2017 CHEVROLET LOW CAB FORWARD engine oil

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Technical Data 395
Oil pan drain plug83.3Y(8.5 kgf m/
61.0 lb ft) 25.0
Y(2.5 kgf m/
18.0 lb ft) 83.3
Y(8.5 kgf m/
61.0 lb ft)
Oil filter drain plug 25.0Y(2.5 kgf m/
18.0 lb ft) —
—
Oil filter —30.0Y(3.1 kgf m/
22.0 lb ft) —
Oil filter cartridge ——63.7Y(6.5 kgf m/
47.0 lb ft)
Remarks:
*1see Engine Oil (Gasoline) 0257 orEngine Oil (Diesel) 0251.
Remarks:*2see Engine Coolant 0263.
Remarks:*3see Automatic Transmission Fluid 0260.
Remarks:*4see Rear Axle (Gear Oil Viscosity Chart) 0283 orRear Axle (Oil Level Check) 0283.
Remarks:*5only for vehicles equipped with optional limited slip differential.
Remarks:*6The fuel tank capacity is stated on a metal plate attached to the fuel tank body. Only fill the tank to
95 percent of its capacity; this allows room for the expansion of the fuel.
Remarks:
*7larger capacity batteries 31 (180-930) × 2 can also be used. However, do not mix batteries of different
types and from different makers.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
396 Technical Data
Engine Drive Belt Routing
Fan Belt and Air Conditioning
Compressor Belt
See theMaintenance Schedule
0 345.
3.0L L4 Engine (IZ3)
No. Name
1 Fan Pulley
2 Tension pulley
3 A/C compressor
4 A/C belt
5 Crank pulley
6 Idler No.
Name
7 Alternator
8 Fan belt
If your air conditioning system is
functioning properly, it is not
necessary to remove and replace
the refrigerant or compressor oil.
6.0L V8 Engine (L96)
No. Name
1 Fan belt idler pulley
2 Alternator
3 Vacuum pulley
4 Power steering pump pulley No.
Name
5 Cooling fan pulley
6 Crank pulley
7 A/C belt
8 A/C compressor
9 Fan belt
10 Fan belt tensioner
5.2L L4 Engine (I1B)
No. Name
1 Fan belt
2 Fan pulley
3 A/C belt

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Technical Data 397
No.Name
4 A/C compressor
5 Tension pulley
6 Crank pulley
7 Alternator
If your air conditioning system is
functioning properly, it is not
necessary to remove and replace
the refrigerant or compressor oil.
. A V-ribbed belt is used for the
fan belt. This type of belt
requires the tension to be
adjusted more accurately than is
required with the conventional V
belt. Inappropriate tension could
cause the belt to make noise or
break. When the fan belt is
damaged, electricity is not
properly generated or becomes
a cause of engine overheating.
You must check the tension of
the fan belt carefully.
. Use dealer-certified genuine
parts when changing the
fan belt. .
Have the vehicle inspected and
serviced at your dealer.
. The air conditioning drive belt,
if equipped, must be adjusted
after fan belt adjustment. If the
belt is not adjusted properly, the
A/C belt may experience
excessive tension, and possible
premature failure.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Index 409
Diesel Engine (cont'd)High Idle System . . . . . . . . . . . . . 174
Diesel Exhaust Fluid . . . . . . . . 30, 189
Diesel Exhaust Fluid (DEF) Gauge . . . . . . . . . . . . . . . . . . . . . . . . . 83
Diesel Exhaust Fluid (DEF) Warning Light . . . . . . . . . . . . . . . . . . 90
Diesel Particulate Filter . . . . . . . . . 180
Distracted Driving . . . . . . . . . . . . . . . 133
Dome Lamps . . . . . . . . . . . . . . . . . . . 107
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Power Locks . . . . . . . . . . . . . . . . . . . . 39
Drive Belt Routing, Engine . . . . . . 396
Driver Behavior . . . . . . . . . . . . . . . . . 133
Driver Information
Center (DIC) . . . . . . . . . . . . . . . . . . . 93
Driving
Emergencies . . . . . . . . . . . . 148, 161
For Better Fuel Economy . . . . . . . 29
Hill and Mountain Roads . . . . . . 144
If the Vehicle is Stuck . . . . . . . . . 148
Wet Roads . . . . . . . . . . . . . . . . . . . 143
Winter . . . . . . . . . . . . . . . . . . . . . . . . 145
Driving the Vehicle . . . . . . . . . . . . . . . . 3
E
Electrical Equipment, Add-On . . . . . . . . . . . . . . . . . . . . . . . 241 Electrical System
Overload . . . . . . . . . . . . . . . . . . . . . 298
Emergencies . . . . . . . . . . . . . . 148, 161
Engine Air Cleaner/Filter . . . . . . . . . . . . . 263
Alarm and AutomaticShutdown . . . . . . . . . . . . . . . . . . . 174
Check Light (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 84
Checks Before Operating . . . . . 175
Compartment Overview . . . . . . . 249
Coolant . . . . . . . . . . . . . . . . . . . . . . . 263
Coolant Temperature Gauge . . . . 82
Cover . . . . . . . . . . . . . . . . . . . . . . . . . 250
Drive Belt Routing . . . . . . . . . . . . 396
Exhaust . . . . . . . . . . . . . . . . . . . . . . 178
Heater . . . . . . . . . . . . . . . . . . . . . . . . 173
High Idle System . . . . . . . . . . . . . 174
Oil Pressure Light . . . . . . . . . . . . . . 89
Overheating . . . . . . . . . . . . . . . . . . 269
Reduced Power Light . . . . . . . . . . . 91
Running While Parked . . . . . . . . 179
Shutdown Warning Light . . . . . . . . 91
Engine Oil Level Indicator Light . . . . . . . . . . . . 90
Engines Diesel Fuel . . . . . . . . . . . . . . . . . . . 232
Exhaust Brake . . . . . . . . . . . . . . . . . . 222 Exhaust Brake Light . . . . . . . . . . . . . 88
Exhaust Fluid
Diesel . . . . . . . . . . . . . . . . . . . . . . . . 189
Extender, Seat Belt . . . . . . . . . . . . . . 55
Exterior Lamp Controls . . . . . . . . . 103
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 180 Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Filter, Engine Air Cleaner . . . . . . . . . . . 263
Fixed Mast Antenna . . . . . . . . . . . . 113
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 104
Flashers, Hazard Warning . . . . . . 105
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 326
Fluid Automatic Transmission . . . . . . 260
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 280
Diesel Exhaust . . . . . . . . . . . . . . . . . 30
Power Steering . . . . . . . . . . . . . . . 273
Washer . . . . . . . . . . . . . . . . . . . . . . . 274
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 404
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 44
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Biodiesel . . . . . . . . . . . . . . . . . . . . . 233
Cold Weather Operation . . . . . . 235
Diesel Engines . . . . . . . . . . . . . . . 232

