2018 FORD F-650/750 catalytic converter

5. Federal requirements for emissions warranties
FEDERAL EMISSIONS DEFECT WARRANTY
Under the Federal Emissions Defect Warranty, Ford warrants to you, the
owner of any 2018-model F-650/F-750 truck that:
•Your truck or engine is designed, built, and equipped to conform, at
the time it is sold, with the emissions regulations of the U.S.
Environmental Protection Agency (EPA).
• Your truck or engine is free from emission-related defects in
factory-supplied materials and workmanship, which are defects that
could prevent the truck or engine from conforming with applicable
EPA regulations.
• You will not be charged for repair, replacement, or adjustment of parts
containing an emissions-related defect listed in the following What Is
Covered? section.
WHAT IS COVERED?
F-650/F-750 trucks are provided Federal Emissions Defect Warranty for
5 years or 50,000 miles (whichever occurs first) for gasoline engines and
5 years or 100,000 miles (whichever occurs first) for Ford diesel engines.
Trucks designated as a VOCATIONAL TRUCK on the driver’s door
VEHICLE EMISSION CONTROL INFORMATION label receive tire
warranty coverage for defects that affect compliance with greenhouse
gas requirements for 2 years/24,000 miles (whichever comes first). The
following is a general list of components that are covered by the Federal
Emissions Defect Warranty. If you would like more detailed information
concerning specific parts covered by Ford warranty, ask your dealer.
For F-650/F-750 trucks, the Ford warranty covers the following if they
are Ford parts:
• Air Induction System
• Catalytic Converter (including Selective Catalytic Reduction and Diesel
Oxidation Catalysts)
• Charge air cooler
• Diesel Exhaust Fluid (DEF) System
17

6. California requirements for emissions warranty
YOUR WARRANTY RIGHTS AND OBLIGATIONS
The California Air Resources Board and Ford are pleased to explain the
emission control system warranty on your 2018-model vehicle. In
California, new motor vehicles must be designed, built, and equipped to
meet the State’s stringent anti-smog standards. Ford must warrant the
emission control system on your vehicle for the periods of time listed
below, provided there has been no abuse, neglect, or improper
maintenance of your vehicle.
Your emission control system may include parts such as the carburetor
or fuel injection system, the ignition system, catalytic converter, and
engine computer. Also included may be hoses, belts, connectors, and
other emission-related assemblies.
Where a warrantable condition exists, Ford will repair your vehicle at no
cost to you including diagnosis, parts, and labor.
MANUFACTURER’S WARRANTY COVERAGE
F-650/F-750 trucks are provided California emissions warranty coverage
for 5 years or 50,000 miles (whichever first occurs) for gasoline engines
and 5 years or 100,000 miles (whichever first occurs) for diesel engines.
If an emissions-related part on your vehicle is defective, the part will be
repaired or replaced by Ford. This is your emission control system
Defects Warranty.
Vehicles Eligible For California Emissions Warranty Coverage
California emission warranty coverage applies if your vehicle meets the
following two criteria:
•Your vehicle is registered in California, Maine, New York (gasoline
only), or Pennsylvania and
• Your vehicle is certified for sale in California, as indicated on the
important engine information label.
19

OWNER’S WARRANTY RESPONSIBILITIES
As the vehicle owner, you are responsible for the performance of the
required maintenance listed in your owner’s manual. Ford recommends
that you retain all receipts covering maintenance on your vehicle, but
Ford cannot deny warranty coverage solely for the lack of receipts or for
your failure to ensure the performance of all scheduled maintenance.
You are responsible for presenting your vehicle to a Ford dealer as soon
as a problem exists. The warranty repairs should be completed in a
reasonable amount of time, not to exceed 30 days.
As the vehicle owner, you should also be aware that Ford may deny you
warranty coverage if your vehicle or a part has failed due to abuse,
neglect, improper maintenance, or unapproved modifications.
If you have questions regarding your warranty rights and responsibilities,
or if you want to report what you believe to be violations of the terms of
this warranty, you may contact the Fleet Customer Relationship Center
at 1-800-343-5338 or contact:
California Air Resources Board
9528 Telstar Avenue
El Monte, California 91731
WHAT IS COVERED?
F-650/F-750 trucks are provided California emissions Warranty Coverage for
5 years or 50,000 miles (whichever first occurs) for gasoline engines and 5
years or 100,000 miles (whichever first occurs) for Ford diesel engines. The
following is a general list of components that are covered by the California
Emissions Warranty. If you would like more detailed information concerning
specific parts covered by Ford warranty, ask your dealer.
For F-650/F-750 trucks the Ford warranty covers the following if they
are Ford parts:
•Air induction system
• Catalytic converter (including selective catalytic reduction and diesel
oxidation catalysts)
• Charge air cooler
20