2017 CHEVROLET LOW CAB FORWARD AUX

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
In Brief 27
Portable Audio Devices
This vehicle is equipped with a
3.5 mm (1/8 in) auxiliary input jack
and a USB port in the radio
faceplate. External devices such as
iPods
®, laptop computers, MP3
players, and USB storage devices
may be connected.
See USB Port 0121 andAuxiliary
Devices 0124.
Cruise Control (Diesel)
1. Press the cruise control main
switch to turn it on.
At this time, the cruise main
indicator light comes on
simultaneously.
2. Use the accelerator pedal toadjust the vehicle to the
desired speed. Upon reaching
the desired speed, turn the
cruise control set switch. The
vehicle speed at the moment
you operate the switch is set in
the system, enabling you to drive with the set speed
automatically maintained
without using the accelerator
pedal.
At the same time the cruise set
indicator light comes on.
See Cruise Control (Diesel) 0224 or
Cruise Control (Gas) 0227.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
In Brief 29
Power Outlets
You can plug in auxiliary electrical
equipment. Just flip the outlet cover
open from the left edge of the cover
and follow the proper installation
instructions that are included with
any electrical equipment you install.
These circuits are protected by a
fuse and have maximum current
loads.
SeePower Outlets 074.
Performance and
Maintenance
Driving for Better Fuel
Economy
Economical Driving
How you drive, where you drive and
when you drive all affect fuel
economy.
For diesel vehicles, driving too fast,
driving so slowly that the engine
knocks, driving with the exhaust
brake switched on all the time, and
frequently using the exhaust brake
to adjust your speed can lead to
poor fuel economy.
Drive at a constant speed as much
as possible. When accelerating,
increase your speed gently and
slowly, and up-shift early.
Maintain a constant cruising speed,
as traffic allows, and avoid sudden
stops. Frequent short trips, excessive
idling and use of the air conditioner
in cool weather when "Vent" would
provide adequate comfort, can all
lead to decreased fuel economy.
Warming up the engine for longer
than necessary, driving with the
vehicle overloaded and revving the
engine are a waste of fuel.
Overcooling of the engine not only
accelerates wear of the vital engine
parts but also hurts fuel economy.
The careful attention you give your
vehicle, as far as maintenance is
concerned, will also help fuel
economy.
Protection of Engine against
Overcooling
Overcooling of the engine not only
accelerates wear of the vital engine
parts but also hurts fuel economy.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
74 Instruments and Controls
If windshield washer fluid does not
come out in sufficient quantity,
immediately release the switch.
Otherwise, the windshield surface
may sustain damage.
If windshield washer fluid does not
come out, release the windshield
washer switch immediately.
Otherwise the motor may seize up.
Do not hold the switch pressed for
more than 30 seconds. Otherwise,
the washer pump may sustain
damage.
Check the washer fluid level
regularly. Do it often when the
weather is bad.
Use a good quality windshield
antifreeze to help prevent freezing
damage, and for better cleaning.
When the vehicle is used in a
cold-climate region or during the
winter:
.Use washer fluid with
appropriate concentration for the
season to prevent frozen fluid. .
Fill the washer fluid reservoir
only 3/4 full to allow for
expansion if the temperature
should fall low enough to freeze
the solution.
See Washer Fluid 0274 for
information on filling the windshield
washer fluid reservoir.
Power Outlets
You can plug in auxiliary electrical
equipment. Just flip the outlet cover
open from the left edge of the cover
and follow the proper installation
instructions that are included with
any electrical equipment you install. These circuits are protected by a
fuse and have maximum current
loads.
When using accessory power
outlets, total maximum electrical
load must not exceed 120W. Always
turn off any electrical equipment
when not in use.
Leaving electrical equipment on for
extended periods will drain your
battery.
Cigarette Lighter
The cigarette lighter can be used
when the engine control switch is in
the ACC or ON position.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
108 Infotainment System
Infotainment
System
Radio
AM-FM Radio . . . . . . . . . . . . . . . . 108
Radio Reception . . . . . . . . . . . . . . 112
Fixed Mast Antenna . . . . . . . . . . 113
Audio Players
CD Player . . . . . . . . . . . . . . . . . . . . 114
USB Port . . . . . . . . . . . . . . . . . . . . . 121
Auxiliary Devices . . . . . . . . . . . . . 124
Trademarks and License
Agreements
Trademarks and LicenseAgreements . . . . . . . . . . . . . . . . . 125
Radio
AM-FM Radio
Control Panel
{Warning
Adjust the radio or CD player only
while the vehicle is stationary.
Adjusting them while the vehicle
is moving could cause an
accident. You and others could be
seriously injured.
Adjust the volume so that sound
outside of the vehicle can be heard.
If outside sound cannot be heard,
accidents may be harder to avoid.
Do not install a radio equipment
antenna near the vehicle's radio
antenna. This could cause
unwanted noise on the radio or
while playing a CD.
The radio or CD/USB player can be
used when the engine control switch
is in the "ACC" or "ON" position. Continued use while engine is
stopped may cause the battery to
discharge.
