2020 MERCEDES-BENZ SPRINTER lock

Jac
ksuppor tpoint, rear axle (vehicles 5. 0t) #
Place thej ackb eneat hthe jac ksupport
point. #
Vehicles with all-wheel drive: turnjack
spindle 2counter-clockwise as farasitw ill
go. #
Raise thev ehicle until thet ireisr aised amax‐
imum of 1.2in(3c m) offthe ground. #
Loosen and remo vethew heel (/ page237). Re
moving awheel Re
quirements:
R The vehicle is raised (/ page235).
When changing awheel, avoid applying any
fo rc etot he brak ediscs since this could
impair thel eve lofc omfort when braking.
* NO
TEDama getothre adin gfromd irton
wheel bolts #
Do no tplace wheel bolt sinsandorona
dirty sur face. #
Unscr ewthew heel bolts or nuts wit hthe
whee lnut wrench. #
On front wheels wit hwheel nuts, remo vethe
wheel nut co ver. #
Remo vethew heel. Installing
anew wheel Re
quirements:
R The wheel is remo ved( /pag e237). &
WARNING Risk of accident from losing a
wheel
Oiled, greased or damaged wheel bolt/wheel
nut thre ads or wheel hub/wheel mounting
bolt thre ads can cause thew heel bolts/wheel
nuts tocome loose.
As aresult, youc oul dlose awheel while driv‐
ing. #
Nevero il or grease thet hreads. #
Inthee vent of damag etothethre ads,
con tact aq ualified specialis tworks hop
immediatel y. #
Have thed amaged wheel bolts or dam‐
aged hub thre ads replaced. #
Do no tcontinue driving. &
WARNING Risk of inju ryfrom tightening
whee lbolts and nuts
If yo ut ighten thew heel bolts or wheel nuts
when thev ehicle is raised, thej ackc ould tip. #
Onlytighten wheel bolts or wheel nuts
when thev ehicle is on theg round. #
Obser vethen otes on thec hoice of tires
(/ page231). #
Fors afet yr easons, onl yuse wheel bolt sor
wheel nut swhichh aveb een appr ovedby
Mercedes-Benza ndfort he wheel in question.
When youi nstallth es teel spar ewheel, it is
essential youu se shor twheel bolt sfor as teel
wheel. Using other wheel bolts when ins talling
th es teel spar ewheel ma ylead todamag etothe
brak esystem. Wheels and tires
237

#
Tighten thew heel bolts or nuts evenlyint he
sequence indicated (1 to6 ).
Specified tightenin gtorque:
R Steel wheel bolts: 177l b-f t(24 0N m)
R Whee lnuts: 133lb-f t(18 0N m)
R Alloywheel bolts: 133lb-f t(18 0N m) #
Push thep isto nont hehydraulic jac kinagain
and close thep ressur erelease scr ew. #
Vehicles with all-wheel drive: turnthe jack
spindle clockwise as farasitw illg o.
% Yo
uc an no winstallth eh ub caps on steel
wheels wit hwheel bolts. The ins tallation pro‐
cedur edepends on whe ther theh ub cap acts
as atrimt hat co vers thew hole wheel, or just
co vers thec enter. #
Wheel with hub cap: positiontheo pening
fo rt he tir evalveint he hub cap overthe tire
va lve. #
Push thee dgeoft he hub cap ont othe wheel
ri mw ithb othh ands until it engages into
place. Mak esuret he hub cap retaining
cat ches engag eonthesteel wheel. #
Wheel with central hub cap: positionthe
re tainin glugs of thec ent ralh ub cap overthe
whee lbolts. #
Hitthem iddle of theh ub cap toengag eiton
th ew heel. #
Secur ethe faulty wheel in thes par ew heel
brac ket. #
Vehicles with Super Single tires: transport
th ef aulty rear wheel on thel oad area. The
re ar wheel is tool arge fort he spar ewheel
brac ket. #
Chec kthe tir epressur eoft he newl yins talled
wheel and adjus titifnecessar y. #
Retighten thew heel bolts or wheel nuts tothe
specified tightening torque af tert he vehicle
has been driven 31miles (50 km). #
When using awhee lors parew hee lwitha
ne worn ewly painted whee lrim, ha vethe
wheel bolt sornutsr etightene dafter appr ox‐
ima tely 620 mile s(1,000 km) to3,10 0m iles
(5,000 km).
