2019 MAZDA MODEL 2 engine
[x] Cancel search: enginePage 582 of 759
& $ 8 7 , 2 1
¾Using oils of viscosity besides those recommended for
specific temperature ranges could
result in engine damage.
¾(SKYACTIV-D 1.5)
SKYACTIV-D 1.5 uses specified oil. Please confirm the specification in owner's manual. If
engine oil other than the
specified oil is used, the Diesel Particulate Filter
effective period of
use will be shortened or the Diesel Particulate Filter may be damaged.
NOTE
(SKYACTIV-G 1.3 and SKYACTIV-G 1.5)
xIt is normal for all engines to consume engine oil under normal driving conditions.
Engine oil consumption may be as high as 0.8 L/1,000 km (1 L/800 miles). This may be as
a result of evaporation, internal ventilation or burning of the lubricating oil in the
working engine. Oil consumption may be higher when the engine is new due to the
running-in process. Oil consumption is also dependant on engine speed and engine load.
Under extreme driving conditions, oil consumption may be higher.
(SKYACTIV-D 1.5)
xInspect the engine oil level periodically. When inspecting the engine oil, if the engine oil
level is exceeds the “X” mark on the dipstick, replace the engine oil. This should be done
by an expert repairer (we recommend an Authorised Mazda Repairer). When replacing
the engine oil, inspect the oil level using the oil dipstick and refill so that the engine oil
level is within the range between MIN and MAX as shown in the figure.
X Mark MAX MIN
xWhenever the engine oil is replaced, the vehicles engine control unit needs to be reset as
soon as possible. Otherwise the wrench indicator light or engine oil warning light may
turn on. To reset the engine control unit, consult an expert repairer (we recommend an
Authorised Mazda Repairer) or refer to the vehicle engine control unit reset procedure on
page 6-27.
0 D L Q W H Q D Q F H D Q G & D U H
2 Z Q H U 0 D L Q W H Q D Q F H
Page 583 of 759
▼ 9 H K L F O H ( Q J L Q H & R Q W U R O 8 Q L W 5 H V H W 3 U R F H G X U H
NOTE
This procedure is intended for vehicles with SKYACTIV-D 1.5 and vehicles with
SKYACTIV-G 1.3 or SKYACTIV-G 1.5 which the engine oil flexible maintenance setting is
selected.
$ I W H U U H S O D F L Q J W K H H Q J L Q H R L O K D Y H D U H S D L U V K R S V X F K D V D Q $ X W K R U L V H G 0 D ] G D 5 H S D L U H U
S H U I R U P W K H L Q L W L D O L ] D W L R Q H Q J L Q H R L O G D W D U H V H W W L Q J R I W K H U H F R U G H G Y D O X H , I W K H Y D O X H
U H F R U G H G E \ W K H F R P S X W H U L V Q R W L Q L W L D O L ] H G W K H Z U H Q F K L Q G L F D W R U O L J K W P D \ Q R W W X U Q R I I R U L W
P D \ W X U Q R Q H D U O L H U W K D Q Q R U P D O
NOTE
The initialization (engine oil data resetting) of the recorded value can be performed using
the following procedure:
1. Switch the ignition OFF.
2. Switch the ignition ON with the selector pressed and continue pressing the selector for
about 5 seconds until the master warning light
flashes.
Selector
3. After the master warning light flashes for several seconds, the initialization is
completed.
