2018 CHRYSLER PACIFICA engine overheat

NOTE:Push the ESC Off switch to place the Electronic
Stability Control (ESC) system in Partial Offmode, before
rocking the vehicle. Refer to “Electronic Brake Control” in
“Safety” for further information. Once the vehicle has been
freed, push the ESC Offswitch again to restore ESC On
mode.
WARNING!
Fast spinning tires can be dangerous. Forces generated
by excessive wheel speeds may cause damage, or even
failure, of the axle and tires. A tire could explode and
injure someone. Do not spin your vehicle’s wheels
faster than 30 mph (48 km/h) or for longer than 30
seconds continuously without stopping when you are
stuck and do not let anyone near a spinning wheel, no
matter what the speed.
CAUTION!
• Racing the engine or spinning the wheels may lead
to transmission overheating and failure. Allow the
engine to idle with the transmission in NEUTRAL
for at least one minute after every five rocking-
motion cycles. This will minimize overheating and
(Continued)
CAUTION! (Continued)
reduce the risk of transmission failure during pro-
longed efforts to free a stuck vehicle.
•
When “rocking” a stuck vehicle by shifting between
DRIVE and REVERSE, do not spin the wheels faster
than 15 mph (24 km/h), or drivetrain damage may result.
• Revving the engine or spinning the wheels too fast
may lead to transmission overheating and failure. It
can also damage the tires. Do not spin the wheels
above 30 mph (48 km/h) while in gear (no transmis-
sion shifting occurring).
TOWING A DISABLED VEHICLE
This section describes procedures for towing a disabled
vehicle using a commercial towing service.
482 IN CASE OF EMERGENCY

have an authorized technician inspect the complete ex-
haust system and adjacent body areas for broken, dam-
aged, deteriorated, or mispositioned parts. Open seams or
loose connections could permit exhaust fumes to seep into
the passenger compartment. In addition, have the exhaust
system inspected each time the vehicle is raised for lubri-
cation or oil change. Replace as required.
WARNING!
•Exhaust gases can injure or kill. They contain carbon
monoxide (CO), which is colorless and odorless.
Breathing it can make you unconscious and can
eventually poison you. To avoid breathing CO, refer
to “Safety Tips” in “Safety” for further information.
• A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your exhaust
system. Do not park or operate your vehicle in areas
where your exhaust system can contact anything that
can burn.
CAUTION!
•The catalytic converter requires the use of unleaded
fuel only. Leaded gasoline will destroy the effective-
ness of the catalyst as an emissions control device
and may seriously reduce engine performance and
cause serious damage to the engine.
• Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition. In
the event of engine malfunction, particularly involv-
ing engine misfire or other apparent loss of perfor-
mance, have your vehicle serviced promptly. Contin-
ued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle.
Under normal operating conditions, the catalytic converter
will not require maintenance. However, it is important to
keep the engine properly tuned to assure proper catalyst
operation and prevent possible catalyst damage.
NOTE: Intentional tampering with emissions control sys-
tems can result in civil penalties being assessed against
you.
8
SERVICING AND MAINTENANCE 509

In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe and
abnormal catalyst overheating. If this occurs, stop the
vehicle, turn off the engine and allow it to cool. Service,
including a tune-up to manufacturer’s specifications,
should be obtained immediately.
To minimize the possibility of catalytic converter damage:
•Do not interrupt the ignition when the transmission is in
gear and the vehicle is in motion.
• Do not try to start the vehicle by pushing or towing the
vehicle.
• Do not idle the engine with any ignition components
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough idle
or malfunctioning operating conditions.
Cooling System
WARNING!
•You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
(Continued)
WARNING! (Continued)
do not open the hood until the radiator has had time
to cool. Never open a cooling system pressure cap
when the radiator or coolant bottle is hot.
• Keep hands, tools, clothing, and jewelry away from
the radiator cooling fan when the hood is raised. The
fan starts automatically and may start at any time,
whether the engine is running or not.
• When working near the radiator cooling fan, discon-
nect the fan motor lead or turn the ignition to the
OFF mode. The fan is temperature controlled and can
start at any time the ignition is in the ON mode.
Engine Coolant Checks
Check the engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where appli-
cable). If the engine coolant (antifreeze) is dirty, the system
should be drained, flushed, and refilled with fresh OAT
coolant (conforming to MS.90032) by an authorized dealer.
Check the front of the A/C condenser for any accumula-
tion of bugs, leaves, etc. If dirty, clean by gently spraying
water from a garden hose vertically down the face of the
condenser.
510 SERVICING AND MAINTENANCE

Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
expansion bottle/recovery tank if so equipped.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is over-
heated. Do not loosen or remove the cap to cool an
overheated engine. Heat causes pressure to build up
in the cooling system. To prevent scalding or injury,
do not remove the pressure cap while the system is
hot or under pressure.
• Do not use a pressure cap other than the one speci-
fied for your vehicle. Personal injury or engine
damage may result.
Disposal Of Used Coolant
Used ethylene glycol-based coolant (antifreeze) is a regu-
lated substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or children,
do not store ethylene glycol-based coolant in open contain-
ers or allow it to remain in puddles on the ground. If
ingested by a child or pet, seek emergency assistance
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant expansion bottle provides a quick visual
method for determining that the coolant level is adequate.
With the engine off and cold, the level of the coolant
(antifreeze) in the bottle should be between the “MAX” and
“MIN” lines marked on the bottle.
As long as the engine operating temperature is satisfactory,
the coolant bottle need only be checked once a month.
When additional coolant (antifreeze) is needed to maintain
the proper level, it should be added to the coolant bottle.
Do not overfill.
See an authorized dealer for service.
8
SERVICING AND MAINTENANCE 513

MMT In Gasoline
Methylcyclopentadienyl Manganese Tricarbonyl (MMT) is
a manganese-containing metallic additive that is blended
into some gasoline to increase octane. Gasoline blended
with MMT provides no performance advantage beyond
gasoline of the same octane number without MMT. Gaso-
line blended with MMT reduces spark plug life and
reduces emissions system performance in some vehicles.
The manufacturer recommends that gasoline without
MMT be used in your vehicle. The MMT content of
gasoline may not be indicated on the gasoline pump;
therefore, you should ask your gasoline retailer whether
the gasoline contains MMT. MMT is prohibited in Federal
and California reformulated gasoline.
Fuel System Cautions
CAUTION!
Follow these guidelines to maintain your vehicle’s
performance:
•The use of leaded gasoline is prohibited by Federal
law. Using leaded gasoline can impair engine perfor-
mance and damage the emissions control system.
(Continued)
CAUTION! (Continued)
•An out-of-tune engine or certain fuel or ignition
malfunctions can cause the catalytic converter to
overheat. If you notice a pungent burning odor or
some light smoke, your engine may be out of tune or
malfunctioning and may require immediate service.
Contact an authorized dealer for service assistance.
• The use of fuel additives, which are now being sold
as octane enhancers, is not recommended. Most of
these products contain high concentrations of metha-
nol. Fuel system damage or vehicle performance
problems resulting from the use of such fuels or
additives is not the responsibility of the manufac-
turer and may void or not be covered under the New
Vehicle Limited Warranty.
NOTE: Intentional tampering with the emissions control
system can result in civil penalties being assessed against
you.
9
TECHNICAL SPECIFICATIONS 553

Corrosion Protection........................542
Cruise Control (Speed Control) .................332
Cruise Light ........................206, 207, 208
Customer Assistance ........................672
Cybersecurity ............................ .563
Daytime Brightness, Interior Lights ..............101
Daytime Running Lights ......................94
Dealer Service ............................ .496
Defroster, Windshield ........................302
Delay (Intermittent) Wipers ...................102
Diagnostic System, Onboard ...................209
Dimmer Switch Headlight ...............................94
Dipsticks Oil (Engine) ............................494
Disable Vehicle Towing ..................... .482
Disposal Antifreeze (Engine Coolant) .................513
Disturb ................................. .665
Door Ajar ............................ .199, 200
Door Ajar Light ........................199, 200
Drag And Drop Menu .......................562
Driver ’s Seat Back Tilt ........................48 Driving
Through Flowing, Rising, Or Shallow Standing
Water .................................420
DVD Player (Video Entertainment System) .........617
Electric Brake Control System ..................215
Anti-Lock Brake System ....................214
Electric Parking Brake .......................313
Electric Remote Mirrors .......................91
Electronic Brake Control System Traction Control System ....................215
Electronic Speed Control (Cruise Control) .........330
Electronic Stability Control (ESC) ...............218
Electronic Throttle Control Warning Light .........199
Emergency, In Case Of Hazard Warning Flasher ...................425
Jacking ........................ .446, 448, 517
Jump Starting .......................... .475
Overheating ............................479
T owing ............................... .482
Emission

