2018 FORD E-450 fuse box

12 Volt DC Power Point
WARNING
Do not plug optional electrical
accessories into the cigar lighter
socket. Incorrect use of the cigar
lighter can cause damage not covered by
the vehicle warranty, and can result in fire
or serious injury. Note:
When you switch the ignition on, you
can use the socket to power 12 volt
appliances with a maximum current rating
of 15 amps.
If the power supply does not work after you
switch the ignition off, switch the ignition
on.
Note: Do not hang any accessory from the
accessory plug.
Note: Do not use the power point over the
vehicle capacity of 12 volt DC 180 watts or
a fuse may blow.
Note: Always keep the power point caps
closed when not in use.
Do not insert objects other than an
accessory plug into the power point. This
damages the power point and may blow
the fuse.
Run the vehicle for full capacity use of the
power point.
To prevent the battery from running out of
charge:
• Do not use the power point longer than
necessary when the vehicle is not
running.
• Do not leave devices plugged in
overnight or when you park your vehicle
for extended periods. Locations
Power points may be in the following
locations:
•
On the instrument panel.
• Inside the glove box.
• Behind the driver's seat, upper trim
panel.
110 Volt AC Power Point (If Equipped) WARNING
Do not keep electrical devices
plugged in the power point whenever
the device is not in use. Do not use
any extension cord with the 110 volt AC
power point, since it will defeat the safety
protection design. Doing so may cause the
power point to overload due to powering
multiple devices that can reach beyond
the 150 watt load limit and could result in
fire or serious injury. Note:
The power point turns off when you
switch the ignition off, or when the battery
voltage drops below 11 volts.
You can use the power point for electric
devices that require up to 150 watts. It is
on the rear of the center console. To gain access to the outlet contacts,
press the plug against the outlet and rotate
clockwise.
71
E-Series (TE4) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Auxiliary Power PointsE194174

FUSE SPECIFICATION CHART
Power Distribution Box
WARNINGS
Always disconnect the battery before
servicing high current fuses.
To reduce risk of electrical shock,
always replace the cover to the
power distribution box before
reconnecting the battery or refilling fluid
reservoirs. Note:
If your vehicle is equipped with dual
batteries, disconnecting the primary
under-hood battery does not remove power
from all circuits.
The power distribution box is in the engine
compartment. It has high-current fuses
that protect your vehicle's main electrical
systems from overloads.
If the battery has been disconnected and
reconnected, you will need to reset some
features. See Changing the 12V Battery
(page 151). Protected Components
Fuse Rating
Fuse or Relay
Number
Powertrain control module relay.
—
1
Starter solenoid relay.
—
2
Wiper relay.
—
3
Trailer tow battery charge relay.
—
4
Fuel pump relay.
—
5
Trailer tow park lamp relay.
—
6
129
E-Series (TE4) Canada/United States of America, enUSA, Edition date: 201712, Second Printing FusesE194305

Protected Components
Fuse Rating
Fuse or Relay
Number
Trailer tow stop lamp and direction indic-
ator lamps.
20A 2
48
Wiper motor.
30A 2
49
Not used.
—
50
Cutaway.
20A 2
51
Modified vehicle and stripped chassis run/
start relay coil.
10A 3
52
Anti-lock brake system run/start feed.
10A 3
53
Fuel pump relay coil.
10A 3
54
Not used.
—
55
Not used.
—
56
Trailer tow park lamp.
20A 3
57
Trailer tow back-up lamp.
15A 3
58
Not used.
—
59
Not used.
—
60
Not used.
—
61
Auxiliary switch #2 relay.
—
62
Trailer tow battery charge.
30A 2
63
Not used.
—
64
Power point 2 (glove box).
20A 2
65
Power point 3 (cutaway B+).
20A 2
66
Power point 1 (instrument panel).
20A 2
67
Modified vehicle.
50A 2
68
Not used.
—
69
132
E-Series (TE4) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Fuses

