2018 CITROEN C4 oil filter

8
C4-cactus_en_Chap00b_vue-ensemble_ed01-2016
Running out of fuel, Diesel 
( priming   pump)  2 18
AdBlue
® additive and SCR system (
BlueHDi   Diesel)  1 75 -181
Maintenance - Technical data
Checking levels 1 70 -172
- oil
-
 
b
rake   fluid
-


coolant
-

s
creenwash fluid
-

a
dditive (Diesel with particle filter)
Checking
  components  
1
73 -174
-


battery
-
 
a
ir   /   passenger   compartment   filter
-

o
il filter
-

p
article filter (Diesel)
-
 
b
rake   pads   /   discs
Changing
 bu

lbs
 1
97-204
-
 
f
ront   lamps
-
 
r
ear   lamps
-
 i

nterior
 l
ighting Dimensions
 2

23
Identification
 ma

rkings
 2
24
Petrol
  weights  
2
20
Diesel   weights  
2
22
Opening   the   bonnet  
1
67
Under the bonnet, petrol

1
68
Under
  the   bonnet,   Diesel  
1
69
Petrol
  engines  
2
19
Diesel
  engines  
2
21
12V
  battery  
2
12-215
Load   reduction,   economy   mode  
1
60
Engine
 c
ompartment
 
f
uses  
2
05 -206,   210 -211
Over view

10
C4-cactus_en_Chap00c_eco-conduite_ed01-2016
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the bottom   of   the   boot,   as   close   as   possible   to   the   rear   seats.
Limit
  the   loads   carried   in   the   vehicle   and   reduce   wind   resistance   (roof  
b

ars,   roof   rack,   bicycle   carrier,   trailer...).   Use   a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your   summer   tyres.
Observe the recommendations on
maintenance
Check the tyre pressures regularly, when cold, referring to the label in the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
b
efore   a   long   journey,
-
 
a
t   each   change   of   season,
-
 
a
fter   a   long   period   out   of   use.
Don't
  forget   the   spare   wheel   and   the   tyres   on   any   trailer   or   caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,   air   filter,  
p

assenger   compartment   filter...)   and   observe   the   schedule   of  
o

perations   in   the   personalised   servicing   schedule   for   your   vehicle.
With
  a   BlueHDi   Diesel   engine,   if   the   SCR   system   develops   a   fault,  
y

our   vehicle   becomes   polluting;   go   to   a   CITROËN   dealer   or   a   qualified  
w

orkshop   without   delay   to   have   the   emissions   of   nitrous   oxides   brought  
w

ithin   the   limits   set   by   the   directive.
When
  refuelling,   do   not   continue   after   the   third   cut-off   of   the   nozzle   to  
a

void   any   over flow.
At
  the   wheel   of   your   new   vehicle,   it   is   only   after   the   first   1   800   miles  
(3
  000   kilometres)   that   you   will   see   the   fuel   consumption   settle   down   to  
a

  consistent   average.
Eco-driving

168
C4-cactus_en_Chap07_info-pratiques_ed01-2016
1. Screenwash  fluid   reservoir.
2. C oolant   header   tank.
3.
 B

rake   fluid   reservoir.
4.
 B

attery.
5.
 F

usebox.
6.
 A

ir   filter.
7.
 E

ngine   oil   dipstick.
8.
 E

ngine   oil   filler   cap.
9.
 R

emote   earth   point.
Petrol engines
Practical information

169
C4-cactus_en_Chap07_info-pratiques_ed01-2016
1. Screenwash  fluid   reservoir.
2. C oolant   header   tank.
3.
 B

rake   fluid   reservoir.
4.
 B

attery.
5.
 F

usebox.
6.
 A

ir   filter.
7.
 E

ngine   oil   dipstick.
8.
 E

ngine   oil   filler   cap.
9.
 P

riming
 pu
mp*.
10.
 R

emote   earth   point.
Diesel engines
* According to engine.
7
Practical information

172
C4-cactus_en_Chap07_info-pratiques_ed01-2016
Coolant level
The coolant level should be close
to  the   "MA X"   mark   but   should   never  
e

xceed   it.
In
 
addition,   as   the   cooling   system   is   pressurised,
 w

ait
 
at
 
least   one   hour   after   switching   off   the
 e

ngine
 
before   carrying   out   any   work.
To
 
avoid
 
any   risk   of   scalding,   unscrew   the   cap   by
 t

wo
 
turns
 
to   allow   the   pressure   to   drop.   When   the
 p

ressure
 
has   dropped,   remove   the   cap   and   top
 u

p
 
the
 
level.
Changing the coolant
The coolant does not have to be replaced at routine services.
The cooling fan may star t after switching
off the engine: take care with ar ticles and
clothing that might be caught by the fan
blades. When   the   engine   is   warm,   the   temperature   of  
t