% Ve
hicles with thet irep ressur emonitor
sy stem: all ins talled wheels mus tbeequip‐
ped wit hfunctioning sensors.
Mak esuretoo bservethef ollowing fur ther rela‐
te ds ubject:
R Notesont irep ressur e(/pag e217 ) Spar
ewheel Note
sont he eme rgency spar ewheel and
spar ewheel Spar
ewheel: wheel and tir edimension saswell
as thet ype of tir ecorrespond totheo ther ins tal‐
led wheels.
Emer gency spar ewheel: wheel and/or tire
dimension saswell asthet ype of tir earediffer‐
ent from thew heel tobe replaced. Alabel wit ha
speed limit can be found on thee mer gency spa re
wheel.
An ins talled emer gency spa rewheel or spare
wheel changes thed riving characteristic sand
bear srisks. &
WARNING Risk of accident caused by
incor rect wheel and tir edimensions
Whe nthe emergency spar ewheel or the
spar ewheel is ins talled, driving characteris‐
tic sm aybe se verely affected.
The reis an inc reased risk of an accident.
To prev ent hazardous situations: #
Oncet he spar ewheel or thee mer gency
spa rewheel has been ins talled, check
th et irep ressur eand adjus tifneces‐
sar y. #
The emer gency spa rewheel ma yonly
be used temp oraril yand mus tbe
re placed wit hastandar dwheel as soon
as possible. #
Neverins tall mor ethan one emergency
spar ewheel. #
When operating your vehicle wit hthe
emergency spar ewheel ins talled, adapt Wheels and tires
239

#
Open ther ear-end doors. #
Place ascrew driver int orecesses 2and
th en pr yoffco vers 1 . #
Using thel ug wrenc hfromt hevehicle tool kit,
unscr ewthen ow visible bolts counter-clock‐
wise byappr oximatel y20turns. #
Slightly raise spar ewheel car rier 4 and
unhook left-hand saf etyh ook 3. #
Assemble thep um pleve rfor thej acka nd
slide it int osleeve5 onther ight-ha ndside
of spar ewheel car rier 4. #
Raise spar ewheel car rier 4 withthe pump
le ve ra nd unhook right-han dsafet yh ook 3. #
Slowl ylow er spar ewhee lcarrier 4 tothe
ground. #
Lift spar ewheel car rier 4 slightl yand pull
th ep um pleve rout of thes lee ve. #
Use thep um pleve rtol iftt he spar ewheel
be yond ther ear edg eofsparew heel car rier
4. #
Carefully remo vethes par ew heel from spare
wheel car rier 4.T he spar ewheel is heavy.
When thes par ew heel is remo ved, thec enter
of gr avity changes due totheh eavy weight of
th ew heel. The spar ewheel ma yslip down or
tip ove r.
Ve hicles with rear wheel drive: installin gthe
spar ewheel (Cargo Van/Passenger Van) #
Carefully place thes par ew heel ont ospare
wheel car rier 4.T he spar ewheel is heavy.
When youp lacethe spar ewheel ont ospare
wheel car rier 4,t he center of gravity
ch anges due tothew eight of thew heel. The
spar ewheel ma yslip down or tip over. #
Slide thep um pleve rfor thej acki ntos leeve
5 on spar ewheel car rier 4. #
Raise spar ewheel car rier 4 withthe pump
le ve ra nd attac hright-ha ndsafetyh ook 3. #
Slight lyraise spar ewheel car rier 4 and
attac hleft-hand saf etyh ook 3. #
Pull thep um pleve rout of slee ve5 . #
Using thel ug wrench, tighten saf etyh ook
bolts 3byturning them clockwise. #
Replace and engag ecovers 1. #
Close ther ear-end doors.