Take care not to spill liquids, etc. on
the radio or CD player. It may cause
damage to the player.
Do not disassemble or apply oil to
radio or CD player.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
124 Infotainment System
MP3/WMA files are compatible with
up to 8 levels of folders. However,
when there are many levels, it may
take some time before the first file is
played. Therefore, a two-level folder
is recommended.
Maximum characters for a folder/file
name: 64 (including extension).
A maximum of 700 folders and
3,000 files can be played in a single
memory device.
Auxiliary Devices
AUX Operations
Connecting Your Portable Audio
Device to Play Music1. Open the cover and connect your portable audio device to
mini jack.
Either place the portable audio
device and mini plug cable
somewhere where they will not
interfere with driving or
temporarily secure them at a
location where they are not in
the way. They could impede
driving and cause a traffic
accident.
Take care that the terminals of
the mini plug cable do not
catch your hands. Do not
connect, adjust or remove the
portable audio device while
driving.
2. To power the portable audio device, use the battery or other
power source supplied with the
device.
AUX device cannot be
controlled from audio player.
AUX volume is reduced to
prevent speaker damage. Switching from Other Audio Mode
to the AUX Mode
When a portable audio device is
connected to play back music, press
the "MODE" button and display
"AUX" to listen to the audio played
back from the device.
Adjusting AUX Volume
Press the "Volume control" button to
adjust the volume.
S: Volume will increase 1 step
every time the button is pressed.
Volume will continuously increase
when the button is pressed
continuously.
—: Volume will decrease 1 step
every time the button is pressed.
Volume will continuously decrease
when the button is pressed
continuously.
It can be adjusted between 63
(maximum) and 0.
Default setting is 19.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
276 Vehicle Care
Follow the recommendations for
brake checks in the Maintenance
Schedule.
GM replacement brake lining
material is recommended for this
vehicle to maintain the balance
between front and rear brake
performance. GM replacement
brake parts have been carefully
selected to provide the proper brake
balance for purposes of both
stopping distance and controllability
over the full range of operating
conditions. Installation of front or
rear brake lining material with
performance different from that of
the replacement parts
recommended for this vehicle can
change the intended brake balance
of this vehicle.
Checking the Brake Electric
Vacuum Pump (4500HD/
4500XD Series)
1. Turn the engine control switchto the "ON" position (do not
start the engine), and press the
brake pedal several times. 2. Check for the noisy sound of
the electric vacuum pump
inside the instrument panel at
the same time as vacuum
warning buzzer sound, and
check that the brake low
vacuum warning light
comes on.
3. Then, start the engine. The main vacuum pump driven by
the engine will start running.
If the electric vacuum pump
operation (noisy sound) and
the vacuum warning buzzer
stop, and the brake low
vacuum warning light goes off
thereafter, the operation is
normal.
4. If you cannot hear the noisy sound or the noisy sound stays
on all the time, have the
vehicle inspected by the
nearest dealer immediately.Hydraulic Brake Booster (HBB)
The 5500HD, 5500XD models are
equipped with a HBB system. HBB
is a brake booster device that utilizes hydraulic pressure from the
HBB pump integral with the power
steering pump.
If the brake booster warning light
comes on or a warning buzzer
continues to sound, there may be a
problem with the HBB.
If this warning light comes on while
driving, immediately stop your
vehicle at a safe place well clear of
traffic and promptly contact the
nearest dealer for inspection.
Hydraulic brake booster (HBB)
characteristics
In the 5500HD, 5500XD models, an
unusual sound from under the
instrument panel may be heard from
the hydraulic system while brakes
are used. It does not mean trouble.
It is not a sign of malfunction.
