2020 CHEVROLET EXPRESS engine coolant

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
238 Vehicle Care
below freezing, use a fluid that has
sufficient protection against
freezing.
Adding Washer Fluid
Open the cap with the washer
symbol on it. Add washer fluid until
the tank is full. SeeEngine
Compartment Overview 0218 for
reservoir location.
Caution
. Do not use washer fluid that
contains any type of water
repellent coating. This can
cause the wiper blades to
chatter or skip.
(Continued)
Caution (Continued)
.Do not use engine coolant
(antifreeze) in the
windshield washer. It can
damage the windshield
washer system and paint.
. Do not mix water with
ready-to-use washer fluid.
Water can cause the
solution to freeze and
damage the washer fluid
tank and other parts of the
washer system.
. When using concentrated
washer fluid, follow the
manufacturer instructions for
adding water.
. Fill the washer fluid tank
only three-quarters full when
it is very cold. This allows
for fluid expansion if
freezing occurs, which could
damage the tank if it is
completely full.
Brakes
Disc brake pads have built-in wear
indicators that make a high-pitched
warning sound when the brake pads
are worn and new pads are needed.
The sound can come and go or can
be heard all the time when the
vehicle is moving, except when
applying the brake pedal firmly.
{Warning
The brake wear warning sound
means that soon the brakes will
not work well. That could lead to
a crash. When the brake wear
warning sound is heard, have the
vehicle serviced.
Caution
Continuing to drive with worn-out
brake pads could result in costly
brake repair.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Service and Maintenance 305
Maintenance
Schedule
Owner Checks and Services
Check the engine oil level. See
Engine Oil0222.
Once a Month
. Check the tire inflation
pressures, including the spare.
See Tire Pressure 0263.
. Inspect the tires for wear. See
Tire Inspection 0268.
. Check the windshield washer
fluid level. See Washer Fluid
0 237.
Engine Oil Change
When the CHANGE ENGINE OIL
SOON message displays, have the
engine oil and filter changed within
the next 1 000 km (600 mi). If driven
under the best conditions, the
engine oil life system may not
indicate the need for vehicle service
for up to a year. The engine oil and
filter must be changed at least once
a year and the oil life system must be reset. Your trained dealer
technician can perform this work.
If the engine oil life system is reset
accidentally, service the vehicle
within 5 000 km (3,000 mi) since the
last service. Reset the oil life
system when the oil is changed.
See
Engine Oil Life System 0224.
Extended Idle Use
When the vehicle is used in a way
that requires extended idle time,
one hour of use shall be deemed
the same as 53 km (33 mi). See
Driver Information Center (DIC) 099
for hourmeter.
Air Conditioning Desiccant
(Replace Every Seven Years)
The air conditioning system requires
maintenance every seven years.
This service requires replacement of
the desiccant to help the longevity
and efficient operation of the air
conditioning system. This service
can be complex. See your dealer.
Tire Rotation and Required
Services Every 12 000 km
(7,500 mi)
Rotate the tires, if recommended for
the vehicle, and perform the
following services. See Tire
Rotation 0268.
. Check engine oil level and oil
life percentage. If needed,
change engine oil and filter, and
reset oil life system. See Engine
Oil 0222 and
Engine Oil Life System 0224.
. Check engine coolant level. See
Cooling System 0230.
. Check windshield washer fluid
level. See Washer Fluid 0237.
. Check tire inflation pressures,
including the spare. See Tire
Pressure 0263.
. Inspect tire wear. See Tire
Inspection 0268.
. Visually check for fluid leaks.
. Inspect engine air cleaner filter.
See Engine Air Cleaner/Filter
0 229.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Service and Maintenance 313
Recommended Fluids, Lubricants, and Parts
Recommended Fluids and Lubricants
This maintenance section applies to vehicles with a gasoline engine. If the vehicle has a diesel engine, see the
maintenance schedule section in the Duramax diesel supplement.