•
An authorized dealer needs to install
mobile communications systems.
Improper installation may harm the
operation of your vehicle, particularly
if the manufacturer did not design the
mobile communication system
specifically for automotive use.
• If you or an authorized Ford dealer add
any non-Ford electrical or electronic
accessories or components to your
vehicle, you may adversely affect
battery performance and durability. In
addition, you may also adversely affect
the performance of other electrical
systems in the vehicle.
AUXILIARY SWITCHES
For maximum vehicle performance, keep
the following information in mind when
adding accessories or equipment to your
vehicle:
• When adding accessories, equipment,
passengers and luggage to your
vehicle, do not exceed the total weight
capacity of the vehicle or of the front
or rear axle (GVWR or GAWR as
indicated on the Safety Compliance
Certification label). Ask an authorized
dealer for specific weight information.
• The Federal Communications
Commission (FCC) and Canadian
Radio Telecommunications
Commission (CRTC) regulate the use
of mobile communications systems
equipped with radio transmitters, for
example, two-way radios, telephones
and theft alarms. Any such equipment
installed in your vehicle should comply
with Federal Communications
Commission (FCC) and Canadian
Radio Telecommunications
Commission (CRTC) regulations, and
should be installed by an authorized
dealer. •
An authorized dealer needs to install
mobile communications systems.
Improper installation may harm the
operation of your vehicle, particularly
if the manufacturer did not design the
mobile communication system
specifically for automotive use.
• If you or an authorized Ford dealer add
any non-Ford electrical or electronic
accessories or components to your
vehicle, you may adversely affect
battery performance and durability. In
addition, you may also adversely affect
the performance of other electrical
systems in the vehicle. The auxiliary switch option package
provides four switches, mounted in the
center of the instrument panel. These
switches operate only when you switch the
ignition on, whether the engine is running
or not. Ford recommends, however, that
the engine remain running to maintain
battery charge when using the auxiliary
switches for extended periods of time or
higher current draws.
When switched on, the auxiliary switches
provide 10 amps, 15 amps or 30 amps of
electrical battery power for a variety of
personal or commercial uses.
The switches include the fuse and relay kit.
This kit contains the required fuses and
relays that an authorized technician needs
to install into the power distribution box,
located under the hood. Refer to the
instruction sketch included in the kit.
Contact an authorized dealer for service.
266
E-Series (TE4) Canada/United States of America, enUSA, Edition date: 201712, Second Printing AccessoriesE163431

Engine Specifications - 6.8L....................194
Drivebelt Routing................................................ 195
Environment......................................................13
Essential Towing Checks...........................107
Before Towing a Trailer....................................... 111
Hitches................................................................... 108
Launching or Retrieving a Boat or Personal Watercraft (PWC).......................................... 112
Safety Chains...................................................... 108
Trailer Brakes....................................................... 108
Trailer Lamps.......................................................... 111
Trailer Towing Connector................................. 107
When Towing a Trailer........................................ 112
Event Data Recording See: Data Recording............................................... 7
Exterior Mirrors................................................49 Fold-Away Exterior Mirrors............................... 49
Power Exterior Mirrors........................................ 49
Telescoping Mirrors ............................................ 50
F
Fastening the Seatbelts..............................26 Seatbelt Locking Modes.................................... 26
Using Seatbelts During Pregnancy................26
Flat Tire See: Changing a Road Wheel........................ 189
Floor Mats
.........................................................115
Ford Credit...........................................................9
US Only....................................................................... 9
Ford Protect..................................................268 Ford Protect Extended Service Plan
(CANADA ONLY).......................................... 269
Ford Protect Extended Service Plans (U.S. Only).................................................................. 268
Fuel and Refueling.........................................76
Fuel Consumption
.........................................80
Fuel Economy....................................................... 80
Fuel Quality - E85
..........................................76
Choosing the Right Fuel - Flex Fuel
Vehicles............................................................... 76
Switching Between E85 and Gasoline.........77
Fuel Quality - Gasoline.................................78 Choosing the Right Fuel..................................... 78
Fuel Shutoff
.....................................................118
Fuses.................................................................129
Fuse Specification Chart...........................129 Passenger Compartment Fuse Panel.........134 Power Distribution Box.....................................
129
G
Gauges................................................................51 Battery Voltage Gauge....................................... 52
Engine Coolant Temperature Gauge............52
Fuel Gauge............................................................... 51
Information Display............................................. 52
Gearbox See: Transmission............................................... 86
General Information on Radio Frequencies....................................................37
General Maintenance Information........270 Multi-point Inspection...................................... 272
Owner Checks and Services........................... 271
Protecting Your Investment........................... 270
Why Maintain Your Vehicle?.......................... 270
Why Maintain Your Vehicle at Your Dealership?..................................................... 270
Getting Assistance Outside the U.S. and Canada..........................................................125
Getting the Services You Need................122 Away From Home............................................... 122
H
Handbrake See: Parking Brake................................................ 91
Hazard Flashers
.............................................118
Headlamp Adjusting See: Adjusting the Headlamps...................... 153
Headlamp Removal See: Removing a Headlamp........................... 154
Headrest See: Head Restraints.......................................... 68
Head Restraints
..............................................68
Heating See: Climate Control.......................................... 64
Hints on Controlling the Interior Climate
............................................................65
Defogging the Side Windows in Cold
Weather.............................................................. 66
General Hints......................................................... 65
Quickly Cooling the Interior.............................. 66
Quickly Heating the Interior............................. 66
Recommended Settings for Cooling............66
Recommended Settings for Heating...........66
315
E-Series (TE4) Canada/United States of America, enUSA, Edition date: 201712, Second Printing Index