2017 KIA OPTIMA PLUG-IN HYBRID engine coolant

ENGINE COMPARTMENT
(BTPMJOF
&OHJOF
/V
-

(%*

5IF
BDUVBM
FOHJOF
SPPN
JO
UIF
WFIJDMF
NBZ
EJGGFS
GSPN
UIF
JMMVTUSBUJPO
1. Engine coolant reservoir
2. Engine oil filler cap
3. Engine oil dipstick
4. Brake fluid reservoir
5. Air cleaner
6. Fuse box
7. Inverter coolant reservoir
8. Radiator cap
9. Windshield washer fluid reservoir

9-03
9
Maintenance

OWNER MAINTENANCE
The following lists are vehicle checks
and inspections that should be per‐
formed at the frequencies indicated to help ensure safe, dependable operation
of your vehicle.
Any adverse conditions should be
brought to the attention of your dealer as soon as possible.
These Owner Maintenance Checks are
generally not covered by warranties
and you may be charged for labor, parts and lubricants used.
Owner maintenance schedule
When you stop for fuel:
• Check the engine oil level.
• Check the coolant level in the coolant reservoir.
• Check the windshield washer fluid level.
• Look for low or under-inflated tires.
WARNING
Be careful when checking your en‐gine coolant level when the engine ishot. Scalding hot coolant and steam
(Continued)
(Continued)
may blow out under pressure. Thiscould cause burns or other seriousinjury.
While operating your vehicle:
• Note any changes in the sound of the exhaust or any smell of exhaust
fumes in the vehicle.
• Check for vibrations in the steering wheel. Notice any increased steering
effort or looseness in the steering
wheel, or change in its straight-
ahead position.
• Notice if your vehicle constantly turns slightly or L

NORMAL MAINTENANCE SCHEDULE - FOR GASOLINE ENGINE [FOR EUROPE (EXCEPT RUSSIA)]
The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for
all vehicle emission services to protect your warranty. Where both mileage and time are shown, the frequency of service is determined by whichever occurs first.
NO.ITEMREMARK
*1 Coolant (Engine / Inverter) When adding coolant, use only deionized water or soft water for your vehicle
and never mix hard water in the coolant filled at the factory. An improper
coolant mixture can result in serious malfunction or engine damage.
*2 Engine oil and engine oil filter Check the engine oil level and leak every 500 km (350 miles) or before start‐ing a long trip.
*3 Fuel additives (Gasoline) Kia recommends that you use unleaded gasoline which has an octane rating
of RON (Research Octane Number) 95 / AKI (Antiknock Index) 91 or higher
(for Europe) or Octane Rating of RON (Research Octane Number) 91 / AKI(Antiknock Index) 87 or higher (except Europe).
For customers who do not use good quality gasolines including fuel additives
regularly, and have problems starting or the engine does not run smoothly,
one bottle of additives added to the fuel tank at every 15,000 km (for Eu‐rope, Australia and New Zealand)/10,000 km (except Europe, Australia andNew Zealand).
Additives are available from your authorized Kia dealer along with informa‐
tion on how to use them. Do not mix other additives.
*4 HSG (Hybrid Starter & Generator) belt Inspect HSG belt for evidence of cuts, crocks, excessive wear or oil saturation
and replace if necessary. If drive belt noise occurred, readjust drive belt ten‐
sion before replace.
*5 Spark plug For your convenience, it can be replaced prior to it's interval when you domaintenance of other items.



9-09
9
Maintenance

NORMAL MAINTENANCE SCHEDULE - FOR GASOLINE ENGINE [FOR EUROPE (EXCEPT RUSSIA)]
(CONTINUED)
MAINTENANCE INTERVALS
Normal Maintenance Schedule - For Gasoline Engine [For Europe (Except Russia)]
Number of months or driving distance, whichever comes first
Months1224364860728496
Miles×1,0001020304050607080
Km×1,000153045607590105120
MAINTENANCE ITEM
Air cleaner filter I I R I I R I I
Air conditioner compressor/refrigerant I I I I I I I I Automatic transaxle fluid No check, No service required
Battery condition I I I I I I I I
Brake discs and pads I I I I I I I I
Brake lines, hoses and connections I I I I I I I IBrake fluid I R I R I R I R
Climate control air filter R R R R R R R R
Coolant (Engine / Inverter) *1
At first, Replace 210,000 km (140,000 miles) or 120 months after that,
Replace every 30,000 km (20,000 miles) or 24 months
Cooling system At first, Inspect 60,000 km (40,000 miles) or 48 months after that, Inspect
every 30,000 km (20,000 miles) or 24 months
Drive shaft and boots I I I I I I I I Engine oil and engine oil fil‐ ter *2
Nu 2.0L GDI R R R R R R R R
Exhaust system - I - I - I - I
Maintenance
9-10