Ve hicles with rear wheel drive: removing the
spar ewheel (vehicl ewithl ow ered chassis) Bolt co
vers fort he saf etyh ooks (exa mp le: Cargo
Va n) Wheel
sand tires 241

#
Open ther ear-end doors. #
Place ascrew driver int orecesses 2and
th en pr yoffco vers 1 . #
Using thel ug wrenc hfromt hevehicle tool kit,
unscr ewthen ow visible bolts counter-clock‐
wise byappr oximatel y20turns. #
Slightly raise spar ewheel car rier 4 and
unhook left-hand saf etyh ook 3. #
Assemble thep um pleve rfor thej acka nd
slide it int osleeve5 onther ight-ha ndside
of spar ewheel car rier 4. #
Raise thes par ew heel car rier wit hthe pump
le ve ra nd unhook right-han dsafet yh ook 3. #
Position loop 7ofextraction device 6on
th es par ew heel so that youw ill later be able
to attac hlug wrench 8. #
Prepar ethe jac k. #
Place thej ackb eneat hthe cor responding
jac ksuppor tpoint. #
Movethep um pleve rupa nd down until the
tir eisr aised amaximum of 1.18 in (3 cm) off
th eg round. #
Hook lug wrench 8intoloop 7ofextrac‐
tio nd evice 6 onthes par ew heel. #
Carefully remo vethes par ew heel from spare
wheel car rier 4.T he spar ewheel is heavy.
When thes par ew heel is remo ved, thec enter
of gr avity changes due totheh eavy weight of
th ew heel. The spar ewheel ma yslip down or
tip ove r. #
Remo vethes par ew heel extraction device
and stor eitinas afep lace. Youc an now
ins tallth es par ew heel on your vehicle. #
Lowe rthe vehicle.
Ve hicles with rear wheel drive: installin gthe
spar ewheel (vehicle with lo weredc hassis)
% In
thee vent of aflat tire, youm aystor et he
fa ulty wheel inside thev ehicle onl y.An intact
whee lmaybe stored in thes par ew heel car‐
ri er onl ywhen thev ehicle is unladen. Aladen
ve hicle mus tfirst be raised. #
Carefull yplace thes par ew heel ont ospare
wheel car rier 4.T he spar ewheel is heavy.
When youp lacethe spar ewheel ont ospare
wheel car rier 4,t he center of gravity
ch anges due tothew eight of thew heel. The
spar ewheel ma yslip down or tip over. #
Slide thep um pleve rfor thej acki ntos leeve
5 on spar ewheel car rier 4. #
Raise spar ewheel car rier 4 withthe pump
le ve ra nd attac hright-ha ndsafetyh ook 3. #
Slight lyraise spar ewheel car rier 4 and
attac hleft-hand saf etyh ook 3. #
Pull thep um pleve rout of slee ve5 . #
Using thel ug wrench, tighten saf etyh ook
bolts 3byturning them clockwise. #
Replace and engag ecovers 1. #
Close ther ear-end doors. 242
Wheels and tires

#
Mak esuret hat no windshield washer
concentrat espills out next tothef iller
opening. *
NO
TEDama getothee xterio rlighting
due tounsuitable windshield washer fluid Uns
uitable windshield washer fluid ma ydam‐
ag et he plastic sur face of thee xterio rlighting. #
Onlyuse windshield washer fluid which
is also suitable foru se on plast ic surfa‐
ces, e.g. MB SummerFit or MB Winter‐
Fit. *
NO
TEBlocked spr aynozzle scaused by
mixing windshield washer fluids #
Do no tmix MB SummerFit and MB Win‐
te rFit wit hother windshield washer flu‐
ids. Do no
tuse distilled or de-ionize dwater .Other‐
wise, thef ill le vels ensor ma ygiveaf alse reading.
