Extended warranty coverage periods are available for certain
vehicle parts and conditions. Specifically,
(1) Your vehicle’s Powertrain components are covered for five years or
60,000 miles, whichever occurs first. The extended coverage applies to
theEngine: all internal lubricated parts, cylinder block, cylinder heads,
electrical fuel pump, powertrain control module, engine mounts,
flywheel, injection pump, manifold (exhaust and intake), manifold bolts,
oil pan, oil pump, seals and gaskets, engine thermostat, engine
thermostat housing, timing chain cover, timing chain (gears or belt),
turbocharger/supercharger unit, valve covers, water pump;
Transmission: all internal parts, clutch cover, seals and gaskets, torque
converter, transfer case (including all internal parts), transmission case,
transmission mounts; single-speed gearbox (for The Focus Electric);
Front-Wheel Drive: axle shafts, front bearings seals and gaskets,
universal and constant velocity joints; Rear-Wheel Drive:axle shafts,
bearings (front and rear), center support bearing, drive axle housing
(including all internal parts), drive shaft, retainers, supports, seals and
gaskets, universal and constant velocity joints. Four-wheel/All-Wheel
Drive: axle shafts, bearings (front and rear), center support bearing,
drive shafts, final drive housing (including all internal parts),
hubs-automatic front locking (four-wheel drive), locking rings
(four-wheel drive), seals and gaskets, universal and constant velocity
joints.
(2) Your vehicle’s safety belts and air bag Supplemental Restraint System
(SRS) are covered for an extended Safety Restraint Coverage Period,
which lasts for five years or 60,000 miles, whichever occurs first.
(3) Your vehicle’s body sheet metal panels are covered for an extended
Corrosion Coverage Period, which lasts for five years, regardless of miles
driven. The extended warranty coverage only applies if a body sheet
metal panel becomes perforated due to corrosion during normal use due
to a manufacturing defect in factory-supplied materials or factory
workmanship. If aluminum body panels have corrosion or rust damage,
and the damage is not the result of abnormal usage, vehicle accident,
customer actions and/or extreme environmental conditions, the corrosion
or rust damage repairs are covered for 5 years, unlimited miles. For
damage caused by airborne material (environmental fallout) where there
11
is no factory-related defect involved and therefore no warranty our
policy is to provide free repair of paint damage due to the airborne
material for 12 months or 12,000 miles, whichever occurs first.
(4) The electrical drivetrain system of your vehicle is covered by the
Hybrid & Electric Vehicle Unique Component coverage for eight years or
100,000 miles, whichever comes first. The components in the electrical
drivetrain system of your vehicle will vary, depending on whether your
vehicle is a hybrid, plug-in hybrid, or all-electric vehicle, but you can rest
assured knowing that your vehicle’s electrical drivetrain system is
covered by this comprehensive warranty.
Depending on your vehicle, electrical drivetrain system components
covered by this warranty may include, and are not limited to:
high-voltage battery, high-voltage battery connector, high-voltage battery
isolation switch (manual disconnect switch), battery pack fan assembly,
battery pack sensor module (HBPSM), battery energy control module
(BECM), on-board charger, on-board charger fan assembly, inverter
system controller (ISC), DC/DC converter, hybrid continuously variable
transmission or electric driveline motor and transmission range sensor.
If an electrical drivetrain system component requires replacement under
warranty, it may be replaced with a new, factory remanufactured, or
factory refurbished component, at Ford’s discretion. Refurbished battery
components selected for your vehicle will align with your vehicle’s age
and mileage, and meet Ford’s stringent requirements and standards. (see
Note: High-Voltage Battery Gradual Capacity Lossbelow).
Note: High Voltage Battery Gradual Capacity Loss
The high voltage battery will experience gradual capacity loss with time
and use, similar to all batteries, which is considered normal wear and
tear. Loss of battery capacity due to or resulting from gradual capacity
loss is NOT covered under the New Vehicle Limited Warranty. See your
Owner’s Manual for important tips on how to maximize the life and
capacity of the high voltage battery.
12
•Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Assembly (Plug-in Hybrid vehicles only)
• Transmission Auxiliary Oil Pump (Plug-in Hybrid vehicles only)
• Transmission Fluid Temperature Sensor (Plug-in Hybrid vehicles only)
• Vacuum Distribution System
* Includes hardware and emission related software changes only
Important Information about List of Parts
Also covered by this warranty are all emissions-related bulbs, hoses, clamps,
brackets, tubes, gaskets, seals, belts, connectors, non diesel fuel lines, and
wiring harnesses that are used with components on the list of parts above.
Concerning parts that should be replaced on a certain maintenance
schedule: these parts remain under warranty until the first required
replacement time that is specified in your Owner’s Manual.
NOTE: If the diagnosis does not reveal a defect, the Defects Warranty
does not apply.
Your Ford Motor Company dealer maintains a complete list of covered
parts. For more details about the specific parts that are covered by the
Defects Warranty, contact your dealer.
WHAT IS NOT COVERED?
Ford Motor Company may deny you emissions warranty coverage if your
vehicle or a part does not contain a defect that affects emissions or has
failed because of abuse, neglect, improper maintenance, unapproved
modifications, or any items included in What Is Not Covered?,
pages 13-16.
29