Fluids and lubricants identified below by name, part number, or specification can be obtained from your dealer.Usage Fluid/Lubricant
Automatic Transmission (6-Speed Transmission) DEXRON-VI Automatic Transmission Fluid.
Automatic Transmission (8-Speed Transmission) DEXRON-HP Automatic Transmission Fluid.
Chassis Lubrication, Parking Brake Cable Guides Chassis Lubricant (GM Part No. 12377985, in Canada 88901242) or
lubricant meeting requirements of NLGI #2, Category LB or GC-LB.
Engine Coolant 50/50 mixture of clean, drinkable water and use only DEX-COOL Coolant. SeeCooling System 0230.
Engine Oil Engine oil meeting the dexos1 specification of the proper SAE viscosity grade. ACDelco dexos1 full synthetic is recommended. See Engine Oil
0 222.
Front Wheel Bearings Wheel bearing lubricant meeting requirements of NLGI #2, Category GC or GC-LB (GM Part No. 1051344, in Canada 993037).
Hydraulic Brake System DOT 3 Hydraulic Brake Fluid (GM Part No. 19353126, in Canada 19353127).

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
346 Index
Cigarette Lighter . . . . . . . . . . . . . . . . . 84
Circuit Breakers . . . . . . . . . . . . . . . . 249
CleaningExterior Care . . . . . . . . . . . . . . . . . 294
Interior Care . . . . . . . . . . . . . . . . . . 299
Climate Control Systems . . . . . . . 144 Air Conditioning . . . . . . . . . . . . . . 144
Heating . . . . . . . . . . . . . . . . . . . . . . . 144
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Rear Heating System . . . . . . . . . 146
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Cluster, Instrument . . . . . . . . . . . . . . 86
Collision Damage Repair . . . . . . . 328
Compartments
Storage . . . . . . . . . . . . . . . . . . . . . . . . . 76
Compass . . . . . . . . . . . . . . . . . . . . . . . . 81
Connected Services
Connections . . . . . . . . . . . . . . . . . . 342
Diagnostics . . . . . . . . . . . . . . . . . . . 343
Navigation . . . . . . . . . . . . . . . . . . . . 341
Connections
Connected Services . . . . . . . . . . 342
Control Traction and ElectronicStability . . . . . . . . . . . . . . . . . . . . . 178
Control of a Vehicle . . . . . . . . . . . . . 153
Convex Mirrors . . . . . . . . . . . . . . . . . . 21 Coolant
Engine Temperature Gauge . . . . 89
Cooling . . . . . . . . . . . . . . . . . . . . 144, 146
Cooling System . . . . . . . . . . . . . . . . . 230
Courtesy Transportation Program . . . . . . . . . . . . . . . . . . . . . . . 327
Cruise Control . . . . . . . . . . . . . . . . . . 180
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Customer Assistance . . . . . . . . . . . 324 Offices . . . . . . . . . . . . . . . . . . . . . . . . 323
Text Telephone (TTY)Users . . . . . . . . . . . . . . . . . . . . . . . 324
Customer Information Publications OrderingInformation . . . . . . . . . . . . . . . . . . 330
Customer Satisfaction
Procedure . . . . . . . . . . . . . . . . . . . . . 321
Cybersecurity . . . . . . . . . . . . . . . . . . . 333
D
Damage Repair, Collision . . . . . . . 328
Danger, Warning, and Caution . . . . 2
Data Collection Infotainment System . . . . . . . . . . 334
OnStar . . . . . . . . . . . . . . . . . . . . . . . 334
Data Recorders, Event . . . . . . . . . 333
Daytime Running
Lamps (DRL) . . . . . . . . . . . . . . . . . . 112 Defensive Driving . . . . . . . . . . . . . . . 152
Delayed Locking . . . . . . . . . . . . . . . . . 14
Devices
Auxiliary . . . . . . . . . . . . . . . . . . . . . . 131
Diagnostics Connected Services . . . . . . . . . . 343
Distracted Driving . . . . . . . . . . . . . . . 151
Dome Lamps . . . . . . . . . . . . . . . . . . . 114
Door