Information on thew indshield washer fluid
Re commended windshield washer fluid:
R abovefreezing point :e.g. MB SummerFit
R below freezing point :e.g. MB WinterFit
Mixin gratio
Fo rthe cor rect mixing ratio ,refer tothei nforma‐
tion on thea nti-freeze container.
Mix thew ashe rfluid wit hwindshield washer fluid
all year round.
Fi lling capacities
Wi ndshield washer sy stem
Wa sher fluid
5.8 qt (5.5 l)Re
frigerant Note
sonr efrigerant
Obser vethen otes on operating fluids
(/ page247).
% Yo
ur vehicle's climat econt rols ystemc an be
fi lled wit hR‑134a refrigerant. The refrigerant
R‑134a contains fluorinated greenhouse gas.
If yo ur vehicle is filled wit hR‑134a refrigerant, the
fo llowing informatio napplies: *
NO
TEDama gecaused byincor rect refrig‐
erant If
th ei ncor rect refrigerant is used ,this can
damag ethe climat econt rols ystem. #
Use onl yR‑134a refrigerant or theP AG
oil appr ovedfor your vehicle by
Mercedes-Benz. #
The appr ovedPAG oil ma ynotbe mixed
wit ha ny ot herPAGo ilth at is not
appr ovedfor R‑134a refrigerant. Maintenance
work,s uc hasa dding refrigerant or
re placing components, ma ybecarried out only
by aq ualified specialis tworks hop. All thea pplica‐
ble regulations relatin gtot his and theS AE J639
st andar dmustbea dhered to.
All workon thec limat econt rols ystems hould
alw aysbec arried out at aqualified specialist
wo rkshop. Example:
refrigerant warning label
1 Warning symbols
2 Refrigerant capacity
3 Applicabl estandards
4 PAGo il par tnumber
5 Refrigerant type
Wa rning symbols 1refertot hefollowing:
R Potential dangers
R The per form anc eofm aintenance workat a
qu alified specialis tworks hop Ve
hicl edata Information on
vehicl edimensions The
following section con tains impor tant tech ni‐
cal da tafory our vehicle. Your vehicle documents
contain fur ther vehicle-specific and equipment-
dependent tech nica ldatas uchasv ehicle dimen‐
sions and weights. Te
ch nica ldata 255

Displa
ymessages
Possible causes/consequences and 0050 0050Solutions #
Stop in accordance wit hthe tra ffic conditions. #
Clean all sensor s(/pag e195). #
Restar tt he engine.
SOS NOT READY *T
he emergency call sy stem is no tavailable.
Po ssible causes fort his include:
R The ignition is switched off.
R The emer gency cal lsyst em is malfunctioning. #
Switc hont he ignition.
If an emergency call is una vailable, amessag etothis ef fect will
appea ronthe multifunction displa yofthe instrument clus ter. #
Visit aq ualified specialis tworks hop.
% Yo
uc an find mor einformation on ther egional availabilit yofthe
emergency call sy stem at :http://www.mercedes-benz.com/
connect_ecall
007A
0025
00E5 Inoperative See Opera-
tor's Manual *
EBD,A BS and ESP ®
arem alfunctioning.
Other driving sy stems and driving saf etys ystems ma yalso be mal‐
functioning. &
WARNING Risk of skidding if EBD, ABS and ESP ®
arem al‐
functioning
If EBD, ABS and ESP ®
arem alfunctioning ,the wheels can lock
when braking and ESP ®
canno tcarry out vehicle stabilization.
The steering capability and braking characteristic sarethus
se verely impaired .The brakin gdista nc einane mergency brak‐
ing situation can increase. In addition, other driving saf etys ys‐
te ms ar eswitched off. #
Driv eonc arefully. #
Have theb rake system checkedi mmediately at aqualified
specialis tworks hop. #
Driv eonc arefully. #
Consult aqualified specialis tworks hop immediatel y.