If you pump the brakes with the
engine off, a squeaking sound can
be heard. This comes from the
auxiliary accumulator. It is not a
malfunction. With the engine
running, a similar sound can be
heard during sudden braking.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Index 407
IndexA
About Driving the Vehicle . . . . . . . . . 3
Accessories andModifications . . . . . . . . . . . . . . . . . . 245
Add-On Electrical Equipment . . . 241
Additional Maintenance
and Care . . . . . . . . . . . . . . . . . . . . . . 375
Adjustments Seat, Initial Drive . . . . . . . . . . . . . . . 44
Agreements
Trademarks and License . . . . . 125
Air Cleaner/Filter, Engine . . . . . . . 263
Air Conditioning . . . . . . . . . . . . . . . . 126
Air Filter, Passenger Compartment . . . . . . . . . . . . . . . . . 130
Air Vents . . . . . . . . . . . . . . . . . . . . . . . 129
AM-FM Radio . . . . . . . . . . . . . . . . . . . 108
Antenna Fixed Mast . . . . . . . . . . . . . . . . . . . .113
Antilock Brake System (ABS) . . . 217 Warning Light . . . . . . . . . . . . . . . . . . . 87
Appearance Care Exterior . . . . . . . . . . . . . . . . . . . . . . . 334
Interior . . . . . . . . . . . . . . . . . . . . . . . . 340
Ashtrays . . . . . . . . . . . . . . . . . . . . . . . . . 75
Assistance Program, Roadside . . . . . . . . . . . . . . . . . . . . . . 400 Audio Players
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . .114
Automatic Transmission . . . . . . . . . . . . . . . . . 204
Transmission Fluid . . . . . . . . . . . 260
Automatic Transmission Selector Lever . . . . . . . . . . . . . . . . 214
Shift Lock Control Function
Check . . . . . . . . . . . . . . . . . . . . . . . 285
Automatic Transmission Fluid Temperature Warning Light . . . . . 88
Automatic Transmission Overdrive Off . . . . . . . . . . . . . . . . . . 215
Auxiliary Devices . . . . . . . . . . . . . . . . . . . . . . . 124
Axle, Rear . . . . . . . . . . . . . . . . . . . . . . 283
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . 281
Battery - North America . . . . . . . . . 326
Battery Warning Light . . . . . . . . . . . . 83
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . 233
Blade Replacement, Wiper . . . . . 286
Brake
Exhaust . . . . . . . . . . . . . . . . . . . . . . 222
System Warning Light . . . . . . . . . . 84
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 275 Antilock . . . . . . . . . . . . . . . . . . . . . . . 217
Exhaust Light . . . . . . . . . . . . . . . . . . . 88

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
408 Index
Brakes (cont'd)Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 280
Parking . . . . . . . . . . . . . . . . . . . . . . . 221
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 137
Break-In, New Vehicle . . . . . . . . . . 162
Bulb Replacement
Headlamp Aiming . . . . . . . . . . . . . 288
Headlamps . . . . . . . . . . . . . . . . . . . 288
Headlamps and Front TurnSignal . . . . . . . . . . . . . . . . . . . . . . . 291
Interior Lamps . . . . . . . . . . . . . . . . 298
License Plate Lamps . . . . . . . . . 297
Roofmarker Lamps . . . . . . . . . . . 295
Sidemarker Lamps . . . . . . . . . . . 295
Taillamps, Turn Signal, Stoplamps, and Back-up
Lamps . . . . . . . . . . . . . . . . . . . . . . 297
Buzzers, Warning . . . . . . . . . . . . . . . 101
C
Cab Tilting . . . . . . . . . . . . . . . . . . . . . . 247
California
Perchlorate MaterialsRequirements . . . . . . . . . . . . . . . 245
California Proposition 65 Warning . . . . . . . . . . . . . . . 245, 326
Capacities and Specifications . . . . . . . . . . . . . . . . . 389 Carbon Monoxide
Engine Exhaust . . . . . . . . . . . . . . . 178
Winter Driving . . . . . . . . . . . . . . . . 145
Cargo Lamp . . . . . . . . . . . . . . . . . . . . 107
Caution, Danger, and Warning . . . . 3
CD Player . . . . . . . . . . . . . . . . . . . . . . 114
Check Engine Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 84
Child Restraints Infants and Young Children . . . . . 57
Systems . . . . . . . . . . . . . . . . . . . . . . . . 57
Cigarette Lighter . . . . . . . . . . . . . . . . . 74
Cleaning Exterior Care . . . . . . . . . . . . . . . . . 334
Interior Care . . . . . . . . . . . . . . . . . . 340
Climate Control Systems . . . . . . . 126 Air Conditioning . . . . . . . . . . . . . . 126
Heating . . . . . . . . . . . . . . . . . . . . . . . 126
Cluster, Instrument . . . . . . . . . . . . . . 77
Cold Weather Operation . . . . . . . . 235
Collision Damage Repair . . . . . . . 401
Compartments Storage . . . . . . . . . . . . . . . . . . . . . . . . . 60
Control of a Vehicle . . . . . . . . . . . . . 133
Coolant
Engine . . . . . . . . . . . . . . . . . . . . . . . . 263
Engine Temperature Gauge . . . . 82 Cooling . . . . . . . . . . . . . . . . . . . . . . . . . 126
Cornering Lamps . . . . . . . . . . . . . . . 106
Cover
Engine . . . . . . . . . . . . . . . . . . . . . . . . 250
Covers Winter . . . . . . . . . . . . . . . . . . . . . . . . 172
Cruise Control . . . . . . . . . . . . . 224, 227
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Cupholders . . . . . . . . . . . . . . . . . . . . . . 62
Customer Assistance . . . . . . . . . . . 399 Offices . . . . . . . . . . . . . . . . . . . . . . . . 399
Text Telephone (TTY)
Users . . . . . . . . . . . . . . . . . . . . . . . 399
Customer Information Service PublicationsOrdering Information . . . . . . . . 403
Customer Satisfaction Procedure . . . . . . . . . . . . . . . . . . . . . 398
D
Damage Repair, Collision . . . . . . . 401
Danger, Warning, and Caution . . . . 3
Daytime Running Lamps (DRL)Indicator Light . . . . . . . . . . . . . . . . . . 92
Devices Auxiliary . . . . . . . . . . . . . . . . . . . . . . 124
Diesel Engine Engine Alarm andAutomatic Shutdown . . . . . . . . 174