2019 CITROEN BERLINGO VAN checking oil

30
- in zone B, the temperature of the engine
coolant is too high; the maximum
temperature and central STOP warning
lamps come on, accompanied by an audible
signal and a warning message.
You must stop as soon as it is safe to do so.
Wait a few minutes before switching off the
engine.
Contact a CITROËN dealer or a qualified
workshop.
Checking
After driving for a few minutes, the temperature
and pressure in the cooling system increase.
To top up the level:
F

w
ait at least one hour for the engine to cool,
F

u
nscrew the cap by two turns to allow the
pressure to drop,
F

w
hen the pressure has dropped, remove the
cap,
F

t
op up the level to the "MA X" mark.
For more information on Checking levels ,
refer to the corresponding section.
Be aware of the risk of scalding when
topping up the coolant. Do not fill above
the maximum level (indicated on the
reservoir).
Engine oil level indicator
On versions fitted with an electric oil level
indicator, the state of the engine oil level is
displayed in the instrument panel for a few
seconds when the ignition is switched on, at
the same time as the ser vicing information.The level read will only be correct if
the vehicle is on level ground and the
engine has been stopped for more than
30


minutes.
Oil level correct
This is indicated by a message in the
instrument panel.
Low oil level
If the low oil level is confirmed by a check using
the dipstick, the level must be topped up to
avoid damage to the engine.
This is indicated by a message in the
instrument panel.
Oil level indicator fault
Dipstick
To locate the dipstick and the oil filler
cap for the Diesel engine , refer to the
corresponding section.
A = maximum; never
exceed this level.
B = minimum; top up
the level via the oil filler
hole, with the oil type
that is suitable for your
engine.
This is indicated by a message in the
instrument panel. Contact a CITROËN dealer
or a qualified workshop.
Instruments

187
Opening
F Open the left-hand front door.
F
P
ull the release lever, located at the bottom
of the door aperture, towards you.
F

L
ift the safety catch and raise the bonnet. F

U
nclip the stay
from its housing
and place it in the
support slot to hold
the bonnet open.
Closing
F Take the stay out of the support slot.
F C lip the stay in its housing.
F

L
ower the bonnet and release it near the
end of its travel.
F

P
ull on the bonnet to check that it is fully
latched.
Because of the presence of electrical
equipment under the bonnet, it is
recommended that exposure to water
(rain, washing, etc.) be limited.
Engines
Petrol
Diesel
These engines are examples provided as a
guide.
The locations of the dipstick and engine oil filler
cap may vary.
1. Screenwash fluid reservoir.
2. Engine coolant reservoir.
3. Brake fluid reser voir.
4. Battery.
5. Fusebox.
6. A i r f i l t e r.
7. Engine oil dipstick.
8. Engine oil filler cap.
Checking levels
Check all of these levels regularly, in line with
the manufacturer's service schedule. Top them
up if necessary, unless other wise indicated.
If a level drops significantly, have the
corresponding system checked by a CITROËN
dealer or a qualified workshop.The Diesel circuit is under very high
pressure.
All work on this circuit must be carried out
only by a CITROËN dealer or a qualified
workshop.
The liquid must comply with the
manufacturer's recommendations and with
the vehicle's engine.
7
Practical information

188
Take care when working under the bonnet,
as certain areas of the engine may be
extremely hot (risk of burns) and the
cooling fan could start at any time (even
with the ignition off).
Used products
Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to health
or indeed very corrosive.Do not discard used oil or fluids into
sewers or onto the ground.
Take used oil to a CITROËN dealer or a
qualified workshop and dispose of it in
the containers reser ved for this purpose.
Engine oil level
The check is carried out either when
the ignition is switched on using the
oil level indicator in the instrument
panel for vehicles equipped with an
electric gauge, or using the dipstick. To ensure that the reading is correct, your
vehicle must be parked on a level sur face
with the engine stopped for more than
30


minutes.
It is normal to top up the oil level between
two ser vices (or oil changes). CITROËN
recommends that you check the level, and top
up if necessary, every 3,000 miles (5,000 km).
Checking using the dipstick
The location of the dipstick is shown in the
corresponding underbonnet layout view.
F

