2016 Peugeot Expert VU air filter

13
Limit the causes of excess
consumption
Spread loads throughout the vehicle; place the
heaviest items in the bottom of the boot, as
close as possible to the rear seats.
Limit the loads carried in the vehicle and reduce
wind resistance (roof bars, roof rack, bicycle
carrier, trailer...). u
s
e a roof box in preference.
Remove roof bars and roof racks after use.
At the end of winter, remove snow tyres and refit
your summer tyres.
Observe the recommendations
on maintenance
Check the tyre pressures regularly, when cold,
referring to the label in the door aperture,
driver's side.
Carry out this check in particular:
-

b
efore a long journey,
-

a
t each change of season,
-

a
fter a long period out of use.
Don't forget the spare wheel and the tyres on
any trailer or caravan.
Have your vehicle serviced regularly (engine
oil, oil filter, air filter, passenger compartment
filter...) and observe the schedule of operations
recommended in the manufacturer's service
schedule.
With a BlueHDi Diesel engine, if the SCR
system is faulty your vehicle becomes polluting;
go to a P
e

ugeot dealer or a qualified
workshop without delay to have the emissions
of nitrogen oxides brought back to the legal
level. When refuelling, do not continue after the third
cut-off of the nozzle to avoid any over flow.
At the wheel of your new vehicle, it is only after
the first 1 800 miles (3 000 kilometres) that you
will see the fuel consumption settle down to a
consistent average.
.
Eco-driving

135
In order for these systems to be fully effective, follow the operation and maintenance
guidelines below:
F t
o o
btain an even air distribution, take care not to obstruct the exterior air intake grilles
located at the base of the windscreen, the nozzles, the vents and the air outlets, as well
as the air extractor located at the rear.
F

D
o not cover the sunshine sensor, located at the top of the windscreen; this is used for
regulation of the air conditioning system.
F
o
p
erate the air conditioning system for at least 5 to 10 minutes, once or twice a month
to keep it in per fect working order.
F
e
n
sure that the passenger compartment filter is in good condition and have the filter
elements replaced regularly.
W

e recommend the use of a combined passenger compartment filter. t
h
anks to its
special active additive, it contributes to the purification of the air breathed by the
occupants and the cleanliness of the passenger compartment (reduction of allergic
symptoms, bad odours and greasy deposits).
F
t
o e
nsure correct operation of the air conditioning system, you are also advised to have
it checked regularly as recommended in the warranty and maintenance record.
F

I
f the system does not produce cold air, switch it off and contact a P
e
ugeot dealer or
a qualified workshop.
Recommendations for heating, ventilation and air conditioning
If after an extended stop in sunshine,
the interior temperature is very high, first
ventilate the passenger compartment for
a few moments.
Put the air flow control at a setting high
enough to quickly change the air in the
passenger compartment.
th

e air conditioning system does not
contain chlorine and does not present
any danger to the ozone layer.
th

e condensation created by the air
conditioning results in a discharge
of water under the vehicle which is
perfectly normal.
When towing the maximum load on a steep gradient in high temperatures, switching off the
air conditioning increases the available engine power and so improves the towing ability.
Stop & Start
the heating and air conditioning
systems only work when the engine is
running.
to m
aintain a comfortable temperature
in the passenger compartment, you can
temporarily deactivate the Stop & Start
system.
For more information on Stop & Star t ,
refer to the corresponding section.
Air vents
to close a vent, move the control
towards the outside of the vehicle. Slight
resistance may be felt.
3
ease of use and comfort

281
Checks
12 V battery
the battery does not require any maintenance.
However, check regularly that the terminals
are correctly tightened (versions without quick
release terminals) and that the connections
are clean.Refer to the manufacturer's
service schedule for details of the
replacement intervals for these
components.
Air filter and passenger compartment filter
Replace the oil filter each time the
engine oil is changed.
Refer to the manufacturer's
service schedule for details of
the replacement interval for this
component.
Oil filterParticle filter (Diesel)
the start of saturation of the particle
filter is indicated by the temporary
illumination of this warning lamp
accompanied by a message in the
multifunction screen.
As soon as the traffic conditions permit,
regenerate the filter by driving at a
speed of at least 40 mph (60 km/h) until
the warning lamp goes off.
If the warning lamp stays on, this
indicates a low additive level.
For more information on Checking
levels , refer to the corresponding
section.
on a n

ew vehicle, the first particle
filter regeneration operations may be
accompanied by a "burning" smell,
which is per fectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration.
t
h
is does
not affect the behaviour of the vehicle
or the environment.un
less otherwise indicated, check these components in accordance with the manufacturer's
service schedule and according to your engine.
ot

her wise, have them checked by a P
e

ugeot
dealer or a qualified workshop.
For more information and the precautions to
take before starting work on the 12 V batter y ,
refer to the corresponding section. Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle
(e.g.

city driving), replace them twice as often
if necessary .
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours.
Versions equipped with Stop & Start are
fitted with a 12 V lead-acid battery of
specific technology and specification.
Its replacement should be carried
out only by a P
e

ugeot
dealer or a
qualified workshop.
7
Practical information

507
Checking the levels ...............................278-280
Checking tyre pressures (using the kit) ........290
Checks
...............

