2018 FORD TRANSIT CONNECT air filter

Transmission:all internal parts, clutch cover, seals and gaskets, torque
converter, transfer case (including all internal parts), transmission case,
transmission mounts; Front-Wheel Drive: axle shafts, front bearings,
seals and gaskets, universal and constant velocity joints; Rear-Wheel
Drive:axle shafts, rear bearings, center support bearing, drive axle
housing (including all internal parts), drive shaft, retainers, supports,
seals and gaskets, universal and constant velocity joints.
Four-Wheel/All-Wheel Drive: axle shafts, bearings (front and rear),
center support bearing, drive shafts, final drive housing (including all
internal parts), hubs-automatic front locking (four-wheel drive), locking
rings (four-wheel drive), seals and gaskets, universal and constant
velocity joints.
(2) Your vehicle’s safety belts and air bag Supplemental Restraint System
(SRS) are covered for an extended Safety Restraint Coverage Period,
which lasts for five years or 60,000 miles, whichever occurs first.
(3) Your vehicle’s body sheet metal panels are covered for an extended
Corrosion Coverage Period, which lasts for five years, regardless of miles
driven. The extended warranty coverage only applies if a body sheet
metal panel becomes perforated due to corrosion during normal use due
to a manufacturing defect in factory-supplied materials or factory
workmanship. If aluminum body panels have corrosion or rust damage,
and the damage is not the result of abnormal usage, vehicle accident,
customer actions and/or extreme environmental conditions, the corrosion
or rust damage repairs are covered for 5 years, unlimited miles. For
damage caused by airborne material (environmental fallout) where there
is no factory-related defect involved and therefore no warranty our
policy is to provide free repair of paint damage due to the airborne
material for 12 months or 12,000 miles, whichever occurs first.
(4) Your vehicle’s direct injection diesel engine and certain engine
components are covered during the PowerStroke Diesel Engine Coverage
Period, which lasts for five years or 100,000 miles, whichever occurs
first. The following parts are covered during this extended coverage
period: the engine, cylinder block, heads and all internal parts, intake
and exhaust manifolds, timing gear, harmonic balancer, valve covers, oil
pan and pump, water pump, fuel system (excluding fuel lines, fuel tank
and frame mounted fuel conditioning module sometimes referred to as
the frame mounted pump/filter/water separator or frame mounted fuel
filter/water separator), high pressure lines, gaskets and seals, glow plugs,
turbocharger, two-stage turbocharger assembly, turbocharger actuator,
11

Maintenance/Wear
The New Vehicle Limited Warranty does not cover: (1) parts and labor
needed to maintain the vehicle; and (2) the replacement of parts due to
normal wear and tear. You, as the owner, are responsible for these items. See
your Owner’s Manual. Some examples of maintenance and normal wear are:
•oil changes
• oils, lubricants, other fluids
• oil/air filters
• tire rotation/inflation
• cleaning/polishing •
clutch linings
• wiper blades*
• wheel alignments and tire
balancing*
• brake pad/lining*
* Ford will replace or adjust certain maintenance items when necessary,
free of charge during a limited period:
• Wiper blade replacements will be provided during the first six months
in service, regardless of miles driven.
• Wheel alignments and tire balancing will be provided during the first
12 months or 12,000 miles in service, whichever occurs first.
• Brake pad/lining replacements will be provided during the first
12 months or 18,000 miles in service, whichever occurs first.
SYNC Hands-Free Communications and Entertainment System
If your vehicle is equipped with SYNC, the New Vehicle Limited Warranty
does not cover repairs under certain conditions, such as failure to
provide proper installation environment. The New Vehicle Limited
Warranty does not cover repairs of certain damage or loss, such as:
• Loss of personal recording media, software or data
• Loss, change, or discontinuation of functionality because of:
•system updates to Ford Motor Company software or lack of
compatibility with non-Ford Motor Company electronic devices
• non-Ford Motor Company software, or
• obsolescence of vehicle software or hardware
• lack of network coverage or availability
• Damage caused by:
•abnormal use such as insertion of foreign objects, fluid spillage
• unauthorized modification to alter functionality or capability
•
computer or internet viruses, bugs, or malware, such as worms,
Trojan Horses, cancelbots
14

WHAT IS COVERED?
For your vehicle if these parts contain an emissions-related defect, they
are covered by both the Emissions Defect Warranty and the Emissions
Performance Warranty.
•Air Flow Sensor
• Air/Fuel Feedback Control
System and Sensors
• Air Induction System
• Catalytic Converters (including
Selective Catalytic Reduction
and Diesel Oxidation Catalysts)
• Cold Start Enrichment System
(diesel only)
• Controls for Deceleration
(diesel only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System
(diesel only)
• Electronic Engine Control
Sensors and Switches
• Powertrain Control Module
(PCM)/Engine Control Module
(ECM)*
• Evaporative Emission Control
System
• Exhaust Gas Recirculation
(EGR) System
• Exhaust Manifold
• Exhaust Pipe
(Manifold to Catalyst)
• Fuel Filler Tube and Seal
(non-diesel only) •
Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control
Valve
• Heating Elements of Side
Mirrors and Back Windows
(3.0L Diesel F-150 only)
• Ignition Coil and/or Control
Module
• Intake Manifold
• Intercooler Assembly -
Engine Charger
• Malfunction Indicator Lamp
(MIL)/On-Board Diagnostic
(OBD) System
• PCV system and Oil Filler Cap
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Control Module
(TCM) and Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
20