0 D L Q W H Q D Q F H D Q G & D U H
2 Z Q H U 0 D L Q W H Q D Q F H
Page 584 of 759
▼ , Q V S H F W L Q J ( Q J L Q H 2 L O / H Y H O
% H V X U H W K H Y H K L F O H L V R Q D O H Y H O
V X U I D F H
: D U P X S W K H H Q J L Q H W R Q R U P D O
R S H U D W L Q J W H P S H U D W X U H
7 X U Q L W R I I D Q G Z D L W D W O H D V W P L Q X W H V
I R U W K H R L O W R U H W X U Q W R W K H V X P S
3 X O O R X W W K H G L S V W L F N Z L S H L W F O H D Q D Q G
U H L Q V H U W L W I X O O \
6 . < $ & 7 , 9 * D Q G
6 . < $ & 7 , 9 *
MAX
MINOK
6 . < $ & 7 , 9 '
MAX
OK
MIN X Mark
NOTE
(SKYACTIV-D 1.5)
When inspecting the engine oil level,
pull out the dipstick straight without
twisting. In addition, when inserting
the dipstick, always insert it without
twisting so that the “X” mark faces the
front of the vehicle.
3 X O O L W R X W D J D L Q D Q G H [ D P L Q H W K H O H Y H O
7 K H O H Y H O L V Q R U P D O L I L W L V E H W Z H H Q W K H
0 , 1 D Q G 0 $ ; P D U N V
, I L W L V Q H D U R U E H O R Z 0 , 1 D G G H Q R X J K
R L O W R E U L Q J W K H O H Y H O W R 0 $ ;
& $ 8 7 , 2 1
Do not overfill the engine oil. This may
cause engine damage.
0 D N H V X U H W K H 2 U L Q J R Q W K H G L S V W L F N L V
S R V L W L R Q H G S U R S H U O \ E H I R U H U H L Q V H U W L Q J
W K H G L S V W L F N
5 H L Q V H U W W K H G L S V W L F N I X O O \
0 D L Q W H Q D Q F H D Q G & D U H
2 Z Q H U 0 D L Q W H Q D Q F H
Page 585 of 759
( Q J L Q H & R R O D Q W
▼ , Q V S H F W L Q J & R R O D Q W / H Y H O
: $ 5 1 , 1 *
Do not use a match or live flame in the
engine compartment. DO NOT ADD
COOLANT WHEN THE ENGINE IS HOT:
A hot engine is dangerous. If the engine has
been running, parts of the engine
compartment can become very hot. You
could be burned. Carefully inspect the
engine coolant in the coolant reservoir, but
do not open it.
Pull over to a safe location, then switch
the ignition off and make sure the fan is
not running before attempting to work
near the cooling fan:
Working near the cooling fan when it is
running is dangerous. The fan could
continue running indefinitely even if the
engine has stopped and the engine
compartment temperature is high. You
could be hit by the fan and seriously
injured.
Do not remove either cooling
system cap when the engine and radiator
are hot:
When the engine and radiator are hot,
scalding coolant and steam may shoot out
under pressure and cause serious injury.
NOTE
Changing the coolant should be done by
an expert repairer (we recommend an
Authorised Mazda Repairer).
, Q V S H F W W K H D Q W L I U H H ] H S U R W H F W L R Q D Q G
F R R O D Q W O H Y H O L Q W K H F R R O D Q W U H V H U Y R L U D W
O H D V W R Q F H D \ H D UŠ D W W K H E H J L Q Q L Q J R I W K H
Z L Q W H U V H D V R QŠ D Q G E H I R U H W U D Y H O O L Q J
Z K H U H W H P S H U D W X U H V P D \ G U R S E H O R Z
I U H H ] L Q J
, Q V S H F W W K H F R Q G L W L R Q D Q G F R Q Q H F W L R Q V R I
D O O F R R O L Q J V \ V W H P D Q G K H D W H U K R V H V
5 H S O D F H D Q \ W K D W D U H V Z R O O H Q R U
G H W H U L R U D W H G
7 K H F R R O D Q W V K R X O G E H D W I X O O L Q W K H
U D G L D W R U D Q G E H W Z H H Q W K H ) R U ) 8 / / D Q G /
P D U N V R Q W K H F R R O D Q W U H V H U Y R L U Z K H Q W K H
H Q J L Q H L V F R R O
6 . < $ & 7 , 9 * D Q G 6 . < $ & 7 , 9 *
7 \ S H $
Cooling system cap Coolant reservoir
Cooling fan
0 D L Q W H Q D Q F H D Q G & D U H
2 Z Q H U 0 D L Q W H Q D Q F H
Page 586 of 759
7 \ S H %
Cooling system cap Coolant reservoir
Cooling fan
6 . < $ & 7 , 9 '
Cooling system cap Coolant reservoir
Cooling fan
, I L W L V D W R U Q H D U / D G G H Q R X J K F R R O D Q W W R
W K H F R R O D Q W U H V H U Y R L U W R S U R Y L G H I U H H ] L Q J
D Q G F R U U R V L R Q S U R W H F W L R Q D Q G W R E U L Q J W K H
O H Y H O W R ) R U ) 8 / /
6 H F X U H O \ W L J K W H Q W K H F R R O D Q W U H V H U Y R L U W D Q N
F D S D I W H U D G G L Q J F R R O D Q W
& $ 8 7 , 2 1
¾Radiator coolant will damage paint.
