2020 CHEVROLET EXPRESS check transmission fluid

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Vehicle Care 289
ground connection you do not
want. You would not be able to
start your vehicle, and the bad
grounding could damage the
electrical systems.
To avoid the possibility of the
vehicles rolling, set the parking
brake firmly on both vehicles
involved in the jump start
procedure. Put an automatic
transmission in P (Park) or a
manual transmission in Neutral
before setting the parking
brake.
Caution
If any accessories are left on or
plugged in during the jump
starting procedure, they could be
damaged. The repairs would not
be covered by the vehicle
warranty. Whenever possible, turn
off or unplug all accessories on
either vehicle when jump starting.
3. Turn the ignition off on both vehicles. Unplug unnecessary
accessories plugged into the cigarette lighter or the
accessory power outlet. Turn
off the radio and all lamps that
are not needed. This will avoid
sparks and help save both
batteries. And it could save the
radio!
4. Open the hoods and locate the positive (+) and negative (−)
terminal locations of the other
vehicle.
On your van, use the unpainted
radio antenna bracket as a
remote negative (−) terminal.
{Warning
Using a match near a battery can
cause battery gas to explode.
People have been hurt doing this,
and some have been blinded.
Use a flashlight if you need more
light.
Battery fluid contains acid that
can burn you. Do not get it on
you. If you accidentally get it in
(Continued)
Warning (Continued)
your eyes or on your skin, flush
the place with water and get
medical help immediately.
{Warning
Fans or other moving engine
parts can injure you badly. Keep
your hands away from moving
parts once the engine is running.
5. Check that the jumper cables do not have loose or missing
insulation. If they do, you could
get a shock. The vehicles
could be damaged too.
Before you connect the cables,
here are some basic things you
should know. Positive (+) will
go to positive (+) or to a remote
positive (+) terminal if the
vehicle has one. Negative (−)
will go to an unpainted metal
part or to a remote negative (−)
terminal if the vehicle has one.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Service and Maintenance 309
Maintenance Schedule
Additional Required
Services - Severe12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi
60 000 km/37,500 mi
72 000 km/45,000 mi
84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi
120 000 km/75,000 mi
132 000 km/82,500 mi
144 000 km/90,000 mi
156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi
204 000 km/127,500 mi
216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Rotate tires and perform Required Services.
Check engine oil level and oil life percentage.
Change engine oil and filter, if needed.
Lubricate the steering linkage.@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Inspect evaporative control system. (1)@ @@
Replace engine air cleaner filter. (2)@@@
Change automatic transmission fluid and filter.@@@
Replace spark plugs. Inspect spark plug wires
and/or boots.@
Drain and fill engine cooling system. (3)@
Visually inspect accessory drive belts. (4)@
Replace brake fluid. (5)
Replace windshield wiper blades. (6)
@ @ @ @ @ @ @ @ @ @
Replace air conditioning desiccant. (7)
Footnotes—Maintenance
Schedule Additional Required
Services - Severe
(1) Visually check all fuel and vapor
lines and hoses for proper
attachment, connection, routing, and
condition. (2)
Or every four years, whichever
comes first. If driving in dusty
conditions, inspect the filter at each
oil change or more often as needed.
See Engine Air Cleaner/Filter 0229. (3)
Or every five years, whichever
comes first. See Cooling System
0 230.
(4) Or every 10 years, whichever
comes first. Inspect for fraying,
excessive cracking, or damage;
replace, if needed.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Technical Data 319
ApplicationCapacities
Metric English
Cutaway (Standard Tank) 124.9 L 33.0 gal
Passenger and Cargo 117.3 L 31.0 gal
* 4 039 mm (159 in) wheelbase or 4 496 mm (177 in) wheelbase only
Wheel Nut Torque 190 Y140 lb ft
All capacities are approximate. When adding, be sure to fill to the approximate level, as recommended in this
manual. Recheck fluid level after filling.
