2019 CITROEN RELAY coolant level

7
Instrument panels
Level 1 instrument panel/
d isplay screen
1. Speedometer (mph or km/h).
2. Display screen.
3. Fuel gauge.
4. Coolant temperature.
5. Rev counter (rpm x 1,000). Level 1
display screen
In the lower part:
- Time,
-
E
xterior temperature,
-
M
iles/kilometres travelled,
-
T
rip computer (range, fuel consumption,
e t c .),
-
H
eadlamp beam height,
-
P
rogrammable overspeed warning,
-
C
ruise control or speed limiter,
- G ear shift indicator ~ Gear efficiency
i n d i c a t o r,
-

S
top & Start.
In the upper part:
-


Date,
-
S

ervice indicator,
-
A

lert messages,
-

S
ystem status messages,
-
V

ehicle configuration.
Level 2 instrument panel/
d isplay screen
1. Speedometer (mph or km/h).
2. Display screen.
3. Fuel gauge.
4. Coolant temperature.
5. Rev counter (rpm x 1,000).
1
Dashboard instruments

10
Warning/indicator lampStateCause Actions/Comments
Red warning/indicator lamps Coolant
temperature On H in the red zone. The coolant temperature is too
high
and/or
an abnormal increase. Park and switch off the ignition.
Allow the system to cool sufficiently.
Check the level visually.
For more information on Checking levels
, refer to the
corresponding section.
If the level is low, top it up.
If the level is correct, contact a
CITROËN dealer or
a


qualified workshop.
Fixed, with the needle
in the red zone.
Engine oil pressure Flashing for a
few
seconds, with
a
message in the
screen. A high level of deterioration of the
engine oil.
Have the engine oil changed as soon as possible.
After the second level of alert, engine per formance will
be limited.
Lit temporarily or
fixed, with the engine
running. Low oil level
or
a major fault. Park and switch off the ignition.
Check the level manually.
For more information on Checking levels
, refer to the
corresponding section.
If the level is low, top it up.
If the level is correct, contact a
CITROËN dealer or
a


qualified workshop.
Battery charge Fixed. A fault with the charging system
or the battery. Check the battery terminals.
For more information on the Battery
, refer to the
corresponding section.
Fixed or flashing,
despite the checks. A fault with the ignition or
injection system. Have it checked by a
CITROËN dealer or a qualified
workshop.
Opening detection Fixed. One of the vehicle access
openings is not properly closed. Check that the cab doors, the rear and side doors and
the bonnet are closed.
Dashboard instruments

20
Coolant temperature
If the needle enters the red zone or if the
warning lamp comes on:
-
s
top immediately, switch off the ignition. The
fan may continue to operate for a
certain
time up to approximately 10
minutes.
-

w
ait for the engine to cool down in order to
check the level and top it up if necessary. When topping up:
Caution, the coolant circuit is pressurised!
In order to avoid any risk of scalding, place
a
cloth around the cap and unscrew the cap by
two turns to allow the pressure to drop.
When the pressure has dropped, remove the
cap to check the level and top up.
The needle is positioned between C (Cold)
and H (Hot): normal operation.
In arduous conditions of use or hot climatic
conditions, the needle may move close to the
red graduations. If the needle remains in the red zone,
contact a CITROËN dealer or a qualified
workshop.
Check the coolant level regularly.
For more information on Checking levels ,
refer to the corresponding section.
Fuel gauge
The fuel level is tested every time the ignition
is turned on.
The gauge is positioned on:
-

F
(Full): the tank is full.
-

E
(Empty): the reserve is being used,
the low level warning lamp lights up
permanently.
The reser ve when the warning lamp first comes
on is approximately:
-

1
0 litres for 60 and 90 litre tanks,
-

1
2 litres for 120 litre tanks.
Fuel tanks of different capacities are available
as an option.
-
6

0

litres (all engines),
-

1
20 litres (except Euro 6 engines).
For more information on Fuel , refer to the
corresponding section.
Dashboard instruments

