2016 VAUXHALL VIVARO stop start

Vehicle care145
Move the safety catch (located
slightly right of centre) sideways to
the left vehicle side and open the
bonnet.
The bonnet is held open
automatically by a lifter.
If the bonnet is opened during an Autostop, the engine will be restarted automatically for safety reasons.
Stop-start system 3 117.
Closing
Lower the bonnet and allow it to fall
into the latch from a low height
(approx. 30 cm). Check that the
bonnet is engaged.
Caution
Do not press the bonnet into the
latch, to avoid dents.
Engine oil
Check the engine oil level manually
on a regular basis to prevent damage
to the engine.
Ensure that the correct specification
of oil is used. Recommended fluids
and lubricants 3 181.
Check with the vehicle on a level
surface. The engine must be at
operating temperature and switched
off for at least 10 minutes.
Pull out the dipstick, wipe it clean, insert it to the stop on the handle, pull
out and read the engine oil level.
Caution
It is the owner's responsibility to
maintain the proper level of an
appropriate quality oil in the
engine.
When the engine oil level has
dropped to the MIN mark, top-up
engine oil.
Caution
Do not allow the engine oil level to drop below the minimum level!

Vehicle care149
The brake fluid level must be betweenthe MINI and MAXI marks.
When topping up, ensure maximum cleanliness as contamination of the
brake fluid can lead to brake system
malfunctions. Have the cause of the
loss of brake fluid remedied by a
workshop.
Only use high-performance brake
fluid approved for your vehicle.
Brake fluid 3 181.
Vehicle battery
The vehicle is equipped with a lead
acid battery. Vehicles with stop-start
system will be equipped with an
AGM (Absorptive Glass Mat) battery
which is not a lead acid battery.
The vehicle battery is maintenance-
free provided that the driving profile
allows sufficient charging of the
battery. Short-distance driving and
frequent engine starts can discharge
the battery. Avoid the use of
unnecessary electrical consumers.
Batteries do not belong in household
waste. They must be disposed of at
an appropriate recycling collection
point.
Laying up the vehicle for more than
4 weeks can lead to battery
discharge. Disconnect the clamp from the negative terminal of the vehicle
battery.
Ensure the ignition is switched off
before connecting or disconnecting
the vehicle battery.
Replacing the vehicle battery
In vehicles with stop-start system, be
sure to have the AGM (Absorptive
Glass Mat) battery replaced with
another AGM battery.
An AGM battery can be identified by
the label on the battery. We
recommend the use of an original
Vauxhall battery.

150Vehicle careNotice
Using an AGM vehicle battery
different from the original Vauxhall vehicle battery may result in a lower performance of the stop-start
system.
We recommend that you have the
vehicle battery replaced by a
workshop.
Stop-start system 3 117.
Charging the vehicle battery9 Warning
On vehicles with stop-start
system, ensure that the charging potential does not exceed
14.6 volts when using a battery
charger. Otherwise the vehicle
battery might be damaged.
9 Danger
Ensure adequate ventilation when
charging the battery. There is a
risk of explosion if gases
generated during charging are
allowed to accumulate!
Jump starting 3 174.
Warning label
Meaning of symbols: ● No sparks, naked flames or smoking.
● Always shield eyes. Explosive gases can cause blindness or
injury.
● Keep the vehicle battery out of reach of children.
● The vehicle battery contains sulfuric acid which could cause
blindness or serious burn
injuries.
● See the Owner's Manual for further information.
● Explosive gas may be present in the vicinity of the battery.
Diesel fuel filter
The diesel fuel filter is accessible from the underside of the vehicle.

Vehicle care151
Drain filter of residual water at every
engine oil change.
Place a container underneath the
filter housing. Loosen the knurled
screw on the lower part of the filter by approx. one turn, to drain off the
water.
The filter is drained as soon as water-
free diesel fuel emerges. Retighten
the screw.
Check diesel fuel filter at shorter
intervals if the vehicle is subjected to
extreme operating conditions.
Diesel fuel system bleeding
If the fuel tank has been run dry, it will be necessary to air vent or bleed the
diesel fuel system.
Refuel then proceed as follows:
With ignition key
● Switch on the ignition (key to position 2) for 5 seconds at a
time.
● Switch off ignition (key to position
1 ) for 3 seconds.
● Repeat this process multiple
times.
● Start the engine (key to position 3) then switch off (key to position
0 ).
Ignition switch positions 3 114.
With power button
● Insert the electronic key in the card reader.
● Press START/STOP without
pressing any of the pedals.
● Wait a few minutes before starting engine.
Power button 3 114.