WHAT IS COVERED?
If the parts on the following list contains a defect that affects emissions,
they are covered by the Defects Warranties.
•Air Flow Sensor
• Air/Fuel Feedback Control
System and Sensors
• Air Induction System
• Catalytic Converters (including
Selective Catalytic Reduction
and Diesel Oxidation Catalysts)
• Cold Start Enrichment System
(diesel only)
• Controls for Deceleration
(diesel only)
• Diesel Exhaust Fluid System
• Diesel Particulate Filter
• Electronic Ignition System
(diesel only)
• Electronic Engine Control
Sensors and Switches
• Powertrain Control Module
(PCM)/Engine Control Module
(ECM)*
• Evaporative Emission Control
System
• Exhaust Gas Recirculation
(EGR) System
• Exhaust Manifold
• Exhaust Pipe (Manifold to
Catalyst)
• Fuel Filler Tube and Seal
(non-diesel only) •
Fuel Injection System
• Fuel Injector Supply Manifold
• Fuel Tank (non-diesel only)
• Fuel Tank Pressure Control
Valve
• Heating Elements of Side
Mirrors and Back Windows
(3.0L Diesel F-150 only)
• Ignition Coil and/or Control
Module
• Intake Manifold
• Intercooler Assembly - Engine
Charger
• Malfunction Indicator Lamp
(MIL)/On-Board Diagnostic
(OBD) System
• PCV System and Oil Filler Cap
• Secondary Air Injection System
• Spark Control Components
• Spark Plugs and Ignition Wires
• Thermostat
• Throttle Body Assembly (MFI)
• Transmission Control Module
(TCM) and Solenoids
• Turbocharger Assembly
• Vacuum Distribution System
* Includes hardware and emissions related software changes only
26

COVERAGE FOR 2018 MODEL VEHICLES (GVWR OF 14,000 LBS. OR LESS) UNDER LONG TERM DEFECTS WARRANTY(Coverage for up to 7 years/70,000 miles, whichever first occurs)
Part Name
1.0L Fiesta
1.0L Focus
1.0L Ecosport
1.5 Fusion
1.5L Escape
1.6L Fiesta
2.0L Fusion
2.0L Focus
2.0L Ecosport
2.0L Taurus
2.0L Escape
2.0L Edge
2.3L Focus
2.3L Mustang
2.3L Explorer
2.5L Fusion
2.5L Escape
2.5L Transit Connect
2.7L Fusion
2.7L Edge
2.7L F-150
3.0L F-150 Diesel
3.2L Transit Diesel
3.3L F-150
3.5L Taurus
3.5L Edge
3.5L Flex
3.5L Explorer
3.5L Expedition
3.5L F-150
3.5L Transit
3.7L Taurus
3.7L Explorer
3.7L Transit
5.0L Mustang
5.0L F-150
5.2L Mustang
6.2L Econoline
6.2L F-Superduty
6.7L F-Superduty Diesel
6.8L Econoline
6.8L F-Superduty
6.8L Strip Chassis
Catalytic Converter X X X X X X X X XXXXXXXXXXXXXXXX XXX XXXXXXXXXXXXXXX
DEF Tank XX
Reductant Pump Assembly XXX
Catalyst and Particulate Filter Assembly XXX
Cylinder Head Temperature Sensor XX
Tube Air Cooler Inlet/Outlet XXTurbocharger Control Valve (Supercharger Bypass Actuator)
X
Cam Timing Assembly XXXXXXXX XXXXXXX XXXX XX XXX XXXXXXXXXXX XXX
Engine Variable Timing Assembly XXX
Engine Variable Camshaft Timing Solenoid XXXX
Crankshaft Position Sensor (CKP) XX X
Variable Camshaft Timing Assembly X X X X X X X X XXXXXXXXXX XX XXX XX XXXXXX
PCV Valve (Part of Rocker Cover Assembly) XXX X X X
Turbo to Manifold Gasket X
Charge Air Cooler Duct XX
Turbocharger XXXXXXXX(3) X XXXXXX XXXXX X(3) X X(3) X X X X
Charge Air Cooler X X(3) X X(3)
Valve Body XXX
Transmission Control Module Assembly X
Transmission Solenoid Assembly XXX X X
Fuel Tank XXXXXXXX XXXXXXXXXXXXX XX XXX XXXXXXXXXX XXX
Fuel Tank Filler Kit XX
EVAP Fuel Vapor Return Tube XX
Fuel Tube Supply X(3) X(3)
Fuel Supply Manifold Assembly XX X X XXXXXX XX XX X
Sensor to Rail Fuel Line X
Fuel Delivery Module XXX XX X X
Fuel Pump to Fuel Rail Tube X(3) X X(3)
Fuel Tube XX
Fuel Pump Assembly XX X X X
Turbocharger Control Solenoid X XX X(3) X X(3) X X
Intake Manifold XXXX X XX XXXXX XX
Exhaust Manifold XX XXX X X X X X X X XXXX X XX
Exhaust Manifold Outlet Pipe X
Resonator Assembly X
Intake Manifold Gasket X
Exhaust Manifold Gasket X XXXXXXXX XX XX XXX X
EGR out pipe gasket XX
27