50
To avoid the risks of poisoning or
asphyxia, the additional heating must
not be used, even for short periods, in
a closed environment such as a garage or
workshop which are not equipped with an
exhaust gas extraction system.
The additional heating switches off when
the battery voltage is low, so as to allow
engine starting.
The additional heating is fed by the
vehicle's fuel tank. Ensure that the low fuel
warning lamp is not on.
Always switch off the additional heating
when refuelling to avoid any risk of fire or
explosion!
The temperature near the heating
system must not exceed 120°C. A higher
temperature (e.g. when baking the
paint) could damage the components of
electronic circuits.
The additional heating is fitted with
a
temperature limiter which cuts off
the combustion in the event of engine
overheating due to a
lack of coolant.
Check the level and top up if necessary.
For more information on Checking levels ,
refer to the corresponding section.
Then press the programme selection
button before switching the heating on
again.Recommendations for ventilation and air conditioning
In order for these systems to be fully effective,
follow the operation and maintenance
guidelines below:
F

T
o ensure that the air is distributed evenly,
keep the external air intake grilles at the
base of the windscreen, the nozzles, the
vents, the air outlets and the air extractor
in the boot free from obstructions.
F

D
o not cover the sunshine sensor,
located on the dashboard; this is used for
regulation of the automatic air conditioning
system.
F

O
perate the air conditioning system for
at least 5
to 10 minutes once or twice
a
month to keep it in per fect working order.
F

E
nsure that the passenger compartment
filter is in good condition and replace
the filter elements periodically. We
recommend the use of a
combined
passenger compartment filter. Thanks to
its special active additive, it helps both to
purify the air breathed by the occupants
and to keep the passenger compartment
clean (reduction of allergic symptoms, bad
odours and greasy deposits). F
T o ensure correct operation of the
air conditioning system, you are also
advised to have it checked regularly as
recommended in the Maintenance and
Warranty Guide.
F

I
f the system does not produce cold air,
switch it off and contact a
CITROËN
dealer or a
qualified workshop.
When towing the maximum load on a
steep
gradient in high temperatures, switching off
the air conditioning increases the available
engine power and so improves the towing
ability.
To avoid the windows misting up and
deterioration in the quality of the air:
-

d
o not drive for too long with the
ventilation switched off.
-

d
o not keep air recirculation set for an
extended period.
Ease of use and comfort

126
Diesel engines
1.Windscreen/headlamp wash fluid
reservoir.
2. Power steering fluid reservoir.
3. Coolant tank.
4. Brake and clutch fluid reser voir.
5. Diesel fuel filter.
6. Fusebox.
7. A i r f i l t e r.
8. Dipstick.
9. Engine oil filler cap.
Battery connections:
+ Positive terminal.
- Negative terminal (earth). The Diesel circuit is under very high
pressure.
All work on this circuit must be carried out
only by a
CITROËN dealer or a qualified
workshop.
Checking levels
Check all of these levels regularly, in line with
the manufacturer's service schedule. Top them
up if necessary, unless other wise indicated.
If a
level drops significantly, have the
corresponding system checked by a
CITROËN
dealer or a
qualified workshop.
If you have to remove/refit the engine
cover, handle it with care to avoid
damaging the fixing clips.
Used products
Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to health
or indeed very corrosive. Do not discard used oil or fluids into
sewers or onto the ground.
Take used oil to a
CITROËN dealer or
a qualified workshop and dispose of it in
the containers reser ved for this purpose.
Engine oil level
Check this regularly and top up as
necessary between two oil changes
(the maximum consumption is
0.5
litres for 620 miles (1,000 km)).
Make the check with the vehicle
standing level, engine cold, using
the dipstick.
Checking using the dipstick
2 marks on the dipstick:
A = MA X
B = MIN
Practical information

128
For access to the reser voir filler cap, remove
the protective cover by turning its three fixing
screws a quarter turn, then remove the second
cover fitted to the cap.
Engine coolant level
Check the coolant level regularly.
It is normal to top up this fluid
between two services.
Check the coolant level regularly,
according to the use made of your vehicle
(every 3,000
miles (5,000 km)/3 months);
if necessary, top up using coolant
recommended by the manufacturer.
The check and top up must only be done
with the engine cold.
A low coolant level presents a
risk of
serious damage to your engine.
When the engine is hot, the temperature of the
coolant is regulated by the electric fan. This
may operate with the ignition off; furthermore,
because the cooling system is under pressure,
wait for at least one hour after the engine has
stopped before carrying out any work. F

