19Your Warranties in Detail
WARRANTY
Exhaust Gas Recirculation
(EGR) System
• EGR gas temperature sensor
• EGR valve
• Associated parts
Ignition System
• Ignition coil and ignitor
• Ignition wires
• Spark plugs*
Positive Crankcase Ventilation
(PCV) System
• Oil filler cap
• PCV valve or orifice
Other Parts Used in
Above Systems
• Data link connector (8/80)
• Hoses, clamps, fittings, tubing and
mounting hardware
• Malfunction indicator light and bulb (8/80)
• Pulleys, belts and idlers
• Sealing gaskets and devices
• Sensors, solenoids, switches and valves
MAINTENANCE
You are responsible for performance
of the required maintenance indicated
in the Owner’s Manual and this booklet.
Toyota will not deny a warranty claim
solely because you do not have records
to show that you maintained your vehicle.
However, any failure or noncompliance
caused by lack of maintenance is not
covered by this warranty.
When maintenance and repairs are
paid for by you, these services may be
performed by you or by any automotive
service provider you choose. Toyota
will not deny a warranty claim solely
because you used a service provider
other than a Toyota dealership for
maintenance and repairs . However,
any failure or noncompliance caused by
improper maintenance or repairs is not
covered by this warranty.
FEDERAL EMISSION CONTROL WARRANTY
* Warranted until first required maintenance under terms of the California Emission Control Warranty.
8/80 = Covered for eight years or 80,000 miles, whichever occurs first.
126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 19126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 197/7/20 7:26 AM7/7/20 7:26 AM
25Your Warranties in Detail
WARRANTY
WHAT IS NOT COVERED
These warranty obligations do not apply
to failures or noncompliance caused by:
• The use of replacement parts not
certified in accordance with aftermarket
parts certification regulations.
• The use of replacement parts not
equivalent in quality or design to
original equipment parts.
Provisions under the “What Is Not Covered”
section of the New Vehicle Limited Warranty
also apply to this warranty.
PARTS LIST:
LONG-TERM EMISSION
DEFECT WARRANTY
The parts listed here are covered for seven
years or 70,000 miles from the vehicle’s
in-service date, whichever occurs first.
Air Induction/Exhaust System
• Cam timing control motor
• Intake manifold
• Throttle body
Catalyst System
• Exhaust front pipe (including
catalytic converter)
•
Exhaust manifold (including
manifold converter)
EGR System
• EGR cooler
Evaporative Control System
• Charcoal canister
• Fuel sub tank
• Fuel tank
Fuel Control System
•
Engine control computer
(engine control module)
• Fuel delivery pipe
• Fuel pressure sensor
• High-pressure fuel pump
Ignition System
• Knock sensor
Other Parts Used in
Systems Listed
• Transmission oil pump in front oil
pump and solenoid cover assembly
equipped with Stop and Start
Engine System (S&S)
• Transmission solenoid
• Transmission valve body
• Wire transmission
(including temperature sensor)
CALIFORNIA EMISSION CONTROL WARRANTY
126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 25126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 257/7/20 7:26 AM7/7/20 7:26 AM
38Maintenance Log
MAINTENANCE LOG
MAINTENANCE
5,000 miles or 6 months
■
Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ���
■ ������� ��� ������ ��� ����� �������
■������� ����� ������
■������ �����
■
�������� ������� ����� �������������
��� ����� ����������
Additional Maintenance Items for
Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect ball joints and dust covers
■������� ����� ����� �����
■������� ������ ��� ������
■������� �������� ������� ��� �����
■������� ������ ��� ��� ��� �������
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Driving while towing, using a car-top
carrier, or heavy vehicle loading:
6
■ Replace engine oil and oil filter2
■�
�������� ��������� ����� ���� ������
■
������� ���� ��� ����� �� �������
��� ����
Repeated trips of less than five miles in
temperatures below 32°F / 0°C:
■Replace engine oil and oil filter2
Extensive idling and/or low speed driving
for a long distance such as police, taxi
or door-to-door delivery use:
■Replace engine oil and oil filter2
10,000 miles or 12 months
■ Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ���
■������� ��� ������ ��� ����� �������
■������� ����� ������
■������� ������ ��� ��� ��� �������
■������ �����
■ �������� ������� ����� �������������
��� ����� ����������
Additional Maintenance Items for
Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect ball joints and dust covers
■������� ����� ����� �����
■������� ������ ��� ������
■������� �������� ������� ��� �����
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Driving while towing, using a car-top
carrier, or heavy vehicle loading:
6
■Re-torque propeller shaft bolt (4WD)4
■ ������� ���� ��� ����� �� �������
��� ����
Dealer Service verification:
D
ate:
Mileage:
D
ealer Service verification:
D
ate:
Mileage:
126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 38126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 387/7/20 7:26 AM7/7/20 7:26 AM
39Maintenance Log
MAINTENANCE LOG
MAINTENANCE
15,000 miles or 18 months
■
Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ��� ■������� ��� ������ ��� ����� �������
NOTE: If 0W-16 oil WAS NOT used at the last oil change, replace engine oil and oil filter.2
Inspect the following:
_
Ball joints and dust covers _
Radiator and condenser
_
Brake lines and hoses _
Rear differential oil (4WD)
_
Cabin air filter _
Steering gear
_
Drive shaft boots _
Steering linkage and boots
_
Engine coolant
5 _
Transfer case oil (4WD)
_
Exhaust pipes and mountings
Additional Maintenance Items for Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect engine air filter ■������� ������ ��� ��� ��� �������
■������� ���� ��� ����� �� ������� ��� ����
Driving while towing, using a car-top carrier, or heavy vehicle loading:6
■Replace engine oil and oil filter2
■������� ���� ������������ ��� ����� ■������� �������� ���� ��� ����� ■������� ���� ��� ����� �� ������� ��� ����
Repeated trips of less than five miles in temperatures below 32°F / 0°C:
■Replace engine oil and oil filter2
Extensive idling and/or low speed driving for a long distance such as police, taxi or
door-to-door delivery use:
■Replace engine oil and oil filter2
1
Inspect sealed transmissions, transfer cases and differentials for signs of leakage. If any leakage from a sealed
component is suspected, it is recommended that you have the sealed component inspected by a Toyota dealer. Inspect
power steering fluid (if equipped) and brake fluid level/condition. Inspect engine and inverter (if equipped) coolant
level/condition/freezing point. Your dealer may recommend services (Dealer-Recommended Maintenance) based on
inspection results.
2 Reset the oil replacement reminder light (“MAINT REQD”) or the message “OIL MAINTENANCE REQUIRED” on the
multi-information display after maintenance at every 5,000 miles.
3 Perform these service items only if you drive primarily under the conditions indicated. 4 Includes operating on roads which road salt has been applied.5
Refer to “Engine Coolant” in the “Explanation of Maintenance Items” section in the back of this guide for more information.6 Not all vehicles are designed for towing. Refer to your Vehicle Owner’s Manual for details.
Dealer Service verification:
D
ate:
Mileage: ■
������� ����� ������ ■��������� ��������� ����� ���� ����� ■������ ����� ■
�������� ������� ����� �������������
��� ����� ����������
NOTE:
Driving in heavy traffic, on dirt roads or in urban, dusty or desert areas may shorten
the life of the cabin air filter. Replacement may be needed if you notice reduced airflow
from the air conditioner and heater or if the windows fog easily when you use the “Fresh”
mode. Consult your dealer if any of these conditions occur.
126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 39126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 397/7/20 7:47 AM7/7/20 7:47 AM
40Maintenance Log
MAINTENANCE LOG
MAINTENANCE
20,000 miles or 24 months
■
Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ���
■������� ��� ������ ��� ����� �������
■������� ����� ������
■������� ������ ��� ��� ��� �������
■������ �����
■ �������� ������� ����� �������������
��� ����� ����������
Additional Maintenance Items for
Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect ball joints and dust covers
■������� ����� ����� �����
■������� ������ ��� ������
■������� �������� ������� ��� �����
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Driving while towing, using a car-top
carrier, or heavy vehicle loading:
7
■Re-torque propeller shaft bolt (4WD)4
■ ������� ���� ��� ����� �� �������
��� ����
25,000 miles or 30 months
■ Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ���
■������� ��� ������ ��� ����� �������
■������� ����� ������
■������ �����
■ �������� ������� ����� �������������
��� ����� ����������
NOTE: If 0W-16 oil WAS NOT used at
the last oil change, replace engine oil
and oil filter.