NORMAL MAINTENANCE SCHEDULE - FOR GASOLINE ENGINE [EXCEPT EUROPE (INCLUDING
RUSSIA)]
The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for
all vehicle emission services to protect your warranty. Where both mileage and time are shown, the frequency of service is
determined by whichever occurs first.
NO.ITEMREMARK
*1 Coolant (Engine/Inverter) When adding coolant, use only deionized water or soft water for your vehicle
and never mix hard water in the coolant filled at the factory. An improper
coolant mixture can result in serious malfunction or engine damage.
*2 Engine oil and engine oil filter Check the engine oil level and leak every 500 km (350 miles) or before start‐ing a long trip.
*3 Fuel additives (Gasoline) Kia recommends that you use unleaded gasoline which has an octane rating
of RON (Research Octane Number) 95 / AKI (Antiknock Index) 91 or higher
(for Europe) or Octane Rating of RON (Research Octane Number) 91 / AKI(Antiknock Index) 87 or higher (except Europe).
For customers who do not use good quality gasolines including fuel additives
regularly, and have problems starting or the engine does not run smoothly,
one bottle of additives added to the fuel tank at every 15,000 km (for Eu‐rope, Australia and New Zealand)/10,000 km (except Europe, Australia andNew Zealand).
Additives are available from your authorized Kia dealer along with informa‐
tion on how to use them. Do not mix other additives.
*4 HSG (Hybrid Starter & Generator) belt Inspect HSG belt for evidence of cuts, crocks, excessive wear or oil saturation
and replace if necessary. If drive belt noise occurred, readjust drive belt ten‐
sion before replace.
*5 Spark plug For your convenience, it can be replaced prior to it's interval when you domaintenance of other items.

Maintenance

9-14

NORMAL MAINTENANCE SCHEDULE - FOR GASOLINE ENGINE [EXCEPT EUROPE (INCLUDING
RUSSIA)] (CONTINUED)
MAINTENANCE INTERVALS
Normal Maintenance Schedule - For Gasoline Engine [Except Europe (Including Russia)]
Number of months or driving distance, whichever comes first
Months1224364860728496
Miles×1,0001020304050607080
Km×1,000153045607590105120
MAINTENANCE ITEM
Air cleaner filter Except China, India, Middle East
I I R I I R I I
For China, India, Mid‐dle East R R R R R R R R
Air conditioner compressor/refrigerant I I I I I I I I Automatic transaxle fluid No check, no service required
Battery condition I I I I I I I I
Brake discs and pads I I I I I I I I
Brake lines, hoses and connections I I I I I I I IBrake fluid I R I R I R I R
Climate control air filter R R R R R R R R
Coolant (Engine/Inverter) *1
At first, replace 210,000 km (140,000 miles) or 120 months
After that, replace every 30,000 km (20,000 miles) or 24 months
Cooling system At first, inspect 60,000 km (40,000 miles) or 48 months
After that, inspect every 30,000 km (20,000 miles) or 24 months
Drive shaft and boots I I I I I I I I

9-15
9
Maintenance

Cooling system
Check the cooling system components,
such as the radiator, coolant reservoir,
hoses and connections for leakage and damage. Replace any damaged parts.
Coolant (Engine/Inverter)
The coolant should be changed at the
intervals specified in the maintenance schedule.
Automatic transaxle fluid
Automatic transaxle fluid should not be
checked under normal usage conditions.
We recommend that the automatic transmission fluid changed by an au‐
thorized Kia dealer according to the
maintenance schedule.
NOTICE
Automatic transaxle fluid color is ba‐
sically red.
As the vehicle is driven, the auto‐
matic transaxle fluid will begin to
look darker. It is normal condition
and you should not judge the need
to replace the fluid based upon the
changed color.
CAUTION
The use of a non-specified fluidcould result in transaxle malfunctionand failure.Use only specified automatic trans‐axle fluid (Refer to L

COOLANT
The high-pressure cooling system has
a reservoir filled with year round anti‐
freeze coolant. The reservoir is filled at the factory.
Check the antifreeze protection and
coolant level at least once a year, at the
beginning of the winter season, and be‐ fore traveling to a colder climate.
CAUTION
•When the engine overheats fromlow engine coolant, suddenly add‐ing engine coolant may causecracks in the engine. To preventdamage, add engine coolant slowlyin small quantities.
•Do not drive with no engine cool‐ant. It may cause water pump fail‐ure and engine seizure, etc.
Checking the coolant level
WARNING
nRemoving radiator cap
•Never attempt to remove the radi‐ator cap while the engine is oper‐ating or hot. Doing so might leadto cooling system and engine dam‐age. Also, hot coolant or steamcould cause serious personal in‐jury.
•Turn the engine off and wait untilit cools down. Use extreme carewhen removing the radiator cap.Wrap a thick towel around it, andturn it counterclockwise slowly tothe first stop. Step back while thepressure is released from the cool‐ing system.When you are sure all the pressurehas been released, press down onthe cap, using a thick towel, andcontinue turning counterclockwiseto remove it.
(Continued)
(Continued)
•Even if the engine is not operating,do not remove the radiator cap orthe drain plug while the engine andradiator are hot. Hot coolant andsteam may still blow out underpressure, causing serious injury.
The engine coolant and/or inverter
coolant level is influenced by the hybrid system temperature. Before checking
or refilling the engine coolant and/or in‐
verter coolant, turn the hybrid vehicle off.
WARNING
The electric motor (cool‐ing fan) is controlled byengine coolant tempera‐ture, refrigerant pressureand vehicle speed. It maysometimes operate evenwhen the engine is notrunning.
(Continued)
Maintenance
9-26