2018 Ram 4500 Chassis Cab transmission fluid

4. Fully apply the parking brake and press the brake pedal.
5. Place the gear selector momentarily into each gearposition (allowing time for the transmission to fully
engage in each position), ending with the transmission
in PARK.
6. Wipe the area around the dipstick clean to prevent dirt from entering the transmission.
7. Remove the dipstick, wipe it clean and reinsert it until seated.
8. Remove the dipstick again and note the fluid level on both sides. The fluid level reading is only valid if there
is a solid coating of oil on both sides of the dipstick.
Note that the holes in the dipstick will be full of fluid if
the actual level is at or above the hole. The fluid level
should be between the “HOT” (upper) reference holes
on the dipstick at normal operating temperature. If the
fluid level is low, add fluid through the dipstick tube to
bring it to the proper level. Do not overfill.Use ONLY
the specified fluid (see Fluids, Lubricants, and Genuine
Parts for fluid specifications). After adding any quan-
tity of oil through the dipstick tube, wait a minimum of
two minutes for the oil to fully drain into the transmis-
sion before rechecking the fluid level. NOTE:If it is necessary to check the transmission
belowthe
operating temperature, the fluid level should be between the
two “COLD” (lower) holes on the dipstick with the fluid at
60-70°F / 16-21°C for 66RFE transmission, or 68-86°F /
20-30°C for AS66RC transmission. Only use the COLD region
of the dipstick as a rough reference when setting the fluid
level after a transmission service or fluid change. Re-check
the fluid level, and adjust as required, once the transmission
reaches normal operating temperature.
CAUTION!
If the fluid temperature is below 50°F (10°C) it may not
register on the dipstick. Do not add fluid until the
temperature is elevated enough to produce an accurate
reading. Run the engine at idle, in PARK, to warm the
fluid.
9. Reinsert the dipstick. Check for leaks. Release the park- ing brake.
NOTE:
To prevent dirt and water from entering the transmis-
sion after checking or replenishing fluid, make sure that the
dipstick cap is properly reseated. It is normal for the dipstick
cap to spring back slightly from its fully seated position, as
long as its seal remains engaged in the dipstick tube.
8
SERVICING AND MAINTENANCE 391

Fluid And Filter Changes
Refer to the “Maintenance Plan” for the proper mainte-
nance intervals.
In addition, change the fluid and filters if the fluid becomes
contaminated (with water, etc.), or if the transmission is
disassembled for any reason.
Rear Axle And 4x4 Front Driving Axle Fluid Level
For models with 9.25 in Front Axles and 11.5 in Rear Axles,
refer to “Fluids And Lubricants” in “Servicing And Main-
tenance” for further information. For normal service, peri-
odic fluid level checks are not required. When the vehicle is
serviced for other reasons, the exterior surfaces of the axle
assembly should be inspected.
When checking the fluid level (4500/5500 only), the vehicle
should be in a level position. The fluid level should be ¼ in
± ¼ in (6.4 mm ± 6.4 mm) below the fill hole on the front
axle. The fluid level should be level with the bottom of the
fill hole on the rear axle.
Drain And Refill
On 4500/5500 vehicles, remove the lower bolt to drain the
axle fluid.
Refer to “Scheduled Servicing” in this chapter for the
proper maintenance intervals.
4500/5500 Rear Axle Plugs
1 — 4500/5500 Rear Axle Fluid Fill Plug
2 — 4500/5500 Rear Axle Fluid Drain Plug
392 SERVICING AND MAINTENANCE

Chassis
ComponentFluid, Lubricant, or Genuine Part
Automatic Transmission (6.4L Engine with 66RFE
Transmission) (For Diesel Engine See Diesel Supple-
ment) Use only ATF+4 Automatic Transmission Fluid. Failure to use
ATF+4 fluid may affect the function or performance of your
transmission. We recommend Mopar ATF+4 fluid.
Automatic Transmission (6.4L Engine with AS66RC
Transmission) Use only Mopar ASRC Automatic Transmission Fluid or
equivalent. Failure to use the proper fluid may affect the
function or performance of your transmission.
Transfer Case We recommend you use Mopar BW44-44 Transfer Case Fluid.
Front and Rear Axle Fluid (4500/5500) We recommend you use GL-5 SAE 75W-90 Synthetic (MS-9763).
Limited slip additive is not required for Limited-Slip Rear
Axles.
Brake Master Cylinder We recommend you use Mopar DOT 3 and SAE J1703. If DOT
3 brake fluid is not available, then DOT 4 is acceptable.
Power Steering Reservoir We recommend you use Mopar Power Steering Fluid +4,
Mopar ATF+4 Automatic Transmission Fluid.
9
TECHNICAL SPECIFICATIONS 437

