2017 TOYOTA HILUX engine overheat

2744-2. Driving procedures
HILUX_OM_OM0K322E_(EE)
■ Steering lock
After turning the engine switch off and opening and closing the doors, the
steering wheel will be locked due to the steering lock function. Operating the
engine switch again automatically cancels the steering lock.
■ When the steering lock cannot be released
■ Steering lock motor overheating prevention
To prevent the steering lock motor from overheating, the motor may be sus-
pended if the engine is turned on and off repeatedly in a short period of time.
In this case, refrain from running the engine. After about 10 seconds, the
steering lock motor will resume functioning.
■ If “SMART ENTRY & START SYSTEM MALFUNCTION SEE OWNER’S
MANUAL”/“Smart Entry & Start System malfunction See owner’s man-
ual” is shown on the multi-information display (if equipped)
The system may be malfunctioning. Have the vehicle inspected by any autho-
rized Toyota retailer or Toyota authorized repairer, or any reliable repairer
immediately.
■ If the electronic key battery is depleted
 P. 575
■ If the smart entry & start system has been deactivated in a customized
setting
 P. 644
A message will be displayed on the multi-
information display.
Check that the shift lever is set in P
(except manual transmission). Press the
engine switch while turning the steering
wheel left and right.

3964-5. Using the driving support systems
HILUX_OM_OM0K322E_(EE)
■Operating tips (vehicles with automatic transmission)
The system will operate when the shift lever is in a position other than P, how-
ever to make effective use of the system it is recommended to select a lower
shift range.
■ The system will not operate when
● The transfer mode is in H2.
● The rear differential is locked. (if equipped)
■ If the downhill assist control system indicator flashes
● In the following situations, the indicator flashes and the system will not oper-
ate:
• The transfer mode is not in L4 or H4.
• The rear differential is locked. (if equipped)
• The shift lever is in P. (vehicles with automatic transmission)
• The accelerator or brake pedal is depressed.
• The vehicle speed exceeds approximately 30 km/h (18 mph).
• The brake system overheats.
● In the following situations, the indicator flashes to alert the driver, but the
system will operate:
• The shift lever is in N. (vehicles with automatic transmission)
• The clutch pedal is depressed. (vehicles with manual transmission)
• The “DAC” switch is turned off while the system is operating.
The system will gradually ceases operat ion. The indicator will flash during
operation, and then go off when the system is fully off.
■ When the downhill assist control system is operated continuously
This may cause the brake actuator to overheat. In this case, the downhill
assist control system will stop operating, a buzzer will sound and the downhill
assist control system indicator will start flashing, and “TRC turned off” is
shown on the multi-information display. Refrain from using the system until
the downhill assist control system indicator stays on and “TRC turned off” dis-
played on the multi-information display goes out. (The vehicle can be driven
normally during this time.)
■ Sounds and vibrations caused by the downhill assist control system
● A sound may be heard from the engine compartment when the engine is
started or just after the vehicle begins to move. This sound does not indicate
that a malfunction has occurred in downhill assist control system.
● Either of the following conditions may occur when the downhill assist control
system is operating. None of these are indicators that a malfunction has
occurred.
• Vibrations may be felt through the vehicle body and steering.
• A motor sound may be heard after the vehicle comes to a stop.

5096-1. Using the air conditioning system and defogger
HILUX_OM_OM0K322E_(EE)
6
Interior features
Heated steering wheel/seat heaters
: If equipped
Heated steering wheel and seat heaters heat the side grips of the
steering wheel and seats, respectively.
WARNING
● Care should be taken to prevent injury if anyone in the following categories
comes in contact with the steering wheel and seats when the heater is on:
• Babies, small children, the elderly, the sick and the physically chal-
lenged
• Persons with sensitive skin
• Persons who are fatigued
• Persons who have taken alcohol or drugs that induce sleep (sleeping
drugs, cold remedies, etc.)
● Observe the following precautions to prevent minor burns or overheating:
• Do not cover the seat with a blanket or cushion when using the seat
heater.
• Do not use seat heater more than necessary.
NOTICE
● Do not put heavy objects that have an uneven surface on the seat and do
not stick sharp objects (needles, nails, etc.) into the seat.
● To prevent battery discharge, do not use the functions when the engine is
not running.

599
8When trouble arises
HILUX_OM_OM0K322E_(EE)
8-1. Essential information
Emergency flashers ........... 600
If your vehicle has to
be stopped in an
emergency ....................... 601
8-2. Steps to take in an
emergency
If your vehicle needs
to be towed ...................... 603
If you think something is
wrong ............................... 608
Fuel pump shut off
system (gasoline engine
only) ................................. 609
If a warning light turns on
or a warning buzzer
sounds ............................. 610
If a warning message is
displayed ......................... 618
If you have a flat tire .......... 625
If the engine will not
start.................................. 642
If the electronic key does
not operate properly
(vehicles with smart
entry & start system)........ 644
If the vehicle battery is
discharged ....................... 648
If your vehicle
overheats ......................... 654
If you run out of fuel
and the engine stalls
(diesel engine only) ......... 657
If the vehicle becomes
stuck ................................ 658