2
Additional Maintenance Items for
Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect ball joints and dust covers
■������� ����� ����� �����
■������� ������ ��� ������
■������� �������� ������� ��� �����
■������� ������ ��� ��� ��� �������
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Driving while towing, using a car-top
carrier, or heavy vehicle loading:
7
■Replace engine oil and oil filter2
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Repeated trips of less than five miles in
temperatures below 32°F / 0°C:
■Replace engine oil and oil filter2
Extensive idling and/or low speed driving
for a long distance such as police, taxi
or door-to-door delivery use:
■Replace engine oil and oil filter2
Dealer Service verification:
D
ate:
Mileage:
D
ealer Service verification:
D
ate:
Mileage:
126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 40126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 407/7/20 7:26 AM7/7/20 7:26 AM
42Maintenance Log
MAINTENANCE LOG
MAINTENANCE
Dealer Service verification:
D
ate:
Mileage:
D
ealer Service verification:
D
ate:
Mileage:
35,000 miles or 42 months
■
Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ���
■ ������� ��� ������ ��� ����� �������
■������� ����� ������
■������ �����
■
�������� ������� ����� �������������
��� ����� ����������
NOTE: If 0W-16 oil WAS NOT used at
the last oil change, replace engine oil
and oil filter.
2
Additional Maintenance Items for
Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect ball joints and dust covers
■������� ����� ����� �����
■������� ������ ��� ������
■������� �������� ������� ��� �����
■������� ������ ��� ��� ��� �������
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Driving while towing, using a car-top
carrier, or heavy vehicle loading:
6
■ Replace engine oil and oil filter2
■�
�������� ��������� ����� ���� ������
■
������� ���� ��� ����� �� �������
��� ����
Repeated trips of less than five miles in
temperatures below 32°F / 0°C:
■Replace engine oil and oil filter2
Extensive idling and/or low speed driving
for a long distance such as police, taxi
or door-to-door delivery use:
■Replace engine oil and oil filter2
40,000 miles or 48 months
■ Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ���
■������� ��� ������ ��� ����� �������
■������� ����� ������
■������� ������ ��� ��� ��� �������
■������ �����
■ �������� ������� ����� �������������
��� ����� ����������
Additional Maintenance Items for
Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect ball joints and dust covers
■������� ����� ����� �����
■������� ������ ��� ������
■������� �������� ������� ��� �����
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Driving while towing, using a car-top
carrier, or heavy vehicle loading:
6
■Re-torque propeller shaft bolt (4WD)4
■ ������� ���� ��� ����� �� �������
��� ����
126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 42126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 427/7/20 7:26 AM7/7/20 7:26 AM
43Maintenance Log
MAINTENANCE LOG
MAINTENANCE
1 Inspect sealed transmissions, transfer cases and differentials for signs of leakage. If any leakage from a sealed
component is suspected, it is recommended that you have the sealed component inspected by a Toyota dealer. Inspect
power steering fluid (if equipped) and brake fluid level/condition. Inspect engine and inverter (if equipped) coolant
level/condition/freezing point. Your dealer may recommend services (Dealer-Recommended Maintenance) based on
inspection results.
2 Reset the oil replacement reminder light (“MAINT REQD”) or the message “OIL MAINTENANCE REQUIRED” on the
multi-information display after maintenance at every 5,000 miles.
3 Perform these service items only if you drive primarily under the conditions indicated. 4 Includes operating on roads which road salt has been applied.5
Refer to “Engine Coolant” in the “Explanation of Maintenance Items” section in the back of this guide for more information.6 Not all vehicles are designed for towing. Refer to your Vehicle Owner’s Manual for details.