F
or access to the header tank filler cap,
remove the protective cover by turning its
three fixing screws a quarter turn.
F
T
o avoid the risk of scalding, place a cloth
around the cap, then loosen the cap by
a
quarter turn to release the pressure.
F

W
hen the pressure has dropped, remove
the cap and top up the level with coolant.
To p p i n g u p
The level must be between the MIN and MAX
marks on the expansion bottle.
As close as possible to the MAX mark is
recommended.
If more than 1
litre of fluid is required to top
up the level, have the system checked by
a
CITROËN dealer or a qualified workshop.
Screenwash and headlamp
wash level
To check the level or top up the fluid
on vehicles fitted with headlamp
washers, immobilise the vehicle and
switch off the engine.
Capacity of the reservoir: approximately
5.5


litres.
F

F

or access to the reser voir filler cap, pull on
the telescopic filler pipe and unclip the cap.
Practical information

185
Accessories .................................................... 67
AdBlue® .................................................. 13 2-13 3
Adjusting the date ........................................... 28
Adjusting the seat angle


................................. 37
Adjusting the seat belt height
.................... 7

2-73
Adjusting the time


........................................... 28
Advice on driving


...................................... 87- 8 9
Airbags
...............................

.............................78
Airbags, curtain


............................................... 76
Airbags, front ....................................... 75 -76, 79
Airbags, lateral


................................................ 76
Air conditioning


......................................... 46 - 47
Air conditioning, additional
....................... 4

6 - 47
Air conditioning, automatic


.......................44, 50
Air conditioning, manual
........................... 4

3, 50
Alarm


............................................................... 35
Anti-lock braking system (ABS)
..........12, 68 - 69
Anti-slip regulation (ASR)


.........................68-69
Armrest, front
.................................................. 38
Assistance, emergency braking


...............68-69
Audio streaming (Bluetooth)


..........................7- 8
Audio system
..................................................... 1Cable, audio
..................................................
7, 4
Cable, Jack ...................................................
7, 4
Capacity, fuel tank ..................................20, 116
CD


.....................................................................7
CD, MP3


............................................................7
Centre console


..................................................4
Changing a


bulb
.....................................14

3 -14 4
Checking the levels


................................126 -128
Checks


...................................................12 9 -131
Checks, routine


.....................................129, 131
Child seats

..............................
...........74, 77, 85
Cigarette lighter


..............................................58
Configuration, vehicle
............................... 2

2, 27
Control, heated seats


......................................38
Control stalk, lighting


................................15, 61
Control stalk, wipers

.......................................65
C

ourtesy lamp, front ...........................52-54, 56
Courtesy lamp, rear
........................................58
Courtesy lamps
...............................................58
Cruise control


.........................................101-105
DAB (Digital Audio Broadcasting) – Digital radio


..........................5
Dashboard


.........................................................4
Daytime running lamps


...................................61
Daytime running lamps, LED


..........................62
Deactivating the passenger airbag


.....75, 78 -79
Dimensions
..............................

.....................162
Direction indicators


...................................15, 61
Display screen, instrument panel


...............7, 92
Driving abroad ................................................. 61
Dynamic stability control (DSC)


................68-69
Battery


............................................. 91, 129, 153
BlueHDi


................................................... 21, 132
Bluetooth (hands-free)
........................... 1

2-13, 5
Bluetooth (telephone)
............................. 1

2-13, 5
Bonnet


........................................................... 125
Brake discs


............................................. 12 9 -131
Brakes


........................................................... 131
Brightness


......................................................... 8
Bulbs (changing)


.................................... 143 -14 4
Bulbs (changing, type)


.................................. 14 4 Electric windows
.............................................
36
Electronic brake force distribution (EBFD) ... 6
8-69
Emergency braking assistance (EBA)
......68-69
Engine compartment
.................................... 12

6
Engine, Diesel


...............................118, 126, 158
Engines


..................................................157-15 8
Filling the AdBlue
® tank ................................ 132
Filling the fuel tank ................................ 11 6 , 11 8
Filter, air


........................................................ 12 9
Filter, Diesel fuel


................................... 126, 131
Filter, oil
................