Cargo Door Relocking . . . . . . . . . . 14
Delayed Locking . . . . . . . . . . . . . . . . 14
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Power Locks . . . . . . . . . . . . . . . . . . . . 14
Rear Doors . . . . . . . . . . . . . . . . . . . . . 18
Side . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Sliding . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Drive Belt Routing, Engine . . . . . . 320
Driver Assistance Systems . . . . . 182
Driver Information Center (DIC) . . . . . . . . . . . . . . . . . . . 99
Driving
Better Fuel Economy . . . . . . . . . 151
Characteristics andTowing Tips . . . . . . . . . . . . . . . . . 196
Defensive . . . . . . . . . . . . . . . . . . . . . 152
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 152
Hill and Mountain Roads . . . . . . 156
If the Vehicle is Stuck . . . . . . . . . 158

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Index 347
Driving (cont'd)Loss of Control . . . . . . . . . . . . . . . 154
Off-Road Recovery . . . . . . . . . . . 154
Vehicle Load Limits . . . . . . . . . . . 158
Wet Roads . . . . . . . . . . . . . . . . . . . 155
Winter . . . . . . . . . . . . . . . . . . . . . . . . 156
Dual Tire
Rotation . . . . . . . . . . . . . . . . . . . . . . 270
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 193
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 213
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 249
Floor Console Fuse Block . . . . 253
Fuses and Circuit Breakers . . . 249
Overload . . . . . . . . . . . . . . . . . . . . . 248
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 336
Engine
Air Cleaner/Filter . . . . . . . . . . . . . 229
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 93
Compartment Overview . . . . . . . 218
Coolant Heater . . . . . . . . . . . . . . . 167
Coolant Temperature Gauge . . . . 89 Engine (cont'd)
Cooling System . . . . . . . . . . . . . . . 230
Drive Belt Routing . . . . . . . . . . . . 320
Exhaust . . . . . . . . . . . . . . . . . . . . . . 170
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 236
Oil Life System . . . . . . . . . . . . . . . 224
Oil Pressure Gauge . . . . . . . . . . . . 88
Oil Pressure Light . . . . . . . . . . . . . . 97
Overheating . . . . . . . . . . . . . . . . . . 235
Power Messages . . . . . . . . . . . . . 104
Running While Parked . . . . . . . . 171
Starting . . . . . . . . . . . . . . . . . . . . . . . 165
Enhanced Technology Glass . . . . 24
Entry Lighting . . . . . . . . . . . . . . . . . . . 115
Entry/Exit Lighting . . . . . . . . . . . . . . 115
Equipment, Towing . . . . . . . . . . . . . 208
Event Data Recorders . . . . . . . . . . 333
Exit Lighting . . . . . . . . . . . . . . . . . . . . 115
Extender, Seat Belt . . . . . . . . . . . . . . 42
Exterior Lamp Controls . . . . . . . . . 110
Exterior Lamps Off Reminder . . . 111
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 116
F
FanEngine . . . . . . . . . . . . . . . . . . . . . . . . 236
Fast Idle System . . . . . . . . . . . . . . . . 166 Filter,
Engine Air Cleaner . . . . . . . . . . . 229
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 111
Flashers, Hazard Warning . . . . . . 113
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 276 Changing . . . . . . . . . . . . . . . . . . . . . 278
FlexFuel
E85 . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 302
Fluid Automatic
Transmission . . . . . . . . . . . 225, 228
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 239
Power Steering . . . . . . . . . . . . . . . 237
Washer . . . . . . . . . . . . . . . . . . . . . . . 237
Folding Mirrors . . . . . . . . . . . . . . . . . . 22