00E5 Inoperative See Opera-
tor's Manual *
ESP ®
is malfunctioning.
Other driving sy stems and driving saf etys yst ems ma yalso be mal‐
functioning.
The brak esystem continues working wit hthe normal ef fect. The
braking dis tance ma yincrease in eme rgency braking situations. &
WARNING Risk of skidding if ESP ®
is malfunctioning
If ESP ®
is malfunctioning ,ESP ®
canno tcarry out vehicle stabili‐
zation .Inaddition ,other driving saf etys ystems ar eswitched off. #
Driv eonc arefull y. #
Have ESP ®
ch eckedataq ualified specialis tworks hop. 266
Displa ymessages and warning and indicator lamps

Brakes
Breaking-i nnotes .............................. 111
New/replaced brakepads/brake
discs .................................................1 11
Breakdown Assi stanc eoverview. .......................... 18
Changin gawheel ............................ .234
Ro adside Assis tance ......................... .23
To ws tartin g. .................................... .211
To wing away ..................................... 208
Tr ansportin gthe vehicle ...................2 10
Breakdown see Fla ttire
Breaking-i nnotes ................................. .111
Bulbs Reversing light .................................... 94
Buttons Steering wheel ..................................1 70C
Car wash
see Care
Car wash (care) .....................................1 93
Care ....................................................... 197
Car wash .......................................... 19 3
Carpe t............................................. .197
Displ ay.............................................. 197
Exterio rlighting ................................ 19 5
Headliner .......................................... 197
Matt efinish ...................................... 194
Pa int ................................................ .194
Plastic trim ....................................... 197
Po we rw ashe r................................... 19 3
Re alwo od/trim elements ................. 197
Re ar vie wcamera/360 °Camer a..... 19 5
Seat bel t.......................................... .197
Sea tcove r........................................ 197
Senso rs............................................ 19 5
Ta ilpipes .......................................... .195
Tr ailer hit ch...................................... 19 5
Wa shing byhand .............................. 194
Wheels/rims .................................... 19 5
Wi ndo ws ........................................... 19 5
Wi per blades .................................... 19 5
Cargo compa rtmen tlighting
Motio ndetector .................................. 89
Cargo compartmen tventilation
Deactivating .................................... .108
Setting .............................................. 108
Cargo tie-down point ............................180Cargo tie-down points
Info rm atio n..................................... .260
Carpe t(care) ........................................ .197
Central locking Wireless central lockin g..................... 24
Chang ebulbs
Ad ditional tur nsignal light (all-
wheel driv evehicles) .......................... 91
Changing abulb
see Changing bulbs
Changing awheel
Lo we ring thev ehicle ........................ 238
Preparing .......................................... 234
Ra ising thev ehicle ........................... 235
Re moving awhee l............................ 237
Changing address .................................. 23
Changing bulbs ....................................... 90
High beam. ......................................... 91
Indicator (front) .................................. 91
Interior lamps (rear compartment) ..... 94
License plate lamp............................. 93
Ligh tbulbt ypes haloge nheadlamps .. 90
Lo wb eam. .......................................... 91
No tes. ................................................90
Ta il lam pbulb types (Cargo Van
and Passenger Van) ............................ 92
Ta il lam pbulb types (chassis) ............ .93
Tu rn signal light (rear) (chassis) ..........94
Changing lamps see Changing bulbs
Changing owner .....................................23
Cha racteristics of thet ire .................. .228
Charging Batter y............................................. 202
Mobile phone (wi reless) .................... .82
Child saf etyl oc k( doors) ........................ 44
Child seat Attach ing (no tes) ................................ 40
Basic instructions ...............................36
