2018 FIAT 500 sunroof

39
ROOF 10) 5)
FIXED GLASS ROOF
(for versions/markets, where provided)
The large glazed roof includes a
transparent panel provided with
manually operated blinds. The blinds
can be used in the “all closed” or “all
open” positions (there are no
fixed intermediate positions).
❒ To open the blind: grip the handle
and press the catch A-fig. 31, then
release the blind and bring it to the
“all open” position.
To close it, repeat the same
operation in the opposite direction.
SUNROOF
(for versions/markets, where provided)
To move the blinds, follow the
instructions in “fixed glass roof”
Opening the sunroof
❒ Keep the button A-fig. 32 pressed:
the sunroof will move to “spoiler”
position.
To fully open the sunroof press
button A again and hold it down: the
sunroof will stop in the position
reached when the button is
released.
32DVDF0S018c
Closing the sunroof
❒ Keep the button B-fig. 32 pressed:
the sunroof will move to “spoiler”
position.
The sunroof will stop in the position
reached when the button is
released. Press button B again and
hold it down until the sunroof is
completely closed.
Anti-pinch device
❒
The sunroof has an anti-pinch safety
system capable of detecting the
presence of an obstacle whilst the
sunroof is closing. When this
happens, the system stops and the
movement of the sunroof is
immediately reversed.
Initialisation procedure
The sunroof must be re-initialised after
disconnecting the battery or if the
relevant protection fuse is blown.
Proceed as follows:
❒ keep the button A fig. 32 pressed
so that the sunroof closes
completely in stages
❒ after full closing, wait for the sunroof
motor to stop.
31DVDF0S017c

KNOWING YOUR CAR
40
Emergency manoeuvre
If the control buttons fail to operate, the
sunroof can be moved manually,
proceeding as described below:
❒ remove the protective cap A-fig. 33
located on the internal covering,
behind the blinds;
❒ take the Allen key (provided as
standard) from the toolbox in the
boot;
❒ fit the Allen key in position B and
turn it:
– clockwise, to open the roof;
– anticlockwise, to close the roof.
33DVDF0S019c
SOFT TOP 10), 11) 6)
❒ The soft top can be opened/closed
through buttons A or B-fig. 34,
located near the ceiling light.
it is advisable to close the soft top
when the car is parked.
The closed top effectively protects the
car from rain and from theft.
IMPORTANT: the motor may overheat
if the soft top is repeatedly operated
within a short space of time, thus
causing the overheating protection to
inhibit system operation. Wait for a
minute and repeat.
Opening from initial position: all
closed soft top
❒ Pressing the one-touch button
A-fig. 34 once the soft top opens
automatically to the horizontal
opening position (spoiler position -
see fig. 35).
❒ If one of the two buttons is pressed
before reaching the stop position,
the top may stop in an intermediate
horizontal opening position.
35DVDF0S174c
34DVDF0S020c

IN AN EMERGENCY
142
FuseAmpereDescription
F13 5 •
Left dipped headlight and headlight alignment control unit power supply
F36 15 Diagnosis socket, radio, climate control, EOBD
F37 5 Brake light switch, instrument panel node
F38 15 Central door locking
F43 15 Windscreen/rear window washer pump
F47 20 Driver’s side power window
F48 20 Passenger’s side power window
F49 5 Parking sensor, control backlighting, electric mirrors
F51 7.5 Climate control, brake lights, clutch, sunroof, electric mirrors
F53 5 Instrument panel node
•
For versions/markets, where provided
ENGINE COMPARTMENT
JUNCTION BOX
The fuse box is located on the right
side of the engine compartment.
To access the fuses, proceed as
follows:
❒ Fully press the screw A fig. 130;
❒ at the same time slowly rotate the
screw anticlockwise, until resistance
is encountered (do not overtighten);
❒ slowly release the screw;
❒ opening is indicated by the entire
screw head coming out of its
housing;
❒ remove cover B, sliding it upwards
on the side guides, as indicated in
the figure.
❒ after replacing the fuse, refit the
cover, making sure that it is closed
properly.
130DVDF0S0201c