he   coolant   is   regulated   by   the   fan.
Fluid specification
The coolant must conform to the ma
nufacturer's r ecommendations.
Fluid specification
For optimum cleaning and to avoid freezing, this   fluid   must   not   be   topped   up   or   replaced  
w

ith   plain   water.
In
 
w
intry  
c
onditions,  
i
t  
i
s  
r
ecommended  
t
hat  
y
ou  
u

se   an   ethyl   alcohol   or   methanol   based   fluid.
Screenwash fluid level
Top up the level when necessary.
To p p i n g u p
The reservoir must be topped up without delay by   a   CITROËN   dealer   or   a   qualified   workshop.
Diesel fuel additive
level (Diesel with particle
filter)
The additive reservoir low level is
indicated  by   fixed   illumination   of  
A
void   prolonged   contact   of   used   oil   or  
f

luids   with   the   skin.
Most   of   these   fluids   are   harmful   to  
h

ealth   or   indeed   very   corrosive.
Do not discard used oil or fluids into
sewers   or   onto   the   ground.
Take   used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
Used products
this warning lamp, accompanied by an audible s
ignal   and   a   message   that   the   particle   filter  
a

dditive   level   is   too   low.
Practical information

173
C4-cactus_en_Chap07_info-pratiques_ed01-2016
Checks
12 V battery
The battery does not require any maintenance.
H owever,   check   regularly   that   the   terminals  
a

re   correctly   tightened   (versions   without   quick  
r

elease   terminals)   and   that   the   connections  
a

re   clean.Refer to the manufacturer's service schedule for details of the
replacement
  intervals   for   these  
c

omponents.
Air filter and passenger compartment filter
Replace the oil filter each time the e ngine   oil   is   changed.
Refer
  to   the   manufacturer's  
s

ervice schedule for details of
the
  replacement   interval   for   this  
c

omponent.
Oil filter
Unless other wise indicated, check these components in accordance with the manufacturer's service schedule and according to your engine.
O ther wise,   have   them   checked   by   a   CITROËN   dealer   or   a   qualified   workshop.
Depending
  on   the   environment   (e.g.   dusty  
a

tmosphere)   and   the   use   of   the   vehicle  
(e.g.
  city   driving),   replace them twice as often
if necessary .
A
  clogged   passenger   compartment   filter   may  
h

ave   an   adverse   effect   on   the   per formance  
o

f   the   air   conditioning   system   and   generate  
u

ndesirable
 o
dours.
Particle filter (Diesel)
The start of saturation of the
particle filter is indicated by the
fixed  illumination   of   this   warning  
l

amp   accompanied   by   a   warning  
m

essage.
As
 
soon
 
as
  the   traffic   conditions   permit,  
r

egenerate
 
the   filter   by   driving   at   a   speed   of   at  
l

east
 
40
 
mph   (60   km/h)   until   the   warning   lamp  
g

oes
 
off.
If
 
the
 
warning   lamp   stays   on,   this   indicates   a  
l

ow
 
additive   level.
Refer
 
to
 
the   "Diesel   additive   level"   section.
On a new vehicle, the first particle
filter
 
regeneration   operations   may   be  
a

ccompanied   by   a   "burning"   smell,  
w

hich   is   per fectly   normal.
Following
  prolonged   operation   of   the  
v

ehicle at very low speed or at idle,
you
 
may,   in   exceptional   circumstances,  
n

otice   the   emission   of   water   vapour   at  
t

he
 
exhaust   on   acceleration.   This   does  
n

ot affect the behaviour of the vehicle
or
 
the   environment.
When
 
carrying
 
out
 
any
 
operation
 
on
 
the
 
12
 
V
 
b

attery,
 
refer
 
to
 
the
 
corresponding
 
section
 
for
 
d

etails
 
of
 
the
 
precautions
 
to
 
be
 
taken
 
before
 
s

tarting
 
work.
Versions
 
equipped
 
with
 
Stop
 
&
 
Start
 
are
 
f

itted with a 12 V lead-acid battery of
specific
 t

echnology
 a

nd
 s

pecification.
Its
 
replacement
 
should
 
be
 
carried
 
out
 
o

nly
 

by
 

a
 

CITROËN
 

dealer
 

or
 

a
 

qualified
 w

orkshop.
7
Practical information

221
C4-cactus_en_Chap09_caracteristiques-techniques_ed01-2016
Enginee-HDi 92BlueHDi 100 BlueHDi 100 S&S
Gearbox ETG6 electronic
(6-speed) Manual
(5-speed) Manual
(5-speed) ETG6 electronic
(6-speed)
Model code 0B9HP0BBHY 0BBHY
Cubic capacity (cc) 1
  5601
  5601
  560
Bore
  x   stroke   (mm) 75
  x   88.375
  x   88.375
  x   88.3
Max
  power:   EU   standard   (kW)* 6873 73
Max
  power   engine   speed   (rpm) 4 0003
  7503
  750
Max
  torque:   EU   standard   (Nm) 230254 254
Max
  torque   engine   speed   (rpm) 1
  7501
  7501
  750
Fuel DieselDiesel Diesel
Catalytic converter yesyes yes
Particle filter yesyes yes
Engine
  oil   capacity   with   replacement   of   the   oil  
f