Rinse it off quickly if spilled.
¾If the “FL22” mark is shown on or near
the cooling system cap, use of FL-22 is
recommended when replacing engine
coolant. Using engine coolant other than
FL-22 may cause serious damage to the
engine and cooling system.
, I W K H F R R O D Q W U H V H U Y R L U L V H P S W \ R U Q H Z
F R R O D Q W L V U H T X L U H G I U H T X H Q W O \ F R Q V X O W D Q
H [ S H U W U H S D L U H U Z H U H F R P P H Q G D Q
$ X W K R U L V H G 0 D ] G D 5 H S D L U H U
0 D L Q W H Q D Q F H D Q G & D U H
2 Z Q H U 0 D L Q W H Q D Q F H
Page 595 of 759
▼ , Q V S H F W L Q J ( O H F W U R O \ W H / H Y H O
$ O R Z O H Y H O R I H O H F W U R O \ W H I O X L G Z L O O F D X V H
W K H E D W W H U \ W R G L V F K D U J H T X L F N O \
Upper level
Lower level
, Q V S H F W W K H H O H F W U R O \ W H O H Y H O D W O H D V W R Q F H D
Z H H N , I L W L V O R Z U H P R Y H W K H F D S V D Q G D G G
H Q R X J K G L V W L O O H G Z D W H U W R E U L Q J W K H O H Y H O
E H W Z H H Q W K H X S S H U D Q G O R Z H U O H Y H O
L O O X V W U D W L R Q
' R Q R W R Y H U I L O O
( [ D P L Q H W K H V S H F L I L F J U D Y L W \ R I W K H
H O H F W U R O \ W H Z L W K D K \ G U R P H W H U H V S H F L D O O \
G X U L Q J F R O G Z H D W K H U , I L W L V O R Z U H F K D U J H
W K H E D W W H U \
▼▼ % D W W H U \ 5 H F K D U J L Q J
NOTE
xBefore performing maintenance or
recharging the battery, turn off all
accessories and stop the engine.
xTo disconnect the battery, remove the
negative lead first. Install it last when
connecting the battery.
xBe sure to remove the caps before
recharging the battery.
x(With i-stop system)
Do not quick-charge the battery.