Adding Engine Coolant (Antifreeze).............385
Adding Fuel ............................. .289
Additives, Fuel ........................ .290, 430
Adjust Down .............................. .46, 48
Forward ............................ .46, 48
Rearward ........................... .46, 48
Up ................................ .46, 48
Adjustable Pedals ...........................59
Air Bag Air Bag Operation ....................... .200
Air Bag Warning Light .....................197
Enhanced Accident Response .............206, 355
Event Data Recorder (EDR) .................355
If A Deployment Occurs ....................205
Knee Impact Bolsters ..................... .201
Maintaining Your Air Bag System .............207
Transporting Pets ....................... .233
Air Bag Light ...................... .150, 197, 234
Air Bag Maintenance ....................... .207
Air Cleaner, Engine (Engine Air Cleaner Filter) ......368
Air Conditioner Maintenance ..................371
Air Conditioning ............................82
Air Conditioning Filter ....................97, 372
Air Conditioning, Operating Tips ................97Air Conditioning Refrigerant
...............371, 372
Air Conditioning System ...................96, 371
Air Filter ............................... .368
Air Pressure, Tires ......................... .405
Alarm, Panic ...............................22
Alarm (Security Alarm) ....................33, 151
Alarm System (Security Alarm) .................33
Alterations/Modifications, Vehicle ................7
Antifreeze (Engine Coolant) ...................385
Capacities ............................. .434
Disposal .............................. .387
Anti-Lock Brake System (ABS) .................164
Anti-Lock Warning Light .....................156
Ashtray ................................ .127
Assist,

Hill Start .......................... .166
Audio Systems (Radio) ...................... .441
Auto Down Power Windows ...................99
Automatic Door Locks ........................40
Automatic Headlights ........................72
Automatic High Beams .......................71
Automatic Temperature Control (ATC) ............96
Automatic Transmission Adding Fluid .......................... .391
Fluid And Filter Changes ...................392
Fluid Level Check .....................389, 390
512 INDEX

Fluid Type......................... .389, 437
Shifting .............................. .248
Special Additives ........................ .390
Axle Fluid ........................ .392, 393, 437
Axle Lubrication ....................... .392, 393
Back-Up ................................ .286
Back-Up Camera .......................... .286
Battery .............................. .152, 365
Charging System Light ....................152
Keyless Key Fob Replacement ................23
Belts, Seat ............................... .234
Body Builders Guide ..........................7
Body Mechanism Lubrication ..................379
B-Pillar Location .......................... .400
Brake Assist System ........................ .166
Brake Control System, Electronic ................165
Brake Fluid .......................... .388, 437
Brake System ......................... .388, 426
Fluid Check ........................... .388
Master Cylinder ........................ .388
Parking .............................. .245
Warning Light .......................... .150
Brake/Transmission Interlock ..................248
Bulb Replacement ......................... .325Bulbs, Light
.......................... .236, 325
Cab Top Clearance Lights .....................330
Camera ................................ .286
Camera, Rear ............................ .286
Capacities, Antifreeze (Engine Coolant) ...........434
Capacities, Fluid .......................... .434
Caps, Filler Oil (Engine) ........................ .364, 368
Power Steering ......................... .269
Radiator (Coolant Pressure) .................386
Carbon Monoxide Warning ................233, 433
Cargo Light ...............................
75
Car Washes .............................. .421
Cellular Phone ........................... .486
Center High Mounted Stop Light ...............328
Center Seat Storage Compartment ...............113
Changing A Flat Tire ....................... .339
Chart, Tire Sizing .......................... .396
Check Engine Light (Malfunction Indicator Light). . . .160
Checking Your Vehicle For Safety ...............233
Checks, Safety ............................ .233
Child Restraint ........................... .208
Child Restraints Booster Seats ........................... .212
12
INDEX 513

