2021 VOLVO XC40 RECHARGE Timing

10
SERVICE AND MAINTENANCE
Maintenance Service Operations
Non-hybrid models only
Service operationSchedule of services
All Non-hybrid
Models miles x 1000
1020 30 40 5060 7080 90100 110120 130 140 150
km x 1000 1632 48 6480 96112 128 144160 176192208 224240
Engine
Engine oil and filter, replace XXXXXXXXXXXXXXX
Engine/Transmission/Timing gear check for
leaks
AX XXXXXX
Service Reminder Indicator (SRI), reset XXXXXXXXXXXXXXX
Fuel lines and fuel filter, check for leakage
and damage X
XX
Engine Air cleaner (ACL), clean the air
cleaner housing/replace filter
B. X
XX
Spark plugs, replace XX
Engine coolant check & adjust antifreeze
rating & anti-corrosion agent X
XXXXXXXXXXXXXX
Accessory drive belt, belt tensioner & idler
pulley, replace
CX
Timing belt tensioner & idler pulley, replace
CX
Steering, Front and Rear Suspension
Power steering fluid level, check/adjust XXXXXXXXXXXXXXX

14
SERVICE AND MAINTENANCE
Hybrid models only
Service operationSchedule of services
Hybrid Models miles x 10001020 30 40 5060 7080 90100 110120 130 140 150
km x 1000 1632 48 6480 96112 128 144160 176192208 224240
Engine
Engine oil and filter, replace XXXXXXXXXXXXXXX
Engine/Transmission/Timing gear check for
leaks
AX XXXXXX
Service Reminder Indicator (SRI), reset XXXXXXXXXXXXXXX
Fuel lines and fuel filter, check for leakage
and damage X
XX
Engine Air cleaner (ACL), clean the air
cleaner housing/replace filter
B. X
XX
Spark plugs, replace XX
Engine coolant check & adjust antifreeze
rating & anti-corrosion agent X
XXXXXXXXXXXXXX
Accessory drive belt, belt tensioner & idler
pulley, replace
CX
Timing belt tensioner & idler pulley, replace
CX
Steering, Front and Rear Suspension
Power steering fluid level, check/adjust XXXXXXXXXXXXXXX

43
WARRANTY
bringing vehicle to any authorized Volvo retailer.
To the extent required by any federal, state, or
provincial law, whether statutory or common
law, a vehicle manufacturer shall be required
to provide a means for non-franchised repair
facilities to perform Emission Performance
Warranty repairs.
However, to avoid delay and ensure proper
service, it is recommended that service under this
warranty be performed by an authorized Volvo
retailer.
When determining whether an owner has
complied with the written instructions for proper
maintenance and use, Volvo may require an
owner to submit evidence of compliance if it has
an objective reason for believing:
1. maintenance was not performed and,
2. that if not performed, it could be the cause
of the vehicle exceeding applicable emission
standards.
Failure to notify the owner of a decision to honor
or deny an Emission Performance Warranty claim
within thirty (30) days from the time the vehicle
is presented for repair shall result in the vehicle
manufacturer being responsible for repairing
the vehicle without charge to the vehicle owner,
unless such failure is attributable to the vehicle
owner or to events which are beyond the control
of the vehicle manufacturer or repair facility.
2021 Emission Warranty Parts List –
Federal – U.S. and Canada
The following are some items covered by the
Emssion Warranty for (2) years or 24,000
miles/40,000 kilometers, whichever occurs
first. Volvo has continued coverage on these
items under the new car warranty for (4) years
or 50,000 miles/80,000 kilometers, whichever
occurs first. Components marked with “*” are
covered by the Long-Term Warranty for eight
(8) years or 80,000 miles/130,000 kilometers,
whichever occurs first. Components marked with
“**” are covered for eight (8) years or 100,000
miles/160,000 kilometers, whichever occurs first.
• Ambient Air Temp Sensor
• Camshaft Position Sensor
• Catalytic Converter*
• Charge Air Cooler
• Coolant Temperature Sensor
• Coolant Thermostat
• Crankshaft Positon Sensor
• CVVT Solenoid Valve (Exhaust/Intake)
• CVVT Timing Device (Exhaust/Intake)
• Electronic Throttle Module (ETM)
• Engine Control Module (ECM) Hardware*
• Engine Control Module (ECM) Software
• Engine Cooling Fan
• EVAP Carbon Canister
• EVAP Leakage Control Module (ECLM)
• Filler Pipe
• Filler Pipe (Capless Unit)
• Fuel High-Pressure Sensor
• Fuel Injector
• Fuel Low-Pressure Sensor
• Fuel Pump
• Fuel Pump ElectronIC/H Module (PEM)
• Fuel Rail
• Fuel Tank
• Fuel Tank Isolation Valve
• Heated Oxygen Sensor(s)
• High-Pressure Fuel Pump
• Ignition Coil
• Knock Sensor
• Manifold Absolute Pressure (MAP) Sensor
• Mass Air Flow (MAF) Sensor
• Oil Separator with Crankcase Pressure
Regulator
• On-Board Diagnostic System (OBD)*
• Purge Valve
• Purge Valve Assembly incl. Purge Valve
• Spark Plug (Kit)
• Supercharger
• Supercharger Bypass Valve
• Supercharger Pressure Sensor
• Temp & Manifold Air Pressure Sensor (TMAP)
• Transmission Control Module (TCM)
Hardware
* Covered by the Long-Term Defect and Performance Warranty for eight (8) years or 80,000 miles/130,000 kilometers, whichever occurs first.