x , I W K H E D W W H U \ T X L F N O \ G L V F K D U J H V
E H F D X V H I R U H [ D P S O H W K H O L J K W V Z H U H
O H I W R Q W R R O R Q J Z L W K W K H H Q J L Q H R I I
V O R Z F K D U J H L W D V U H T X L U H G E \ E D W W H U \
V L ] H D Q G F K D U J H U F D S D F L W \
x , I W K H E D W W H U \ J U D G X D O O \ G L V F K D U J H V
E H F D X V H R I K L J K H O H F W U L F O R D G Z K L O H W K H
Y H K L F O H L V E H L Q J X V H G U H F K D U J H L W D V
U H T X L U H G E \ E D W W H U \ V L ] H D Q G F K D U J H U
F D S D F L W \
▼ % D W W H U \ 5 H S O D F H P H Q W
& R Q W D F W D Q $ X W K R U L V H G 0 D ] G D 5 H S D L U H U I R U
E D W W H U \ U H S O D F H P H Q W
0 D L Q W H Q D Q F H D Q G & D U H
2 Z Q H U 0 D L Q W H Q D Q F H
6 R P H P R G H O V
Page 619 of 759
: D W H U 0 D U N V
2 F F X U U H Q F H
5 D L Q I R J G H Z D Q G H Y H Q W D S Z D W H U F D Q
F R Q W D L Q K D U P I X O P L Q H U D O V V X F K D V V D O W D Q G
O L P H , I P R L V W X U H F R Q W D L Q L Q J W K H V H P L Q H U D O V
V H W W O H V R Q W K H Y H K L F O H D Q G H Y D S R U D W H V W K H
P L Q H U D O V Z L O O F R Q F H Q W U D W H D Q G K D U G H Q W R
I R U P Z K L W H U L Q J V 7 K H U L Q J V F D Q G D P D J H
\ R X U Y H K L F O H
V I L Q L V K
3 U H Y H Q W L R Q
, W L V Q H F H V V D U \ W R Z D V K D Q G Z D [ \ R X U
Y H K L F O H W R S U H V H U Y H L W V I L Q L V K D F F R U G L Q J W R
W K H L Q V W U X F W L R Q V L Q W K L V V H F W L R Q 7 K H V H V W H S V
V K R X O G E H W D N H Q L P P H G L D W H O \ D I W H U \ R X I L Q G
Z D W H U P D U N V R Q \ R X U Y H K L F O H
V I L Q L V K
3 D L Q W & K L S S L Q J
2 F F X U U H Q F H
3 D L Q W F K L S S L Q J R F F X U V Z K H Q J U D Y H O W K U R Z Q
L Q W K H D L U E \ D Q R W K H U Y H K L F O H
V W \ U H V K L W V
\ R X U Y H K L F O H
+ R Z W R D Y R L G S D L Q W F K L S S L Q J
. H H S L Q J D V D I H G L V W D Q F H E H W Z H H Q \ R X D Q G
W K H Y H K L F O H D K H D G U H G X F H V W K H F K D Q F H V R I
K D Y L Q J \ R X U S D L Q W F K L S S H G E \ I O \ L Q J
J U D Y H O
NOTE
xThe paint chipping zone varies with the
speed of the vehicle. For example, when
travelling at 90 km/h (56 mph), the paint
chipping zone is 50 m (164 ft).
xIn low temperatures a vehicle's finish
hardens. This increases the chance of
paint chipping.
xChipped paint can lead to rust forming
on your Mazda. Before this happens,
repair the damage by using Mazda
touch-up paint according to the
instructions in this section. Failure to
repair the affected area could lead to
serious rusting and expensive repairs.
) R O O R Z D O O O D E H O D Q G F R Q W D L Q H U G L U H F W L R Q V
Z K H Q X V L Q J D F K H P L F D O F O H D Q H U R U S R O L V K
5 H D G D O O Z D U Q L Q J V D Q G F D X W L R Q V
▼ 0 D L Q W D L Q L Q J W K H ) L Q L V K
: D V K L Q J
& $ 8 7 , 2 1
¾When the wiper lever is in the AUTO
position and the ignition is switched ON,
the wipers may move automatically in
the following cases:
¾If the windscreen above the rain sensor
is touched or wiped with a cloth.
¾If the windscreen is struck with a hand
or other object from either outside or
inside the vehicle.
Keep hands and scrapers clear of the
windscreen when the wiper lever is in the
AUTO position and the ignition is
switched ON as
fingers could be pinched
or the wipers and wiper blades damaged
when the wipers activate automatically.
If you are going to clean the windscreen,
be sure the wipers are turned off
completely (when it is most likely that the
engine is left running) this is particularly
important when clearing ice and snow.