Fr ont-passenger seat (no tes) .............. 43
LA TC H-type (ISOFIX )(ins talling) .......... 41
No tesonr isksa nd danger s................37
Re arwa rd-facing child restra int sys‐
te m( Information) .............................. .43
Secu ring on thef ront passenger
seat ....................................................43
Secu ring on ther ear seat ................... 42
To pT ether .......................................... 42
Children Avoiding danger sinthevehicle ..........37
Basi cinstructions ............................... 36 Index
295

Chec
kBrake Pads See Operator's
Manual .............................................2 65
Cruise Control Inoperative ...............268
Curr ently Un available Radar Sen‐
sor sD irty .........................................2 69
Driver's Door Open &Transmission
No tinPR isk ofVehicle Rolling
Aw ay ................................................ 280
NP ermanentl yActiv eRiskofR oll‐
ing Away ........................................... 280
Only Shif tto'P' when Vehicle is
St ationary ........................................ 280
Ra dar Sensor sDirty See Opera‐
to r's Manual .................................... .265
Re generation No tPossible ................2 74
Re versing No tPossible Service
Re quired .......................................... .280
Service Required Do No tShift
Gear sVisit Dealer ........................... .280
Shif tto' P' or 'N' toStartE ngine ...... 279
SOS NO TREADY .............................. 266
Ti re Press. Monitor Cur rently
Un available ...................................... .276
Ti re Pressur eMonitor Inoperative ....277
Ti re Pressur eMonitor Inoperative
No Wheel Sensors ............................2 76
To Engag eTransmiss .Position R
Fir stDep ress theB rake .................... 279
Tr ansmission Malfunction Stop ........ 280
Displa yrang e(trip menu) .................... 173
Displa ytotal di stance (trip menu) ......173
Distance cont rol
see ActiveD ista nce Assi stDISTRONIC
Di stance recorder
see Trip dis tance
DI STRO NIC
see ActiveD ista nce Assi stDISTRONIC
Door Locking (emergency key) .................... 50
Un lockin g(emer gency key) ................ 50
Door cont rolp anel ................................ .16
DO T,Tire Identification Number
(TIN) ....................................................... 227
Drinkin gand driving ............................. 111Driv
eAwayA ssist .................................1 59
Driver's seat see Seats
Driving and drinking .............................111
Drivin gcharacteristics (unusual) ........215
Drivin ginstructions
Fo reign trip (information) .................. 11 3
Drivin glight
see Automatic driving lights
Drivin gnotes
Brak esubject toload ........................ 11 4
Braking ............................................. 11 4
Breaking-i nnotes .............................. 111
Downhil lgradien t.............................. 11 4
Drinking and driving .......................... 111
Gene rald rivin gtips .......................... .111
Ne wb rake discs and brak epads/
linings ............................................... 11 4
Pa rking brak e................................... .114
Re stricted braking ef fect (salt-trea‐
te dr oads) .........................................1 14
Tr anspor tbyrail ................................ 11 4
We troad sur faces ............................ .114
Drivin gSafet yS ystem
AB S(Anti-loc kBrakin gS ystem) ........ 14 6
ASR (acceleration ski dcontrol )........ 147
BA S(Brak eAssistSystem) ............... 14 6
EBD (electroni cbrake forc ed istri‐
bution) ..............................................1 48
ESP ®
Crosswind Assis t..................... 14 8
ESP ®
traile rstabilizatio n................. .148
Overvie w.......................................... 14 6
Ra dar sensor s................................. .145
Re sponsibility ................................... 14 5
Drivin gsafet ys ystem
see ActiveB rake Assi st
see ESP ®
(Electronic Stabilit yProgram)
Driving sy stem
see Activating/deactivating the
HOLD function
see ActiveD ista nce Assi stDISTRONIC
see ActiveL aneK eeping Assist
see ATTENTION ASSIST
see Blind Spo tAssist
see Cruise control
see HOLD function
see Lane Keeping Assist
Driving tips Driving abroad (symmetrical low
beam) .................................................84
Driving in winter ................................ 11 5
Driving off-roa d................................. 11 6 Index
299