143
LPG versions
The LPG system components are
protected by specific fuses.
Contact a Fiat Dealership for
replacement.
The number identifying the electrical
component corresponding to each
fuse is shown on the cover fig. 131.
FuseAmpereDescription
F02 20 Hi-Fi
F08 30 Climate control system fan
F09 30 Headlight washers
F10 10 Horns
F14 15 Main beam headlights
F15 20 Electric sunroof motor
F16 7.5 Dualogic gearbox control unit power supply
(+ignition)
F20 30 Heated rear window
F30 15 Fog lights
F84 10 Dualogic gearbox control unit
F85 20 Front power socket
(with or without cigar lighter)
131DVDF0S0202c

SERVICING AND CARE
162
❒ lower the cover.
WINDSCREEN WASHER
NOZZLES
If the jet of fluid is inadequate, firstly
check that there is fluid in the reservoir
(see “Checking levels” in this chapter).
Then check that the nozzle holes are
not clogged; use a needle to unblock
them if necessary.
The windscreen jets are directed by
adjusting the angle.
The jets should be directed at about a
third of the height from the top edge of
the windscreen fig. 146.
145DVDF0S0130c
IMPORTANT In versions with sunroof,
make sure that the sunroof is closed
before operating the front jets.
REAR WINDOW WASHER
NOZZLE
The rear window washer jets are fixed.
The nozzle holder is located above the
rear window fig. 147.
146DVDF0S0131c
147DVDF0S0132c
BODYWORK
ADVICE FOR
PRESERVING THE
BODYWORK
Paint
Paintwork does not only serve an
aesthetic purpose, but also protects the
underlying sheet metal. Normal care for
paintwork consists of washing the car;
how often depends on the conditions
and environment where the car is used.
For example, in highly polluted areas, or
if the roads are spread with salt, it is
advisable to wash the car more
frequently.
IMPORTANT Bird droppings should be
washed off immediately and thoroughly
as the acid they contain is particularly
aggressive.
Versions with matt paintwork
These versions have exclusive matt
paintwork which requires special care
for its preservation.

177
Unladen weight (with all fluids,
fuel tank 90% full and
without optional equipment): 865 905 930/940  970/980  940 980
Payload
 including the driver: 475 445 440 415 440 415
Maximum
permitted loads
– front axle: 770 770 830 830 830 830
– rear axle: 640 640 640 640 640 640
– total: 1340 1350 1370/1380  1385/1395  1380 1395
Towable loads
with braked trailer: 800 800 800 800 800 800
trailer without brakes: 400 400 400 400 400 400
Maximum load on the tow hook
with braked trailer: 60 60 60 60 60 60
Weights (kg)
0.9 TwinAir
60 HP*- 65 HP0.9 TwinAir 105 HP
If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
Loads not to be exceeded. The driver is responsible for arranging goods in the luggage compartment and/or load platform within the
maximum permitted loads.
Dualogic versions.
* For versions/markets, where provided
0.9 TwinAir 80 HP*- 85 HP
WEIGHTS

TECHNICAL DATA
178
Unladen weight (with all fluids,
fuel tank 90% full and
without optional equipment): 865/900  905/940  865 905 930/940  970/980 
Payload  including the driver: 480/450  450/420  480 450 440 415
Maximum
permitted loads
– front axle: 770 770 770 770 830 830
– rear axle: 640 640 640 640 640 640
– total: 1345/1350  1355/1360  1345 1355 1370/1380  1385/1395 
Towable loads
with braked trailer: 800 800 800 800 800 800
trailer without brakes: 400 400 400 400 400 400
Maximum load on the tow hook
with braked trailer: 60 60 60 60 60 60
Weights (kg)
1.2 8V 69 HP
If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
Loads not to be exceeded. The driver is responsible for arranging goods in the luggage compartment and/or load platform within the
maximum permitted loads.
Dualogic versions.
* For versions/markets, where provided
1.4 16V 100 HP*1.2 8V 69 HP EVO2 S&S

179
Unladen weight (with all fluids,
fuel tank 90% full and
without optional equipment): 980 1020 865
Payload
including the driver: 440 415 480
Maximum permitted loads
– front axle: 830 830 770
– rear axle: 640 640 640
– total: 1420 1435 1345
Towable loads
with braked trailer: 800 800 –
trailer without brakes: 400 400 –
Maximum load on the tow hook
with braked trailer: 60 60 60
Weights (kg)1.3 16V 78 HP / 95 HP EURO 61.2 8V
69 HP LPG
If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
Loads not to be exceeded. The driver is responsible for arranging goods in the luggage compartment and/or load platform within the
maximum permitted loads.
Dualogic versions.
* For versions/markets, where provided