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Index 411
LightsAntilock Brake System
(ABS) Warning . . . . . . . . . . . . . . . . 87
Automatic Transmission Fluid Temperature . . . . . . . . . . . . . 88
Battery Warning . . . . . . . . . . . . . . . . 83
Brake System Warning . . . . . . . . . 84
Check Engine (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 84
Cruise Control . . . . . . . . . . . . . . . . . . 92
Daytime Running Lamps (DRL) . . . . . . . . . . . . . . . . . . 92
Diesel Exhaust Fluid (DEF) . . . . . 90
Engine Oil Level Indicator . . . . . . 90
Engine Oil Pressure . . . . . . . . . . . . 89
Engine Shutdown Warning . . . . . 91
Exhaust Brake . . . . . . . . . . . . . . . . . . 88
Flash-to-Pass . . . . . . . . . . . . . . . . . 104
High-Beam On . . . . . . . . . . . . . . . . . . 92
High/Low Beam Changer . . . . . 104
Overdrive Off . . . . . . . . . . . . . . . . . . . 89
Reduced Engine Power . . . . . . . . 91
Seat Belt Reminders . . . . . . . . . . . . 83
Service Transmission Warning . . . . . . . . . . . . . . . . . . . . . . . 88
Service Vehicle Soon . . . . . . . . . . . 84
Wait to Start . . . . . . . . . . . . . . . . . . . . 89
Loading the Vehicle . . . . . . . . . . . . . . 64 Locks
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Power Door . . . . . . . . . . . . . . . . . . . . . 39
M
Maintenance and CareAdditional . . . . . . . . . . . . . . . . . . . . . 375
Maintenance Schedule . . . . . . . . . 345 Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 378
Malfunction Indicator Lamp . . . . . . 84
Messages Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 97
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . 39 Heated . . . . . . . . . . . . . . . . . . . . . . . . . 40
N
New Vehicle Break-In . . . . . . . . . . . 162
Noise Control System . . . . . . . . . . 284
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . . 80Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80
Oil Engine . . . . . . . . . . . . . . . . . . . 251, 257
Pressure Light . . . . . . . . . . . . . . . . . . 89
Online Owner Center . . . . . . . . . . . 399
Operating Temperature . . . . . . . . . 172
Ordering Service Publications . . . . . . . . . . 403 Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Overdrive Off . . . . . . . . . . . . . . . . . . . 215
Overdrive Off Light . . . . . . . . . . . . . . 89
Overheating, Engine . . . . . . . . . . . . 269
Owner Checks and Services . . . . 367
P
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . 221
Over Things That Burn . . . . . . . 176
Passenger Compartment Air
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Perchlorate Materials Requirements, California . . . . . . 245
Port
USB . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Power Door Locks . . . . . . . . . . . . . . . . . . . . . 39
Outlets . . . . . . . . . . . . . . . . . . . . . . . . . 74
Reduced Engine Light . . . . . . . . . . 91
Steering Fluid . . . . . . . . . . . . . . . . . 273
Windows . . . . . . . . . . . . . . . . . . . . . . . 41
Power Take-Off (PTO) . . . . . . . . . . 242
Pregnancy, Using Seat Belts . . . . 53
Privacy Vehicle Data Recording . . . . . . . 405