Engine Specifications
Engine VIN CodeTransmission Spark Plug Gap
4.3L V6 (LV1) PAutomatic 0.95–1.10 mm (0.037–
0.043 in)
6.0L V8 (L96) GAutomatic 0.95–1.10 mm (0.037–
0.043 in)
6.0L V8 (LC8) (Capable of
Being Upfit for Gaseous Fuel) B
Automatic 0.95–1.10 mm (0.037–
0.043 in)
Spark plug gaps are preset by the manufacturer. Re-gapping the spark plug is not recommended and can damage
the spark plug.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Index 345
Automatic (cont'd)Headlamp System . . . . . . . . . . . . .112
Transmission . . . . . . . . . . . . . . . . . 171
Transmission Fluid . . . . . . 225, 228
Automatic Transmission Manual Mode . . . . . . . . . . . . . . . . . 174
Shift Lock Control FunctionCheck . . . . . . . . . . . . . . . . . . . . . . . 243
Auxiliary Devices . . . . . . . . . . . . . . . . . . . . . . . 131
Avoiding Untrusted Media Devices . . . . . . . . . . . . . . . . . . . . . . . 126
Axle, Rear . . . . . . . . . . . . . . . . . . . . . . 241
B
Battery Exterior Lighting Battery
Saver . . . . . . . . . . . . . . . . . . . . . . . .116
Load Management . . . . . . . . . . . . .115
Power Protection . . . . . . . . . . . . . .116
Battery - North America . . . . 240, 288
Blade Replacement, Wiper . . . . . 244
Bluetooth Overview . . . . . . . . . . . . . . . . . . . . . 136
Brake System Warning Light . . . . . . . . . . 94
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 238 Antilock . . . . . . . . . . . . . . . . . . . . . . . 176 Brakes (cont'd)
Assist . . . . . . . . . . . . . . . . . . . . . . . . . 177
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 239
Parking . . . . . . . . . . . . . . . . . . . . . . . 177
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 153
Break-In, New Vehicle . . . . . . . . . . 162
Bulb Replacement Center High-MountedStoplamp (CHMSL) . . . . . . . . . 247
Front Turn Signal, Sidemarker, and Parking
Lamps . . . . . . . . . . . . . . . . . . . . . . 245
Halogen Bulbs . . . . . . . . . . . . . . . . 245
Headlamp Aiming . . . . . . . . . . . . . 245
Headlamps . . . . . . . . . . . . . . . . . . . 245
License Plate Lamps . . . . . . . . . 247
Taillamps . . . . . . . . . . . . . . . . . . . . . 246
Buying New Tires . . . . . . . . . . . . . . . 271
C
Calibration . . . . . . . . . . . . . . . . . . . . . . . 81
California Perchlorate MaterialsRequirements . . . . . . . . . . . . . . . 216
California Proposition
65 Warning . . . . . . . . . .215, 240, 288,
Back CoverCamera
Rear Vision (RVC) . . . . . . . . . . . . 184
Canadian Vehicle Owners . . . . . . . . 2
Capacities and Specifications . . . . . . . . . . . . . . . . . 318
Carbon Monoxide Engine Exhaust . . . . . . . . . . . . . . . 170
Winter Driving . . . . . . . . . . . . . . . . 156
Cargo Tie-Downs . . . . . . . . . . . . . . . . . . . . . . 77
Cargo Door Relocking . . . . . . . . . . . 14
Caution, Danger, and Warning . . . . 2
CD Player . . . . . . . . . . . . . . . . . . . . . . 126
Center High-Mounted
Stoplamp (CHMSL) . . . . . . . . . . . 247
Chains, Tire . . . . . . . . . . . . . . . . . . . . 275
Charging System Light . . . . . . . . . . 92
Check
Engine Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 93
Ignition Transmission Lock . . . 243
Child Restraints Infants and Young Children . . . . . 57
Lower Anchors and Tethersfor Children . . . . . . . . . . . . . . . . . . . 62
Older Children . . . . . . . . . . . . . . . . . . 55
Securing . . . . . . . . . . . . . . . . . . . . 70, 72
Systems . . . . . . . . . . . . . . . . . . . . . . . . 59

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
Index 347
Driving (cont'd)Loss of Control . . . . . . . . . . . . . . . 154
Off-Road Recovery . . . . . . . . . . . 154
Vehicle Load Limits . . . . . . . . . . . 158
Wet Roads . . . . . . . . . . . . . . . . . . . 155
Winter . . . . . . . . . . . . . . . . . . . . . . . . 156
Dual Tire
Rotation . . . . . . . . . . . . . . . . . . . . . . 270
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 193
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 213
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 249
Floor Console Fuse Block . . . . 253
Fuses and Circuit Breakers . . . 249
Overload . . . . . . . . . . . . . . . . . . . . . 248
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 336
Engine
Air Cleaner/Filter . . . . . . . . . . . . . 229
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 93
Compartment Overview . . . . . . . 218
Coolant Heater . . . . . . . . . . . . . . . 167
Coolant Temperature Gauge . . . . 89 Engine (cont'd)
Cooling System . . . . . . . . . . . . . . . 230
Drive Belt Routing . . . . . . . . . . . . 320
Exhaust . . . . . . . . . . . . . . . . . . . . . . 170
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 236
Oil Life System . . . . . . . . . . . . . . . 224
Oil Pressure Gauge . . . . . . . . . . . . 88
Oil Pressure Light . . . . . . . . . . . . . . 97
Overheating . . . . . . . . . . . . . . . . . . 235
Power Messages . . . . . . . . . . . . . 104
Running While Parked . . . . . . . . 171
Starting . . . . . . . . . . . . . . . . . . . . . . . 165
Enhanced Technology Glass . . . . 24
Entry Lighting . . . . . . . . . . . . . . . . . . . 115