......................................... 12 9
Filter, particle


......................................... 12 9 -13 0
Filter, passenger compartment


..................... 12 9
Fittings, front


............................................. 52-56
Fittings, interior
......................................... 5

2-56
Flap, fuel filler


................................................ 11 6
Fluid, brake


............................................ 126 -128
Fluid, engine coolant


.............................. 126 -128
Fluid, power steering
............................. 12

6 -128
Foglamps, front


............................................... 61
Foglamps, rear
................................................ 61
Fr

ont doors
...................................................... 33
Fu

el ................................................................ 11 8
Fuel tank ........................................................ 11 6
AC
D
B
E
F
.
Alphabetical index

186
Jack ...............................................................7, 4Pads, brake ............................................
12 9 -131
Parking brake ........................11, 91-92, 129 -131
Player, USB
................................................6 - 7, 4
Port, USB
...................................................6 - 7, 4
Pre-tensioning seat belts


................................74
Protecting children


..............................75, 77, 79
Radio


......................................................4, 7, 2-3
Radio, digital (Digital Audio Broadcasting – DAB)
......................................5
Range, AdBlue


................................................21
Regeneration of the particle filter
..........12 9 -13 0
Remote control


..........................................30, 89
Replacing bulbs
..................................... 14

3 -14 4
Replacing the air filter
................................... 12

9
Replacing the oil filter
................................... 12

9
Replacing the passenger compartment filter


....12 9
Resetting the service indicator


..................18 -19
Rev counter


.......................................................7
Gauge, fuel
.............................................. 20, 116
Gearbox, manual
.............................. 92, 94, 130
Gear shift indicator ~ Gear efficiency indicator


....................................... 17
Glove box

.................................................. 52-55
Immobiliser, electronic


.................................... 89
Indicator, coolant temperature


........................ 20
Indicator, engine oil level

........................... 18 -19
Indicator lamps, operation
................................ 9
I

ndicators, direction


........................................ 61
Information, vehicle ......................................... 14
Instrument panels


............................................. 7
Instruments and controls

.................................. 4
Intelligent Traction Control


.............................. 71Lane Departure Warning
System (LDWS)


................................... 10 6 -107
Level, engine coolant


...................................... 20
Levels


..................................................... 126 -128
Levels and checks

..............................
..........126
Lighting dimmer


................................................ 8
Low fuel level

.......................................... 2

0, 116
Lumbar


............................................................ 37
Menu


....................................... 22, 4, 6, 9, 12, 14
Menus (audio)


............................................... 4, 6
Mirrors, door .................................................... 42
Hazard warning lamps


.................................... 68
Headlamp flash


............................................... 61
Headlamps, dipped beam


............................... 61
Headlamps, main beam


............................ 16, 61
Head restraints, front

...................................... 37
Heating
............................................................ 43
H

eating, additional


.................................... 46 - 47
Hill Descent Control


................................... 71-72
Hill start assist

................................................. 95
Horn ................................................................. 68Kit, hands-free
.......................................
1

2-13, 5
Oil, engine


.............................................. 126 -128
On-board tools


....................................... 137-142
Opening the bonnet


...................................... 125
Overhead storage
............................... 5

2-54, 56Safety, children


...................................75, 77, 79
Screen, colour
................................................... 4
S

creen menu map

.........................4, 6, 9, 12, 14
Screenwash fluid


...................................126 -128
SCR (Selective Catalytic Reduction)


............132
Seat belts


...................................................7 2 -74
Seat belts, rear


................................................73
Seats, heated


..................................................38
Service indicator


........................................18 -19
Servicing
.................................................... 1

8 -19JP
R
G
I
L
M
H
K
O
S
Alphabetical index