...........................277, 281, 282
Child lock
...............................

................19 4, 195
Child lock, electric
...............................

..........19 4
Child lock on rear windows
...........................195
Children
...............................

..182, 187, 188, 190
Children (safety)
...............................

.............19 4
Child seats


....169, 174-176, 180, 181, 182, 184, 193
Child seats, conventional


..............180 -182, 18 4
Child seats, IS
oF

IX
......................1

87, 188, 190
Closing the boot
.............................................. 94
Closing the doors
............. 5

9, 64, 74, 75, 77, 82, 91, 93
Collision risk alert
................... 2

3, 243-245, 247
Compressor, tyre inflation


............................290
Connection, Bluetooth


....380, 406 - 408, 436, 462- 464, 498
Connection, MirrorLink


........382, 384, 438, 440
Connection, Wi-Fi network


...................3 81, 4 37
Connectivity


.......................................... 378, 434
Control, emergency boot release


...................94
Control, emergency door


..........................53, 68
Control, heated seats


............................103, 105
Control stalk, lighting
.............................. 3

0, 146
Control stalk, wipers
.............................15 6, 157
Courtesy lamp
............................................... 312
Courtesy lamp, front
..............141, 142, 312, 315
Courtesy lamp, rear
...............141, 142, 312, 315
Courtesy lamps
......................141, 142, 312, 315
Cover, load space

......................................... 12

3
Crew cab, fixed
............................................. 117
Cruise control
........................................ 23

2-235
Cruise control, dynamic
........................236 -242
Cruise control by speed limit recognition


.................................................. 225
DE
F
DAB (Digital Audio Broadcasting) -
Digital radio ........396, 397, 452, 453, 490, 491
Date (setting)
...............................

....46, 420, 476
Daytime running lamps


.........146, 149, 3 0 4 - 3 0 6
Deactivating the passenger airbag


.......171, 17 7
Deactivation of DSC (
e

SC) ...........................163
Deadlocking


........................................ 51, 58, 65
Defrosting


.............................................. 132, 14 4
Demisting
...............................

.......................132
Demisting, rear screen


.........................13 3, 13 4
Diagnostic system, engine
..............................21
Dial


............................................................ 15, 16
Dials and gauges


............................................ 14
Dimensions


........................................... 328-330
Dipstick
................

.................................... 34, 278
Direction indicators


....148, 304, 307, 308, 310, 313, 315
Display, head-up


........................................... 222
Display screen, instrument panel


......14 -16, 2 0 8
Door pockets
................................................. 12

0
Doors


............................................................... 74
Doors, rear
...................................................... 91
Doors, side-hinged


........64, 65, 91-93, 310, 311
Driver’s attention warning


.....................250, 251
Driver's door open warning


.............................75
Driving abroad ............................................... 148
Driving economically ....................................... 12
Driving time warning


.............................250, 251
Dynamic stability control (DSC)


.................................... 25, 161, 163, 16 4ec
o-driving (advice) ........................................12ec
onomy mode .............................................270
el

ectric windows

.............................................98
ele

ctronic brake force
distribution (
e
B
FD)

.....................................161
em

ergency braking
assistance (
eB

A)
........................................16

1
em

ergency call
.....................................16

0, 338
em

ergency collision braking

...........23, 243-247
em

ergency warning lamps
...................1

60, 287
em

issions control system, SCR .....................27
en

ergy economy mode

.................................270
en

gine compartment

....................................277
en

gine,
Diesel


............21, 267, 277, 327, 333, 335, 336
en

vironment
...............................
.12, 54, 70, 139
el

ectronic stability control (
e
SC) ....................25
Fatigue detection


..................................250, 251
Filling the fuel tank

................................26

5, 267
Filter, air
...............

.........................................281
Filter, oil


.........................................................281
Filter, particle


........................................280, 281
Filter, passenger compartment


.....................281
Finisher


.........................................................302
Fitting a wheel

...............................
................299
Fitting roof bars


.............................................273
Fittings, interior


.....................................120, 123
Fittings, rear
...............................