0 D L Q W H Q D Q F H D Q G & D U H
$ S S H D U D Q F H & D U H
Page 620 of 759
¾Do not spray water in the engine
compartment. Otherwise, it could result
in engine-starting problems or damage
to electrical parts.
¾When washing and waxing the vehicle,
be careful not to apply excessive force to
any single area of the vehicle roof or the
aerial. Otherwise, you could dent the
vehicle or damage the aerial.
7 R K H O S S U R W H F W W K H I L Q L V K I U R P U X V W D Q G
G H W H U L R U D W L R Q Z D V K \ R X U 0 D ] G D
W K R U R X J K O \ D Q G I U H T X H Q W O \ D W O H D V W R Q F H D
P R Q W K Z L W K O X N H Z D U P R U F R O G Z D W H U
, I W K H Y H K L F O H L V Z D V K H G L P S U R S H U O \ W K H
S D L Q W V X U I D F H F R X O G E H V F U D W F K H G + H U H D U H
V R P H H [ D P S O H V R I K R Z V F U D W F K L Q J F R X O G
R F F X U
6 F U D W F K H V R F F X U R Q W K H S D L Q W V X U I D F H Z K H Q
x 7 K H Y H K L F O H L V Z D V K H G Z L W K R X W I L U V W
U L Q V L Q J R I I G L U W D Q G R W K H U I R U H L J Q P D W W H U
x 7 K H Y H K L F O H L V Z D V K H G Z L W K D U R X J K G U \
R U G L U W \ F O R W K
x 7 K H Y H K L F O H L V Z D V K H G D W D F D U Z D V K W K D W
X V H V E U X V K H V W K D W D U H G L U W \ R U W R R V W L I I
x & O H D Q V H U V R U Z D [ F R Q W D L Q L Q J D E U D V L Y H V
D U H X V H G
NOTE
xMazda is not responsible for scratches
caused by automatic car washes or
improper washing.
xScratches are more noticeable on
vehicles with darker paint finishes.
7 R P L Q L P L ] H V F U D W F K H V R Q W K H Y H K L F O H
V
S D L Q W I L Q L V K
x 5 L Q V H R I I D Q \ G L U W R U R W K H U I R U H L J Q P D W W H U
X V L Q J O X N H Z D U P R U F R O G Z D W H U E H I R U H
Z D V K L Q J
x 8 V H S O H Q W \ R I O X N H Z D U P R U F R O G Z D W H U
D Q G D V R I W F O R W K Z K H Q Z D V K L Q J W K H
Y H K L F O H ' R Q R W X V H D Q \ O R Q F O R W K
x 5 X E J H Q W O \ Z K H Q Z D V K L Q J R U G U \ L Q J W K H
Y H K L F O H
x 7 D N H \ R X U Y H K L F O H R Q O \ W R D F D U Z D V K
W K D W N H H S V L W V E U X V K H V Z H O O P D L Q W D L Q H G
x ' R Q R W X V H D E U D V L Y H F O H D Q V H U V R U Z D [
W K D W F R Q W D L Q D E U D V L Y H V
& $ 8 7 , 2 1
¾Do not use steel wool, abrasive cleaners,
or strong detergents containing highly
alkaline or caustic agents on
chrome-plated or anodised aluminium
parts. This may damage the protective
coating; also, cleaners and detergents
may discolour or deteriorate the paint.
¾(With detachable aerial)
To prevent damaging the aerial, remove
it before entering a car wash facility or
passing beneath a low overhead
clearance.
3 D \ V S H F L D O D W W H Q W L R Q W R U H P R Y L Q J V D O W G L U W
P X G D Q G R W K H U I R U H L J Q P D W H U L D O I U R P W K H
X Q G H U V L G H R I W K H Z L Q J V D Q G P D N H V X U H W K H
G U D L Q K R O H V L Q W K H O R Z H U H G J H V R I W K H G R R U V
D Q G U R F N H U S D Q H O V D U H F O H D Q
0 D L Q W H Q D Q F H D Q G & D U H
$ S S H D U D Q F H & D U H