ilter (in litres) 3.75
3.75 3.75
*
  
T
he   maximum   power   corresponds   to   the   value   type   approved   on   a   test   bed,   under   conditions   defined   by   European   legislation  
(Directive
 1

999/99/EC).
Engines and gearboxes - DIESEL
9
Technical data

291
C4-cactus_en_Chap11_index-alpha_ed01-2016
D
Earth point, remote ...............................16 8, 16 9
EBA ............................................................. ....91
Eco-driving
 (

advice)
 .......................................... 9
E

conomy   mode  
...............................
..............160
Electronic
  brake   force   distribution  
(EBFD)
 ...............................

...........................91
Electronic
  gearbox   system  
...........................13

0
Emergency
 c

all
 ...................................... 9
0,   226
Emissions
  control   system,   SCR  
.....................20
E

nergy   economy   mode  
.................................16

0
Engine
 c

ompartment
 ............................ 16

8,
 16
9
Engine,
  Diesel  
.........1
4,   156,   169,   218,   221,   222 Hazard
 w

arning
 lam
ps
 ............................9
0,   184
Headlamps,   automatic   illumination  
..........7
9,   82
Headlamps,   dipped   beam  
.................7
8,   79,   198
Headlamps,   main   beam  
............ 7
8,   79,   197,   199
Head restraints, front  
......................................
50
H
ead restraints, rear  
.......................................
52
H
eating
 ................
............................ 9,   57,   59,   61
Hill start assist  ...............................................
13 1
Horn ................................................................. 90
F
H
Filling the fuel tank ........................153,   155,   156
Filter, air ............... ......................................... 173
Filter, oil
 ......................................................... 17

3
Filter, particle
 ........................................ 17

2 ,
 17
3
Filter,
 p

assenger
 c
ompartment
 .....................17

3
Fitting
  roof   bars  
............................................. 16

4
Fittings,
  boot  
.............................................7
5,   77
Fittings,
 in

terior
 .......................................... 6

9 -74
Flap, fuel filler
 
...............................
.........153,
 15

5
Foglamp,
 r

ear
 ...............................
...........80, 202
Foglamps,
 f

ront
 .........................8
0,   85,   197,   200
Frequency
  (radio)  
..................................2
42,   243
Fuel ................................................................ 15 6
Fuel
 c

onsumption
 .............................................. 9
F

uel   tank........................................................ 153
Fuses
 ................

.....................................205,   207
E
DAB (Digital Audio Broadcasting) - 
D igital r adio ......................................... 244,   245
Date
  (setting)  
...............................
....................38
Daytime
  running   lamps  
.......................7
8,   79,   83
Daytime
  running   lamps,   LED  
................19

7,
 19
8
Deactivating
 t

he
 p
assenger
 
ai

rbag
 .................................................. 10

0, 107
Defrosting
 ...............................

...................65,   66
Demisting
 ...............................

...................65,   66
Diesel
 ...............................

.............................15 6
Dimensions
 ..............................

.....................223
Dipstick
 ................

.................................... 2 7, 17 0
Direction indicators
 ........... 8

1,   83,   197,   199,   202
Doors
 ..............................................................

.45
Driving
 e

conomically ......................................... 9
Dynamic
  stability   control  
(

DSC)
 ....................................1
6,   18,   91,   93,   95Engine,
  petrol  ........................1 56,   168,   219,   220
Engines ..............................
...................219, 2
21
Environment
 ...............................

................. 9,   42
ESC (electronic stability control)
 .............. 1

6,   91,   94Gauge,
  fuel.............................................. 11,   153
Gearbox, e
lectronic ....................9
,   23,   70,   73,   127,  
1
32,   133,   174
Gearbox,
 m

anual
 ...........9

,   69,   73,   125,   131,   132,  

1

33,   174
Gear shift indicator
 ....................................... 12

6
Gear
  lever,   manual   gearbox  
.........................12

5
Glove
  box  
...................................................6

9 -71
Grip control
 
.....................................................94
G
Identification, vehicle ....................................2 24
Ignition ................ .....................................64,   123
I
.
Alphabetical index