...................123
.
Alphabetical index

510
Radio ................... 394, 398, 450, 454, 488, 489
Radio, digital (Digital Audio Broadcasting - DA B) ................................... 396, 397, 452, 453
Radio Media


........388, 390, 392, 444, 446, 448
Range


.............................................................. 42
Range, AdBlue
® ............................... ...............35
RDS
....................................................... 3 9 5 , 4 51
Rear screen, demisting


......................... 13 3, 13 4
Recharging the battery
................................. 32

3
Recirculation, air


................... 125, 126, 128, 131
Reduction of electrical load


.......................... 270
Regeneration of the particle filter

.................2

81
Reinitialisation of the under-inflation detection system
......................................... 263
Reinitialising the remote control
............... 5

4, 70
Reminder, key in ignition
............................... 201
Reminder, lighting on


.................................... 148
Remote control
...... 4

7-50, 52, 55 -59, 67, 68, 71, 74, 75
Removing a wheel
........................................ 299
Removing the mat


......................................... 11 9
Replacing bulbs


..... 3 03, 3 0 4, 310, 311, 313 - 315
Replacing fuses
..............................

......316, 317
Replacing the air filter


................................... 281
Replacing the oil filter
................................... 2

81
Replacing the passenger compartment filter


...................................... 281
Reservoir, headlamp wash


........................... 280
Reservoir, screenwash
................................. 28

0
Resetting the service indicator


.......................33
Resetting the trip recorder


.............................. 38
Rev counter


................................................ 14 -16
Reversing camera


......................................... 259
Reversing camera (on interior mirror)
..........258
Reversing lamp
............................. 31

0, 313, 315
Roof bars
............................................... 2

72, 273
Roof rack
............................................... 2

72, 273
Running out of fuel (Diesel)

.......................... 3

27
RS
Safety, children ..............................17 1, 174 -176 ,
182, 187, 188, 190, 193
Saturation of the particle filter (Diesel)

.........2

81
Screen, instrument panel


..........................4 0 , 41
Screen menu map


.......................352, 354, 356,
358, 360, 362, 370, 372, 374, 378, 384, 386, 388, 390, 392, 400, 402, 404,
412, 414, 416, 434, 440, 442, 444, 446, 448, 456, 458, 460, 468, 470, 472
Screen, multifunction (with audio system)
..................................... 487
Screenwash


.................................................. 15 8
Screenwash, rear


.......................................... 157
SCR (Selective Catalytic Reduction)


............283
Seat and bench seat, rear, fixed
........... 11

3 , 11 6
Seat and bench seat, rear,
on rails


........................................................ 11 6
Seat belts
...................... 1

66, 168, 169, 180, 181
Seat belts, rear


.............................................. 167
Seat, front bench, 2-seat


......................104, 167
Seat, rear bench


........................................... 11 6
Seats, electric


............................................... 102
Seats, front
...............................

.......99, 101, 102
Seats, front bench


......................................... 105
Seats, heated


........................................ 103, 105
Seats, rear


............................................. 11 0 , 113
Selector, gear


................................................ 214
Serial number, vehicle
.................................. 3

37
Service indicator


....................................... 31, 3 3
Service (warning lamp)
................................... 28
S

ervicing
...............................
..........................12
Settings
...............

..412, 414, 416, 468, 470, 472
Settings, system


.................................... 420, 476
Sidelamps


.............146, 304-306, 310, 313, 315
Side repeater
..............................

..................305
Sliding side door, electric


............................ 49, 57, 64, 65, 78 - 84
Sliding side door, hands-free

..............87

, 89, 90
Sliding side door, manual


.........................75 -77
Pads, brake
................................................... 282
Paint colour code

.......................................... 337
Parking brake


.................................. 18, 205, 282
Parking sensors, audible and visual


....................................... 256
Parking sensors, front


................................... 256
Parking sensors, rear ............................255, 256
P
e

ugeot
Connect Assistance

................... 338
P
e

ugeot
Connect Nav

............................... 3

41
P
e

ugeot
Connect Packs

........................... 338
P
e

ugeot
Connect Radio

........................... 429
P
e

ugeot
Connect S
oS


............................. 33

8
Plates, identification ...................................... 337
Platform cab
.......................................... 3

15, 332
Player, Apple
® .............................. 3 99, 455, 495
Player, MP3 CD ............................................. 494
Player,
u
S

B

.................................. 398, 454, 492
Port,
u
S

B

............................. 1

22, 398, 454, 492
Pressures, tyres


................... 290, 295, 302, 337
Pre-tensioning seat belts


.............................. 169
Priming pump


................................................ 327
Priming the fuel system
................................ 327
Profiles


.................................................. 418 , 474
Protecting children


......................... 171, 174 -176 ,
182, 187, 188, 190, 193
Puncture


........................................................ 290
P
Alphabetical index