Exterior Lights......................... .69, 236
Filters Air Cleaner ............................ .368
Air Conditioning ..................... .97, 372
Engine Fuel ........................... .435
Engine Oil ......................... .368, 435
Engine Oil Disposal ...................... .368
Flashers Turn Signal ...................... .75, 158, 236
Flash-To-Pass ..............................72
Flat Tire Stowage .......................... .344
Flooded Engine Starting ..................... .243
Fluid, Brake ............................. .437
Fluid Capacities ........................... .434
Fluid Leaks .............................. .236
Fluid Level Checks Automatic Transmission ....................390
Brake ................................ .388
Power Steering ......................... .269
Fluids And Lubricants ...................... .435
Fog Lights ......................... .74, 157, 328
Fold Flat Load Floor ........................117
Folding Rear Seat ...........................43
Four-Way Hazard Flasher .....................320 Four Wheel Drive
......................... .257
Freeing A Stuck Vehicle ..................... .350
Front Axle (Differential) ..................... .392
Fuel ................................... .429
Adding .............................. .289
Additives .......................... .290, 430
Clean Air ............................. .430
Ethanol .............................. .431
Filler Cap (Gas Cap) ..................... .290
Filter ................................ .435
Gasoline .............................. .429
Light ................................ .156
Materials Added ..................... .290, 430
Methanol ............................. .431
Octane

Rating .......................... .429
Requirements .......................... .429
Tank Capacity .......................... .434
Fuses .................................. .331
Garage Door Opener (HomeLink) ............102, 108
Gas Cap (Fuel Filler Cap) .....................290
Gasoline, Clean Air ........................ .430
Gasoline, Reformulated ..................... .430
Gear Ranges ............................. .249
Gear Select Lever Override ....................349
516 INDEX

Passing................................72
Seat Belt Reminder ...................... .150
Security Alarm ......................... .151
Service ............................... .325
Tire Pressure Monitoring (TPMS) ..........155, 176
Traction Control ........................ .172
Transfer Case .......................... .260
Turn Signal ....................75, 158, 236, 326
Warning (Instrument Cluster Description) . . . .151, 158
Limited-Slip Differential ..................265, 393
Loading Vehicle ........................... .290
Tires................................. .400
Load Shed Battery Saver Mode ...................... .148
Battery Saver On ........................ .148
Electrical Load Reduction ...................148
Intelligent Battery Sensor ...................148
Locks Automatic Door ..........................40
Child Protection ..........................41
Power Door .............................37
Low Tire Pressure System .....................176
Lubrication, Body ......................... .379
Lug Nuts ............................ .343, 427Maintenance Free Battery
.....................365
Maintenance Schedule ...................... .359
Malfunction Indicator Light (Check Engine) . . . .153, 160
Manual, Service ........................... .510
Manual Transmission Fluid Level Check ....................... .393
Memory Feature (Memory Seat) .................43
Memory Seat ........................... .43, 48
Memory Seats And Radio .....................43
Methanol ............................... .431
Mirrors ..................................60
Electric Powered ..........................63
Heated .................................67
Memory ................................48
Outside ................................62
Rearview ...................... .60, 61, 62, 320
Trailer Towing ...........................67
Modifications/Alterations,
Vehicle................7
Monitor, Tire Pressure System ..................176
Mopar Parts ............................. .509
Multi-Function Control Lever ...................71
Navigation System (Uconnect GPS) ..............286
New Vehicle Break-In Period ..................244
12
INDEX 519

Load Capacity...................... .400, 401
Pressure Monitor System (TPMS) .............176
Pressure Warning Light ....................155
Quality Grading ........................ .418
Radial ............................... .406
Replacement ........................... .409
Rotation .............................. .416
Safety ............................ .394, 404
Sizes ................................ .396
Snow Tires .............................411
Spare Tire ...........................411,413
Spinning .............................. .407
Trailer Towing .......................... .301
Tread Wear Indicators .....................408
Wheel Nut Torque ....................343, 427
Tire Safety Information ...................... .394
Tongue Weight/Trailer Weight .................299
To Open Hood ........................... .101
Torque Converter Clutch .....................256
Towing ............................. .292, 352
Disabled Vehicle ........................ .352
Guide ................................ .299
Recreational ............................311
Weight ............................... .299
Towing Vehicle Behind A Motorhome ............311Traction
................................ .316
Traction Control .......................... .168
Trailer Sway Control (TSC) ....................173
Trailer Towing ............................ .292
Cooling System Tips ..................... .308
Hitches ............................... .298
Minimum Requirements ....................300
Mirrors ................................67
Tips ................................. .307
Trailer And Tongue Weight ..................299
Wiring ............................... .306
T

railer Towing Guide ....................... .299
Trailer Weight ............................ .299
Transfer Case ............................ .393
Electronically Shifted ..................... .260
Fluid ................................ .437
Transmission Automatic ......................... .248, 389
Fluid ................................ .437
Maintenance ........................... .389
Shifting .............................. .246
Transporting Pets ......................... .233
Tread Wear Indicators ...................... .408
Turn Signals ....................... .75, 158, 326
524 INDEX