T
ake the dipstick by its coloured grip and
pull it out completely.
F

W
ipe the end of the dipstick using a clean
non-fluffy cloth.
F

R
efit the dipstick and push fully down, then
pull it out again to make the visual check:
the correct level is between marks A and B .A = MA X
B = MIN
If you find that the level is above the A mark or
below the B mark, do not star t the engine .
- I f the level is above the MAX mark (risk of
damage to the engine), contact a CITROËN
dealer or a qualified workshop.
-

I
f the level is below the MIN mark, you must
top up the engine oil.
Oil grade
Before topping up the oil or changing the oil,
check that the oil is the correct grade for your
engine and conforms to the manufacturer's
recommendations.
Topping up the engine oil level
The location of the oil filler cap is shown in the
corresponding underbonnet layout view.
Practical information

189
After topping up the oil, the check when
switching on the ignition with the oil level
indicator in the instrument panel is not
valid during the 30 minutes after topping
up.
F

U
nscrew the oil filler cap to access the filler
opening.
F

A
dd oil in small quantities, avoiding any
spills on engine components (risk of fire).
F

W
ait a few minutes before checking the
level again using the dipstick.
F

A
dd more oil if necessary.
F

A
fter checking the level, carefully refit the oil
filler cap and the dipstick in its tube.
Brake fluid level
The brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Changing the fluid
Refer to the manufacturer's service schedule
for details of the inter val for this operation.
Fluid specification
This fluid must conform to the manufacturer's
recommendations.
Coolant level
Check the coolant level regularly.
It is normal to top up this fluid
between two services.
To avoid the risk of scalding when you need to
top up in an emergency, place a cloth around the
cap and unscrew the cap by two turns to allow
the pressure to drop.
Once the pressure has dropped, remove the cap
and top up to the required level.
The cooling fan may star t after
switching off the engine: take care
with articles and clothing that might be
caught by the fan blades.
Screenwash fluid level
Top up to the required level when
necessary.
Fluid specification
This fluid must conform to the manufacturer's
recommendations.
Engine oil change
In order to maintain the reliability of the engine
and emissions control system, never use
additives in the engine oil. The check and top-up must only be done with
the engine cold.
A low coolant level presents a risk of serious
damage to your engine.
The coolant level should be close to the "MA X"
mark but should never exceed it.
If the level is close to or below the "MIN" mark,
it is essential to top up.
When the engine is hot, the temperature of this
fluid is regulated by the fan.
In addition, as the cooling system is pressurised,
wait at least one hour after switching off the
engine before carrying out any work.
Tank capacity:
-
5 .3 litres for the "very cold climate" versions.
- 2 .2 litres for other versions.
Fluid specification
The screenwash fluid must be topped up with a
ready for use mix.
7
Practical information

191
Particle filter (Diesel)
orThe start of saturation of the particle
filter is signalled by the temporary
illumination of this warning lamp
accompanied by a message warning
of the risk of the filter clogging up.
Traffic conditions permitting, regenerate
the filter by driving at a speed of at least
37
mph (60 km/h) until the warning lamp
goes off.
If the warning lamp stays on, this indicates
a low Diesel additive level.
For more information on Checking levels ,
refer to the corresponding section.
Manual gearbox
The gearbox does not require any
maintenance (no oil change).
Automatic gearbox
The gearbox does not require any
maintenance (no oil change).
Brake pads
Brake wear depends on the style
of driving, particularly in the case
of vehicles used in town, over short
distances. It may be necessary to
have the condition of the brakes
checked, even between vehicle
services.
Unless there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake
pads are worn.
Brake disc wear
For all information on checking
brake disc wear, contact a CITROËN
dealer or a qualified workshop. This system must be checked by a CITROËN
dealer or a qualified workshop.
Parking brake
If excessive travel or a loss of
effectiveness of this system is
noticed, the parking brake must
be adjusted, even between two
services.
On a new vehicle, the first particle
filter regeneration operations may be
accompanied by a "burning" smell, which
is per fectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at the
exhaust on acceleration. This does not
affect the behaviour of the vehicle or the
environment.
Electric parking brake
This system does not require any
specific check. However, in the
event of a problem, have the system
checked by a CITROËN dealer or a
qualified workshop.
For more information on the Electric
parking brake , refer to the corresponding
section.
Wheels and tyres
The pressure must be checked on
all tyres, including the spare wheel,
when the tyres are "cold", at least
once a month and before a long
j o u r n ey.
7
Practical information