52
WARRANTY
2021 Model Year Emission Parts List
Non-hybrid models onlyCalifornia, Connecticut, Delaware, Maine,
Massachusetts, Maryland, New Jersey, New York,
Oregon, Pennsylvania, Rhode Island, Vermont and
Washington The components listed in the chart below apply
to non-hybrid models and are covered by the
Long-Term Defect and Performance Warranty
for seven (7) years or 70,000 miles, whichever
occurs first.

ENGINE VIN CODE NUMBER
A2 1016AC
Catalytic Converter
AX XXX
Charge Air Cooler XXXX
CVVT Timing Device (Exhaust) XXXX
CVVT Timing Device (Inlet) XXXX
Electronic Throttle Module (ETM) XXXX
Engine Control Module (ECM)
AX XXX
Fuel Pump XXXX
Fuel Tank Assembly XXXX
High-Pressure Fuel Pump XXXX
Supercharger X
Supercharger Bypass Valve X
Transmission Control Module XXXX
Turbocharger XXXX
A The Engine Control Module and Catalytic Converter are also covered by the 8-year or 80,000-mile Long-Term Emissions Warranty. Please see the list in the article “2021 Emission Warranty Parts List –
Federal – U.S. and Canada” in this booklet.

53
WARRANTY
2021 Model Year Emission Parts List
Hybrid models onlyHybrid models only purchased and registered in
Delaware, Pennsylvania and Washington. The
components listed in the chart below apply to
Hybrid models and are covered by the Long-Term
Defect and Performance Warranty for seven (7)
years or 70,000 miles, whichever occurs first.
ENGINE VIN CODE NUMBER
BK BR
AC Compressor (Electrical) XX
Active Brake Booster XX
Battery Coolant Pump XX
Battery Energy Control Module HW (BECM) XX
Brake Control Module (BCM2) XX
Catalytic Converter* XX
Charge Air Cooler XX
Combined Inverter DC/DC (CIDD) XX
Condenser XX
Cooling Fan (Hybrid) XX
CVVT Timing Device (Exhaust/Intake) XX
Electric Drive Coolant Pump XX
Electric Oil Pump (EOP) XX
Electric Oil Pump Control Module XX
Electric Rear Axle Drive (ERAD)* XX