Dealer Service verification:
D
ate:
Mileage:
45,000 miles or 18 months
■
Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ��� ■������� ��� ������ ��� ����� �������
NOTE: If 0W-16 oil WAS NOT used at the last oil change, replace engine oil and oil filter.2
Inspect the following:
_
Ball joints and dust covers _
Radiator and condenser
_
Brake lines and hoses _
Rear differential oil (4WD)
_
Cabin air filter _
Steering gear
_
Drive shaft boots _
Steering linkage and boots
_
Engine coolant
5 _ Transfer case oil (4WD)
_
Exhaust pipes and mountings
Additional Maintenance Items for Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect engine air filter ■������� ������ ��� ��� ��� �������
■������� ���� ��� ����� �� ������� ��� ����
Driving while towing, using a car-top carrier, or heavy vehicle loading:6
■Replace engine oil and oil filter2
■������� ���� ������������ ��� ����� ■������� �������� ���� ��� ����� ■������� ���� ��� ����� �� ������� ��� ����
Repeated trips of less than five miles in temperatures below 32°F / 0°C:
■Replace engine oil and oil filter2
Extensive idling and/or low speed driving for a long distance such as police, taxi or
door-to-door delivery use:
■Replace engine oil and oil filter2
■������� ����� ������ ■��������� ��������� ����� ���� ����� ■������ ����� ■ �������� ������� ����� �������������
��� ����� ����������
NOTE: Driving in heavy traffic, on dirt roads or in urban, dusty or desert areas may shorten
the life of the cabin air filter. Replacement may be needed if you notice reduced airflow
from the air conditioner and heater or if the windows fog easily when you use the “Fresh”
mode. Consult your dealer if any of these conditions occur.
126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 43126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 437/7/20 7:47 AM7/7/20 7:47 AM
44Maintenance Log
MAINTENANCE LOG
MAINTENANCE
50,000 miles or 60 months
■
Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ���
■������� ��� ������ ��� ����� �������
■������� ����� ������
■������� ������ ��� ��� ��� �������
■������ �����
■ �������� ������� ����� �������������
��� ����� ����������
Additional Maintenance Items for
Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect ball joints and dust covers
■������� ����� ����� �����
■������� ������ ��� ������
■������� �������� ������� ��� �����
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Driving while towing, using a car-top
carrier, or heavy vehicle loading:
8
■Re-torque propeller shaft bolt (4WD)4
■ ������� ���� ��� ����� �� �������
��� ����
55,000 miles or 66 months
■ Add Toyota EFI Tank Additive or equivalent
(Hawaii, Puerto Rico, Saipan and
American Samoa only)
■����� ������������ �� �������� ����� ���
■������� ��� ������ ��� ����� �������
■������� ����� ������
■������ �����
■ �������� ������� ����� �������������
��� ����� ����������
NOTE: If 0W-16 oil WAS NOT used at
the last oil change, replace engine oil
and oil filter.
2
Additional Maintenance Items for
Special Operating Conditions3
Driving on dirt roads or dusty roads: ■Inspect ball joints and dust covers
■������� ����� ����� �����
■������� ������ ��� ������
■������� �������� ������� ��� �����
■������� ������ ��� ��� ��� �������
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Driving while towing, using a car-top
carrier, or heavy vehicle loading:
8
■������� ������ ��� ��� ��� �������
■��������� ��������� ����� ���� ������
■ ������� ���� ��� ����� �� �������
��� ����
Repeated trips of less than five miles in
temperatures below 32°F / 0°C:
■Replace engine oil and oil filter2
Extensive idling and/or low speed driving
for a long distance such as police, taxi
or door-to-door delivery use:
■Replace engine oil and oil filter2
Dealer Service verification:
D
ate:
Mileage:
D
ealer Service verification:
D
ate:
Mileage:
126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 44126981_19-TCS-14207 MY21 WMG RAV4 GUTS 2_R1.indd 447/7/20 7:26 AM7/7/20 7:26 AM