Forward Collision Alert
(FCA) System . . . . . . . . . . . . . . . . . 186
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 331
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . 27
Front Storage . . . . . . . . . . . . . . . . . . . . 76
Front Turn Signal Bulb Replacement . . . . . . . . . . . . 245
Fuel Additives . . . . . . . . . . . . . . . . . . . . . 192
Economy, Driving for Better . . . 151

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
348 Index
Fuel (cont'd)Filling a Portable Fuel
Container . . . . . . . . . . . . . . . . . . . 195
Filling the Tank . . . . . . . . . . . . . . . 194
Foreign Countries . . . . . . . . . . . . 192
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Low Fuel Warning Light . . . . . . . . . 98
Prohibited Fuels . . . . . . . . . . . . . . 192
Recommended . . . . . . . . . . . . . . . 192
Top Tier . . . . . . . . . . . . . . . . . . . . . . 191
Full-Size Spare Tire . . . . . . . . . . . . 287
Fuses Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 249
Floor Console Fuse Block . . . . 253
Fuses and Circuit Breakers . . . 249
G
Gauges Engine Coolant Temperature . . . 89
Engine Oil Pressure . . . . . . . . . . . . 88
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Odometer . . . . . . . . . . . . . . . . . . . . . . . 87
Speedometer . . . . . . . . . . . . . . . . . . . 87
Trip Odometer . . . . . . . . . . . . . . . . . . 87
Voltmeter . . . . . . . . . . . . . . . . . . . . . . . 90
Warning Lights andIndicators . . . . . . . . . . . . . . . . . . . . . 85 General Information
Service and Maintenance . . . . . 303
Towing . . . . . . . . . . . . . . . . . . . . . . . . 196
Vehicle Care . . . . . . . . . . . . . . . . . . 215
Glass, Enhanced Technology . . . . 24
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 325
H
Halogen Bulbs . . . . . . . . . . . . . . . . . . 245
Hazard Warning Flashers . . . . . . . 113
Head Restraints . . . . . . . . . . . . . . . . . 27
Headlamps
Aiming . . . . . . . . . . . . . . . . . . . . . . . . 245
Automatic . . . . . . . . . . . . . . . . . . . . . .112
Bulb Replacement . . . . . . . . . . . . 245
Daytime RunningLamps (DRL) . . . . . . . . . . . . . . . . .112
Flash-to-Pass . . . . . . . . . . . . . . . . . . 111
High-Beam On Light . . . . . . . . . . . . 98
High/Low Beam Changer . . . . . . 111
Heated Mirrors . . . . . . . . . . . . . . . . . . . 22
Heater Engine Coolant . . . . . . . . . . . . . . . 167
Heating . . . . . . . . . . . . . . . . . . . . 144, 146
High-Beam On Light . . . . . . . . . . . . . 98
Hill and Mountain Roads . . . . . . . . 156
Hill Start Assist (HSA) . . . . . . . . . . 177 Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
How to Wear Seat Belts
Properly . . . . . . . . . . . . . . . . . . . . . . . . 34
HVAC . . . . . . . . . . . . . . . . . . . . . . 144, 146
I
Idle System Fast . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Ignition Positions . . . . . . . . . . . . . . . 163
Ignition Transmission Lock Check . . . . . . . . . . . . . . . . . . . . . . . . . 243
Immobilizer . . . . . . . . . . . . . . . . . . . . . . 20
Indicator Vehicle Ahead . . . . . . . . . . . . . . . . . . 96
Infants and Young Children, Restraints . . . . . . . . . . . . . . . . . . . . . . 57
Information Publication Ordering . . . . . . . . . . 330
Infotainment . . . . . . . . . . . . . . . . . . . . 117
Infotainment System . . . . . . . . . . . . 334
Instrument Cluster . . . . . . . . . . . . . . . 86
Instrument Panel Overview . . . . . . . 5
Interior Rearview Mirrors . . . . . . . . . 22
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 288