleaner
................................................ 243Air Conditioning................................. 49, 244Engine Oil........................................ 243, 293Engine Oil Disposal................................... 243FlashersHazard Warning........................................ 218Turn Signals................................ 38, 77, 216Flash-To-Pass...................................................37Flooded Engine Starting...................................81Floor Console...................................................51Fluid Capacities............................................ 292Fluid Leaks.................................................... 216Fluid Level ChecksEngine Oil................................................. 241Fluid, Brake................................................... 293Fog Lights........................................................38Folding Rear Seats...........................................26Freeing A Stuck Vehicle................................. 231Front And Rear Park Assist System............... 102Fuel............................................................... 290Adding...................................................... 111Additives................................................... 290Clean Air................................................... 290Ethanol..................................................... 291Gasoline................................................... 29011

22_FD_OM_EN_USC_t.book Page 301

302 Gauge
.......................................................... 73Materials Added........................................ 290Methanol................................................... 291Octane Rating................................. 290, 293Specifications............................................ 293Tank Capacity............................................ 292Full Brake Control System............................. 182Fuses............................................................. 252
G
Gasoline, (Fuel)............................................. 290Gasoline, Clean Air........................................ 290Gasoline, Reformulated................................. 290GaugesFuel............................................................. 73Gear Selector Override.................................. 230Glass Cleaning............................................... 288Gross Axle Weight Rating............................... 113GVWR............................................................ 112
H
HazardDriving Through Flowing, Rising, Or Shallow Standing Water
........................ 120Hazard Warning Flashers.............................. 218Head Restraints............................................... 30HeadlightsAutomatic.................................................... 37Cleaning.................................................... 286Delay........................................................... 37
High Beam/Low Beam Select Switch.......... 36Lights On Reminder..................................... 37Passing........................................................ 37Switch.......................................................... 36Time Delay................................................... 37Heated Mirrors................................................. 35Heated Seats................................................... 29High Beam/Low Beam Select (Dimmer)
Switch.............................................................. 36Hill Start Assist.............................................. 177HitchesTrailer Towing........................................... 115Holder, Coin..................................................... 51Hood Prop........................................................ 58Hood Release.................................................. 58
I
Ignition............................................................. 17Switch.......................................................... 17Inside Rearview Mirror..................................... 33Instrument Cluster........................................... 63Display......................................................... 64Instrument Panel Lens Cleaning................... 288Interior Appearance Care.............................. 287Interior Lights................................................... 38Intermittent Wipers (Delay Wipers).................. 40iPod/USB/MP3 Control.................................... 51
J
Jack Location................................................ 219Jack Operation.............................................. 220Jacking Instructions...................................... 220Jump Starting................................................ 226
K
Key FobArm The Alarm
.............................................21Disarm The Alarm........................................21Keyless Entry...............................................23Remote Keyless Entry..................................14Key Fob Battery Service (Remote Keyless
Entry)...............................................................15Keyless Enter 'n Go™Enter The Trunk...........................................23Lock The Vehicle’s Doors................... 23, 132Passive Entry...............................................23Passive Entry Programming.........................23Remote Control............................................23Unlock From The Driver’s Side.....................23Unlock From The Passenger’s Side.............23Keyless Entry...................................................14Keys.................................................................14Replacement...............................................16
L
Lane Change And Turn Signals........................38Lane Change Assist..........................................38LaneSense.................................................... 108

22_FD_OM_EN_USC_t.book Page 302