6548-2. Steps to take in an emergency
HILUX_OM_OM0K322E_(EE)
If your vehicle overheats
●The needle of the engine coolant temperature gauge (P. 132)
enters the red zone or a loss of engine power is experienced. (For
example, the vehicle speed does not increase.)
● Steam comes out from under the hood.
Stop the vehicle in a safe place and turn off the air conditioning sys-
tem, and then stop the engine.
If you see steam:
Carefully lift the hood after the steam subsides.
If you do not see steam:
Carefully lift the hood.
After the engine has cooled down sufficiently, inspect the hoses and
radiator core (radiator) for any leaks.
Radiator
Cooling fan
If a large amount of coolant
leaks, immediately contact any
authorized Toyota retailer or
Toyota authorized repairer, or
any reliable repairer.
The following may indicate that your vehicle is overheating.
Correction procedures
1
2
3
1
2

6578-2. Steps to take in an emergency
HILUX_OM_OM0K322E_(EE)
8
When trouble arises
If you run out of fuel and the engine stalls
(diesel engine only)
If you run out of fuel and the engine stalls:
Refuel your vehicle.
To bleed the fuel system, oper-
ate the priming pump until you
feel more resistance.
Start the engine. ( P. 266, 269)
If the engine does not start after the above steps have been performed,
wait for 10 seconds and try steps and again. If the engine still does
not start, contact any authorized Toyo ta retailer or Toyota authorized
repairer, or any reliable repairer.
After starting the engine, depress the accelerator pedal lightly until the
engine runs smoothly.
1
2
NOTICE
■ When restarting the engine
● Do not crank the engine before refueling and operating the priming pump.
This may damage the engine and fuel system.
● Do not crank the engine for more than 30 seconds at a time. This may
overheat the starter and wiring system.
3
23

710Alphabetical index
HILUX_OM_OM0K322E_(EE)
Child safety ................................ 64
Airbag precautions .................. 47
Battery precautions ....... 558, 652
Child restraint system ............. 65
How your child should
wear the seat belt ................. 42
Installing child restraints.... 81, 90
Power window lock
switch.................................. 233
Power window precautions ... 235
Rear door child-protectors .... 177
Removed key battery
precautions ......................... 577
Seat belt precautions .............. 44
Seat heater precautions ........ 509
Child-protectors ....................... 177
Cleaning............................ 534, 537
Aluminum wheels .................. 535
Exterior.................................. 534
Interior ................................... 537
Seat belts .............................. 538
Clock ......................................... 523
Clutch........................................ 687
Coat hooks ............................... 527
Condenser ................................ 554
Console box ............................. 515
Cooling system
Engine overheating ............... 654
Cruise control .......................... 348
Cup holders .............................. 516
Curtain shield airbags ............... 45
DAC ........................................... 395
Daytime running light
system .................................... 296
Deck hooks .............................. 521
Defogger
Outside rear view
mirrors ........................ 493, 502
Rear window ................. 493, 502
Windshield .................... 493, 502
Differential
Oil ......................................... 687
Dimension ................................ 662
Display
LDA (Lane Departure
Alert)................................... 344
Multi-information
display ........................ 137, 141
Trip information ............. 138, 143
Do-it-yourself maintenance .... 543
Doors
Door glasses ......................... 232
Door lock............................... 174
Open door warning light........ 614
Outside rear view mirrors...... 229
Rear door child-protectors .... 177
Side doors............................. 174
Downhill assist control
system .................................... 395
DPF (Diesel Particulate Filter)
system .................................... 398
Warning message ................. 622
Driver’s seat belt
reminder light ........................ 614
Driving
Break-in tips .......................... 241
Correct posture ....................... 38
Procedures ........................... 238
Winter drive tips .................... 402
D

711Alphabetical index
HILUX_OM_OM0K322E_(EE)
Eco Driving Indicator....... 128, 130
Emergency flashers................. 600
Electronic key
If the electronic key does
not operate properly ........... 644
Replacing the battery ............ 575
Emergency, in case of
If a warning buzzer
sounds ................................ 610
If a warning light turns on ...... 610
If the electronic key does
not operate properly ........... 644
If the engine will not start ...... 642
If the vehicle battery is
discharged .......................... 648
If you have a flat tire.............. 625
If you lose your keys ............. 156
If you run out of fuel and
the engine stalls.................. 657
If you think something is
wrong .................................. 608
If your vehicle becomes
stuck ................................... 658
If your vehicle has to be
stopped in an
emergency.......................... 601
If your vehicle needs to be
towed .................................. 603
If your vehicle overheats ....... 654
Engine
“ACC” position ...................... 267
Compartment ........................ 547
Engine switch................ 266, 269
Hood ..................................... 545
How to start the
engine......................... 266, 269
Identification number ............ 668
If the engine will not start ...... 642
If you run out of fuel and the
engine stalls ....................... 657
If your vehicle has to be
stopped in an
emergency.......................... 601
Ignition switch
(engine switch) ........... 266, 269
Overheating .......................... 654
Engine coolant
Capacity ................................ 683
Checking ............................... 553
Preparing and checking
before winter....................... 402
Engine coolant
temperature gauge ................ 134
Engine immobilizer system ...... 95
Engine oil
Capacity ................................ 671
Checking ............................... 550
Oil level warning light ............ 614
Oil pressure warning light ..... 610
Preparing and checking
before winter....................... 402
Engine oil maintenance
data ......................................... 552
E