199
The speed limit sticker must be secured
to the interior of the vehicle in the driver's
field of vision, to remind you that a wheel
is in temporary use.Take care, the sealant product is harmful
if swallowed and causes irritation to the
eyes.
Keep this product out of the reach of
children.
The use-by date of the fluid is marked on
the bottle.
After use, do not discard the bottle in
standard waste, take it to a CITROËN
dealer or an authorised waste disposal
site.
Do not forget to obtain a new bottle of
sealant, available from a CITROËN dealer
or a qualified workshop.
Checking/adjusting tyre
pressures
You can also use the compressor,
without injecting sealant, to check and, if
necessary, adjust the tyre pressures.
F

R
emove the valve cap from the tyre and
place it in a clean area.
F

U
ncoil the pipe stowed under the
compressor.
The tyre inflation pressures are given on
this label.
F

S

witch on the ignition.
F

S

tart the compressor by turning the switch
to the " l" position until the pressure of the
tyre reaches 2.0

bars. The sealant product
is injected under pressure into the tyre;
do not disconnect the pipe from the valve
during this operation (risk of blowback). If a pressure of 2

bars is not reached
after about 7

minutes, this indicates
that the tyre is not repairable; contact a
CITROËN dealer or a qualified workshop
for assistance.
F

P

lace the switch in the "
O" position.
F

D

isconnect the compressor's electric plug
from the vehicle's 12

V socket.
F

R

eplace the cap on the valve.
F

R

emove the kit.
F

R

emove and then store the bottle of sealant.
Do not exceed the speed of 50 mph
(80
k
m/h) when driving with a tyre repaired
using this type of kit.
F

D
rive immediately for approximately three
miles (five kilometres), at reduced speed
(between 12 and 37 mph (20 and 60 km/h)),
to plug the puncture.
F

S
top to check the repair and measure the
tyre pressure using the kit.
8
In the event of a breakdown

227
AABS ........................................................................\
.... 94
Accessories ........................................................ 91,
1 25
Access to the 3rd row
................................................. 61
Access to the spare wheel

......................................2

01
Active Safety Brake
.................................... 18,

15
6 -15 8
AdBlue
® ................................................. 23, 31, 19 2-193
AdBlue® tank ............................................................ 193
Additive, Diesel ................................................... 21,
19 1
Adjusting headlamp beam height
............................. 87
Ad

justing head restraints
.......................................... 62
Ad

justing seats
.................................................... 56,


61
Ad

justing the air distribution .................................71
-7

2
Adjusting the air flow


............................................ 71
-7

2
Adjusting the date
........................................... 36,


17,


32
A

djusting the height and reach of the steering wheel


......................................................... 53
Adjusting the lumbar support


.................................... 56
Adjusting the temperature
.................................... 71-7

2
Adjusting the time
.......................................... 36,


17,


33
Adv

anced Grip Control ......................................... 97
-
9
8
Advice on driving


.............................................. 120 -121
Airbags


............................................... 19,

10
3,

10
5,

10
7
Airbags, curtain
............................................... 10

5,

10
8
Airbags, front


..................................... 104 -105,

10
7-108
Airbags, lateral


................................................. 104 -105
Air conditioning


.............................................. 71,

72,


75
A

ir conditioning, automatic

....................................... 79
Air conditioning, dual-zone automatic


.................71
-7

2
Air conditioning, electronic (with display screen)
...... 75
A

ir conditioning, manual

..........................70
-71,


74,


79
A

ir intake

............................................................... 71
-7

3
Alarm


.................................................................... 49,

51
A

nti-lock braking system (ABS) ................................94
Anti-slip regulation (ASR)