Entry/Exit Lighting . . . . . . . . . . . . . . 115
Equipment, Towing . . . . . . . . . . . . . 208
Event Data Recorders . . . . . . . . . . 333
Exit Lighting . . . . . . . . . . . . . . . . . . . . 115
Extender, Seat Belt . . . . . . . . . . . . . . 42
Exterior Lamp Controls . . . . . . . . . 110
Exterior Lamps Off Reminder . . . 111
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 116
F
FanEngine . . . . . . . . . . . . . . . . . . . . . . . . 236
Fast Idle System . . . . . . . . . . . . . . . . 166 Filter,
Engine Air Cleaner . . . . . . . . . . . 229
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 111
Flashers, Hazard Warning . . . . . . 113
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 276 Changing . . . . . . . . . . . . . . . . . . . . . 278
FlexFuel
E85 . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 302
Fluid Automatic
Transmission . . . . . . . . . . . 225, 228
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 239
Power Steering . . . . . . . . . . . . . . . 237
Washer . . . . . . . . . . . . . . . . . . . . . . . 237
Folding Mirrors . . . . . . . . . . . . . . . . . . 22
Forward Collision Alert
(FCA) System . . . . . . . . . . . . . . . . . 186
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 331
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . 27
Front Storage . . . . . . . . . . . . . . . . . . . . 76
Front Turn Signal Bulb Replacement . . . . . . . . . . . . 245
Fuel Additives . . . . . . . . . . . . . . . . . . . . . 192
Economy, Driving for Better . . . 151

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13882570) - 2020 - CRC - 11/1/19
352 Index
SeatsAdjustment, Front . . . . . . . . . . . . . . . 27
Head Restraints . . . . . . . . . . . . . . . . 27
Power Adjustment, Front . . . . . . . 27
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Reclining Seatbacks . . . . . . . . . . . . 28
Securing Child Restraints . . . . 70, 72
Security
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
OnStar . . . . . . . . . . . . . . . . . . . . . . . 337
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 19
Vehicle Alarm . . . . . . . . . . . . . . . . . . . 19
Service . . . . . . . . . . . . . . . . . . . . . . . . . 149 Accessories andModifications . . . . . . . . . . . . . . . . 216
Climate Control System . . . . . . . 144
Doing Your Own Work . . . . . . . . 216
Maintenance Records . . . . . . . . 316
Maintenance, General
Information . . . . . . . . . . . . . . . . . . 303
Parts Identification . . . . . . . . . . . . 317
Scheduling Appointments . . . . . 327
Services Special Application . . . . . . . . . . . 310
Servicing the Airbag . . . . . . . . . . . . . 53
Shift Lock Control Function
Check, Automatic
Transmission . . . . . . . . . . . . . . . . . . 243 Shifting
Into Park . . . . . . . . . . . . . . . . . . . . . . 169
Out of Park . . . . . . . . . . . . . . . . . . . 170
Side Blind Zone Alert (SBZA) . . . 188
Side Door . . . . . . . . . . . . . . . . . . . . . . . 16
Sidemarker Bulb Replacement . . . . . . . . . . . . 245
Signals, Turn and Lane-Change . . . . . . . . . . . . . . . . . 113
Sliding Door . . . . . . . . . . . . . . . . . . . . . 17
Special Application Services . . . . 310
Specifications and Capacities . . . . . . . . . . . . . . . . . . . . . 318
Speedometer . . . . . . . . . . . . . . . . . . . . 87
StabiliTrak OFF Light . . . . . . . . . . . . . . . . . . . . . . . 96
Start Assist, Hill . . . . . . . . . . . . . . . . . 177
Start Vehicle, Remote . . . . . . . . . . . 12
Starter Switch Check . . . . . . . . . . . 242
Starting the Engine . . . . . . . . . . . . . 165
Steering . . . . . . . . . . . . . . . . . . . . . . . . 153 Fluid, Power . . . . . . . . . . . . . . . . . . 237
Wheel Adjustment . . . . . . . . . . . . . . 79
Wheel Controls . . . . . . . . . . . . . . . . . 79
Storage Areas
Front . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
Storage Compartments . . . . . . . . . . 76
Stuck Vehicle . . . . . . . . . . . . . . . . . . . 158 Sun Visors . . . . . . . . . . . . . . . . . . . . . . . 25
Swing-out Windows . . . . . . . . . . . . . . 24
Switches
Airbag On-Off . . . . . . . . . . . . . . . . . . . 50
Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . 3
System Forward Collision
Alert (FCA) . . . . . . . . . . . . . . . . . . 186
Infotainment . . . . . . . . . . . . . 117, 334
Noise Control . . . . . . . . . . . . . . . . . 241
Systems
Driver Assistance . . . . . . . . . . . . . 182
T
Taillamps . . . . . . . . . . . . . . . . . . . . . . . 246
Text Telephone (TTY) Users . . . . 324
Theft-Deterrent Systems . . . . . . . . . 20Immobilizer . . . . . . . . . . . . . . . . . . . . . 20
Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . 255 All-Season . . . . . . . . . . . . . . . . . . . . 256
Buying New Tires . . . . . . . . . . . . . 271
Chains . . . . . . . . . . . . . . . . . . . . . . . . 275
Changing . . . . . . . . . . . . . . . . . . . . . 278
Designations . . . . . . . . . . . . . . . . . 259
Different Size . . . . . . . . . . . . . . . . . 272
Dual Rotation . . . . . . . . . . . . . . . . . 270
Full-Size Spare . . . . . . . . . . . . . . . 287