Control System Maintenance ............210
Engine ................................. .493
Air Cleaner ............................ .498
Block Heater ............................311
Break-In Recommendations .................312
12
INDEX 681

Checking Oil Level.......................494
Compartment .......................... .493
Compartment Identification .................493
Coolant (Antifreeze) ..................... .555
Cooling ...............................510
Exhaust Gas Caution ...................301, 554
Fails To Start ............................310
Flooded, Starting ........................ .310
Fuel Requirements ........................550
Oil ...............................496, 555
Oil Filler Cap .......................... .493
Oil Filter ...............................498
Oil Selection ........................ .496, 555
Oil Synthetic ............................497
Overheating ............................479
Starting ...............................309
Engine Oil Viscosity ........................ .497
Engine Oil Viscosity Chart ....................497
Enhanced Accident Response Feature .........273, 485
Ethanol ................................. .551
Exhaust Gas Cautions ....................301, 554
Exhaust System ........................301, 508
Exterior Lighting ........................94, 435
Exterior Lights ...................94, 303, 431, 435 Filters
Air Cleaner ............................ .498
Air Conditioning .....................132, 501
Engine Oil ..........................498, 555
Engine Oil Disposal .......................498
Flashers Hazard Warning ........................ .425
Turn Signals ...................94, 207, 303, 435
Flash-To-Pass ............................94, 96
Flooded Engine Starting ..................... .310
Fluid, Brake ............................. .557
Fluid Capacities ............................555
Fluid Leaks...............................304
Fluid

Level Checks
Brake .................................515
Fluids And Lubricants .......................555
Fog Lights ..........................94, 97, 436
Fog Lights, Service ........................ .436
Fold-Flat Seats .............................48
Fold In Floor (Stow ‘n Go) Seating ...............62
Forward Collision Warning ....................230
Freeing A Stuck Vehicle ..................... .481
Front Position Light ........................ .435
Fuel ................................... .550
Additives ............................. .551
682 INDEX

Mini-Trip Computer........................ .197
Mirrors ..................................89
Automatic Dimming .......................89
Electric Remote ...........................91
Exterior Folding ..........................92
Heated ............................. .89, 92
Outside ............................. .89, 90
Rearview ............................89, 425
Vanity .................................93
Modifications/Alterations, Vehicle ................5
Monitor, Tire Pressure System ..................234
Mopar Parts ............................. .675
MP3 Control ............................. .616
Multi-Function Control Lever ...................94
New Vehicle Break-In Period ..................312
Occupant Restraints ........................ .239
Octane Rating, Gasoline (Fuel) ..............550, 555
Oil Change Indicator ........................187
Reset .................................187
Oil, Engine ............................496, 555
Capacity ...............................555
Change Interval ........................ .496
Checking ............................. .494Disposal
...............................498
Filter ............................. .498, 555
Filter Disposal .......................... .498
Identification Logo .......................497
Materials Added To .......................497
Pressure Warning Light ....................202
Recommendation .....................496, 555
Synthetic ............................. .497
Viscosity .......................... .497, 555
Oil Filter, Change ..........................498
Oil Filter, Selection ..........................498
Oil Pressure Light ..........................202
Onboard Diagnostic System ...................209
Operating Precautions .......................209
Operator Manual

(Owner’s Manual) ...............5
Outside Rearview Mirrors ...................89, 90
Overheating, Engine ........................479
Owner’s Manual (Operator Manual) ...........5,676
Paint Care ............................... .542
Parking Brake ............................ .313
ParkSense System, Rear ...................351, 360
Personalized Main Menu .....................562
Pets ................................... .300
Placard, Tire And Loading Information ...........523
686 INDEX