......................................... 94
Anti-theft/Immobiliser


.............................................. 126
Apple CarPlay connection


................................... 12,

18
A

rmrest

...................................................................... 57
Armrest, front


............................................................. 63
Assistance, emergency braking


.......................94,

15
8
Assistance call ...................................................... 92 -9 3
Audio streaming (Bluetooth) ........................9,
9,
2 5- 26
BBattery .............................................. 185, 19 0, 21 3 -216
Battery, 12 V .............................................................213
Battery, charging
...................................................... 2

15
Battery, remote control


..................................44
-45,


78
B

lind spot detection

......................................... 162,

16
4
BlueHDi
.............................................................. 31,


19
6
Bluetooth (hands-free)


...................1 0
-11,


1
3
-
14,

2
7 -
2
8
Bluetooth (telephone)


................................13
-

15,

2
7 -
2
8
Bonnet


............................................................... 18 6 -187
Boot lid
................................................................. 40,

43
B

rake discs

....................................................... 191-192
Brake lamps


............................................................. 209
Brakes


......................................................... 14,

19
1-192
Braking, automatic emergency


..................18,

15
6 -15 8
Braking, emergency


................................................ 129
Braking assistance system


.......................................94
Brightness


................................................................... 16
Bulbs


........................................................................\
205
Bulbs (changing)


............................................... 204-206
Bulbs (changing, type)
............................................. 20

5
CCable, audio ............................................................... 25
Cable, Jack ................................................................ 25
C
ap, fuel filler .................................................... 18 0 -181
Capacity, fuel tank


............................................ 18 0 -181
CD


...................................................................... 9,

9,


25
C

D, MP3
............................................................ 9,


9,


25
C

entral locking

..................................................... 38,

40
C

hanging a bulb
............................................... 20

4-208
Changing a fuse
................................................ 21

1-213Changing a wheel
.....................................
19
6 -197
,
20
0
Changing a wiper blade

.......................................
88
-89
C
hanging the remote control battery ........................
44
Charger, wireless ....................................................... 66
Checking the engine oil level

....................................
30
Checking the levels

..........................................
187-189
Checking tyre pressures (using the kit)

...........
197-19 9
Checks

......................................................
187,
19
0 -192
Checks, routine ................................................. 19 0 -192
Child lock

..................................................................
11 9
Child lock, electric

....................................................
11 9
Children

......................................................
113,
11
5 -117
Children (safety)
....................................................... 11
9
Child seats

...........
102-103 ,
10
6 -107
,
111
,

11
3
,
11
6 -11 8
Child seats, conventional
......................................... 111
C
hild seats, i-Size ....................................................
117
Child seats, ISOFIX

...........................................
115 -117
CITROËN Connect Nav ...............................................
1
CITROËN Connect Radio
............................................ 1
Cl
osing the doors

................................................
38,
40
C
ollision Risk Alert
.....................................
18,

15
6 -157
Configuration, vehicle

...............................................
29
Connection, Bluetooth ..............11,
1
3
-
15
,
21-2
2
,
2
7 -
2
8
Connection, MirrorLink ....................................11
-1
2
,
19
C
onnection, Wi-Fi network

.......................................
22
Control, back-up boot release ..................................
43
Control, back-up door release ...................................
42
Control, heated seats
................................................ 58
C
ontrol stalk, lighting

...........................................
81,
83
C
ontrol stalk, wipers .............................................
87 -9 0
Cour tesy lamp, front ..................................................80
Cour tesy lamp, rear
...................................................80
Courtesy lamps
......................................................... 80
C

over, luggage

..........................................................69
Cruise control


............................142,

1
4 5 -151,

15
4 -15 6
Cruise control, adaptive


...................................148 -149
Cruise control, adaptive with Stop function ........................................... 142,

1
4 8 -151,

15
4
Cruise control by speed limit recognition


................142
Cup holder
................................................................. 63
.
Alphabetical index