200IndexAAbsorptive Glass Mat battery .....149
Accessories and vehicle modifications .......................... 143
Adaptive forward lighting .............97
Adblue .......................................... 91
AdBlue .......................... 87, 121, 181
AdBlue tank ................................ 195
Adjustable air vents ...................109
AGM battery ............................... 149
Airbag and belt tensioners ...........84
Airbag deactivation ................56, 84
Airbag label............................. 52, 56
Airbag system .............................. 52
Air conditioning regular operation ................................ 110
Air conditioning system .............. 102
Air intake .................................... 110
Air recirculation ...................102, 175
Air vents...................................... 109
Alert .............................................. 90
Antifreeze ................................... 147
Antilock brake system ................ 126
Antilock brake system (ABS) .......86
Anti-theft alarm system ................33
Anti-theft bolts............................. 171
Anti-theft locking system .............. 32
Anti-theft security lock ..................23
Appearance care ........................177
Armrest ........................................ 45Ashtrays ....................................... 78
Automatic anti-dazzle ..................38
Automatic fuel cut-off ..................117
Automatic light control .................95
Automatic locking ........................28
Autostop ............................... 88, 116
Auxiliary heater ........................... 106
B Battery ........................................ 149
Battery, jump starting.................. 174
Belts.............................................. 48 Bench seat.................................... 67
BlueInjection ............................... 121
Bonnet ....................................... 144
Bottle holders................................ 66
Brake and clutch fluid .................181
Brake assist ............................... 127
Brake fluid .................................. 148
Brakes ............................... 126, 148
Brake system ............................... 85
Breakdown.................................. 175
Bulb replacement ....................... 152
C Capacities .................................. 195
Car Pass ...................................... 20
Catalytic converter .....................121
Central locking system ................23
Centre high-mounted brake light 155
Changing tyre and wheel size ...167

204Seat position ................................ 42
Seats ............................................ 67
Selective catalytic reduction .......121
Service ............................... 111, 180
Service display ............................ 80
Service information ....................180
Service vehicle soon .................... 85
Side airbag system ......................55
Sidelights ...................................... 95
Side turn signal lights ................155
Sliding door .................................. 29
Spare wheel ............................... 172
Spare wheel security tool ...........162
Speed limiter......................... 78, 134
Speedometer ............................... 78
Starting and operating ................114
Starting off ................................... 17
Starting the engine ...............17, 116
Steering ...................................... 113
Steering column controls ..............74
Steering wheel adjustment ......9, 74
Steering wheel controls ...............74
Stop engine .................................. 85
Stop-start system.................. 17, 117
Storage ......................................... 65
Storage box .................................. 67
Storage compartments .................65
Sun visors .................................... 40
Symbols ......................................... 4T
Tablet holder................................. 65 Tachograph ............................ 89, 93
Tachometer ................................. 79
Tailgate ......................................... 31
Tail lights ................................... 154
Technical data ............................ 186
Temporary spare wheel ..............172
Three-point seat belt .................... 49
Toll road stickers .......................... 38
Tools .......................................... 162
Top-tether fastening eyes ............64
Torx key ...................................... 162
Tow bar....................................... 140
Towing ................................ 140, 175
Towing another vehicle .............176
Towing a trailer ........................... 140
Towing eye ......................... 162, 175
Towing the vehicle .....................175
Traction Control system ............. 128
Trailer coupling ........................... 140
Trailer stability assist .................141
Trailer towing ............................. 140
Transmission ............................... 16
Tread depth ............................... 167
Trip computer .............................. 91
Trip odometer .............................. 79
Turbo engine warm-up ...............116
Turn and lane-change signals .....97
Turn signal ................................... 83Tyre chains ................................ 168
Tyre changing ............................. 171
Tyre designations ......................163
Tyre pressure ............................ 163
Tyre pressure monitoring system ............................... 87, 164
Tyre pressures ........................... 196
Tyre repair kit ............................. 168
Tyres .......................................... 163
Tyres and wheel size, changing. 167
U Ultrasonic parking assist............. 134
Underseat storage .......................67
Upholstery .................................. 178
Upshift .......................................... 86
Using this manual ..........................3
V Vehicle battery ...................149, 174
Vehicle checks............................ 144
Vehicle data ................................ 185
Vehicle data recording and privacy ..................................... 199
Vehicle dimensions .................... 190
Vehicle Identification Number ....183
Vehicle jack ................................ 162
Vehicle messages .......................90
Vehicle security ............................ 32
Vehicle shutdown ......................117
Vehicle specific data ......................3